Print this page

10.0

really awful
Crashes / Fires:
3 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
13,431 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2004 Chevrolet Malibu steering problems

steering problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2004 Chevrolet Malibu:

Unsubscribe any time. We don't sell/share your email.

2004 Chevrolet Malibu Owner Comments (Page 6 of 7)

« Read the previous 20 complaints

problem #39

Jul 062004

Malibu

  • Automatic transmission
  • miles

A D V E R T I S E M E N T S

While driving at any speed power steering failed. This caused the driver to have difficulty in steering, but was able to maintain control of the vehicle. It was taken to the dealer for inspection, and mechanic determined that the steering column needed to be replaced. Ea04018_cat

- Paducah, KY, USA

problem #38

Jul 052004

Malibu 6-cyl

  • Automatic transmission
  • 5,700 miles
While driving my 2004 Chevy Malibu my steering wheel started to jerk back and forth, this would happen when turning right. At low speeds. I also had the ABS brake light come on intermittently, the dealership was able to verify the brake light problem due to a recall and the steering also was verified. This resulted in replacement of the "rack is what the dealer called it." I have noticed this is a problem on many 2004 Malibu. Chevrolet had bettter look into thisand take appropriate action before it results in death and major legal action. Ea04018_cat.

- Silverdale, WA, USA

problem #37

Jul 122004

Malibu 4-cyl

  • Automatic transmission
  • miles
Electric power steering failed and the vehicle became very difficult to steer. Sport Chevrolet said they had heard of this defect before. They told my wife to turn the car and then turn the car on again. This solved the problem. This "fix" leaves something to be desired, especially if you are driving on the highway. Ea04018_cat.

- Silver Spring, MD, USA

problem #36

Jun 212004

Malibu 4-cyl

  • Automatic transmission
  • 129 miles

A D V E R T I S E M E N T S

Traveling down street at low speed when a sudden but light jolt from the engine is felt. Moments later slowing down for a traffic light total lose of electrical power. This does not happen all the time. Vehicle is in for repairs on this date. Ea04018_cat

- Biloxi, MS, USA

problem #35

Jun 222004

Malibu 6-cyl

  • Automatic transmission
  • 10,509 miles
Driving the vehicle down the road at 45 mph. Everything was operating normally and all driving was normal. The steering wheel started moving violently to the right, pulling the wheel from my hand. While trying to slow the vehicle down to turn off the road, the steering was lost. I could not steer the vehicle. Approximately 15 seconds later; the car chimed, the check engine light came on, and on the computer display on the stereo the words "power steering" were displayed. At this time I was able to turn the vehicle off the road by using great force on the wheel. I did not get into an accident because the road was straight and had plenty off room and little traffic. The vehicle is new, purchased in Feb 2004 and has 10,500 miles on it. This is the first time this has happened. Ea04018_cat

- Alamogordo, NM, USA

problem #34

Jun 172004

Malibu 6-cyl

  • Automatic transmission
  • 5,600 miles
While making a right turn, the steering wheel failed. A light for the steering wheel flashed on the dashboard and remained on. The consumer was able to maintain control of the vehicle and drove it to the dealer. The mechanic informed the consumer that the cause of the problem had not been determined. Pe04031_cat the steering column was replaced.

- Pittsburgh, PA, USA

problem #33

Feb 022004

Malibu

  • 5,000 miles

A D V E R T I S E M E N T S

The consumer felt severe vibrations in the steering column. The vehicle could not be controlled normally by the steering column. The dealer examined the vehicle and replaced the steering column. The vehicle already had three steering columns replaced on the vehicle since February. The steering column recently locked up and caused the consumer to jump the curb and almost struck several pedestrians. There were no injuries involved but there was some damage done to the vehicles bumper. Pe04031_cat

- Virginia Beach, VA, USA

problem #32

Jan 112004

Malibu 6-cyl

  • Automatic transmission
  • 5,465 miles
I was in the middle of an intersection making a left turn, and my check engine" light engaged, my center information console read "power steering", and my steering became very stiff. I managed to get the vehicle to my home (less than 1 mile away), and had the vehicle towed to bob bell Chevrolet (East point) location. The car was out of service until January 29, 2004, at which time I signed a repair order that states that the service department found "code 0545", and replaced the power steering column. This service as covered by my factory warranty, since the car was only 90 days old. On June 7, 2004, again while making a left turn in the middle of a very busy intersection (philadelphia road and rossville blvd in rosedale, md), my power steering failed in the same exact manner as the previous occurance. However, this was more serious because I nearly hit a Ford F-150 head on. I had the vehicle again towed to bob bell Chevrolet-eastpoint. They are now stating that the problem has been fixed again, but I am not picking the car up because I am too scared to drive it. I have filed a claim with the BBB, sent a certified letter to gmac (return receipt requested), and verbally filed a case with gmac customer relations (1-224-501-301). Pe04031_cat

- Rosedale, MD, USA

problem #31

Jun 032004

Malibu 6-cyl

  • Automatic transmission
  • miles
Power steering failure while vehicle in motion. Occurred approx. 10 times since purchase 6 months ago. Power steering usually resumes after vehicle turned off for a few minutes. No damage/injuries. Left vehicle at dealership May 26, 2004. After two days, service dept. Claimed they could not replicate, therefore they could not resolve. Told me to bring it back when it happens more frequently. At various speeds, power steering failed approx 5 times between 5/26 & 6/3. took vehicle back to dealership 6/7, where it remains. Service dept. Now says it's a "known issue" and placed an order for a new steering column. Pe04031_cat.

- Rochester, NY, USA

problem #30

Apr 082004

Malibu 6-cyl

  • Automatic transmission
  • miles
I purchased my 2004 Malibu from frank parra Chevrolet in dallas, tx. I spoke with the service advisor there to inform them of the steering issue. When you turn either direction the car will continue in that direction unless you manually turn it to center your self. The advisor told me that it could be one of two things 1) the Contour of the road, 2) how the car was tied down on the deliver truck that has caused the alignment to be out of wack. If the second response is true then wait for 500 miles, if the steering doesn't change then they will perform a all wheel alignment on it. Well 500 miles came and went and there was no change in the steering. The advisor says the the head technician stated due to the steering being electrical that is how it will drive, it is perfectly normal. I didn't like that response so I spoke with the manager of the service department and he suggested that I test drive another vehicle to see if there was a difference. I did that and the newer vehicle drove totally different than mine but the advisor refused to do anything about it so a couple of weeks later the steering locked up while driving on the freeway at 65 miles per hour. I had absolutely no power to the steering. Fortunately I was on my way to another dearlership and they checked it out for me but once you turned the vehicle off and on again the power came back. Since then I have had the maintenance light come on for service. It has been checked out and serviced. The steering is still returning to center after directional turns. Pe04031_cat.

- Dallas, TX, USA

problem #29

Jun 062004

Malibu 6-cyl

  • Automatic transmission
  • 9,750 miles

A D V E R T I S E M E N T S

I have a 6 mos old 2004 Chevy Malibu ltv6 (10,000 miles). The electric steering is giving me some concerns. When I'm at a stop light the wheel wants to turn. Not far just more like a shake back and forth. If you let go you can see and hear it rattle. Probably moves 1/4 inch. Back and forth. Then if you really pay attention you can feel it when you are driving. Finally, the power steering cut off all together at high speeds. This all happened after the car sat in a parking lot for 8 days. Any idea's? pe04031_cat

- Palm Coast, FL, USA

problem #28

Jun 042004

Malibu 6-cyl

  • Automatic transmission
  • 28,000 miles
I had noticed while driving that the words "power steering" had come across my display and an orange light with a wrench came up on the dash in the bottom left corner. When I first noticed this problem a few months ago, I took the car back to the dealer where I purchased the car. They told me the sensors were faulty, and they need to replace them. To my knowledge they replaced the sensors in the stirring column. I thought the problem was fixed. Today while I was sitting still in a drive through at a restaurant, the light came on again, and I saw "power steering" come across the display again. My car became extremely hard to turn and I drove it to the nearest Chevrolet dealership which was about 2 miles away from the restaurant. One of the workers at the dealership drove my car into the area where they repair them and the light went off, but came back on. I am still waiting to find out what caused this problem. I also have had a problem with my air conditioner button getting stuck in position. Pe04031_cat

- Greenfield, TN, USA

problem #27

May 292004

Malibu 6-cyl

  • Automatic transmission
  • 6,833 miles
Stopped at a service station to refuel, when I restarted the auto and started to leave, the "service vehicle soon light" came on, a chime sounded, and the"driver information center displayed the following message"power steering" the steering wheel became very difficult to turn. I turned off the auto and restarted. Everything appeared normal but a few minutes later, the problem repeated. I was only 1 mile from home and was able to drive the car home but with great difficulty steering.the following day I started the car an let it run for 10 minutes but the problem did not repeat. I have not driven the car since 5/29/2004. On 06/01/2004 I drove the car to the dealer(distance:1-1/2 miles) jackson Chevrolet, South main St middletown, ct. 06457 the problem did not occur. I am presently waiting for the service dept. To call me.the reason I am sending you this complaint before I hear from the dealer, is: I have read 25 other complaints on your web site about 2004 Chevrolet Malibu electric assist power steering and it appears that neither the dealers or Chevrolet division of General Motors really knows why this is happening or has a 100% fix! there is no dought in my mind that this is a very serious safety issue and I hope you get Chevrolet division of General Motors to get this problem fixed fast or get these Malibu's off the road before someone gets into a serious accident or still worse, gets killed!! pe04031_cat

- Middletown, CT, USA

problem #26

May 112004

Malibu

  • Automatic transmission
  • 20 miles
While driving the vehicle suddenly lost power steering which made it turning the steering wheel very difficult. The dealership replaced the power steering, but the problem still exist. Pe04031_cat

- Naples, FL, USA

problem #25

May 142004

Malibu

  • 5,800 miles
While driving at any speed steering whee shook violently four times in four weeks. Dealer has examined the vehicle and will replace the steering column. Pe04031_cat

- Huntington Beach, CA, USA

problem #24

Apr 062004

Malibu 6-cyl

  • Automatic transmission
  • 29 miles
My power steering fails while driving. This happens many times. I have to stop the car and restart it to bring back the power steering. It will work for awhile, then fail again at a random time. Pe04031_cat

- Dexter, MI, USA

problem #23

May 082004

Malibu

  • 8,590 miles
While driving 35 mph driver lost power steering. Consumer was able to maintain control of the vehicle and pulled over. Consumer turned off the vehicle, restarted it, and drove vehicleto the dealer for inspection. Dealer was unable to resolve the problem. Pe04031_cat

- Vincentown, NJ, USA

problem #22

Apr 212004

Malibu 6-cyl

  • Automatic transmission
  • 5,500 miles
Had power steering fail on three occasions. Service light comes on in dashboard (car with wrench) and "power steering" displayed on information center. Steering became very difficult. After pulling over, turned off ignition. When restarted, everything normal. Both occurences at slow speed, thank goodness! brake warning light appeared intermittently on panel, and directionals did not work. Turned off ignition and restarted - all back to normal. Brought to dealer, who had for over 1 week. Replaced "BCM" (body control module) and rerouted harness to obtain slack in cable. Three days after service, power-steering problem occured again. Currently returning for service. This problem is a definite safety hazard. Pe04031_cat

- Arlington Heights, IL, USA

problem #21

May 032004

(reported on)

Malibu

  • 2,000 miles
Engine check light came on, and the steering went out. It did not move in either direction. Vehicle was towed to the dealer, who claimed it was too soon to determine any defect. Pe04031_cat

- Elkhart, IN, USA

problem #20

May 022004

Malibu 6-cyl

  • 8,653 miles
While driving, the power steering failed. The consumer explained that the steering became extremely difficult. Pe04031_cat a component was replaced in the steering column. The consumer stated the power steering is electrical.

- Effort, PA, USA

Read the next 19 complaints »

Not what you are looking for?