If you find CarComplaints.com is helpful ... We rely completely on word of mouth. Talk about us on Facebook, Twitter, tell your mother-in-law. Help us help more people.

Print this page
2003 Chevrolet Suburban electrical problems: speedometer cluster not working

Speedometer Cluster Not Working

7.2

pretty bad
Typical Repair Cost:
$229.00
Average Mileage:
86,094 miles
Total Complaints:
12 complaints

Most Common Solutions:

  1. not sure (4 reports)
  2. new cluster for the speedometer (3 reports)
  3. replace the stepper motor in gauge assembly (2 reports)
  4. buy a new stepper motor on ebay (1 reports)
  5. re solder new stepper motor onto circuit board (1 reports)
  6. use GPS that shows speed (1 reports)
2003 Chevrolet Suburban electrical problems

electrical problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2003 Chevrolet Suburban:

Unsubscribe any time. We don't sell/share your email.

2003 Chevrolet Suburban Owner Comments

problem #12

Jan 142013

Suburban LT 5.3L V8

  • Automatic transmission
  • 82,000 miles

A D V E R T I S E M E N T S

Just went down the road heading to work, when suddenly I looked down and the thing was stuck at 100 MPH. When I came to a stop it was at 80 MPH. Eventually it seized at "130" MPH (past the 120 mark) and stayed there. I took the dash out, and the motor was completely seized. De-soldered the motor and replaced, voila! No more stuck dash. Still would have been nicer if it was covered under a warranty/recall thing.

- , Southern, VA, USA

problem #11

Apr 212006

Suburban LTD

  • Automatic transmission
  • 63,000 miles

received a notice (not a recall) but chevrolet would fix the problem if car had 62,000 miles or less. I had taken the car in and could show the speedometer had gone out within the mileage range but chevrolet would not fix the problem. By this time our vehicle had 80,000 miles. So not a happy camper.

We have driven chevrolet auto mostly suburbans since we married in 1960 - Think it is time to change. Service to an account means a lot.

- , Mabelvale, AR, USA

problem #10

Jun 062009

Suburban

  • Automatic transmission
  • 75,000 miles

I bought stepper motors on ebay from a great seller, he included directions. You do not have to be a 'car guy' to fix these! They are an easy fix!!

- , Lindale, TX, USA

problem #9

Jan 142009

Suburban LT V8

  • Automatic transmission
  • 90,000 miles

A D V E R T I S E M E N T S

I was not yet done paying off my vehicle when the speedometor was not working. I took the suburban back to the dealership and the service gentleman told me it was the cluster in the dash board the part was appx. $450.00 plus parts and labor.

- , Edinburg, TX, USA

problem #8

Dec 312009

Suburban

  • Automatic transmission
  • 115,130 miles

The hole dashboard just stopped working.the gas gauge,all of the gauges,and my water pump light is on so the dash is messed up.i need 2 know how fast im going and how far i can go.we really come 2 like r cars until stuff like this happens,i need my gauges.i think it wrong 4 big business 2 make money off of us the little people.i mean don't we pay enough with the monthly payments,oil changes,brakes,and so they should do some things just because it came off the line as a default.i don't have money 2 keep paying 4 there(Chevy dealers)mess ups.fix ur cars right cause i don't have money 2 pay 4 there mistakes.

- , Riverside, CA, USA

problem #7

Dec 052007

Suburban LX 5.3L

  • Automatic transmission
  • 100,000 miles

speedometer,oil pressure gauge,fuel gauge,voilt meter gauge,do not work.transmission jerks,steering rattles.the fan motor has a mind of its own.it may be made in America but its not made for Americans.no wonder gm is in so much trouble.

- , San Angelo, TX, USA

problem #6

Jul 012008

Suburban

  • Automatic transmission
  • 90,000 miles

A D V E R T I S E M E N T S

My speedometer would read 10 or 20 mph at a standstill and then 120 mph at highway speeds. It eventually just stopped working altogether

- , Pittsburgh, PA, USA

problem #5

Apr 012009

Suburban 1500 LT 5.3L Flex Fuel

  • Automatic transmission
  • 111,000 miles

I have had the problem with my Suburban's speedometer gradually creeping up until it reads above 120 mph. I noticed that when I start the car, the speedometer will jump down about 10 mph. So for a while I would just start the car a number of times until the speedometer was down to 0. This would work for a while, but I was concerned about the wear and tear on the starter. So, I decided to take apart the instrument cluster and see how it works. Turns out, each needle is controlled by a "stepper motor". This is a motor that is designed to take electrical pulses to work. There is a pulse up input and a pulse down input. Each gauge uses the identical stepper motor. My stepper motor for the speedometer was showing some wear. It could increase easily, but would stick a bit when decreasing. This would cause the indications to get higher over time. Take a look at the needle when you slow down - does it move smoothly, or sort of jerky? If its jerky, then you have a worn out stepper motor. The cool thing is that these stepper motors are fairly cheap and easy to replace. I found some guy on ebay selling lots of 10 for about $43 bucks. You can de-solder the existing one from the instrument cluster circuit board and just solder the new one back in it's place. I am currently waiting for the stepper motors to arrive. If it works, I will post a followup with pictures and instructions for doing it yourself...

Hope this helps someone out there!

- , Redmond, WA, USA

problem #4

Jun 222007

Suburban LS 5.3L V8

  • Automatic transmission
  • 77,000 miles

The oil pressure gauge was intermittently working then pegged all the way to the right about a year ago when my friend owned the vehicle. Chevy will replace your cluster up to 75000 miles for free. His miles at the time were 84000. He took it in and his extended warranty company said the gauge cluster was a "performance part" and wouldn't replace it under warranty. I read here how to fix it yourself and it took less than an hour to complete: http://www.fullsizechevy.com/forums/general-discussion/tech-articles2/254501-03-06-instrument-cluster-stepper-motor-replacement.html

The parts cost $15 a stepper motor on Ebay or $45 for all 6. I replaced only one, but bought all 6. Figured it was good insurance, and alot cheaper than $550 the dealer wanted!

- , Denver, CO, USA

problem #3

Mar 122008

Suburban Z71 5.3L V6

  • Automatic transmission
  • 78,000 miles

The worst thing about this is when I was at the dealership they commented that they replace these all the time even on the 2007 suburbans but yet no recall?????????

- , Albany, OR, USA

problem #2

Sep 062007

(reported on)

Suburban LX V8

  • Automatic transmission
  • 79,000 miles

Have heard this is a common problem with the Chevy with no recall

- , Victorville, CA, USA

problem #1

Nov 052007

(reported on)

Suburban 1500

  • Automatic transmission
  • 73,000 miles

I have heard on lots of Chevrolet Suburbans that the instrument panels have gone out. My speedometer is the only thing that has went out and it costs $550.00 to fix this. Also fuel tank went out and had to fax that. Never a Surburban again.

- , Arkadelphia, AR, USA

Not what you are looking for?