Huge win for car owners! All TSBs to be made public. The Center for Auto Safety just made the NHTSA (US Government) make public the full text of all TSBs from now on. They are the same organization that has petitioned the NHTSA & filed lawsuits to protect car owners over exploding gas tanks & other major safety issues. Whenever you drive in your car, you are safer thanks in part to a lot of work over the years by this small but very effective consumer advocacy group.

Please take a moment & say thank you by donating $5 or whatever you can to the Center for Auto Safety. Notes: The 2002 Ford Explorer is hands-down our worst vehicle on record. "Avoid like the plague" is putting it lightly.

The 2002-2005 Explorer has a very well-established record of expensive transmission failure at under 100k miles. The Explorer has an enclosed transmission which is typically replaced with a rebuilt transmission at a cost of almost $3,000.

Another common problem for the 2002-2003 Explorer is wheel bearing failure at around 90k miles, with a typical repair bill of $500 to $1000 depending on how many wheel bearings failed.

Adding insult to injury, the 2002-2005 Explorer also has a massive problem with the rear panel cracking. While it's a minor annoyance compared to transmission failure, ironically the crack usually goes right through the Ford logo.


fairly significant
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
15,000 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2002 Ford Explorer brakes problems

brakes problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2002 Ford Explorer:

Unsubscribe any time. We don't sell/share your email.

2002 Ford Explorer Owner Comments

problem #1

May 112002

Explorer 4WD 6-cyl

  • Automatic transmission
  • 15,000 miles


Excessive problems with transmission jerking, and shifting problems, purchased vehicle as brand new after 4 months contacted dealer where care was purchased regarding problem. Brought vehicle in at least twice before problem was found.the transmission was replaced has since had the same problem along with other problems, vehicle stalling while driving, cd player power shuts off. Rattling when hitting brakes. Filed a complaint dealer refuses to buy car back ask me to trade car in with more money down. The dealer repair persons confirmed that they have had replaced at least 10 transmissions on the same style vehicle prior to my visit and recognized a pattern. But nothing has been done!!

- Perris, CA, USA

Not what you are looking for?