[ switch models ] 2005 Dodge Caravan 2005 Dodge Dakota 2005 Dodge Durango 2005 Dodge Grand Caravan 2005 Dodge Neon 2005 Dodge Power Wagon 2005 Dodge Ram 1500 2005 Dodge Ram 2500 2005 Dodge Ram 3500 2005 Dodge Stratus 2005 Dodge Vipor [ switch years ] 2006 Dodge Magnum

2005 Dodge Magnum

Technical Service Bulletins

There are also 4 Dodge recalls » 62 TSBs » for the Dodge Magnum.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB number & contact your local dealer.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING

• TSB #1900206 -- MOAN/GROAN SOUND HEARD AT IDLE. *TT (NHTSA ID #10019533, FEBRUARY 16 2006)
• TSB #1900805 -- REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC (NHTSA ID #10017651, NOVEMBER 02 2005)
• TSB #1900205 -- VARIABLE STEERING EFFORT IN COLD TEMPERATURES. *SC (NHTSA ID #10013706, MARCH 22 2005)
• TSB #1901004 -- POWER STEERING FLUID CONTAMINATION. *TT (NHTSA ID #10011958, NOVEMBER 29 2004)

SUSPENSION

• TSB #0200304 -- RIGHT LEAD/REVISED ALIGNMENT SPECIFICATIONS. 2005-2006 CHRYSLER 300/CHARGER/MAGNUM. *SC (NHTSA ID #10013692, MARCH 12 2005)
• TSB #0200404 -- SUSPENSION/TOWING/LIFTING DAMAGE. *TT (NHTSA ID #10008424, JUNE 15 2004)
• TSB #0200304 -- VEHICLE LEADS TO THE RIGHT. *TT (NHTSA ID #10007925, MAY 25 2004)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #0900505 -- MULTIPLE CYLINDER MISFIRE OR ROUGH IDLE. *TT (NHTSA ID #10018981, SEPTEMBER 16 2006)
• TSB #1801105 -- ENGINE OR RPM UNDERSHOOTING WHILE SLOWING TO A STOP. *TT (NHTSA ID #10012815, FEBRUARY 22 2005)
• TSB #1804404 -- COLD START IDLE CYCLING OR RADIATOR STEAMING AT IDLE. *TT (NHTSA ID #10011927, DECEMBER 08 2004)
• TSB #0901504 -- ENGINE OIL VISCOSITY GRADES FOR 5.7L MULTIPLE DISPLACEMENT SYSTEM (MDS). *TT (NHTSA ID #10011560, NOVEMBER 04 2004)
• TSB #0901304 -- GASOLINE ENGINE OIL QUALITY AND VISCOSITY GRADES. *TT (NHTSA ID #10009773, AUGUST 06 2004)
• TSB #1802704 -- FLASH: ROUGH IDLE OR HIGH RPM ON START OR SPARK KNOCK. *TT (NHTSA ID #10008049, JUNE 21 2004)
• TSB #0406 -- NEW LAUNCH FAST FEEDBACK ENGINE PROGRAM. WARRANTY PLANNING & ADMINISTRATION BULLETIN. *TT (NHTSA ID #10007047, APRIL 01 2004)

ENGINE AND ENGINE COOLING:COOLING SYSTEM

• TSB #04026 -- ENGINE COOLING MODULE REVISION. RAPID RESPONSE TRANSMITTAL #04-026. AN INCORRECT ENGINE COOLING MODULE (RADIATOR/FAN ASSEMBLY) WHICH COULD RESULT IN ENGINE OVERHEATING WHEN THE VEHICLE IS FULLY LOADED AND TOWING AT THE MAXIMUM LOAD RATING (NHTSA ID #10011547, NOVEMBER 05 2004)
• TSB #51 -- CUSTOMER SATISFACTION NOTIFICATION D51 ANTI-FREEZE CONCENTRATION LEVEL. THE ENGINE COOLANT MAY HAVE A LOW (WEAK) ANTI-FREEZE CONCENTRATION LEVEL. *TT (NHTSA ID #10011552, NOVEMBER 01 2004)

ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

• TSB #50 -- CUSTOMER SATISFACTION NOTIFICATION D50 RADIATOR ISOLATOR BRACKETS. THE RADIATOR ISOLATOR BRACKETS MAY CRACK. *TT (NHTSA ID #10011551, NOVEMBER 01 2004)

POWER TRAIN

• TSB #0424 -- ALL WHEEL DRIVE A580 TRANSMISSION FAST FEEDBACK PROGRAM. *TT (NHTSA ID #10010497, SEPTEMBER 01 2004)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #1803506 -- MALFUNCTION INDICATOR LAMP (MIL) ON FOR P0573. *KB (NHTSA ID #10021238, NOVEMBER 17 2006)
• TSB #1803106 -- DELAYED ENGINE CRANK OR MIL ILLUMINATION WITH DTC P0573. *KB (NHTSA ID #10020541, OCTOBER 28 2006)
• TSB #0803006 -- POWERTRAIN CONTROL MODULE INITIALIZATION. *KB (NHTSA ID #10021239, AUGUST 25 2006)
• TSB #2101105 -- NAG1 (W5A580) TRANSMISSION - SHUDDER WHEN TORQUE CONVERTER CLUTCH ENGAGES. *TT (NHTSA ID #10015066, FEBRUARY 18 2006)
• TSB #2100903 -- AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC (NHTSA ID #10003524, OCTOBER 02 2005)
• TSB #2101405 -- CLICKING SOUND FROM REAR OF VEHICLE AFTER ACCELERATING FROM A STOP. *TT (NHTSA ID #10016585, AUGUST 23 2005)
• TSB #2100205 -- TRANSMISSION FLUID MAY BE WICKING IN THE RIGHT FRONT CORNER OF THE TRANSMISSION OIL PAN AREA. *EH (NHTSA ID #10012339, MAY 07 2005)
• TSB #2100604 -- SHUDDER DURING SHIFTS. *TT THIS BULLETIN SUPERSEDES BULLETIN 21-006-04 DATED APRIL 27, 2004. *TT (NHTSA ID #10006886, OCTOBER 06 2004)
• TSB #0405 -- NAG1 TRANSMISSION EQUIPPED VEHICLES WILL BE INVOLVED IN A STAR CENTER TRANSMISSION NEW LAUNCH FEEDBACK PROGRAM. WARRANTY PLANNING & ADMINISTRATION BULLETIN. *TT (NHTSA ID #10007046, APRIL 01 2004)

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

• TSB #1800706 -- GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. *AK (NHTSA ID #10019740, MARCH 16 2006)
• TSB #1803105 -- SHIFT HESITATION DURING WIDE OPEN THROTTLE. TO INCLUDE 2005 DODGE CHARGER SRT-8. *TT (NHTSA ID #10016027, JULY 21 2005)
• TSB #1800904 -- GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. THIS BULLETIN SUPERSEDES BULLETIN 18-009-04 DATED 03/02/2004. *TT (NHTSA ID #10010485, SEPTEMBER 13 2004)
• TSB #2100904 -- FLASH: TRANSMISSION CONTROL MODULE INITIALIZE EGS-52 PROCEDURE. *MJ (NHTSA ID #10008743, JULY 08 2004)
• TSB #1803303 -- GENERIC POWER TRAIN CONTROL MODULE (PCM) FLASH PROCEDURE. 2004 DURANGO. *TT *MJ (NHTSA ID #10003988, MARCH 02 2004)

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

• TSB #2101905A -- TRANSFER CASE SHUDDER. *SC (NHTSA ID #10017629, APRIL 19 2006)
• TSB #04023 -- TRANSFER CASE VENT HOSE IMPROPERLY ROUTED WHICH COULD RESULT IN WATER ENTERING THE TRANSFER CASE AND CAUSE DRIVELINE SHUDDER (CROW HOPPING) DURING PARKING LOT MANEUVERS. RAPID RESPONSE TRANSMITTAL #04-023. *TT (NHTSA ID #10010565, OCTOBER 08 2004)

POWER TRAIN:AXLE ASSEMBLY

• TSB #0410 -- REAR AXLE NEW LAUNCH FAST FEEDBACK PROGRAM FOR ALL 2005 CHRYSLER 300 SERIES AND DODGE MAGNUM VEHICLES. *TT (NHTSA ID #10006997, APRIL 01 2004)

ELECTRICAL SYSTEM

• TSB #1801806 -- FLASH: MIL ILLUMINATION AT START-UP DUE TO DTC P2112 OR P1521. *TT (NHTSA ID #10020092, MAY 13 2006)
• TSB #0801506 -- DUE TO A SOFTWARE ISSUE IN THE FCM, SOME VEHICLES MAY EXHIBIT ILLUMINATED APPROACH, FOG LAMPS AND/OR REAR WIPER OPERATION. *TT (NHTSA ID #10019943, APRIL 01 2006)
• TSB #0803405 -- MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION, DIAGNOSTIC TROUBLE CODES (DTCS) P0037, P0058, P0131, P0132, P0133, P0138, P0151, P0153, P0159. *TT (NHTSA ID #10016925, JUNE 30 2005)
• TSB #0801405 -- MOPAR ACCESSORY REMOTE STARTER INOPERATIVE DUE TO HOOD SWITCH. *TT (NHTSA ID #10012809, FEBRUARY 17 2005)
• TSB #36 -- INACCURATE SPEEDOMETER, TACHOMETER, COOLANT TEMPERATURE, AND FUEL GAUGE READINGS. CUSTOMER SATISFACTION NOTIFICATION D36. *TT (NHTSA ID #10011936, DECEMBER 01 2004)
• TSB #1803104 -- FLASH: DRIVEABILITY IMPROVEMENTS MALFUNCTION INDICATOR LAMP (MIL) DIAGNOSTIC TROUBLE CODES P0116, P0139, P0159, P0197, U110B OR U1402. *MJ THIS BULLETIN SUPERSEDES BULLETIN 18-031-04, DATED JULY 8, 2004. *TT (NHTSA ID #10008744, NOVEMBER 12 2004)
• TSB #0803104 -- INSTRUMENT CLUSTER LANGUAGE (NON-ENGLISH) SELECTION IS NOT SAVED. *TT THIS BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 08-031-04 DATED 09/08/04. *TT (NHTSA ID #10010481, SEPTEMBER 29 2004)
• TSB #0803204 -- POOR RADIO RECEPTION. *TT (NHTSA ID #10010482, SEPTEMBER 22 2004)
• TSB #0802104 -- ERRONEOUS RADIO DIAGNOSTIC TROUBLE CODE (DTC). *TT (NHTSA ID #10007918, MAY 25 2004)
• TSB #0801804 -- WIPER LINKAGE CONTACTS MAP SENSOR WIRING. *TT (NHTSA ID #10007923, MAY 01 2004)
• TSB #0801304 -- RECALIBRATION PROCEDURES REQUIRED AFTER BATTERY DISCONNECT. *TT *MJ (NHTSA ID #10006457, APRIL 06 2004)
• TSB #30 -- LX ELECTRICAL SYSTEM. *EH (NHTSA ID #10012931, APRIL 01 2004)

EXTERIOR LIGHTING:HEADLIGHTS

• TSB #0801705 -- HEADLAMPS REMAIN ON AFTER DELAY TIME OUT. *SC (NHTSA ID #10013698, MARCH 16 2005)

VISIBILITY:WINDSHIELD WIPER/WASHER

• TSB #10182004 -- ADDED DTC B2319 AND B2315 TO WIPER SYSTEM. *EH (NHTSA ID #10013973, OCTOBER 18 2004)

AIR BAGS

• TSB #0800107 -- PASSENGER AIR BAG DEACTIVATION. *KB (NHTSA ID #10021599, FEBRUARY 07 2007)
• TSB #0803205 -- DAIMLERCHRYSLER CORPORATION IS NOW OFFERING A PASSENGER AIRBAG DEACTIVATION WIRING PACKAGE. TO INCLUDE 2006 CHRYSLER TOWN AND COUNTRY AND 300/TOURING. *TT (NHTSA ID #10016171, JANUARY 03 2006)

SEAT BELTS:FRONT:RETRACTOR

• TSB #1481 -- SEAT BELT TIGHTENING DOWN WHILE DRIVING - BEFORE REPLACING THE SEAT BELT RETRACTOR..... *TT (NHTSA ID #10016695, no date provided)

STRUCTURE

• TSB #2301805 -- POP/SNAP SOUND ON RIGHT SIDE OF INSTRUMENT PANEL. *SC (NHTSA ID #10013680, MARCH 11 2005)

STRUCTURE:BODY

• TSB #2303804 -- REAR DOOR GLASS BINDS. *TT (NHTSA ID #10010492, SEPTEMBER 23 2004)
• TSB #2302404 -- LIFT STRAP ON THE CARGO TRI-FOLD LOAD FLOOR DETACHES. *MJ (NHTSA ID #10008382, JUNE 29 2004)

STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS

• TSB #2302004 -- HOOD SECONDARY CATCH BINDING. *TT (NHTSA ID #10008055, JUNE 01 2004)

VEHICLE SPEED CONTROL

• TSB #29 -- CUSTOMER SATISFACTION NOTIFICATION D29. INTERMITTENT LOSS OF THROTTLE CONTROL. REPROGRAM POWERTRAIN CONTROL MODULE (PCM). *TT (NHTSA ID #10008816, JULY 01 2004)

TIRES:TEMPORARY/EMERGENCY SPARE TIRE

• TSB #49 -- CUSTOMER SATISFACTION NOTIFICATION D49. COMPACT SPARE WHEEL. THE WHEEL FOR THE COMPACT SPARE MAY CONTACT THE FRONT SUSPENSION LOWER CONTROL ARM BALL JOINT STUD DURING CERTAIN VEHICLE MANEUVERS. *TT (NHTSA ID #10011550, NOVEMBER 01 2004)

EQUIPMENT:ELECTRICAL:AIR CONDITIONER

• TSB #2400705 -- KNOCK SOUND HEARD AT IDLE WITH A/C ON. VARIOUS MODELS INCLUDING 2005/2006 DODGE CHARGER. *TT (NHTSA ID #10015055, APRIL 02 2005)
• TSB #2400504 -- POOR OR INTERMITTENT A/C PERFORMANCE. *TT (NHTSA ID #10012795, FEBRUARY 11 2004)

EQUIPMENT:OTHER:LABELS

• TSB #38 -- EMISSIONS RECALL D38 - VECI LABEL REPLACEMENT. AN INCORRECT VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL WAS INADVERTENTLY INSTALLED. *TT (NHTSA ID #10010494, SEPTEMBER 01 2004)

UNKNOWN OR OTHER

• TSB #2304006 -- REAR OF SUNROOF GLASS IS NOT FLUSH TO ROOF/SUNROOF WILL NOT CLOSE. *KB (NHTSA ID #10020544, SEPTEMBER 26 2006)