2003 Ford Excursion
2003 Defect Investigations
There are also 3 Ford recalls » 13 defect investigations » 199 TSBs » for the Ford Excursion.
ENGINE STALLING: Engine And Engine Cooling:Engine:Diesel**
Recall #05V270000
** This defect investigation is filed under 3 related vehicle components.
2003 FORD EXCURSION -- In a June 7, 2005 letter, Ford notified ODI that it would be conducting a safety recall of approximately 180,000 Ford F-Super Duty, Excursion and E-series vehicles equipped with 6.0L diesel engines to correct two wiring related conditions that could result in engine stall (NHTSA recall no. 05V-270, Ford no. 05S34). The affected vehicles were built between September 29, 2003 and May 31, 2004. According to Ford, vehicles with the conditions may stall without warning and may or may not restart. Ford will instruct owners of vehicles included in the recall to take their vehicles to a dealer to have the fuel injector control module wire harness upgraded or replaced and or have a new injection control pressure sensor connector installed. During a May 2005 presentation to ODI, Ford identified a number of potential failure mechanisms that could affect engine performance in various segments of the subject vehicle population, including the wiring conditions addressed by 05V-270. The wiring conditions, which both affect engine fueling, were the most likely conditions to result in engine stall. The recalled vehicles comprise approximately 43% of the subject vehicle population and account for 75 of the 113 ODI reports that have a valid VIN (66%). the voq complaint rate for the recall population is 45/100K while the rate for vehicles outside the recall population is 17/100K and their trend (by date of receipt) is declining. Based on the analysis, ODI believes Ford¿S actions are sufficient to address the current safety risks and the investigation is thus closed. The closing of this investigation does not constitute a finding by NHTSA that a safety related defect does not exist. Further action will be taken if warranted by future circumstances.
Investigation was initiated on February 15 2005. Closed on November 02 2005. For detailed information & supporting documents, see the official NHTSA page concerning investigation #EA05003 »
ENGINE STALLING: Engine And Engine Cooling:Engine:Diesel
no recall issued
2003 FORD EXCURSION -- Twenty five of the ODI failure reports are duplicative of Ford complaints. Twenty ODI reports do not contain a VIN (and may or may not be duplicative of Ford reports). The 14 alleged crashes and 2 alleged injuries were all minor. Submitted during preliminary evaluation (PE) 04-070, Ford's response to ODI's information request (ir) letter contained about 5,000 consumer reports (mors) and 8,700 field reports (cqis). Ford reviewed the complaints and categorized them. The manufacturer reports shown above represent a count of unique vehicles that Ford categorized as allegedly stalling due to a subject engine component ('a' category, see Ford's ir response letter for further detail); some of these vehicles received multiple reports. ODI has not yet confirmed Ford's categorization of these reports, nor has ODI confirmed Ford's categorization of the remaining reports (which Ford states do not pertain to the alleged defect). Ford submitted nearly 19,000 warranty claims, many of which involved claims for a technical service bulletin (tsb 04-13-08) and field service action (fsa 03B05) which Ford identified as potential remedies for stalling complaints. ODI has not confirmed that either of these are a remedy for engine stalling complaints. Several other dealer communications related to engine stall were also submitted as well as over 50 product modifications, 15 of which involve revisions to the software for the electronic engine control unit. Further investigation is required and ODI is upgrading PE04-070 to an engineering analysis (ea). During the ea, ODI will establish and update manufacturer failure report counts, further investigate the frequency and trend of stalling complaints, and determine the scope and safety implication of stalling events. ODI will also investigate Ford's remedies, their effectiveness, and whether further action is required. Investigation was initiated on October 07 2004. Closed on February 15 2005. For detailed information & supporting documents, see the official NHTSA page concerning investigation #PE04070 »
NHTSA Defect Investigation #DP05005SPARK PLUG EJECTION FROM CYLINDER HEAD: Engine And Engine Cooling:Engine:Gasoline**
no recall issued
** This defect investigation is filed under 3 related vehicle components.
2003 FORD EXCURSION -- On September 6, 2005, ODI received a petition requesting that the Agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 Ford vehicles with Triton V-8 and V-10 engines. ODI received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine. As of December 8, 2005, ODI is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles. In addition, ODI is aware of only two incidents where the vehicle stalled without restart. Information contained in the ODI consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on MY 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall. In the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine. In one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire. In another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location. None of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident. As the petitioner noted, and ODI¿S analysis showed, it is possible for a spark plug to detach from the engine cylinder threads in the subject vehicles. However, ODI¿S analysis of 474 complaints describing such incidents found only a very few alleged any safety-related consequences. None of these showed any evidence of a serious safety consequence. Given the large population and relatively long exposure time of the subject vehicles, the complaint analysis indicates that the risk to motor vehicle safety from the alleged defect is very low. In view of the foregoing, it is unlikely that NHTSA would issue an order for the notification and remedy of the alleged defect at the conclusion of the investigation requested in the petition. Therefore, in view of the need to allocate and prioritize NHTSA¿S limited resources to best accomplish the Agency¿S safety mission, the petition is denied.
Investigation was initiated on September 22 2005. Closed on January 04 2006. For detailed information & supporting documents, see the official NHTSA page concerning investigation #DP05005 »
ACCELERATOR PEDAL SENSOR FAILURE (ETC): Vehicle Speed Control:Accelerator Pedal**
no recall issued
** This defect investigation is filed under 2 related vehicle components.
2003 FORD EXCURSION -- The subject vehicles for this investigation include model year 2002 and 2003 Excursion and F Super Duty trucks equipped with 7.3L diesel engines and an optional power adjustable pedal (pap) feature. The subject vehicles utilize an electronic throttle control (etc) system to control engine speed and power. The accelerator pedal position sensor of the etc system was replaced under Ford's field service action (fsa) 03B03 (announced in February 2003) due to concerns that it may not operate as designed and as a result, may cause the vehicle to continue to idle or unexpectedly slow when the accelerator is applied. Certain complaint and warranty information related to the vehicles involved in fsa 03B03 has not been provided by Ford, as discussed in detail in Ford's response letter (dated December 2, 2003) to ODI's preliminary evaluation information request. This additional information, which is required to adequately assess the safety implications of the alleged defect, will be obtained and analyzed during the engineering analysis phase of the investigation. The manufacturer failure report counts will be determined at that time.
Investigation was initiated on September 26 2003. Closed on February 18 2004. For detailed information & supporting documents, see the official NHTSA page concerning investigation #PE03044 »
ACCELERATOR PEDAL SENSOR (ETC): Vehicle Speed Control:Linkages**
no recall issued
** This defect investigation is filed under 4 related vehicle components.
2003 FORD EXCURSION -- Failure counts from ODI¿S analysis are stated above; see the additional problem experience discussion in the summary report. Ford data contained duplicative reports for 4 ODI complaints and 1 crash. Three crashes were allegedly due to intermittent operation of the electronic throttle control (etc) pedal, one crash occurred when an etc disabled vehicle was struck by another motorist, one report contained no detail. The injuries were minor. An issue involving fixed etc pedals was investigated also, however failure reports and populations are not shown above; see summary report for detail. Although Ford has used etc based throttle control systems for many years, the pap feature was new for MY 2002. The subject etc sensor produces two output signals which the engine management system (ems) utilizes to:1) determine fueling requirements; and 2) perform sensor diagnostics. One signal is linearly proportional to throttle pedal position; the second is a digital signal. By design, the detection of a sensor fault results in the engine returning to (or remaining at) the idle state. Ford identified a defect in the pap etc sensor which prematurely affected an output signal; the migration of internal sensor lubricant caused a loss of proportional signal. The failure mechanism is progressive and as the sensor deteriorates, the ems will detect a fault, store a fault code, illuminate a warning lamp, and the engine may remain at/return to idle. In the early stages, normal operation can be regained by pedal re-application. The failure progresses until the engine remains at idle. The engine does not stall, power assisted steering and braking systems are unaffected. Ford corrected the etc sensor defect and conducted field service action (fsa) 03B03 to replace etc pedals, addressing 50% of vehicles. At Agency request to improve completion rate, Ford extended fsa 03B03 for 6 months. Based on ODI's analysis of available data, Ford's action has appropriately resolved the etc sensor proplem in the subject vehicles. The closing of the investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and should not be considered as having any precedential value or effect binding the Agency in future defect investigations. See the attached summary report for additional information.
Investigation was initiated on February 23 2004. Closed on February 10 2005. For detailed information & supporting documents, see the official NHTSA page concerning investigation #EA04006 »