NHTSA Campaign #07E021000 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

MARCH 12
2007

742 vehicles recalled

2002 CHEVROLET MALIBU -- Certain delphi fuel pressure regulators, P/nos. FP10020-11B1, FP10026-11B1, and FP10027-11B1, sold after January 9, 2007, as aftermarket equipment for various passenger vehicles listed above. The universal pressure regulators (upr) were produced without an O'ring and retainer.

Fuel may leak, possibly resulting in a fire.

Delphi will notify owners and replace the upr free of charge. The recall began on April 23, 2007. Owners can contact delphi at 877-411-8770. For detailed information & supporting documents, see the official NHTSA page concerning recall #07E021000 »

NHTSA Campaign #02V107000 EXTERIOR LIGHTING:HEADLIGHTS

APRIL 10
2002

10,168 vehicles recalled

2002 CHEVROLET MALIBU -- Certain passenger vehicles fail to conform to Federal Motor Vehicle Safety Standard no. 108, "Lamps, Reflective Devices, And Associated Equipment." Some of these vehicles were produced with a left low-beam headlamp that does not meet the photometric performance requirements of the standard.

Light intensities below the minimum intensity requirements cause reduction in visibility down the road for the driver of the vehicle and intensities above the maximum intensity requirements cause increase in glare for drivers ahead of, or approaching, the vehicle.

Dealers will inspect the left low-beam headlamp and replace it if it does not meet requirements. Owner notification began May 23, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Chevrolet at 1-800-222-1020. For detailed information & supporting documents, see the official NHTSA page concerning recall #02V107000 »