[ switch models ] 2006 Chevrolet Aveo 2006 Chevrolet Cobalt 2006 Chevrolet Colorado 2006 Chevrolet Epica 2006 Chevrolet Equinox 2006 Chevrolet Impala 2006 Chevrolet Malibu 2006 Chevrolet Monte Carlo 2006 Chevrolet Novo Vectra 2006 Chevrolet Optra 2006 Chevrolet Silverado 2006 Chevrolet Suburban 2006 Chevrolet Tahoe 2006 Chevrolet Tavera 2006 Chevrolet Trailblazer 2006 Chevrolet Uplander [ switch years ] 2008 Chevrolet HHR 2007 Chevrolet HHR

2006 Chevrolet HHR

2006 Chevrolet HHR TSBs (Technical Service Bulletins)

There are also 3 Chevrolet recalls » 56 TSBs » for the Chevrolet HHR.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING

• TSB #050232005 -- EI05093 - CLUNK NOISE IN STEERING SYSTEM AT SLOW SPEEDS WHILE TURNING AND/OR DRIVING OVER BUMPS. *TT (REPLACE INTERMEDIATE SHAFT). UPDATED 10/05/07. *NJ UPDATED 11/02/07 *NJ (NHTSA ID #10017497, SEPTEMBER 01 2007)
• TSB #070232007 -- DIAGNOSTIC TIPS FOR POWER STEERING INOPERATIVE/STEERING WHEEL HARD TO TURN, POWER STEERING MESSAGE DISPLAYED ON DIC, DTC'S C0176, C0176, C0475, C0476, C0550, U2105, U2107 SET. *NJ (NHTSA ID #10022958, AUGUST 01 2007)
• TSB #060232002 -- NORMAL OPERATING CHARACTERISTICS OF ELECTRIC POWER STEERING (EPS) SYSTEM DURING EXTENDED LOCK-TO-LOCK (MAXIMUM STEERING WHEEL ROTATION) USAGE. *TT (NHTSA ID #10019478, DECEMBER 01 2006)
• TSB #050235007 -- INFORMATION ON INADVERTENT TURNING OF KEY CYLINDER, LOSS OF ELECTRICAL SYSTEM AND NO DTC'S. *KB (NHTSA ID #10020951, OCTOBER 01 2006)
• TSB #050232002 -- POWER STEERING INOPERATIVE/STEERING WHEEL HARD TO TURN, PWR STR DISPLAYED ON DRIVER INFORMATION CENTER (DIC). AFTER JUMP STARTING THE VEHICLE. *KB (NHTSA ID #10020740, SEPTEMBER 01 2006)
• TSB #050232002A -- POWER STEERING INOPERATIVE/STEERING WHEEL HARD TO TURN, PWR STR MESSAGE DISPLAYED ON DRIVER INFORMATION CENTER (DIC) AFTER JUMP STARTING VEHICLE. *TT (NHTSA ID #10017423, OCTOBER 01 2005)

STEERING:COLUMN

• TSB #070235004 -- STEERING COLUMN RATTLE OR KNOCKING NOISE AT LOW SPEEDS (DIAGNOSIS AND REPLACE STEERING COLUMN, IF NECESSARY) *NJ (NHTSA ID #10023214, SEPTEMBER 01 2007)
• TSB #4145 -- STEERING COLUMN POP/RATTLE CONCERNS. *KB (NHTSA ID #10020589, no date provided)
• TSB #4070 -- STEERING COLUMN RESTRICTION. *TT (NHTSA ID #10020054, no date provided)

STEERING:HYDRAULIC POWER ASSIST SYSTEM

• TSB #3678 -- POWER STEERING INOPERATIVE DUE TO OPEN FUSE. *SC (NHTSA ID #10016956, no date provided)

SUSPENSION

• TSB #3687 -- CLUNK NOISE FROM FRONT OF VEHICLE DURING TURNING MANEUVER. *SC (NHTSA ID #10016948, no date provided)

ENGINE AND ENGINE COOLING

• TSB #3786 -- NO START AFTER ENGINE HARNESS REPLACEMENT (NON-ABS). *TT (NHTSA ID #10018600, no date provided)
• TSB #3634A -- SES LIGHT DUE TO A P0326 DTC - INSTALL NEW ECM CALIBRATION. *TT (NHTSA ID #10018581, no date provided)
• TSB #3646A -- SES LIGHT DUE TO DTCS P1516 AND P1682 - ECM CALIBRATION PENDING. *TT (NHTSA ID #10018604, no date provided)
• TSB #3642 -- SES LIGHT WITH A P0230 DTC AND NO PERFORMANCE CONCERNS - REPLACE ECM. *TT (NHTSA ID #10018533, no date provided)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #PIP4310 -- INTERMITTENT SES LIGHT DUE TO DTC'S P060E, P2135, AND/OR P2138. *NJ UPDATED 5/12/08. *NJ (NHTSA ID #10023997, APRIL 01 2008)
• TSB #4110 -- LONG CRANK, ENGINE WILL NOT START. *KB UPDATED 1/30/08. *NJ (NHTSA ID #10022361, DECEMBER 01 2007)
• TSB #060604033 -- ENGINE MALFUNCTION INDICATOR LAMP (MIL)/SERVICE ENGINE SOON (SES) LAMP ILLUMINATED WITH DTC P0171. *KB (NHTSA ID #10020838, JUNE 01 2006)
• TSB #050604073 -- CHECK ENGINE LIGHT MALFUNCTION INDICATOR LAMP ILLUMINATED, USUALLY WITHOUT DRIVEABILITY SYMPTOMS, DIAGNOSTIC TROUBLE CODES P0128, P0326, PO420, P0717, P2431 SET ON L61 ENGINE (FOLLOW SI, AND IF NECESSARY, REPROGRAM ENGINE CONTROL MODULE (EC (NHTSA ID #10019583, DECEMBER 01 2005)
• TSB #3404 -- MACHINING DEBRIS ON THE OIL FILTER ELEMENT. *SC (NHTSA ID #10016822, no date provided)
• TSB #3802 -- SES LIGHT AND ENGINE MISFIRE - INSPECT #4 IGNITION COIL CONNECTION. *TT (NHTSA ID #10020074, no date provided)
• TSB #3666 -- START AND STALL ONLY WHEN STARTING WITH REMOTE START - REPLACE ECM. *TT (NHTSA ID #10018928, no date provided)
• TSB #3310D -- SERVICE ENGINE SOON (SES) LIGHT DUE TO A P0171 - INSPECT AIR INTAKE AND OIL DIPSTICK. *TT (NHTSA ID #10017261, no date provided)
• TSB #3433 -- SERVICE ENGINE SOON (SES) LIGHT AND SEVERE ENGINE MISFIRE ON CYLINDERS 1 AND 4 OR CYLINDERS 2 AND 3. *TT UPDATED 08-15-07. *KB (NHTSA ID #10017032, no date provided)
• TSB #3859 -- LOW OIL PRESSURE - INSPECT OIL FILTER FOR DAMAGE. *KB UPDATED 10/18/07. *NJ (NHTSA ID #10020923, no date provided)
• TSB #3667 -- START AND STALL ONLY WHEN STARTING WITH REMOTE START - CALIBRATION PENDING. *TT (NHTSA ID #10018927, no date provided)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

• TSB #3562C -- SERVICE ENGINE SOON LIGHT DUE TO P0420 DIAGNOSTIC TROUBLE CODE ON LOW MILEAGE VEHICLES - UPDATE ECM CALIBRATION. *TT (NHTSA ID #10018539, no date provided)

FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM

• TSB #3720 -- FUEL LEVEL DIAGNOSTICS/SPECS INACCURATE. *TT (NHTSA ID #10017695, no date provided)

POWER TRAIN:MANUAL TRANSMISSION

• TSB #070729001 -- MG3, M86 TRANSAXLE GRINDING/WHINING NOISE IN 3RD OR 4TH GEAR, EXCESSIVE ENGAGEMENT OR DISENGAGEMENT EFFORT WHILE SHIFTING INTO 3RD OR 4TH GEAR, WILL NOT SHIFT INTO EITHER 3RD OR 4TH GEAR. (REPLACE COMPLETE OUTPUT SHAFT ASSEMBLY). *KB (NHTSA ID #10021453, APRIL 01 2007)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #070730025 -- INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. *NJ (NHTSA ID #10023942, OCTOBER 01 2007)

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

• TSB #070730005 -- 4T45 TRANSMISSION, MIL/SES ON, DTC P1818, POWER DOOR LOCKS, CRUISE CONTROL, SHIFT INTERLOCK OR RETRACTABLE HARDTOP INOPERATIVE, ENGINE SPEED REVS LIMITED, HYBRIDS-AUTOSTOP, REGEN OR BOOST INOPERATIVE. (REPROGRAM TCM). *KB UPDATED 1 (NHTSA ID #10022473, SEPTEMBER 01 2007)
• TSB #050730016 -- TRANSMISSION CONTROL MODULE (TCM) SHORTED TO BATTERY VOLTAGE DURING DIAGNOSIS AND/OR SERVICE. *TT UPDATED. *NM (NHTSA ID #10017512, NOVEMBER 01 2005)
• TSB #3867 -- POSSIBLE INTERMITTENT NO CRANK. *AK (NHTSA ID #10019232, no date provided)

ELECTRICAL SYSTEM

• TSB #3683 -- SES LIGHT DUE TO DIAGNOSTIC TROUBLE CODES P1682-REPROGRAM ECM. *AK (NHTSA ID #10019227, no date provided)
• TSB #3629 -- PROGRAMMING ALERT: PROGRESS BAR ON TECH 2 MAY NOT DISPLAY 100%. *TT (NHTSA ID #10018541, no date provided)

ELECTRICAL SYSTEM:WIRING

• TSB #08-06-04-022 -- INTERMITTENT CHECK ENGINE LIGHT ON, ENGINE POWER REDUCED MESSAGE DISPLAYED IN DIC, DTC P2135 SET (INSPECT ENGINE WIRING HARNESS FOR CHAFING AND RECRIMP ECM TERMINALS, IF NECESSARY). *NJ UPDATE 8/7/2008. *PE (NHTSA ID #10024788, APRIL 01 2008)
• TSB #060604045 -- NO START, LONG CRANK, LOSS OF ENGINE POWER, DISCHARGED BATTERY, CHECK ENGINE LIGHT ILLUMINATES, ENGINE POWER REDUCED MESSAGE DISPLAYED, DTC'S SET. *KB (NHTSA ID #10020728, SEPTEMBER 01 2006)

ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

• TSB #070845003 -- INTERMITTENT NO START/LONG CRANK, START THEN STALL, CHECK ENGINE LIGHT ON, INTERMITTENTLY FUNCTIONING OR INOPERATIVE ELECTRICAL SYSTEMS, DTC P0442 OR P0449 SET (INSPECT UBEC AND REPLACE CONNECTORS AS NECESSARY) *NJ (NHTSA ID #10023219, SEPTEMBER 01 2007)
• TSB #3648 -- HESITATION ON ACCELERATION AFTER INTERNAL ENGINE REPAIRS - CHECK INJECTOR HARNESS ORIENTATION. *TT (NHTSA ID #10018915, no date provided)

ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS

• TSB #4578 -- EPS/STR WHEEL CONTROL FUSE (#19) OPEN. *KB UPDATED 10/04/07. *NJ (NHTSA ID #10022806, no date provided)
• TSB #3981 -- REPEATED PARK LPS FUSE OPEN. *TT (NHTSA ID #10019827, no date provided)

DIGITAL INSTRUMENT PANEL

• TSB #060849016 -- INSTRUMENT PANEL CLUSTER (IPC) BACKLIGHTING INOPERATIVE DURING DAYLIGHT HOURS. *KB (NHTSA ID #10020735, SEPTEMBER 01 2006)
• TSB #3799 -- SIR LIGHT ON/SERVICE AIRBAG WARNING MESSAGE WITH DTC B0081. *TT UPDATED 03-01-07. *KB UPDATED 04-06-07. *KB (NHTSA ID #10020228, no date provided)

EXTERIOR LIGHTING

• TSB #070847002 -- PARK LAMPS DO NOT ILLUMINATE INTERMITTENTLY DURING A REMOTE VEHICLE START (REPLACE BCM). *KB (NHTSA ID #10021334, FEBRUARY 01 2007)
• TSB #3393A -- BACKLIGHTING IS INOP DURING DAYLIGHT CONDITIONS (HEADLIGHT SWITCH TURNED ON MANUALLY) *SC (NHTSA ID #10017006, no date provided)

EXTERIOR LIGHTING:BACK UP LIGHTS

• TSB #3859 -- PARK LAMPS DO NOT COME ON SOMETIMES AFTER A REMOTE START. *AK (NHTSA ID #10019277, no date provided)

EXTERIOR LIGHTING:BRAKE LIGHTS

• TSB #3956 -- RED BRAKE LIGHT/LOW BRAKE FLUID MESSAGE ON INTERMITTENTLY. *KB UPDATED ON 12/10/07. *NJ (NHTSA ID #10021396, OCTOBER 01 2007)

VISIBILITY:SUN ROOF ASSEMBLY

• TSB #3757 -- SUNROOF INOPERATIVE BINDING OR STUCK. *TT (NHTSA ID #10018645, no date provided)

VISIBILITY:REAR WINDOW WIPER/WASHER

• TSB #3860 -- REAR WIPER NOT WORKING PROPERLY. *AK (NHTSA ID #10019234, no date provided)

AIR BAGS

• TSB #4011 -- AIR BAG INDICATOR LIGHT IS ON. *KB UPDATED ON 12/13/07. *NJ (NHTSA ID #10020881, DECEMBER 13 2007)

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

• TSB #3799A -- SIR LIGHT ON/SERVICE AIR BAG WARNING MESSAGE WITH DIAGNOSTIC TROUBLE CODE B0081. *AK (NHTSA ID #10019210, no date provided)

STRUCTURE:BODY:HATCHBACK/LIFTGATE

• TSB #060866003 -- LIFTGATE HANDLE (REAR TOUCH PAD) INOPERATIVE OR DOES NOT OPEN LIFTGATE. *TT (NHTSA ID #10019484, FEBRUARY 01 2006)

EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

• TSB #05083 -- ONSTAR SYSTEM INOPERATIVE. *SC (NHTSA ID #10017079, AUGUST 01 2005)

EQUIPMENT:ELECTRICAL:AIR CONDITIONER

• TSB #050138016 -- WATER LEAKING ON FRONT PASSENGER SIDE FLOOR OF VEHICLE, WATER BLOWING OUT OF VENTS (SEAL HEATER CORE COVER). *NM (NHTSA ID #10018663, NOVEMBER 01 2005)

UNKNOWN OR OTHER

• TSB #070857001 -- FRONT AND REAR CARPET WET/BLOWER MOTOR INOPERATIVE (RESEAL BODY SEAMS) *NJ (NHTSA ID #10023224, SEPTEMBER 01 2007)
• TSB #4014 -- PARTS UPDATE - TIMING CHAIN TENSIONER DESIGN CHANGE. *KB (NHTSA ID #10021074, no date provided)