CarComplaints.com Notes: The 2005 Ford Explorer one of our worst vehicles on record. "Avoid like the plague" is putting it lightly.

The 2002-2005 Explorer has a very well-established record of expensive transmission failure at under 100k miles. The Explorer has an enclosed transmission which is typically replaced with a rebuilt transmission at a cost of almost $3,000.

Adding insult to injury, the 2002-2005 Explorer also has a massive problem with the rear panel cracking. While it's a minor annoyance compared to transmission failure, ironically the crack usually goes right through the Ford logo.

10.0

really awful
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
0 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2005 Ford Explorer exhaust system problems

exhaust system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2005 Ford Explorer:

Unsubscribe any time. We don't sell/share your email.

2005 Ford Explorer Owner Comments

problem #1

Jun 222005

Explorer 8-cyl

  • miles

A D V E R T I S E M E N T S

The tailpipe on the 2005 Ford Explorer had burned the left side of the bumper. The tailpipe was found to be too flexible. The dealerships final conclusion was that the problem was due to driver error.

- Turnersville, NJ, USA

Not what you are looking for?