2004 Dodge Durango
2004 Dodge Durango TSBs (Technical Service Bulletins)
There are also 5 Dodge recalls » 11 defect investigations » 48 TSBs » for the Dodge Durango.
Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.
ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.
STEERING
- TSB #1900805 -- REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC (NHTSA ID #10017651, NOVEMBER 02 2005)
- TSB #1901204 -- STEERING COLUMN SNAPPING OR TICKING SOUND. *TT (NHTSA ID #10011930, MAY 03 2005)
- TSB #1901004 -- POWER STEERING FLUID CONTAMINATION. *TT (NHTSA ID #10011958, NOVEMBER 29 2004)
SUSPENSION
SUSPENSION:MULTIPLE AXLE
SERVICE BRAKES, HYDRAULIC
SERVICE BRAKES, AIR:ANTILOCK:INTERCONNECTING ASSEMBLY(WIRING)
ENGINE AND ENGINE COOLING
- TSB #05002 -- NEW WATER PUMP FOR 3.7L ENGINE - NO LONGER COMMON WITH 4.7L. ADVANCED SERVICE INFORMATION #05-002. *TT (NHTSA ID #10015075, APRIL 28 2005)
- TSB #1801305 -- IDLE FLUCTUATION/DIAGNOSTIC TROUBLE CODES. *TT (NHTSA ID #10015058, APRIL 19 2005)
ENGINE AND ENGINE COOLING:ENGINE
- TSB #1802406 -- ENGINE CYLINDER MISFIRE OR IGNITION COIL MALFUNCTION DURING HEAVY RAIN OR CAR WASH. *TT (NHTSA ID #10020194, JULY 21 2006)
- TSB #0422 -- 5.7L ENGINE LONG BLOCK REPAIR / REPLACE PROCEDURES. WARRANTY PLANNING & ADMINISTRATION *TT (NHTSA ID #10010567, OCTOBER 01 2004)
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
POWER TRAIN
POWER TRAIN:AUTOMATIC TRANSMISSION
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
- TSB #1800706 -- GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. *AK (NHTSA ID #10019740, MARCH 16 2006)
- TSB #0801505 -- POWERTRAIN CONTROL MODULE INITIALIZATION. *SC (NHTSA ID #10013731, MARCH 02 2005)
- TSB #1800904 -- GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. THIS BULLETIN SUPERSEDES BULLETIN 18-009-04 DATED 03/02/2004. *TT (NHTSA ID #10010485, SEPTEMBER 13 2004)
- TSB #1801404 -- 42RLE SLOW OR HARSH GEAR ENGAGEMENT AFTER INITIAL COLD START. *TT *MJ (NHTSA ID #10006574, MAY 25 2004)
- TSB #1803303 -- GENERIC POWER TRAIN CONTROL MODULE (PCM) FLASH PROCEDURE. 2004 DURANGO. *TT *MJ (NHTSA ID #10003988, MARCH 02 2004)
POWER TRAIN:AXLE ASSEMBLY
- TSB #0300104A -- THE AXLES ARE LOCATED CONSIDERABLY HIGHER THAT THE ACTUAL FLUID LEVEL. FILLING THE AXLE UNTIL THE FLUID COMES OUT OF THE FILL HOLE WILL OVER FILL THE AXLE, WHICH COULD CAUSE FLUID FOAMING. *MN *TT (NHTSA ID #10005561, MAY 11 2004)
- TSB #04004 -- CERTAIN 2004 TRUCKS EQUIPPED 8-1/4 IN. OR 9-1/4 IN. REAR AXLES MAY HAVE BEEN BUILT WITH CONTAMINATED AXLE FLUID. RAPID RESPONSE TRANSMITTAL. *TT (NHTSA ID #10005999, MARCH 03 2004)
- TSB #04004 -- CERTAIN 2004 TRUCKS EQUIPPED 8-1/4 IN. OR 9-1/4 IN. REAR AXLES MAY HAVE BEEN BUILT WITH CONTAMINATED AXLE FLUID. RAPID RESPONSE TRANSMITTAL SUPPLEMENT A. *TT (NHTSA ID #10005998, FEBRUARY 26 2004)
ELECTRICAL SYSTEM
- TSB #2100905 -- MIL (MALFUNCTION INDICATOR LAMP) ILLUMINATION FOR DTC'S (DIAGNOSTIC TROUBLE CODES) P0750, P0755, P0760, P0765, P0846, P0871 OR P0841. 2004-2005 JEEP CHEROKEE AND 2005 CHRYSLER 300/MAGNUM *SC (NHTSA ID #10013708, MARCH 22 2005)
- TSB #0801405 -- MOPAR ACCESSORY REMOTE STARTER INOPERATIVE DUE TO HOOD SWITCH. *TT (NHTSA ID #10012809, FEBRUARY 17 2005)
- TSB #10182004 -- ADDITIONAL STEP HAS BEEN ADDED TO INSTRUMENT CLUSTER DTC 2213. *EH (NHTSA ID #10013975, OCTOBER 18 2004)
- TSB #1802904 -- DRIVEABILITY IMPROVEMENTS MIL ILLUMINATION DIAGNOSTIC TROUBLE CODES P0137 P0157 P0403 P0404 P0405 P0406 P2174 P2175. *TT (NHTSA ID #10008053, JUNE 29 2004)
- TSB #1801004 -- MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION DIAGNOSTIC TROUBLE CODES (DTC'S) P0403, P0404, P0405, P0406. *TT (NHTSA ID #10006449, MARCH 02 2004)
- TSB #0800904 -- MEMORY SEAT DOES NOT RETURN TO LAST DRIVING POSITION. *TT (NHTSA ID #10006458, MARCH 02 2004)
- TSB #0800704 -- INTERMITTENT OPERATION OF ELECTRICAL COMPONENTS DUE TO IGNITION OFF DRAW (IOD) FUSE NOT BEING FULLY SEATED. *TT (NHTSA ID #10005993, FEBRUARY 17 2004)
ELECTRICAL SYSTEM:IGNITION
- TSB #1800605 -- CYLINDER MISFIRE/IGNITION COIL MALFUNCTION. *TT (NHTSA ID #10012241, MAY 13 2005)
- TSB #0800304 -- DIAGNOSTIC TROUBLE CODES BECAUSE IGNITION OFF DRAW FUSE CARTRIDGE BEING REMOVED, THE IGNITION SWITCH POSITION AND THE CONTROLLER AREA NETWORK (CAN) IN SLEEP MODE. *MN (NHTSA ID #10005583, JANUARY 06 2004)
ELECTRICAL SYSTEM: SOFTWARE
AIR BAGS:FRONTAL
SEAT BELTS
STRUCTURE:BODY:DOOR
- TSB #10182004 -- NON TROUBLE CODE POWER DOOR LOCK SYMPTOMS HAVE BEEN ADDED. *EH (NHTSA ID #10013976, OCTOBER 18 2004)
- TSB #04018 -- RAPID RESPONSE TRANSMITTAL. APPROXIMATELY 50, 2004 MODEL YEAR DURANGOS MAY HAVE BEEN SHIPPED WITH SEALER SKIPS IN THE UPPER FRONT DOOR FRAME . IF THIS CONDITION IS PRESENT, IT MAY CAUSE A CORROSION CONDITION IN THE FUTURE. *MJ (NHTSA ID #10008752, JULY 02 2004)
- TSB #10 -- THE ADHESIVE THAT BONDS THE INNER AND OUTER PANEL FLANGES OF THE LEFT FRONT (DRIVER'S) DOOR MAY NOT HAVE BEEN PROPERLY APPLIED CAUSING PREMATURE CORROSION OF THE LEFT FRONT DOOR FLANGE. CUSTOMER SATISFACTION NOTIFICATION NO. D10. *TT (NHTSA ID #10006541, MARCH 01 2004)
- TSB #04002 -- LEFT FRONT DOOR ADHESIVE SKIP POSSIBLY CAUSING A CORROSION CONDITION IN THE FUTURE. RAPID RESPONSE TRANSMITTAL. *TT (NHTSA ID #10006002, FEBRUARY 11 2004)
VEHICLE SPEED CONTROL
- TSB #1801605 -- THROTTLE BODY COKING. *TT (NHTSA ID #10015068, APRIL 12 2005)
- TSB #1803404 -- ELECTRONIC THROTTLE CONTROL DIAGNOSTICS. *TT (NHTSA ID #10009794, AUGUST 23 2004)
EQUIPMENT
EQUIPMENT:ELECTRICAL:AIR CONDITIONER
- TSB #2401605 -- 4.7L IMPROVED A/C PERFORMANCE. *SC (NHTSA ID #10017624, OCTOBER 07 2005)
- TSB #2400605B -- 5.7L FLASH: IMPROVED A/C PERFORMANCE. *SC (NHTSA ID #10013718, OCTOBER 07 2005)
- TSB #2401305 -- AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT (NHTSA ID #10016603, AUGUST 04 2005)
- TSB #10182004 -- EXCHANGE A/C HEATER CONTROL. *EH (NHTSA ID #10013992, OCTOBER 18 2004)
- TSB #30 -- DURANGO A/C SYSTEM NVH CONCERNS. *EH (NHTSA ID #10012927, APRIL 01 2004)