Huge win for car owners! All TSBs to be made public. The Center for Auto Safety just made the NHTSA (US Government) make public the full text of all TSBs from now on. They are the same organization that has petitioned the NHTSA & filed lawsuits to protect car owners over exploding gas tanks & other major safety issues. Whenever you drive in your car, you are safer thanks in part to a lot of work over the years by this small but very effective consumer advocacy group.

Please take a moment & say thank you by donating $5 or whatever you can to the Center for Auto Safety.

Print this page

CarComplaints.com Notes: The first year for Chevrolet's replacement for the S-10.

2.6

hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
55,617 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2004 Chevrolet Colorado accessories - exterior problems

accessories - exterior problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2004 Chevrolet Colorado:

Unsubscribe any time. We don't sell/share your email.

2004 Chevrolet Colorado Owner Comments

problem #2

Dec 162013

Colorado 5-cyl

  • 111,234 miles

A D V E R T I S E M E N T S

This incident occurred twice. It involves the heater blower motor resistor assembly. 8 years ago my daughter used put her back pack on the passenger floor where it repeatedly made impacted the connection to the blower motor relay assembly. This eventually caused the pin and socket on the orange wire to separate to the point where it arced and burnt. I found and repaired the socket when the heater would only work on high. On the 16th of Dec 2013, a passenger size 12 shoes accidentally, and unwittingly kicked the same spot and caused the same fault. I repaired the socket again. My complaint is the resistor connection is in a spot to easily service, but it is in a vulnerable spot for accidental contact. I believe it needs a robust protective cover, either metal or plastic. For people that cannot repair their own vehicles, this situation could cost them a couple of hundred dollars. My other electrical fault is the right side window motor. It quit working couple of years ago, and I was able to take it apart and clean the brushes. It worked for a couple of years until it stopped a couple of weeks ago. I replaced the motor because I could not find brushes to replace. I am convinced that the brushes failed because they were made brittle from slamming the doors too hard by the passengers. The doors are light and it is common for them to slammed. The brushes or the motor need to be more robust.

- El Paso, TX, USA

problem #1

Aug 152007

Colorado 5-cyl

  • Automatic transmission
  • miles
Blower motor speed control for ac heater lost 3 of 4 speeds. Only high speed works. New part #15238515 is $400 plus labor. Will try to replace with a used part. Vehicle has 39,500 miles. 2004 Chevy Colorado 5 cyl. Auto.

- Valencia, CA, USA

Search CarComplaints.com for these popular complaint phrases...

Not what you are looking for?