[ switch models ] 2002 Chrysler 300M 2002 Chrysler Concorde 2002 Chrysler Neon 2002 Chrysler Sebring 2002 Chrysler Town & Country [ switch years ] 2007 Chrysler PT Cruiser 2006 Chrysler PT Cruiser 2005 Chrysler PT Cruiser 2004 Chrysler PT Cruiser 2003 Chrysler PT Cruiser 2001 Chrysler PT Cruiser 2000 Chrysler PT Cruiser

2002 Chrysler PT Cruiser

Technical Service Bulletins

There are also 4 Chrysler recalls » 5 defect investigations » 43 TSBs » for the Chrysler PT Cruiser.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB number & contact your local dealer.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING

• TSB #1900805 -- REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC (NHTSA ID #10017651, NOVEMBER 02 2005)
• TSB #1900304 -- STEERING COLUMN CLICK SOUND. *TT (NHTSA ID #10009785, AUGUST 27 2004)

STEERING:WHEEL AND HANDLE BAR

• TSB #1900402 -- SUBJECT REGARDING STEERING COLUMN CLICK SOUND. *SLC (NHTSA ID #634066, APRIL 29 2002)

STEERING:COLUMN

• TSB #1900702 -- LOWER STEERING COLUMN CLICK SOUND. *TT (NHTSA ID #10000833, APRIL 06 2004)
• TSB #1900402 -- STEERING COLUMN CLICK SOUND. *MJ (NHTSA ID #10007587, APRIL 06 2004)

STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID

• TSB #1900701 -- INFORMATION ON NEW POWER STEERING FLUID.*SLC (NHTSA ID #623172, AUGUST 03 2001)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #1802004 -- FLASH: ENGINE SAG OR ROUGH IDLE OR VEICHLE SURGE AT ENGINE SPEEDS AROUND 3000 RPM. *MJ (NHTSA ID #10007938, MAY 04 2004)
• TSB #0900704 -- IRREGULAR ENGINE SNAPPING SOUND. *TT (NHTSA ID #10006455, MARCH 02 2004)

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

• TSB #1802701 -- SOME VEHICLES MAY EXHIBIT MODERATE TO SEVERE HIGH WAY SPEED 45-60 MPH VEHICLE SURGE. *TT (NHTSA ID #628186, NOVEMBER 23 2001)

ENGINE AND ENGINE COOLING:COOLING SYSTEM

• TSB #02001A -- SUBJECT REGARDING COOLANT OUTLET RUBBER PLUG LEAK FOR PT CRUISER DIESEL, THIS IS A REVISION TO CORRECT A PART NUMBER AND ADD A PICTURE OF THE PART FOR IDENTIFICATION PURPOSES. *SLC (NHTSA ID #634137, MARCH 15 2002)
• TSB #02001 -- SUBJECT REGARDING COOLANT OUTLET RUBBER PLUG LEAK FOR PT CRUISER DIESEL. *SLC (NHTSA ID #634134, MARCH 13 2002)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

• TSB #1100103 -- LOSS OF POWER, SQUEALING / ASPIRATION SOUND, MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT (NHTSA ID #10000904, JANUARY 31 2003)

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

• TSB #1400102A -- FUEL CAP DIFFICULT TO REMOVE. *TT (NHTSA ID #10000310, OCTOBER 07 2002)
• TSB #1400102 -- SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC (NHTSA ID #634090, MAY 06 2002)

POWER TRAIN:MANUAL TRANSMISSION

• TSB #0600105 -- TRANSMISSION GEAR RATTLE SOUND AT IDLE. *TT (NHTSA ID #10012813, FEBRUARY 19 2005)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #0803006 -- POWERTRAIN CONTROL MODULE INITIALIZATION. *KB (NHTSA ID #10021239, AUGUST 25 2006)
• TSB #2100903 -- AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC (NHTSA ID #10003524, OCTOBER 02 2005)
• TSB #2100102 -- SOME VEHICLES MAY HAVE A TRANSAXLE THAT WILL NOT MOVE OR SLIPS IN REVERSE OR FIRST GEAR. *TT (NHTSA ID #635719, JULY 01 2002)
• TSB #2100601 -- AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ (NHTSA ID #621898, MARCH 16 2001)

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

• TSB #0801505 -- POWERTRAIN CONTROL MODULE INITIALIZATION. *SC (NHTSA ID #10013731, MARCH 02 2005)

POWER TRAIN:AXLE ASSEMBLY

• TSB #02020 -- DELAYED TRANSAXLE ENGAGEMENT AFTER INITIAL START UP. *TT (NHTSA ID #10000329, OCTOBER 23 2002)
• TSB #27 -- THE TRANSAXLE LOW/REVERSE ACCUMULATOR COVER O-RING ON CERTAIN VEHICLES MAY BECOME DISLODGED. *TT (NHTSA ID #10000330, OCTOBER 01 2002)
• TSB #02012 -- SOME VEHICLES MAY EXPERIENCE A SLIPPING OR NO DRIVE CONDITION IN REVERSE OR FIRST GEAR. *TT (NHTSA ID #635706, AUGUST 21 2002)
• TSB #02012 -- SOME VEHICLES MAY EXPERIENCE A SLIPPING OR NO DRIVE CONDITION IN REVERSE OR FIRST GEAR. *TT (NHTSA ID #635704, AUGUST 05 2002)

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT

• TSB #0300604 -- FRONT HUB/HALF SHAFT CLICK/POP SOUND. *TT (NHTSA ID #10010478, SEPTEMBER 15 2004)

ELECTRICAL SYSTEM

• TSB #1801603 -- INTERIOR/EXTERIOR LAMPS FLICKER. *TT (NHTSA ID #10001525, APRIL 18 2003)
• TSB #0801701 -- SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT (NHTSA ID #625620, SEPTEMBER 21 2001)
• TSB #01009 -- RAPID RESPONSE TRANSMITTION REGARDING VEHICLES BUILT AND SHIPPED WITH POSSIBLE 41TE SOLENOID ASSEMBLIES THAT MAY CONTAIN NON-HEAT TREATED PLUNGERS. *TT (NHTSA ID #620953, JULY 26 2001)
• TSB #0801001 -- SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT (NHTSA ID #620059, MAY 25 2001)

EXTERIOR LIGHTING:HEADLIGHTS

• TSB #0802801 -- MOISTURE ACCUMULATION INSIDE A VENTED HEADLAMP ASSEMBLY CONDITION. *TT (NHTSA ID #629139, AUGUST 16 2005)

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

• TSB #2300402 -- SUBJECT REGARDING FRONT WINDOW REGULATOR SQUEAK. *TT (NHTSA ID #629163, JANUARY 28 2002)

VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

• TSB #2301502 -- SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC (NHTSA ID #634077, APRIL 01 2002)
• TSB #2302701 -- SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT (NHTSA ID #625650, SEPTEMBER 21 2001)

AIR BAGS

• TSB #0800107 -- PASSENGER AIR BAG DEACTIVATION. *KB (NHTSA ID #10021599, FEBRUARY 07 2007)
• TSB #2300502 -- SUBJECT REGARDING WHITE FILM ON INSTRUMENT CLUSTER BEZEL AND/OR PASSENGER AIRBAG COVER. *TT (NHTSA ID #629148, JANUARY 28 2002)

SEAT BELTS

• TSB #0801003 -- SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT (NHTSA ID #10001520, APRIL 25 2003)

EQUIPMENT

• TSB #1801201 -- SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT (NHTSA ID #620066, MAY 25 2001)

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

• TSB #0801601 -- INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC (NHTSA ID #623312, AUGUST 03 2001)

UNKNOWN OR OTHER

• TSB #2304304 -- TRANSIT FILM REMOVAL. 2006 CHRYSLER PT CRUISER, AND 2005-2006 RAM TRUCK *SC (NHTSA ID #10013780, MARCH 09 2005)
• TSB #1802002 -- FLASH PROGRAMMING FAILURE RECOVERY. *SLC (NHTSA ID #634272, JUNE 24 2002)
• TSB #I0880302 -- SUBJECT REGARDING SPIRAL PLATE DIESEL BATTERY TESTING, CHARGING, AND VEHICLE STORAGE PROCEDURES. *SLC (NHTSA ID #633958, APRIL 22 2002)
• TSB #2200102 -- CHROME WHEEL CARE. *SLC (NHTSA ID #634082, MARCH 11 2002)
• TSB #02002 -- SUBJECT REGARDING TECHNICAL SERVICE BULLETIN 230052 INCORRECT INFORMATION, 2002 (PG/PT) PT CRUISER.*SLC (NHTSA ID #634254, MARCH 08 2002)