Huge win for car owners! All TSBs to be made public. The Center for Auto Safety just made the NHTSA (US Government) make public the full text of all TSBs from now on. They are the same organization that has petitioned the NHTSA & filed lawsuits to protect car owners over exploding gas tanks & other major safety issues. Whenever you drive in your car, you are safer thanks in part to a lot of work over the years by this small but very effective consumer advocacy group.

Please take a moment & say thank you by donating $5 or whatever you can to the Center for Auto Safety.

2.7

hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
54,600 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2005 Chevrolet Silverado 1500 Hybrid body / paint problems

body / paint problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2005 Chevrolet Silverado 1500 Hybrid:

Unsubscribe any time. We don't sell/share your email.

2005 Chevrolet Silverado 1500 Hybrid Owner Comments

problem #5

Apr 242012

Silverado 1500 Hybrid

  • 104,000 miles

A D V E R T I S E M E N T S

The contact owns a 2005 Chevrolet Silverado 1500. The contact was driving 55 mph when the frame bed of the vehicle dropped. The contact then pulled over and noticed that the spring shackles to the frame were fractured. The vehicle was taken to an authorized dealer where they advised that there was corrosion on the frame and offered no assistance in repairing the vehicle. The manufacturer was not made aware of the failure and the vehicle was not repaired. The failure mileage was 104,000 and the current mileage was 108,617.

- Lakeland, PA, USA

problem #4

Jul 282010

Silverado 1500 Hybrid

  • miles
Letter from senator on behalf of constituent re problems with 2005 Chevy Silverado. Dot/I#2010-1208. The consumer stated his vehicle has severe corrosion on the frame. Within two yeas, the entire undercarriage had corroded, which caused the brakes and power steering to fail catastrophically. The consumer sued alleging breach of warranty. The case was heard, however GM experts testified that the corrosion was caused by sea air and they were not under any obligation to cover corrosion caused by the environment. They also testified that the corrosion was primarily cosmetic and that the vehicle was in good driving condition. The consumer stated two days later, as he attempted to drive the vehicle to a repair shop, the brake lines ruptured and the drive shaft sheared in half, nearly causing a major accident.

- Melbourne Beach, FL, USA

problem #3

Sep 182009

Silverado 1500 Hybrid

  • 103,000 miles
The contact owns a 2005 Chevrolet K1500 Silverado. The contact stated that upon routine inspection, a technician concluded that the frame had fractured due to stress from the lift kit installed on the vehicle. He then added that the previous dealer( Southern Comfort conversions) installed the lift kit and that it would cost $11,000 for repairs.the manufacturer was contacted, but because the warranty expired they would not provide any assistance. The failure and current mileages were 103.000.

- Warmsprings, GA, USA

problem #2

Sep 272007

Silverado 1500 Hybrid 4WD 8-cyl

  • Automatic transmission
  • 46,000 miles
The contact owns a 2005 Chevrolet Silverado 1500. While driving 35 mph, the front end vibrated violently. The contact inspected the vehicle and noticed that the frame split in half. As of October 1, 2007, the dealer had not inspected the vehicle to determine the cause of failure. The current and failure mileages were 46,000. Updated 10/24/07.

- Lagrange, GA, USA

problem #1

Oct 012006

Silverado 1500 Hybrid 6-cyl

  • Manual transmission
  • 20,000 miles
When the temp outside is about 40 degrees or cooler, something under the vehicle rattles(driver front). This rattling is metal on metal, and sounds like rapidly banging 2 steel cans together. The noise dissipates after driving the vehicle for about 10 minutes, but is quite noticeable when going over bumps in the road during the first 10 mins of usage.

- Tucson, AZ, USA

Not what you are looking for?