CarComplaints.com Notes: The 2005 Ford Explorer one of our worst vehicles on record. "Avoid like the plague" is putting it lightly.

The 2002-2005 Explorer has a very well-established record of expensive transmission failure at under 100k miles. The Explorer has an enclosed transmission which is typically replaced with a rebuilt transmission at a cost of almost $3,000.

Adding insult to injury, the 2002-2005 Explorer also has a massive problem with the rear panel cracking. While it's a minor annoyance compared to transmission failure, ironically the crack usually goes right through the Ford logo.

8.0

pretty bad
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
5,000 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2005 Ford Explorer suspension problems

suspension problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2005 Ford Explorer:

Unsubscribe any time. We don't sell/share your email.

2005 Ford Explorer Owner Comments

problem #1

Sep 122005

Explorer 6-cyl

  • Automatic transmission
  • 5,000 miles

A D V E R T I S E M E N T S

2005 Ford Explorer. The contact states the vehicle has been in the repair shop four times with nine repairs since purchase, approximately a month ago. The rear axle assembly/wheel bearings had to be replaced. Also, the rear window on the driver's side/the pulley in the motor, had to be replaced, and the computer chip had to be reset. The key was getting stuck in the ignition; the dealership could find what was wrong with ignition. There were other problems with the vehicle, but the contact did not have that information. The contact was asking Ford to take the vehicle back at this time. A service advisor was suppose to speak with the contact.

- Mufreesboro, TN, USA

Not what you are looking for?