Huge win for car owners! All TSBs to be made public. The Center for Auto Safety just made the NHTSA (US Government) make public the full text of all TSBs from now on. They are the same organization that has petitioned the NHTSA & filed lawsuits to protect car owners over exploding gas tanks & other major safety issues. Whenever you drive in your car, you are safer thanks in part to a lot of work over the years by this small but very effective consumer advocacy group.

Please take a moment & say thank you by donating $5 or whatever you can to the Center for Auto Safety.


really awful
Crashes / Fires:
2 / 0
Injuries / Deaths:
3 / 0
Average Mileage:
17,908 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2004 Ford Explorer Sport Trac brakes problems

brakes problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2004 Ford Explorer Sport Trac:

Unsubscribe any time. We don't sell/share your email.

2004 Ford Explorer Sport Trac Owner Comments

problem #3

Aug 312005

Explorer Sport Trac 6-cyl

  • Automatic transmission
  • 32,000 miles


The caller said that while slowing down and when applying the brakes they went to the floor, and vehicle rolled through a stop light. This happened once and without warning. It resulted in an accident, and the vehicle was towed to a body shop after the insurance company approved it. Dealer and manufacturer have not been contacted yet. A police report was taken. The caller was injured.

- Greenville, SC, USA

problem #2

Oct 282004

Explorer Sport Trac 4WD 6-cyl

  • Automatic transmission
  • 21,724 miles
October 28, 2004, motor vehicle accident, chain reaction 3 vehicle, I was at full stop with foot on brake. Vehicle behind me stopped, next vehicle did not stop, pushed vehicle behind me into and under the driver side rear of my vehicle. Bumper damage, truck bed twisted several inches, etc. My seat belt did not hold/catch or stop my forward movement. I was thrown into the steering wheel and then snapped back, injuring my head, neck, mid and low back, I had numbness and tingling bilateral lower extremities, and bilateral upper extremities. I also experienced severe muscle spasms neck and mid back. I hit the steering wheel hard. The air bag did not engage. Passenger seat belt engaged and protected my passenger. I was taken to an emergency hospital, C-spine/backboard, neck and back spasms, lots of pain, tingling bilateral arms and legs, etc. Now unable to work, unknown time due to neck and back injury. I am an er nurse. If my seat belt had held me, I would probably be at work right now and not writing this complaint. Your question of number of failures: The belt catches about 1 in 30 or more attempt to get it to hold/catch. I am awaiting a scheduled mri of my spine, and will be following up with a neurologist. The seat belt has not been repaired at yet and remains faulty.

- Sacramento, CA, USA

problem #1

Mar 122004

Explorer Sport Trac

  • miles
While driving over standing water or snow rear ABS brakes failintermittently.

- Celina, TN, USA

Not what you are looking for?