Huge win for car owners! All TSBs to be made public. The Center for Auto Safety just made the NHTSA (US Government) make public the full text of all TSBs from now on. They are the same organization that has petitioned the NHTSA & filed lawsuits to protect car owners over exploding gas tanks & other major safety issues. Whenever you drive in your car, you are safer thanks in part to a lot of work over the years by this small but very effective consumer advocacy group.

Please take a moment & say thank you by donating $5 or whatever you can to the Center for Auto Safety.

CarComplaints.com Notes: The 2004 Ford Explorer one of our worst vehicles on record. "Avoid like the plague" is putting it lightly.

The 2002-2005 Explorer has a very well-established record of expensive transmission failure at under 100k miles. The Explorer has an enclosed transmission which is typically replaced with a rebuilt transmission at a cost of almost $3,000.

Another common problem for the 2002-2005 Explorer is wheel bearing failure at around 90k miles, with a typical repair bill of $500 to $1000 depending on how many wheel bearings failed.

Adding insult to injury, the 2002-2005 Explorer also has a massive problem with the rear panel cracking. While it's a minor annoyance compared to transmission failure, ironically the crack usually goes right through the Ford logo.

5.2

fairly significant
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
18,333 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2004 Ford Explorer accessories - interior problems

accessories - interior problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2004 Ford Explorer:

Unsubscribe any time. We don't sell/share your email.

2004 Ford Explorer Owner Comments

problem #3

Dec 072007

Explorer 4WD 6-cyl

  • Automatic transmission
  • 20,000 miles

A D V E R T I S E M E N T S

The contact owns a 2004 Ford Explorer. The vehicle was quality checked with a 115 point inspection; however, she was later notified that the vehicle was in a major crash. The driver side door is misaligned. The sunroof was replaced with tape. She doesn't know if the vehicle is equipped with air bags. The windows have condensation on the inside of the vehicle. The speedometer does not register the proper speed in the vehicle. The approximate speed can range from 20 to 50mph. The fuel pump and sensors were replaced. The vehicle was purchased March 20, 2007. The dealer stated that the vehicle is currently operating normally. The dealer has diagnosed the failure on several occasions. The failure mileage was 20,000 and the current mileage was 23,000.

- Burbank , IL, USA

problem #2

Aug 012006

Explorer 6-cyl

  • Automatic transmission
  • 35,000 miles
The contact owns a 2004 Ford Explorer. While driving 40 mph, all of the warning indicator lights illuminated on the instrument panel. The speedometer and tachometer malfunctioned and the headlights dimmed. The dealer installed a wire harness, cluster, and PCM; however, the failure continued. The VIN and engine size were unknown. The failure mileage was 35,000 and current mileage was 66,000.

- Baltimore, MD, USA

problem #1

Jan 032006

Explorer 4WD 8-cyl

  • Automatic transmission
  • miles
2004 Ford Explorer limited-owned SUV for 38K been in shop repeatedly-from minor to major things. SUV is a $ 34,000 turd. Currently needing to go back to shop for multiple repairs. The day our warranty expires car is gone.

- Indianola, IA, USA

Not what you are looking for?