- July 24: GM Recalls Buick, Chevy and GMC Vehicles For Rollaway Risk recalls | 5 days ago
- July 21: GM Recalls 308,000 Chevy Impalas in the U.S. and Canada recalls | 8 days ago
- July 18: Chevy Cruze Diesel Emissions Lawsuit Says Cars Are Illegal news | 11 days ago
- June 7: Sports Car Crash-Test Ratings All Over the Place news | 52 days ago
- June 3: GM Recalls 1.9 Million Vehicles the Automaker Says Are Safe recalls | 56 days ago
2005 Chevrolet Malibu
6 Recalls & Safety Reports
Recall List for the 2005 Chevrolet Malibu
Official recalls have been issued for the 2005 Chevrolet Malibu by the NHTSA. The complete details of all recalls are listed below, along with what they cover and the recommended solutions.
Recalls don't cost you anything to get fixed, but most are time-limited, so if your car is affected you should call your local Chevrolet service department immediately!
If you have questions about a recall, write down your VIN & then call Chevrolet customer service.
2005 Chevrolet Malibu STEERING NHTSA Campaign #14E044000
Summary: Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
Consequence: A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Actions: Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492. For detailed information & supporting documents, see the official NHTSA page concerning recall #14E044000 »
2005 Chevrolet Malibu SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT, ELECTRICAL SYSTEM:WIRING, EXTERIOR LIGHTING:BRAKE LIGHTS, VEHICLE SPEED CONTROL:CRUISE CONTROL, ELECTRONIC STABILITY CONTROL NHTSA Campaign #14V252000
Summary: General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Actions: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036. For detailed information & supporting documents, see the official NHTSA page concerning recall #14V252000 »
2005 Chevrolet Malibu POWER TRAIN:AUTOMATIC TRANSMISSION, POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT NHTSA Campaign #14V224000
Summary: General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the ┐PARK┐ position, the transmission may not be in ┐PARK.┐ If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Actions: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152. For detailed information & supporting documents, see the official NHTSA page concerning recall #14V224000 »
2005 Chevrolet Malibu STEERING:ELECTRIC POWER ASSIST SYSTEM NHTSA Campaign #14V153000
Summary: General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Actions: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle. For detailed information & supporting documents, see the official NHTSA page concerning recall #14V153000 »
2005 Chevrolet Malibu FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP NHTSA Campaign #11E009000
Summary: Ti automotive is recalling certain fuel pumps, part numbers TU456 and TU303, sold under various brand names as aftermarket and replacement equipment for the motor vehicles listed above. The defective fuel pump may seize, stopping the fuel flow to the engine creating a stalling condition.
Consequence: A vehicle crash could occur should the engine stall while in use.
Actions: Ti automotive will notify owners of record and will replace any defective fuel pump with a new or reworked fuel pump free of charge. The safety recall began on February 22, 2011. Owners may contact ti automotive at 1-866-867-3759 or log on to www.recallresponse.com. For detailed information & supporting documents, see the official NHTSA page concerning recall #11E009000 »
2005 Chevrolet Malibu EXTERIOR LIGHTING NHTSA Campaign #09E012000
Summary: Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment." These lamps do not contain the required amber side reflectors.
Consequence: Decreased lighting visibility may result in a vehicle crash.
Actions: Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on May 11, 2009. Owners may contact sabersport at 1-909-598-7589. For detailed information & supporting documents, see the official NHTSA page concerning recall #09E012000 »
Browse Other Malibu Years
- 2016 Chevrolet Malibu
- 2015 Chevrolet Malibu
- 2014 Chevrolet Malibu
- 2013 Chevrolet Malibu
- 2012 Chevrolet Malibu
- 2011 Chevrolet Malibu
- 2010 Chevrolet Malibu
- 2009 Chevrolet Malibu
- 2008 Chevrolet Malibu
- 2007 Chevrolet Malibu
- 2006 Chevrolet Malibu
- 2005 Chevrolet Malibu
- 2004 Chevrolet Malibu
- 2003 Chevrolet Malibu
- 2002 Chevrolet Malibu
- 2001 Chevrolet Malibu
- 2000 Chevrolet Malibu
- 1999 Chevrolet Malibu