2004 Chevrolet Trailblazer
2004 Chevrolet Trailblazer TSBs (Technical Service Bulletins)
There are also 2 Chevrolet recalls » 3 defect investigations » 293 TSBs » for the Chevrolet Trailblazer.
Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.
ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.
STEERING
- TSB #040232001 -- RELEASE OF STEERING GEAR STUB SHAFT BEARING KIT FOR SERVICE. *TT UPDATED 08-15-07. *KB UPDATED 10/09/07. *NJ (NHTSA ID #10012694, AUGUST 01 2007)
- TSB #050235006 -- HISS/RUSH NOISE FROM STEERING (STRG) COLUMN AREA. *TT (NHTSA ID #10017371, AUGUST 01 2005)
- TSB #040232007 -- STEERING SYSTEM MOAN, GROAN, SHUDDER AND/OR VIBRATION TYPE NOISE DURING LOW SPEED TURNING MANEUVERS. *TT (NHTSA ID #10017440, DECEMBER 01 2004)
- TSB #3274 -- INSTALLATION OF A POWER STEERING HOSE TO A NEW STEERING GEAR. *EH (NHTSA ID #10011719, no date provided)
- TSB #3928 -- BIND OR SHUDDER ON TURNS. *KB (NHTSA ID #10020914, no date provided)
SUSPENSION
- TSB #05-03-08-007 -- RATTLE, CLUNK, POP, SNAP NOISE FROM FRONT AND/OR REAR SUSPENSION WHILE DRIVING OVER ROUGH, UNEVEN, WASH BOARD ROAD SURFACES. *TT (REPLACE APPROPRIATE STABILIZER LINK(S)). UPDATED 7/11/08. *NJ (NHTSA ID #10017342, APRIL 01 2008)
- TSB #050308014 -- REVISED STABILIZER SHAFT REPLACEMENT. *TT (NHTSA ID #10019013, NOVEMBER 01 2005)
- TSB #020309002B -- INTERMITTENT BOOM, RUMBLING NOISE AND / OR DISTURBANCE HEARD IN PASSENGER COMPARTMENT WHILE DRIVING AT HIGHWAY SPEEDS. *TT (NHTSA ID #10005147, DECEMBER 01 2004)
- TSB #3124 -- UPPER AND LOWER INTERMEDIATE SHAFT PARTS RESTRICTION. *SC (NHTSA ID #10010188, JANUARY 01 2004)
- TSB #01115A -- CLUNK, RATTLE NOISE FROM FRONT OF VEHICLE OVER BUMPS. *TT (NHTSA ID #10007273, JANUARY 01 2004)
SUSPENSION:FRONT
SUSPENSION:REAR
SUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM
SERVICE BRAKES, HYDRAULIC
- TSB #03092005 -- SQUEAK OR A SQUEEGEE TYPE NOISE WHEN THE BRAKE PEDAL IS APPLIED OR RELEASED. *EH (NHTSA ID #10014839, MARCH 09 2005)
- TSB #02053 -- INFORMATION ON RESURFACING THE PARK BRAKE PORTION OF THE REAR BRAKE ROTOR. *TT (NHTSA ID #10007739, JANUARY 01 2004)
- TSB #3779 -- SQUEAK NOISE ON BRAKE APPLY. *TT (NHTSA ID #10018628, no date provided)
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
SERVICE BRAKES, HYDRAULIC:ANTILOCK
- TSB #3832 -- ABS, RED BRAKE ,SVC AND 4WD LIGHT ON HVAC BLOWER INOPERATIVE. *AK UPDATED 1/30/08. *NJ (NHTSA ID #10019241, DECEMBER 01 2007)
- TSB #1750177 -- ABS BRAKE SVC AND 4WD LIGHT ON HVAC BLOWER INOPERATIVE. *AK (NHTSA ID #10019207, no date provided)
SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE
SERVICE BRAKES, AIR:DISC:CALIPER
SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
ENGINE AND ENGINE COOLING
- TSB #060602003 -- OPERATING CHARACTERISTICS OF THE ELECTRO-VISCOUS (EV) FAN CLUTCH AND DIAGNOSTIC TIPS FOR COOLING FAN NOISE, DELAYED TRANSMISSION SHIFTS AND/OR ENGINE REVVING TOO HIGH. *TT (NHTSA ID #10019510, FEBRUARY 01 2006)
- TSB #050601034 -- ENGINE OIL LEAK AT REAR COVER ASSEMBLY AREA. *TT (NHTSA ID #10018733, NOVEMBER 01 2005)
- TSB #050601026 -- INFORMATION ON USE OF BOLT EXTRACTOR TOOL KIT PART NUMBER EN-47702 FOR REMOVING BROKEN CYLINDER HEAD OR MAIN BEARING CAP BOLTS ON INLINE TRUCK ENGINES. *TT (NHTSA ID #10017818, SEPTEMBER 01 2005)
- TSB #07082004 -- HIGHER THAT PERCEIVED NORMAL ENGINE COOLANT TEMPERATURE GAUGE READINGS WHEN OPERATING THE VEHICLE IN VERY HIGH OUT SIDE AMBIENT TEMPERATURES AND IN STOP AND GO OR SLOW MOVING TRAFFIC CONDITIONS. *EH (NHTSA ID #10013185, JULY 08 2004)
- TSB #05062004 -- S ENGINE POSSIBLE FALSE CODE DTC P0172. *EH (NHTSA ID #10013212, MAY 06 2004)
- TSB #040603002 -- DIAGNOSTIC INFORMATION FOR INTERMITTENT VEHICLE NO CRANK DEAD BATTERY. *EH (NHTSA ID #10012703, FEBRUARY 01 2004)
- TSB #01012004 -- HIGH COOLANT TEMPERATURE GAUGE READINGS DURING LOW RPM OPERATION. *TT (NHTSA ID #10009584, JANUARY 01 2004)
- TSB #3614 -- P0300 DUE TO RANDOM MISFIRES NOT FELT - POSSIBLE ACCESSORY PULLEY. *TT (NHTSA ID #10018577, no date provided)
- TSB #3330 -- SERVICE ENGINE SOON (SES) LIGHT DUE TO A P0171 DIAGNOSTIC TROUBLE CODE. *TT (NHTSA ID #10014881, no date provided)
- TSB #3150 -- CYLINDER LINER REPLACEMENT INFORMATION - INLINE TRUCK ENGINES. *EH (NHTSA ID #10010547, no date provided)
ENGINE AND ENGINE COOLING:ENGINE
- TSB #060139002 -- FRONT BLOWER MOTOR INOPERATIVE OR MAY NOT SHUT OFF IN EXTREMELY LOW AMBIENT TEMPERATURE CONDITIONS. *KB (NHTSA ID #10022260, APRIL 01 2007)
- TSB #030604030 -- MULTIPLE DRIVEABILITY SYMPTOMS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT (NHTSA ID #10002166, MARCH 01 2007)
- TSB #3154 -- MISFIRE, BUMP OR MULTIPLE BUMPS AFTER A 1-2 UPSHIFT. *TT (NHTSA ID #10010285, OCTOBER 06 2006)
- TSB #050602012 -- SERVICE ENGINE SOON (SES) OR CHECK ENGINE LIGHT ON, DTC P0526, P0480, P1481, AND P1484 SET. *TT UPDATED. *KB (NHTSA ID #10018986, OCTOBER 01 2006)
- TSB #060604048 -- 4.2L LL8 ENGINE FLASHING AND/OR MIL/SES LIGHT. ROUGH IDLE, MISFIRE. DTC P0300, P0301, P0302, P0303, P0304, P0305, AND P0306. *KB (NHTSA ID #10020879, SEPTEMBER 01 2006)
- TSB #050601014 -- OIL LEAK UNDER EXTREME COLD TEMPERATURES (-34 DEGREES C) (-30 DEGREES F) OR COLDER). *TT (NHTSA ID #10017409, MAY 01 2005)
- TSB #040602005 -- HIGHER THAN NORMAL ENGINE COOLANT TEMPERATURE GAUGE READINGS. *TT (NHTSA ID #10011205, AUGUST 01 2004)
- TSB #040601022 -- NEW CYLINDER BORE LINER/PISTON SLEEVE REPLACEMENT PROCEDURE. *TT (NHTSA ID #10012109, JULY 01 2004)
- TSB #040604053 -- SERVICE ENGINE SOON LIGHT ON P0133, P0172. *TT (NHTSA ID #10012114, JULY 01 2004)
- TSB #040604043 -- UNABLE TO RESET ENGINE OIL LIFE MONITOR. *TT (NHTSA ID #10012163, JUNE 01 2004)
- TSB #040604038 -- SERVICE ENGINE SOON LIGHT ON, P1680. *TT (NHTSA ID #10012153, JUNE 01 2004)
- TSB #040601015 -- NEW DESIGN OIL PICK UP TUBE AND FRONT COVER. *MJ (NHTSA ID #10008501, MAY 01 2004)
- TSB #030604033 -- REVISED DIAGNOSTIC TROUBLE CODE P0336. *TT UPDATE. TO INCLUDE 2004 ISUZU NQR COMMERCIAL MODELS. *TT (NHTSA ID #10002860, MARCH 01 2004)
- TSB #040601003 -- INFORMATION ON 2ND DESIGN BALANCER HUB. *TT (NHTSA ID #10008663, MARCH 01 2004)
- TSB #02064A -- A DIM SERVICE ENGINE SOON (SES) LIGHT MAY BE NOTED WITH THE IGNITION KEY IN THE ACCESSORY POSITION. *TT (NHTSA ID #10007866, JANUARY 01 2004)
- TSB #3018 -- ENGINE CYLINDER HEAD CUP PLUG COOLANT LEAK. *MJ (NHTSA ID #10008804, JANUARY 01 2004)
- TSB #01745 -- 4.2L LL8 ENGINE- NO CRANK, NO START. *MR (NHTSA ID #10006252, JANUARY 01 2004)
- TSB #3086 -- WHISTLE NOISE FROM THE THROTTLE BODY AREA ON LIGHT THROTTLE ACCELERATION ON VEHICLES WITH GEN III ENGINES AND ELECTRONIC THROTTLE. *TT (NHTSA ID #10009512, JANUARY 01 2004)
- TSB #00411D -- LACK OF POWER AND ENGINE LIGHT ON (03-04 GMT 800,820 AND 830). *NM (NHTSA ID #10007209, JANUARY 01 2004)
- TSB #00810A -- TICK NOISE AT IDLE. *TT (NHTSA ID #10005468, JANUARY 01 2004)
- TSB #01353 -- ENGINE MISFIRE DUE TO INJECTOR FRETTING CORROSION. *TT (NHTSA ID #10007937, JANUARY 01 2004)
- TSB #01762 -- 4.2 LL8 ENGINE ELECTRONIC POWERTRAIN CONTROL MODULE (PCM) RESTRICTION. *MR (NHTSA ID #10006309, JANUARY 01 2004)
- TSB #01579 -- OIL PAN BAFFLES DELETED. SIT BULLETIN 1413402. *TT (NHTSA ID #10005422, JANUARY 01 2004)
- TSB #01672 -- OIL PAN DRAIN PLUG THREADS - INFORMATION. *TT (NHTSA ID #10007247, JANUARY 01 2004)
- TSB #02129 -- ROUGH IDLE OR IDLE SHAKE AT TIMES. *TT (NHTSA ID #10007805, JANUARY 01 2004)
- TSB #3076 -- REPLACEMENT GOODWRENCH ENGINES - PARTS WHICH MUST BE SWAPPED FROM ORIGINAL ENGINE. *TT (NHTSA ID #10009626, JANUARY 01 2004)
- TSB #00156A -- 4.2L LL8 ENGINE ROUGH IDLE - RUN POSSIBLE P1345 OR P0016. *MJ *TT (NHTSA ID #10007656, JANUARY 01 2004)
- TSB #3142 -- BROKEN HEAD BOLT REPAIR. *TC (NHTSA ID #10010194, JANUARY 01 2004)
- TSB #01746 -- 4.2 5.3 LL8 LM4 ENGINE WITH DIAGNOSTIC TROUBLE CODE P2120 OR P2122 OR P2123 OR P2127 OR P2128. *MR (NHTSA ID #10006289, JANUARY 01 2004)
- TSB #02023 -- INTERMITTENT NO CRANK NO START. SECURITY LIGHT MAY BE ON OR OFF. 4.2 LL8 ENGINE. *NM (NHTSA ID #10007212, JANUARY 01 2004)
- TSB #00540B -- ENGINE OIL LEAK AT INTAKE GASKET. SIT BULLETIN 1412496. *TT (NHTSA ID #10005417, JANUARY 01 2004)
- TSB #01416 -- ENGINE OIL LEAK AFTER CRANK SHAFT BALANCER REPLACEMENT. *TT (NHTSA ID #10004220, NOVEMBER 18 2003)
- TSB #01314 -- ENGINE MISFIRE POSSIBLE DIAGNOSTIC TROUBLE CODES (DTCS) P0300 - P0306. *TT (NHTSA ID #10004094, NOVEMBER 17 2003)
- TSB #030604055 -- SERVICE ENGINE SOON/CHECK ENGINE LIGHT ILLUMINATED, MISFIRE OR ROUGHNESS, DIAGNOSTIC TROUBLE CODE (DTC) P0300 SET. *TT (NHTSA ID #10004317, OCTOBER 01 2003)
- TSB #030604060 -- INFORMATION ON NEW SPARK PLUGS AND GAPPING. VARIOUS MODELS INCLUDING PONTIAC GTO 2004. *TT (NHTSA ID #10004733, OCTOBER 01 2003)
- TSB #3659A -- SES LIGHT AFTER INTERNAL ENGINE REPAIRS DUE DTC P0016 OR P1345. *TT (NHTSA ID #10019182, no date provided)
- TSB #3405 -- ENGINE IS HARD TO START AFTER FILLING THE FUEL TANK. *TT (NHTSA ID #10017130, no date provided)
- TSB #3164A -- SERVICE ENGINE SOON LIGHT DUE A DIAGNOSTIC TROUBLE CODE P0606 DIAGNOSTIC TROUBLE CODE, OPERATE IN REDUCED ENGINE POWER MODE, AND POTENTIALLY STALL. *TT (NHTSA ID #10017230, no date provided)
- TSB #3232 -- 1999 - 2005 GEN II COLD ENGINE MISFIRE AT IDLE WITH POSSIBLE P0171 AND/OR P0174. *TT (NHTSA ID #10014870, no date provided)
- TSB #3056 -- CHECK ENGINE LIGHT WITH A P0300 DUE TO 2-4 CYLINDERS MISFIRING ON THE SAME BANK OF THE ENGINE. *TT (NHTSA ID #10010364, no date provided)
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
- TSB #01526A -- BELT NOISE SQUEAL OR SQUEAK. *MN *MJ (NHTSA ID #10005413, JANUARY 01 2004)
- TSB #01526 -- BELT SQUEAL. SIT BULLETIN 1406354. *TT (NHTSA ID #10005463, JANUARY 01 2004)
ENGINE AND ENGINE COOLING:COOLING SYSTEM
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
- TSB #0810B -- TICK NOISE AT IDLE. *TT (NHTSA ID #10005383, JANUARY 01 2004)
- TSB #01578 -- COOLING FAN OPERATION. SIT BULLETIN 1413381. *TT (NHTSA ID #10005421, JANUARY 01 2004)
- TSB #01676 -- 4.2 4L60E ENGINE COOLING FAN CONTACTS SHROUD AFTER REPLACING RADIATOR. *MR (NHTSA ID #10007188, JANUARY 01 2004)
- TSB #3077 -- TICK NOISE AT IDLE. *TT (NHTSA ID #10009677, no date provided)
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
- TSB #050604014 -- DIAGNOSTIC AIDS FOR DIAGNOSTIC TROUBLE CODES P0440, P0455 AND/OR P0442 - EVAPORATIVE EMISSION (EVAP) SYSTEM LEAK. *TT (NHTSA ID #10014993, MARCH 01 2005)
- TSB #050604021 -- REVISED INSPECTION/MAINTENANCE (I/M) EVAPORATIVE EMISSION (EVAP) SYSTEM SET PROCEDURE. *TT (NHTSA ID #10015005, MARCH 01 2005)
- TSB #510 -- 2004 SECONDARY AIR INJECTION SYSTEM- IN 6 CYLINDER ENGINE INCORPORATES A NEW AIR PUMP AND AN ELECTRONIC AIR SHUT OFF VALVE. *SC (NHTSA ID #10016220, OCTOBER 01 2003)
FUEL SYSTEM, GASOLINE
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
- TSB #07076 -- GM: SPECIAL COVERAGE ADJUSTMENT - FUEL TANK MODULAR RESERVOIR ASSEMBLY CORROSION. CSC LETTER WAS RECEIVED. UPDATED 11/6/08. *PE UPDATED 5/5/09. CSC LETTER WAS RECEIVED. *PE (NHTSA ID #10026522, OCTOBER 01 2008)
- TSB #040604003 -- VEHICLE IS DIFFICULT TO FILL WITH FUEL OR FILLING STATION PUMP SHUTS OFF BEFORE TANK IS FULL OR FUEL SPITS BACK/OUT WHEN FILLING TANK. *TT (NHTSA ID #10011209, AUGUST 01 2004)
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
FUEL SYSTEM, OTHER
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
- TSB #PIT-3046E -- GMC: FUEL GAUGE FLUCTUATION IN PARK OR NEUTRAL, CAUSING THE LOW FUEL LIGHT TO ILLUMINATE. *PE (NHTSA ID #10026704, AUGUST 01 2008)
- TSB #3208 -- 4WD INOPERATIVE AND OR ERRATIC FUEL GAUGE AND OR DIAGNOSTIC TROUBLE CODE'S. *EH (NHTSA ID #10010607, OCTOBER 13 2006)
- TSB #3046A -- FUEL GAUGE FLUCTUATION IN PARK OR NEUTRAL. *TT (NHTSA ID #10009382, no date provided)
POWER TRAIN
- TSB #3222 -- INTERMITTENT BOOM, RUMBLING NOISE AT HIGHWAY SPEED. *TT UPDATED 2/27/08. *NJ (NHTSA ID #10010630, DECEMBER 01 2007)
- TSB #01707 -- C0379 SETS AFTER OVERNIGHT COLD TEMPERATURE START UP. *TT (NHTSA ID #10006406, JANUARY 01 2004)
- TSB #01599 -- 4L60E, 4L65E FORWARD AND LOW REVERSE WAVED STEEL CLUTCH PLATE APPEARANCE CHANGE. *TT (NHTSA ID #10007237, JANUARY 01 2004)
- TSB #02117 -- TCCM WILL NOT PROGRAM THROUGH TIS. *MJ (NHTSA ID #10007448, JANUARY 01 2004)
- TSB #02030 -- PING, POP OR CLICK NOISE FROM THE PROPELLER SHAFT. SERVICE VME. *TT (NHTSA ID #10007750, JANUARY 01 2004)
- TSB #02086 -- 4L60E, 4L65E INTERMITTENT NEUTRAL FROM A STOP OR STEADY SPEED. *TT (NHTSA ID #10007782, JANUARY 01 2004)
- TSB #990730022A -- SHIFT STABILIZATION AND TOW/HAUL MODE FEATURE FOR HYDRA-MATIC 4L60-E/4L65-E AND 4L80-E/4L85-E TRANSMISSIONS. *TT (NHTSA ID #10002886, JUNE 01 2003)
- TSB #3420A -- PING, POP OR CLICK NOISE FROM UNDER THE REAR. *SC (NHTSA ID #10017010, no date provided)
- TSB #3444 -- SERVICE VME-TCC SURGE OR SHUDDER, INVESTIGATION OF WATER INTRUSION INTO THE TRANSMISSION. *SC (NHTSA ID #10017051, no date provided)
- TSB #3002 -- 4L60E/4L65E INTERMITTENT NEUTRAL CONDITION WHILE ACCELERATING FROM A STOP OR WHILE DRIVING. *TT 1999-2006 GM CARS, LIGHT DUTY TRUCKS AND UTILITIES. *TT (NHTSA ID #10008802, no date provided)
- TSB #3138 -- REDUCED POWER LIGHT ON AND DIAGNOSTIC TROUBLE CODE P1680 P1221 AND OR P1271 STORED IN THE POWERTRAIN CONTROL MODULE. *EH (NHTSA ID #10011821, no date provided)
POWER TRAIN:MANUAL TRANSMISSION
POWER TRAIN:AUTOMATIC TRANSMISSION
- TSB #050730031 -- 4L60-E AUTOMATIC TRANSMISSION TORQUE CONVERTER CLUTCH (TCC) SHUDDER, WATER IN TRANSMISSION (REPAIR TRANSMISSION AND REPLACE TRANSMISSION FILLER TUBE, LEVEL INDICATOR AND SEAL). *AK (NHTSA ID #10018721, NOVEMBER 01 2005)
- TSB #010730038B -- THE SERVICE ENGINE SOON LAMP IS ILLUMINATED, NO 3RD AND 4TH GEAR, THE TRANSMISSION DOES NOT SHIFT CORRECTLY, THE TRANSMISSION FEELS LIKE IT SHIFTS TO NEUTRAL OR A LOSS OF DRIVE OCCURS. *TT (NHTSA ID #10005162, OCTOBER 01 2005)
- TSB #040730041 -- SERVICE ENGINE SOON (SES) LIGHT ON, DIAGNOSTIC TROUBLE CODE (DTC) P0741, HARSH SHIFT, CRUISE CONTROL INOPERATIVE. *TT (NHTSA ID #10012732, OCTOBER 01 2004)
- TSB #040730035 -- RELEASE OF REAR TRANSMISSION MOUNT SEPARATE FROM EXHAUST MOUNT. *TT (NHTSA ID #10011217, AUGUST 01 2004)
- TSB #040730022 -- HARSH GARAGE SHIFT FROM PARK TO DRIVE OR FROM PARK TO REVERSE WITH TRANSMISSION FLUID AT COLD AMBIENT TEMPERATURES. *EH (NHTSA ID #10012605, MAY 01 2004)
- TSB #04202004 -- HARSH PARK TO REVERSE OR PARK TO DRIVE GARAGE SHIFT ENGAGEMENT ESPECIALLY WHEN THE TRANSMISSION FLUID IS AT A LOW AMBIENT TEMPERATURE. GM VOICEMAIL EXPRESS. *TT (NHTSA ID #10009227, APRIL 20 2004)
- TSB #00702 -- SLIP CONDITION IN 2ND, 3RD OR 4TH DAMAGED 2-4 BAND 3-4 CLUTCH ON THE 4L60E/4L65E AUTOMATIC TRANSMISSION. *TT *MJ (NHTSA ID #10005476, JANUARY 01 2004)
- TSB #01973 -- HARSH SHIFTS FROM PARK TO DRIVE OR DRIVE TO REVERSE (GARAGE SHIFT). WORSE IN COLD AMBIENT TEMPERATURES. *NM (NHTSA ID #10007213, JANUARY 01 2004)
- TSB #01654 -- SQUAWK OR GRUNT NOISE THAT OCCURS ON THE 2-3 UPSHIFT ON VEHICLES WITH 4L60E - M30, 4L60E M32 TRANSMISSION. *TT (NHTSA ID #10007233, JANUARY 01 2004)
- TSB #040730002 -- RATTLE TYPE NOISE COMING FROM UNDER THE VEHICLE. *TT (NHTSA ID #10011130, JANUARY 01 2004)
- TSB #11202003 -- RATTLE NOISE UNDERNEATH THE VEHICLE OR AN AUTOMATIC TRANSMISSION FLUID LEAK. *EH (NHTSA ID #10013261, NOVEMBER 20 2003)
- TSB #030730056 -- 4L60-E AUTOMATIC TRANSMISSION OIL PUMP FIRST AND SECOND DESIGN IDENTIFICATION. *TT (NHTSA ID #10005566, NOVEMBER 01 2003)
- TSB #3170 -- HARSH 1-2 SHIFT. *EH (NHTSA ID #10010577, no date provided)
- TSB #3516 -- VIBRATION FELT AND HEARD AT LOW RPM DURING PARKING LOT MANEUVERS. *TT (NHTSA ID #10017393, no date provided)
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
- TSB #3061 -- DTC C0327 WITH OR WITHOUT ADDITIONAL DTC'S SETTING. WITH FOUR WHEEL DRIVE (4WD) ONLY. *NJ (NHTSA ID #10023773, DECEMBER 01 2007)
- TSB #01483 -- VEHICLE HAS NO PCM (POWER TRAIN CONTROL MODULE) COMMUNICATION WITH TECH 2. SIT BULLETIN 1400427. *TT (NHTSA ID #10005496, JANUARY 01 2004)
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
- TSB #PIT-4722 -- GMC: FLUID LEAK FROM TRANSMISSION OIL COOLER LINES DUE TO CORROSION. ALL 2000-2006 LIGHT DUTY TRUCKS EQUIPPED WITH THE LIGHT DUTY AUTOMATIC TRANSMISSION. *PE (NHTSA ID #10026804, OCTOBER 01 2008)
- TSB #01573 -- RATTLE NOISE AND/OR TRANSMISSION FLUID LEAK FROM TRANSMISSION COOLER LINE CONTACT WITH CATALYTIC CONVERTER. *TT *MJ (NHTSA ID #10005419, JANUARY 01 2004)
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
- TSB #05-04-21-003 -- SERVICE 4WD LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE (DTC) C0374 SET. *TT UPDATED 10/05/07. *NJ INSPECT WIRING HARNESS TO TRANSFER CASE SPEED SENSORS, REPLACE WIRING HARNESS. UPDATED 7/18/08 *PE (NHTSA ID #10017464, JANUARY 01 2008)
- TSB #040421004 -- 4WD SWITCH INDICATOR LIGHTS FLASHING, 4WD INOPERATIVE, DIAGNOSTIC TROUBLE CODES C0327, P0550 SET. *TT (NHTSA ID #10017442, DECEMBER 01 2004)
- TSB #020421006C -- INOPERATIVE 4WD/AWD LAMPS, INOPERATIVE 4WD/AWD SYSTEM. *TT (NHTSA ID #10004357, MARCH 01 2004)
- TSB #01446A -- SERVICE 4WD LIGHT ON NO CODES BESIDES U1000 CODES. *TT (NHTSA ID #10004255, JANUARY 01 2004)
- TSB #01843 -- CALIBRATION FOR IMPROVED TRANSFER CASE OPERATION IN AWD MODE. *TT (NHTSA ID #10007961, JANUARY 01 2004)
- TSB #081103 -- THE SERVICE FOUR-WHEEL DRIVE LIGHT OR THE FOUR-WHEEL DRIVE IS INOPERATIVE WITH NO COMMUNICATIONS WITH THE TECH 2, OR C0550 CODE IS STORED IN THE TCCM. *TT (NHTSA ID #10003863, AUGUST 11 2003)
- TSB #030421006 -- SERVICE 4WD LIGHT ON, 4WD INOPERATIVE, HARSH ENGAGEMENT OF 4WD, NO COMMUNICATION WITH TRANSFER CASE CONTROL MODULE (TCCM), TCCM DIAGNOSTIC TROUBLE CODE (DTC) C0550 SET. *TT (NHTSA ID #10004367, AUGUST 01 2003)
- TSB #3351 -- INTERMITTENT MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) C0374 OR ERRATIC 4WD/AWD OPERATION. *TT (NHTSA ID #10014853, no date provided)
- TSB #3424 -- ELECTRONIC TRANSFER CASE UNABLE TO COMPLETE SHIFT. *TT (NHTSA ID #10017299, no date provided)
POWER TRAIN:DRIVELINE
- TSB #040421001 -- DELAYED ENGAGEMENT OF FRONT WHEELS DURING A SLIP CONDITION. *MJ (NHTSA ID #10008503, MAY 01 2004)
- TSB #3300 -- 4WD MODELS WITH NOISE, VIBRATION ON DRY PAVEMENT. *EH (NHTSA ID #10013572, no date provided)
POWER TRAIN:AXLE ASSEMBLY
- TSB #030417002 -- WHINE NOISE FROM REAR AXLE. *TT (NHTSA ID #10001111, DECEMBER 01 2006)
- TSB #030419002 -- SQUEAK, SQUEAL OR WHISTLE NOISE FROM FRONT AXLE. *TT (NHTSA ID #10001123, SEPTEMBER 01 2004)
- TSB #040419001 -- DIAGNOSTIC TROUBLE CODE (DTC) C0379 SET, SERVICE 4WD LIGHT ON, 4WD INOPERATIVE. *TT (NHTSA ID #10012696, FEBRUARY 01 2004)
- TSB #3137 -- SERVICE 4WD LIGHT ON AND NO COMMUNICATION WITH TRANSFER CASE CONTROL MODULE. *EH (NHTSA ID #10010612, no date provided)
- TSB #3177 -- REPEAT FRONT AXLE FLUID LEAK. *EH (NHTSA ID #10010599, no date provided)
ELECTRICAL SYSTEM
- TSB #08089-B -- GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE (NHTSA ID #10027804, NOVEMBER 01 2008)
- TSB #040603005 -- PROPER CONNECTION INFORMATION TO AVOID BLOWN 125 AMP FUSE AND VARIOUS INTERIOR ELECTRICAL SYSTEM CONDITIONS WHEN JUMP STARTING VEHICLE. *TT (NHTSA ID #10008665, MAY 01 2006)
- TSB #040845010 -- VARIOUS INTERIOR ELECTRICAL CONCERNS, IP GAUGES/LIGHTING INOPERATIVE, HVAC CONTROLS INOPERATIVE, BLOWER MOTOR INOPERATIVE, RADIO INOPERATIVE, FLASHER INOPERATIVE. *TT (NHTSA ID #10011074, SEPTEMBER 01 2004)
- TSB #3138 -- REDUCED POWER LIGHT ON AND DIAGNOSTIC TROUBLE CODE P1680 P1221 AND/OR P1271 STORED IN THE POWER CONTROL MODULE. *SC (NHTSA ID #10010105, JANUARY 01 2004)
- TSB #3031 -- INTERMITTENT P0483 DIAGNOSTIC TROUBLE CODE. *TT (NHTSA ID #10008761, JANUARY 01 2004)
- TSB #02038 -- DIAGNOSTIC TROUBLE CODE B1000. *MR (NHTSA ID #10006946, JANUARY 01 2004)
- TSB #01623 -- 4.2 LL8 ENGINE DIAGNOSTIC TROUBLE CODE P0016 OR P1345 WITH NO DRIVEABILITY SYMPTOMS.*MR (NHTSA ID #10007186, JANUARY 01 2004)
- TSB #1528102 -- 02-04 4.2L LL8 DIAGNOSTIC TROUBLE CODE P0171. *MJ (NHTSA ID #10008820, JANUARY 01 2004)
- TSB #01816 -- DIAGNOSTIC TROUBLE CODE P0130. *MR *TT (NHTSA ID #10006670, JANUARY 01 2004)
- TSB #01592 -- 2003-2004 GENERATION 5 ONSTAR STEERING WHEEL CONTROL FUNCTION EXPLANATION. SIT BULLETIN 1416474. *TT (NHTSA ID #10005438, JANUARY 01 2004)
- TSB #01016 -- ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON, RED BRAKE LIGHT ON, SERVICE 4WD LIGHT ON, HVAC BLOWER MOTOR INOPERATIVE. *TT (NHTSA ID #10007572, JANUARY 01 2004)
- TSB #01925 -- TECH 2 ENGINE DATA INCORRECT- GEN L-TERMINAL SIGNAL COMMAND DATA PARAMETER. *MR (NHTSA ID #10006566, JANUARY 01 2004)
- TSB #3172 -- MULTIPLE ELECTRICAL CONCERNS AND DIAGNOSTIC TROUBLE CODE U1064. VARIOUS MODELS INCLUDING 2005 BUICK RAINIER AND 2005 CHEVROLET TRAILBLAZER. *TT (NHTSA ID #10010252, JANUARY 01 2004)
- TSB #00859 -- DIAGNOSTIC TROUBLE CODE (DTC) C0327 WITH OR WITHOUT ADDITIONAL DIAGNOSTIC TROUBLE CODES (DTCS) SETTING. *TT *MJ (NHTSA ID #10007281, JANUARY 01 2004)
- TSB #01181C -- DIAGNOSTIC TROUBLE CODE (DTC) P0172. 4.2 LL8 ENGINE. *TT *MJ (NHTSA ID #10007530, JANUARY 01 2004)
- TSB #01917 -- FALSE DIAGNOSTIC TROUBLE CODE (DTC) P1680. *TT (NHTSA ID #10006820, JANUARY 01 2004)
- TSB #01968A -- DIAGNOSTIC TROUBLE CODE (DTC) P0171. *TT (NHTSA ID #10007277, JANUARY 01 2004)
- TSB #01802A -- APP SENSOR 2 AND/OR TP SENSOR 2 SIGNAL CIRCUIT VOLTAGES DROP. *TT (NHTSA ID #10007965, JANUARY 01 2004)
- TSB #3016 -- VARIOUS ELECTRICAL CONCERNS. *TT (NHTSA ID #10008777, JANUARY 01 2004)
- TSB #01402A -- 4.2L LL8 DIAGNOSTIC TROUBLE CODE (DTC) P0410. *TT (NHTSA ID #10004171, NOVEMBER 18 2003)
- TSB #3756A -- IPC GAUGES AND AC INOPERATIVE, SEVERAL INDICATORS ILLUMINATE DTCS U1016 U1000. *TT (NHTSA ID #10018908, no date provided)
- TSB #3192 -- REDUCED ENGINE POWER MESSAGE AND/OR CHECK ENGINE LIGHT WITH ANY COMBINATION OF THE FOLLOWING DIAGNOSTIC TROUBLE CODES: P0107, P0112, P0452, P1120, P1220, P1221, P1271, P1275, P1280, P1481, P1515, P1540, P1633, P1635, P1639 AND P1682 POWERT (NHTSA ID #10010867, no date provided)
- TSB #3697 -- ANTI-LOCK BRAKING SYSTEM (ABS) AND SERVICE ENGINE SOON (SES) LIGHT ON WITH DIAGNOSTIC TROUBLE CODES C0055 B0540 SPEEDOMETER INOPERATIVE. TO INCLUDE 2005-2006 SAAB 9-7X. *TT (NHTSA ID #10016553, no date provided)
- TSB #3263 -- 125A MEGA FUSE OPENS WHEN ATTEMPTING TO JUMP START. *EH (NHTSA ID #10011636, no date provided)
- TSB #3089 -- SERVICE ENGINE SOON LIGHT AND REDUCED ENGINE POWER WITH A DIAGNOSTIC TROUBLE CODE P1516. DIAGNOSTIC TROUBLE CODES P0120, P0220, P1514, P1515, P1518 AND P2135 MAY ALSO BE PRESENT. *TT (NHTSA ID #10009520, no date provided)
- TSB #3061C -- DIAGNOSTIC TROUBLE CODE C0327 WITH OR WITHOUT ADDITIONAL DIAGNOSTIC TROUBLE CODES SETTING. *TT (NHTSA ID #10010634, no date provided)
- TSB #4338 -- LIGHTS FLICKER ERRATIC OPERATION OF VEHICLES ELECTRONICS. *KB (NHTSA ID #10021675, no date provided)
- TSB #3079 -- INTERMITTENT P0483 DIAGNOSTIC TROUBLE CODE. *TT (NHTSA ID #10010373, no date provided)
- TSB #3116 -- ENGINE STALLS WHEN AIR CONDITIONING IS TURNED ON AT IDLE. (TO INCLUDE 2005 CHEVROLET TRAILBLAZER, 2005 OLDSMOBILE BRAVADA, AND BUICK RAINIER) *SC UPDATED 01-26-07. *KB (NHTSA ID #10010189, no date provided)
ELECTRICAL SYSTEM:STARTER ASSEMBLY
ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY
ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
ELECTRICAL SYSTEM:IGNITION
- TSB #080503 -- THE PURPOSE OF THIS MESSAGE IS TO PROVIDE INFORMATION ABOUT A NEW PRODUCT EMISSION RECALL. THE RECALL NUMBER OF 03042. THIS RECALL IS FOR VEHICLES IN DEALER INVENTORY ONLY. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH SPARKPLUGS THAT (NHTSA ID #10003871, AUGUST 05 2003)
- TSB #3083 -- KEY MAY NOT TURN OR BIND IN THE IGNITION. *TT (NHTSA ID #10010371, no date provided)
- TSB #3216 -- ERRATIC OPERATION OF PERSONALIZATION WITH IGNITION CYCLE. *EH (NHTSA ID #10010618, no date provided)
ELECTRICAL SYSTEM:IGNITION:SWITCH
- TSB #050730021 -- IGNITION KEY WILL NOT REMOVE FROM IGNITION LOCK CYLINDER. *TT (NHTSA ID #10017381, AUGUST 01 2005)
- TSB #02140 -- WHEN ATTEMPTING TO TURN THE KEY TO START THE VEHICLE, YOU MAY EXPERIENCE HARD OR INTERMITTENT MECHANICAL BINDING IN THE IGNITION CYLINDER. *TT (NHTSA ID #10007786, JANUARY 01 2004)
DIGITAL INSTRUMENT PANEL
ELECTRICAL SYSTEM: SOFTWARE
EXTERIOR LIGHTING
- TSB #04087 -- TAIL LAMPS/STOP LAMPS PRODUCT FIELD ACTION ANNOUNCEMENT. *TT ADMINISTRATIVE MESSAGE. *TT (NHTSA ID #10011954, NOVEMBER 16 2004)
- TSB #04017A -- TAIL LAMPS/STOP LAMPS. SPECIAL POLICY SERVICE BULLETIN. *TT (NHTSA ID #10009630, AUGUST 01 2004)
EXTERIOR LIGHTING:HEADLIGHTS
- TSB #4491 -- HEADLAMP FLICKER OR MOMENTARILY DIM WHILE DRIVING. 06-06-03-004 SUPPLEMENT. SHORT WHEEL BASE ONLY. *NJ UPDATED 1/30/08. *NJ (NHTSA ID #10023137, DECEMBER 01 2007)
- TSB #050842001 -- DIAGNOSTIC INFORMATION ON HEADLAMPS FLICKER OR MOMENTARILY DIM WHILE DRIVING. *TT (NHTSA ID #10015012, MARCH 01 2005)
- TSB #3044 -- LOCATION OF THE HEADLAMP DRIVER MODULE (HDM). *TT (NHTSA ID #10009649, JANUARY 01 2004)
- TSB #3170E -- IPC, INTERIOR LIGHTS AND/OR HEADLAMPS FLICKER. *AK FB2 (NHTSA ID #10019186, no date provided)
- TSB #3680 -- AUTOMATIC HEADLAMP DEFEAT INOPERATIVE AFTER BCM REPLACEMENT. *TT (NHTSA ID #10016544, no date provided)
- TSB #3317A -- HEADLAMPS FLICKER OR DIM WHILE DRIVING. *TT (NHTSA ID #10013495, no date provided)
EXTERIOR LIGHTING:TAIL LIGHTS
- TSB #04087 -- TAIL LAMP THAT MAY BECOME INOPERATIVE PREMATURELY. *EH (NHTSA ID #10014003, NOVEMBER 01 2004)
- TSB #04017A -- TAIL LAMP/STOP LAMP(S) MAY BECOME INOPERATIVE. GM ADMINISTRATIVE MESSAGE. *NM (NHTSA ID #10010181, SEPTEMBER 29 2004)
- TSB #04017 -- SPECIAL POLICY ADJUSTMENT - TAIL LAMP/STOP LAMP INOPERATIVE. ANSWERS TO ASSIST IN RESPONDING TO CUSTOMER INQUIRIES. *MJ THIS IS THE FIRST PHASE WHICH WAS RELEASED JUNE 3, 2004. *TT THIS IS THE SECOND PHASE - PHASE II. *TT PHASE II (NHTSA ID #10007440, AUGUST 05 2004)
- TSB #3335 -- SUPPLEMENT TO CAMPAIGN 04087 / SCREWS BREAK IN THE TAIL LAMP HOUSING. *SC (NHTSA ID #10017179, no date provided)
EXTERIOR LIGHTING:TAIL LIGHTS:SWITCH
- TSB #030842006A -- TAIL LAMP CIRCUIT BOARD NOW AVAILABLE FOR SERVICE USE. *TT (NHTSA ID #10004774, JUNE 01 2004)
- TSB #092203 -- TAIL LAMP CIRCUIT BOARD PART NUMBER INFORMATION. GM VOICEMAIL LOG. *TT (NHTSA ID #10005045, SEPTEMBER 22 2003)
EXTERIOR LIGHTING:BRAKE LIGHTS
EXTERIOR LIGHTING:TURN SIGNAL:FLASHER UNIT
VISIBILITY:GLASS, SIDE/REAR
- TSB #3095 -- OPERATION OF REAR GLASS RELEASE KEY CYLINDER. TO INCLUDE 2005 TRAILBLAZER AND BUICK RAINIER. *SC (NHTSA ID #10010244, JANUARY 01 2004)
- TSB #3037 -- INTERMITTENT REAR LIFTGLASS CONCERNS. *TT (NHTSA ID #10009632, JANUARY 01 2004)
VISIBILITY:SUN ROOF ASSEMBLY
VISIBILITY:REARVIEW MIRRORS/DEVICES
VISIBILITY:REARVIEW MIRRORS/DEVICES:INTERIOR
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
- TSB #050864003 -- OUTSIDE REARVIEW MIRROR VIBRATION. *TT (NHTSA ID #10013454, JANUARY 01 2005)
- TSB #030864033 -- AVAILABILITY OF REPLACEMENT MIRROR ACTUATOR. *TT (NHTSA ID #10004343, SEPTEMBER 01 2003)
- TSB #030864032 -- AVAILABILITY OF REPLACEMENT PARTS FOR OUTSIDE REARVIEW MIRROR. *TT (NHTSA ID #10004342, SEPTEMBER 01 2003)
VISIBILITY:WINDSHIELD WIPER/WASHER
- TSB #3110A -- WASHER MOTOR FOR THE FRONT WIPERS CONTINUOUSLY RUNS WHILE THE KEY ON. *SC UPDATE. *TT (NHTSA ID #10010201, no date provided)
- TSB #3110C -- WIPER/WASHER WILL NOT SHUT OFF OR OTHER POSSIBLE ISSUES. *TT (NHTSA ID #10017249, no date provided)
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
VISIBILITY:REAR WINDOW WIPER/WASHER
VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:BLOWER
- TSB #3656 -- REPEAT REAR BLOWER MOTOR FAILURE OR INOPERATIVE. *TT UPDATED 12/5/08. *PE (NHTSA ID #10017014, SEPTEMBER 01 2008)
- TSB #040139009 -- HVAC BLOWER MOTOR INOPERATIVE OR STAYS RUNNING. *TT (NHTSA ID #10011191, AUGUST 01 2004)
- TSB #030138015 -- HVAC BLOWER MOTOR MAY RUN CONTINUOUSLY AFTER VEHICLE IS TURNED OFF. *TT (NHTSA ID #10004293, SEPTEMBER 01 2003)
- TSB #3766 -- FRONT BLOWER INOPERATIVE STAY RUNNING DURING LOW AMBIENT TEMPERATURE. *TT (NHTSA ID #10018566, no date provided)
VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:CONTROLS/WIRING
AIR BAGS
SEAT BELTS:FRONT
SEAT BELTS:FRONT:RETRACTOR
STRUCTURE
STRUCTURE:BODY
- TSB #030857004 -- WET FRONT FLOOR CARPET. *TT UPDATE. *TT UPDATE. *KB (NHTSA ID #10004735, JUNE 01 2006)
- TSB #0508110004 -- CARGO COVER HANDLE BROKEN. *TT (NHTSA ID #10017326, APRIL 01 2005)
- TSB #040844014A -- BUZZ TYPE NOISE COMING FROM REAR SPEAKERS. *TT UPDATE. *TT (NHTSA ID #10011071, OCTOBER 01 2004)
- TSB #0308111002A -- PAINT CHIPPING BEHIND FRONT WHEELS/FRONT OF REAR WHEELS, DAMAGED LOWER DOOR/CLADDING AND ROCKER PANELS. *TT THIS SERVICE BULLETIN REPLACES 0308111002. *EH UPDATE. *TT (NHTSA ID #10005189, OCTOBER 01 2004)
- TSB #040866001 -- REAR LICENSE PLATE POCKET GASKET LOOSE OR OUT OF POSITION. *TT UDATE. *TT (NHTSA ID #10011141, OCTOBER 01 2004)
- TSB #040864012 -- FRONT OR REAR SIDE DOOR GLASS SCRATCHED. *TT (NHTSA ID #10011083, SEPTEMBER 01 2004)
- TSB #0408111003 -- REAR LICENSE PLATE POCKET PARTS NEW AVAILABLE INDIVIDUALLY. *TT (NHTSA ID #10012546, JUNE 01 2004)
- TSB #020862004 -- FRONT FASCIA WAVY. THIS SERVICE BULLETIN REPLACES 020862004. *EH (NHTSA ID #10012157, JUNE 01 2004)
- TSB #040844004 -- POP NOISE HEARD FROM REAR SPEAKERS WHEN REAR SEAT AUDIO (RSA) IS TURNED ON OR OFF (NO FIX AT TIME, FIX UNDER DEVELOPMENT). *MJ THIS SERVICE BULLETIN REPLACES 040844004. *EH (NHTSA ID #10008685, MAY 01 2004)
- TSB #040851002 -- INCORRECT PAINT CODE LISTED ON SERVICE PARTS IDENTIFICATION LABEL. *MJ (NHTSA ID #10008693, APRIL 01 2004)
- TSB #00731A -- NOISE FROM FRONT OF VEHICLE OVER BUMPS OR UNDER LIGHT ACCELERATION. *TT (NHTSA ID #10007578, JANUARY 01 2004)
- TSB #030863003 -- RATTLE FROM FRONT OF VEHICLE. *TT (NHTSA ID #10005188, DECEMBER 01 2003)
STRUCTURE:BODY:DOOR
- TSB #030864006 -- DOORS HARD TO CLOSE. *TT UPDATED 07-24-07. *KB (NHTSA ID #10001264, APRIL 01 2007)
STRUCTURE:BODY:HATCHBACK/LIFTGATE
- TSB #060866011 -- REAR LIFTGATE BINDS, IMPROPER FIT. MAY BE CAUSED BY BROKEN WELDS OR CRACKS FORMED AROUND THE TWO INNER WELDS. *KB (NHTSA ID #10020523, AUGUST 01 2006)
- TSB #060866001 -- REVISED LIFTGATE LOCK CYLINDER REPLACEMENT. *TT (NHTSA ID #10019506, FEBRUARY 01 2006)
- TSB #3135 -- CHMSL APPLIQUE CONTACTS ROOF WHEN OPENING REAR GATE/GLASS. (TO INCLUDE 2005 CHEVROLET TRAILBLAZER) (MT 370 ONLY) *SC (NHTSA ID #10010175, JANUARY 01 2004)
- TSB #3999 -- LIFTGATE GLASS WILL NOT LOCK UNLESS LOCK IS PRESS A SECOND TIME. *KB (NHTSA ID #10021085, no date provided)
STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS
- TSB #040866004 -- LIFTGATE GLASS UNLATCHES ON ROUGH/BUMPY ROAD SURFACES. THIS BULLETIN REPLACES PREVIOUS BULLETIN NUMBER 04-08-66-004. *TT (NHTSA ID #10012538, JUNE 01 2004)
- TSB #3108 -- FASTENER MISSING ON THE REAR CHMSL APPLIQUE. (TO INCLUDE 2005 CHEVROLET TRAILBLAZER AND 2005 BUICK RAINIER) *SC (NHTSA ID #10010204, JANUARY 01 2004)
- TSB #00949C -- THE LIFTGATE OR LIFTGATE GLASS BINDS WHEN OPENING OR DOES NOT OPEN COMPLETELY BECAUSE THE CENTER HIGH MOUNTED STOP LAMP (CHMSL) APPLIQUE HITS THE ROOF OF THE VEHICLE. *TT (NHTSA ID #10007289, JANUARY 01 2004)
STRUCTURE:BODY:HOOD
VEHICLE SPEED CONTROL:CRUISE CONTROL
- TSB #3042 -- CRUISE CONTROL DISENGAGES AFTER ACCELERATING. *TT (NHTSA ID #10009642, JANUARY 01 2004)
- TSB #3329 -- SURGE, CHUGGLE OR BUCK WHILE DRIVING DOWNHILL (APPROXIMATELY 1500 - 3000 FEET ABOVE SEA LEVEL) AT HIGHWAY SPEEDS WITH THE CRUISE CONTROL ON. *TT (NHTSA ID #10017201, no date provided)
- TSB #3198 -- NO CRUISE CONTROL AND DIAGNOSTIC TROUBLE CODE P0741. *EH (NHTSA ID #10010653, no date provided)
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
- TSB #00877A -- INTERMITTENT LACK OF HEAT IN 2ND AND 3RD ROW SEATING POSITIONS. *TT (NHTSA ID #10007972, JANUARY 01 2004)
- TSB #3334A -- B3606 HEATED SEAT(S) INOPERATIVE AND/OR ADJUSTABLE PEDALS DO NOT RECALL. *TT (NHTSA ID #10017127, no date provided)
- TSB #3351 -- HEATED SEAT OPERATION CLARIFICATION. *TT (NHTSA ID #10013503, no date provided)
INTERIOR LIGHTING
- TSB #010866007 -- CENTER HIGH-MOUNT STOP LAMP (CHMSL) APPLIQUE LOOSE (RE-TAPE APPLIQUE) *TT UPDATED 11/02/07 *NJ (NHTSA ID #10010430, SEPTEMBER 01 2007)
- TSB #3170E -- IPC, INTERIOR LIGHTS AND/OR HEADLAMPS FLICKER. *AK FB2 (NHTSA ID #10019186, no date provided)
COMMUNICATIONS:HORN ASSEMBLY
- TSB #3300C -- APPLICATION OF HORN AT HORN PAD INOPERATIVE. RKE FUNCTION FOR PANIC ALARM WORKS. *TT (NHTSA ID #10013378, no date provided)
- TSB #3300 -- HORN INOPERATIVE AT TIMES. *KB (NHTSA ID #10021206, no date provided)
EQUIPMENT
- TSB #050846006A -- INFORMATION ON UPGRADING CERTAIN ONSTAR GENERATION 5 ANALOG/DIGITAL-READY SYSTEMS TO ONSTAR GENERATION 6 DUAL-MODE (ANALOG/DIGITAL). *TT (NHTSA ID #10015018, SEPTEMBER 01 2005)
- TSB #03092004 -- POPPING NOISE HEARD THROUGH THE SPEAKER SYSTEMS WHEN THE REAR SEAT AUDIO IS TURNED ON OR OFF. *TT (NHTSA ID #10013019, MARCH 09 2004)
- TSB #3050A -- 02-05 ONSTAR EQUIPPED VEHICLES EMITTING BEEPING NOISE BEFORE CONNECTING TO ONSTAR. *TT (NHTSA ID #10009623, JANUARY 01 2004)
- TSB #3047 -- 99 THROUGH 05 YEAR VEHICLES, EQUIPPED WITH THREE-BUTTON ONSTAR SYSTEMS. *TT (NHTSA ID #10009607, JANUARY 01 2004)
- TSB #3011 -- WHEN USING VOICE RECOGNITION DIALING, SOME NUMBERS OR COMMANDS MAY NOT BE UNDERSTOOD BY THE SYSTEM ESPECIALLY THE NUMBER TWO (2). *TT (NHTSA ID #10008898, JANUARY 01 2004)
- TSB #082103 -- ACCESSORIES BRUSH GUARD PACKAGE ON VEHICLES WITH THE NORTH FACE EDITION. *TT (NHTSA ID #10003825, AUGUST 21 2003)
- TSB #3044 -- GENERATION 5 ONSTAR STEERING WHEEL CONTROL FUNCTION. *TT (NHTSA ID #10010363, no date provided)
EQUIPMENT:ELECTRICAL
- TSB #08-089 -- GM: SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. FCC RULED IN 2002 WIRELESS CARRIERS WOULD NO LONGER RE REQUIRED TO SUPPORT ANALOG WIRELESS NETWORK STARTING IN 2008. *PE CSC LETTER WAS RECEIVED. UPDATED 12/1/08. *PE (NHTSA ID #10026586, JUNE 01 2008)
- TSB #040139002 -- POOR HEATER PERFORMANCE - 2ND AND 3RD ROW SEATS. *TT (NHTSA ID #10008648, MARCH 01 2004)
- TSB #00372D -- ONSTAR SYSTEM IS ATTEMPTING AND/OR COMPLETING PHONE CALLS WHICH THE OPERATOR OF THE VEHICLE DID NOT INITIATE. *TT (NHTSA ID #10007287, JANUARY 01 2004)
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
- TSB #01759 -- XM RAPID ACTIVATION UTILIZATION. *MR (NHTSA ID #10006302, JANUARY 01 2004)
- TSB #01799 -- NO VOLUME FROM RADIO IN COLD AMBIENT TEMPERATURES FOR 20-30 MINUTES. *MR (NHTSA ID #10006327, JANUARY 01 2004)
- TSB #01552 -- ACCESSING XM RADIO IDENTIFICATION NUMBER. SIT BULLETIN 1410305. GMC DENALI 2004 INCLUDED. *TT (NHTSA ID #10005391, JANUARY 01 2004)
- TSB #01577 -- RADIO DISPLAYS CALIBRATION ERROR AFTER REPLACING RADIO. *MN (NHTSA ID #10005437, JANUARY 01 2004)
- TSB #3150 -- MISSING CODES FROM CD CHANGER. *TC (NHTSA ID #10009982, JANUARY 01 2004)
- TSB #02060 -- NO AUDIO AND RADIO DISPLAY INOPERATIVE OR CLOCK RESETS. *TT (NHTSA ID #10007760, JANUARY 01 2004)
- TSB #02044 -- NO SOUND FROM RADIO OR RADIO WILL NOT PROGRAM. *TT (NHTSA ID #10007757, JANUARY 01 2004)
- TSB #01662 -- XM ERROR ON A RADIO DISPLAY. *TT (NHTSA ID #10007248, JANUARY 01 2004)
- TSB #00686B -- AUTOMATIC VOLUME FEATURE DIAGNOSIS ON THE UQA BOSE RADIO. *TT (NHTSA ID #10007292, JANUARY 01 2004)
- TSB #01958 -- PRODUCT INFORMATION REGARDING RADIO PERSONALIZATION. *MR (NHTSA ID #10006948, JANUARY 01 2004)
- TSB #030844020 -- BOSE RADIO MAY HAVE POOR FIDELITY. *TT (NHTSA ID #10005154, DECEMBER 01 2003)
- TSB #01390 -- XM RADIO MUST BE TUNED TO CHANNEL 1 THROUGH 66 DURING ACTIVATION ATTEMPT. 2004 CHEVROLET CANYON, GMC DENALI, GMC COLORADO ALSO INCLUDED. *TT (NHTSA ID #10004195, NOVEMBER 18 2003)
EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
- TSB #08089-B -- GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE (NHTSA ID #10027804, NOVEMBER 01 2008)
- TSB #702 -- NAVIGATION RADIO SYSTEM DOES NOT HAVE COMPLETE COVERAGE. GM TECH LINKS. *TT (NHTSA ID #10016375, FEBRUARY 01 2005)
- TSB #3120 -- ONSTAR CENTER UNABLE TO PERFORM REMOTE DIAGNOSTIC. (2004-2005 CHEVROLET YUKON, 2005 CHEVROLET TRAILBLAZER, 2002, 2003, 2005 BUICK RAINIER, 2005 CHEVROLET EXPRESS VAN, AND 2005 CADILLAC SEVILLE) *SC (NHTSA ID #10010109, JANUARY 01 2004)
- TSB #3113 -- GEN 6 VEHICLES IN MOUNT AIRY, NC CANNOT CONNECT TO ONSTAR OR EMERGENCY SERVICES. *SC (NHTSA ID #10010199, JANUARY 01 2004)
- TSB #01661 -- XM CHANNEL ZERO NOT AVAILABLE ON CERTAIN VEHICLES EQUIPPED WITH NAVIGATION STYLE RADIOS. ALSO INCLUDING GMC DENALI 2004. *TT (NHTSA ID #10007232, JANUARY 01 2004)
- TSB #3090 -- UNABLE TO PERFORM SET UP NEW ONSTAR ON VEHICLES WITH GEN 6.05 HARDWARE. *SC (NHTSA ID #10010236, JANUARY 01 2004)
EQUIPMENT:ELECTRICAL:AIR CONDITIONER
- TSB #050138012 -- EI05082 - LOSS OF BLOWER MOTOR SPEEDS EXCEPT FOR HIGH SPEED OR INOPERATIVE. *TT UPDATED. *KB UPDATED *KB (NHTSA ID #10017373, NOVEMBER 01 2006)
- TSB #3152 -- BLOWER SPEED CHANGES ON ITS OWN. *TC UPDATE. *TT (NHTSA ID #10009989, DECEMBER 01 2004)
- TSB #040138005 -- HVAC CONTROL MODULE MEMORY FUNCTIONS - ELIMINATION OF CLIMATE CONTROL PERSONALIZATION FEATURE. *TT (NHTSA ID #10008647, MARCH 01 2004)
- TSB #02122004 -- INADEQUATE HVAC FOR PASSENGERS SEATED IN THE SECOND AND THIRD ROW. *TT (NHTSA ID #10012992, FEBRUARY 12 2004)
- TSB #3076 -- REPEAT HVAC BLOWER MOTOR FAILURE. *TT (NHTSA ID #10009603, JANUARY 01 2004)
- TSB #3179 -- AUTOMATIC DUAL ZONE HVAC BATTERY DRAW SUPPLEMENT TO 02-01-39-007A. *TT (NHTSA ID #10010266, JANUARY 01 2004)
- TSB #3104 -- ONLY REPLACEMENT OF EVAPORATOR CORE OR PIPES FOR REAR HVAC. (TO INCLUDE 2005 CHEVROLET TRAILBLAZER) *SC (NHTSA ID #10010225, JANUARY 01 2004)
- TSB #1531018 -- HVAC MODE ACTUATOR CAM GEAR ALIGNMENT IS INCORRECT AFTER REPLACEMENT. *MJ (NHTSA ID #10008771, JANUARY 01 2004)
EQUIPMENT:MECHANICAL:CARRIER/RACK
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- TSB #08-089B -- GMC: SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. CSC LETTER WAS RECEIVED. *PE (NHTSA ID #10026805, SEPTEMBER 01 2008)
- TSB #07012004 -- OIL LIFE SYSTEM RESET PROCEDURES-TRUCKS. BUICK TERAZZA 2005, GMC SIERRA DENALI 2002-2003, GMC B7 CHASSIS MEDIUM DUTY 2003-2005 AND GMC 560 C-SERIES 2003-2005 *SC (NHTSA ID #10014251, JULY 01 2004)
- TSB #030089018 -- VEHICLE CONTENT CHANGES FOR THE 2004 MODEL YEAR. *EH (NHTSA ID #10012548, JULY 01 2003)
- TSB #3857 -- SUPPLEMENT TO BULLETIN 05-01-37-002A, POOR HEAT PERFORMANCE. *AK (NHTSA ID #10019212, no date provided)
UNKNOWN OR OTHER
- TSB #020846010E -- PROGRAMMING ONSTAR MODULE FOR CANADIAN FRENCH VOICE RECOGNITION. *TT UPDATE. *TT UPDATED *EH (NHTSA ID #10002998, NOVEMBER 01 2004)
- TSB #020139007 -- AUTOMATIC DUAL ZONE HVAC BATTERY DRAW. *AR (NHTSA ID #10011227, AUGUST 01 2004)
- TSB #3019A -- DIAGNOSTIC TROUBLE CODE P0171 . *SC SERVICE ENGINE SOON LIGHT DUE TO DIAGNOSTIC TROUBLE CODE P0171. *TT (NHTSA ID #10010238, JANUARY 01 2004)
- TSB #081103 -- 8-1 SC NEW BODY STYLE LABOR TIME GUIDE CONTAINS INCORRECT INFORMATION FOR PPI LABOR OP C7000. *TT (NHTSA ID #10003864, AUGUST 11 2003)
- TSB #01444 -- XM DEALER ASSISTANCE LINE INFORMATION. *TT (NHTSA ID #10004411, JANUARY 01 2003)
- TSB #3113 -- NO CONNECT. GEN 6 VEHICLES IN ASHE, ALLEGHANY, SURRY AND WILKES COUNTY, NC CANNOT CONNECT O ONSTAR OR EMERGENCY SERVICES. *TT (NHTSA ID #10010835, no date provided)