NHTSA Campaign #06E043000 FUEL SYSTEM, GASOLINE

MAY 19
2006

88,303 vehicles recalled

2002 CHEVROLET AVALANCHE -- Certain replacement fuel filters, fram brand name P/N G3727, with date codes X52911 through X60801 sequentially or X600141 and a mexico country or origin marking on the fuel filter housing manufactured from October 18, 2005, through March 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). the connector on the fuel filter was not manufactured to honeywell's specification. As a result, the O-ring may not seat correctly on the fuel line.

This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.

Honeywell will notify owners and replace the fuel filters free of charge. The recall began on October 18, 2006. Owners may contact fram customer service at 1-800-890-2075 (option 1). For detailed information & supporting documents, see the official NHTSA page concerning recall #06E043000 »

NHTSA Campaign #05V379000 SERVICE BRAKES, HYDRAULIC:ANTILOCK

AUGUST 29
2005

1,353,718 vehicles recalled

2002 CHEVROLET AVALANCHE -- Certain pickup trucks and sport utility vehicles may experience unwanted antilock brake system (ABS) activation. This condition is more likely to occur in environmentally corrosive areas. This recall will be launched in the "salt belt" states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maryland, Massachusetts, Maine, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia only.

This can cause increased stopping distances during low-speed brake applications, which could result in a crash.

Dealers are to remove the wheel speed sensor and thoroughly clean the wheel speed sensor mounting surface on the bearing, apply rust inhibitor to the cleaned surface, grease the mounting surface, reinstall the wheel speed sensor, and check the peak-to-peak output voltage to ensure the wheel speed signal is within specifications. The recall began September 22, 2005. Owners may contact Chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463. For detailed information & supporting documents, see the official NHTSA page concerning recall #05V379000 »

NHTSA Campaign #04V129000 STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS

MARCH 17
2004

3,662,211 vehicles recalled

2002 CHEVROLET AVALANCHE -- On certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. If both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper.

Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. On vehicles that have had the bumper removed, the tailgate may drop even lower. Additionally, if there is cargo on the tailgate the cargo may fall off if the support cables fracture.

Dealers will replace the cables. Interim owner notification began on April 7, 20004. The recall began on September 24, 2004, when replacement parts were available, and will continue through October 29, 2004. Owners should contact Cadillac at 1-866-982-2339, Chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463, or visit www.mygmlink.com, and enter your vehicle identification number. For detailed information & supporting documents, see the official NHTSA page concerning recall #04V129000 »