Huge win for car owners! All TSBs to be made public. The Center for Auto Safety just made the NHTSA (US Government) make public the full text of all TSBs from now on. They are the same organization that has petitioned the NHTSA & filed lawsuits to protect car owners over exploding gas tanks & other major safety issues. Whenever you drive in your car, you are safer thanks in part to a lot of work over the years by this small but very effective consumer advocacy group.

Please take a moment & say thank you by donating $5 or whatever you can to the Center for Auto Safety. Notes: The 2005 Escape has problems where the engine shuts down while driving. Ford finally issued a September 2014 recall. Time will tell if the recall fix really solves the problem.

However the 2005 Escape also has a defect where the PCM (Power Control Module) fries at around 100k miles. Ford extended the PCM warranty to 80,000 miles, but only after most owners were past the mileage limit. Now owners are on the hook for the average repair cost of over $2,000 (!!)


definitely annoying
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
30,000 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2005 Ford Escape AC / heater problems

AC / heater problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2005 Ford Escape:

Unsubscribe any time. We don't sell/share your email.

2005 Ford Escape Owner Comments

problem #1

Jun 262014


  • 30,000 miles


The contact owns a 2005 Ford Escape. The contact stated that the air conditioning unit only blew out hot air. The vehicle was taken to the dealer where it was diagnosed that the air conditioning compressor was defective and needed to be replaced. The vehicle was not repaired. The manufacturer was notified. The failure mileage was approximately 30,000. The VIN was not provided.

- St. Clairsville, OH, USA

Not what you are looking for?