[ switch models ] 2004 Ford E-350 2004 Ford Escape 2004 Ford Excursion 2004 Ford Expedition 2004 Ford Explorer 2004 Ford Explorer Sport Trac 2004 Ford F-250 2004 Ford F-350 2004 Ford F-450 2004 Ford F-550 2004 Ford Focus 2004 Ford Mustang 2004 Ford Ranger 2004 Ford Taurus 2004 Ford Thunderbird [ switch years ] 2008 Ford F-150 2006 Ford F-150 2005 Ford F-150 2003 Ford F-150 2002 Ford F-150 2001 Ford F-150 2000 Ford F-150 1999 Ford F-150 1998 Ford F-150 1997 Ford F-150 1996 Ford F-150 1995 Ford F-150 1994 Ford F-150 1993 Ford F-150 1992 Ford F-150 1991 Ford F-150 1990 Ford F-150 1989 Ford F-150 1988 Ford F-150 1987 Ford F-150 1986 Ford F-150 1985 Ford F-150 1984 Ford F-150 1977 Ford F-150

2004 Ford F-150

Technical Service Bulletins

There are also 11 Ford recalls » 3 defect investigations » 135 TSBs » for the Ford F-150.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB number & contact your local dealer.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING

• TSB #03208 -- STEERING WHEEL SHIMMY/NIBBLE AT 100 KM/H (60 MPH) AND GREATER SPEEDS ON VEHICLES BUILT PRIOR TO 8/20/2003. *TT (NHTSA ID #10004891, JANUARY 01 2006)
• TSB #04257 -- VEHICLE/STEERING WHEEL VIBRATION AT 50 MPH (80 KM/H) OR HIGHER - STEERING WHEEL NIBBLE AT 65 MPH (105 KM/H) OR HIGHER. *TT (NHTSA ID #10014252, JANUARY 01 2006)
• TSB #17169 -- STEERING WHEEL NIBBLE AT 60 MPH AND HIGHER. *TT (NHTSA ID #10004062, SEPTEMBER 01 2003)

STEERING:HYDRAULIC POWER ASSIST SYSTEM

• TSB #17731 -- WHINE FROM POWER STEERING. *TT (NHTSA ID #10008232, APRIL 01 2004)

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

• TSB #07213 -- HIGH PRESSURE POWER STEERING LINE SEEPAGE-COLD CLIMATES ONLY (EXCLUDING HERITAGE F-150). *NJ (NHTSA ID #10023854, OCTOBER 01 2007)
• TSB #17823 -- POWER STEERING LEAK - SERVICE TIP. *TT (NHTSA ID #10008572, MAY 01 2004)

SUSPENSION

• TSB #05131 -- SHUDDER/VIBRATION ON MODERATE TO HARD ACCELERATION. *SC (NHTSA ID #10016794, JANUARY 01 2006)
• TSB #05919 -- FRONT TIRE WEAR ON INSIDE AND/OR OUTSIDE EDGE. *TT RAPID FEATHERING WEAR OF FRONT TIRES. *TT RAPID SHOULDER (TOE) WEAR ON INSIDE EDGE OF FRONT TIRES. *TT (NHTSA ID #10017938, JUNE 07 2005)
• TSB #050502 -- FRONT END SHUDDER/VIBRATION WHEN BRAKING - VEHICLES BUILT BEFORE 11/18/2004. *TT (NHTSA ID #10017890, APRIL 01 2005)
• TSB #18161 -- VIBRATION 45 MPH (72 KM/H) AND HIGHER. *TT (NHTSA ID #10011340, SEPTEMBER 01 2004)
• TSB #0433 -- VIBRATION AT HIGHWAY SPEEDS. SERVICE TIPS. *TT (NHTSA ID #10007362, JANUARY 26 2004)

SUSPENSION:FRONT

• TSB #07109 -- VIBRATION FROM THE DRIVELINE AT HIGHWAY SPEEDS. *KB (NHTSA ID #10022160, no date provided)

SUSPENSION:REAR

• TSB #050618 -- REAR AXLE NOISE REPAIR. *SC (NHTSA ID #10016789, JANUARY 01 2005)

SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

• TSB #17777 -- REAR LEAF SPRING NOISE. *TT (NHTSA ID #10008552, MAY 01 2004)

SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY

• TSB #0765 -- REAR AXLE TUBE FRACTURE AT CENTER CARRIER. *KB (NHTSA ID #10022279, no date provided)
• TSB #061916 -- SHUDDER/VIBRATION ON MODERATE TO HARD ACCELERATION. *KB (NHTSA ID #10021178, no date provided)

SERVICE BRAKES, HYDRAULIC

• TSB #050621 -- FRONT BRAKE ROUGHNESS - SHUDDER WHILE BRAKING. *TT (NHTSA ID #10017808, OCTOBER 31 2005)
• TSB #18678 -- REPEAT BRAKE SHUDDER/VIBRATION FROM THE FRONT BRAKES WHEN BRAKING. *TT (NHTSA ID #10017872, JUNE 01 2005)
• TSB #042611 -- FRONT END SHUDDER/VIBRATION WHEN BRAKING - VEHICLES BUILT BEFORE 11/18/2004. *TT (NHTSA ID #10014683, MARCH 21 2005)
• TSB #041501 -- FRONT END SHUDDER/VIBRATION WHEN BRAKING - VEHICLES BUILT BEFORE 11/18/2004. *TT (NHTSA ID #10014280, DECEMBER 31 2004)
• TSB #04151 -- FRONT END SHUDDER/VIBRATION WHEN BRAKING. *TT (NHTSA ID #10011147, AUGUST 09 2004)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

• TSB #012605 -- FORD MOTOR COMPANY HAS MADE A DESIGN CHANGE TO THE FRONT BRAKE LINE(S) ON ALL F-150'S BUILD 11/29/04 AND LATER. RANCHO PRODUCT ADVISORY BULLETIN. *TT (NHTSA ID #10012773, no date provided)

SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE

• TSB #17570 -- ANTI-LOCK BRAKE SYSTEM (ABS) WARNING INDICATOR ON AND/OR ABS RELATED DIAGNOSTIC TROUBLE CODES (DTCS). *TT (NHTSA ID #10008133, FEBRUARY 01 2004)

SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE

• TSB #17750 -- ANTI-LOCK BRAKE SYSTEM (ABS) WARNING INDICATOR ON AND/OR ABS RELATED DIAGNOSTIC TROUBLE CODES (DTCS). *TT (NHTSA ID #10008243, APRIL 01 2004)

SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT

• TSB #17272 -- LACK OF POWER WITH THE MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODE (DTC) P2106 (THROTTLE ACTUATOR CONTROL SYSTEM - FORCED LIMITED POWER) STORED AND ANTI-LOCK BRAKE SYSTEM LIGHTS ON. *TT (NHTSA ID #10004919, OCTOBER 01 2003)

PARKING BRAKE

• TSB #08-14-18 -- INTERMITTENT VEHICLE VIBRATION--PARKING BRAKE DISENGAGEMENT CONCERNS. *NJ (NHTSA ID #10024843, MARCH 01 2008)

ENGINE AND ENGINE COOLING

• TSB #041601 -- WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT (NHTSA ID #10018745, NOVEMBER 14 2005)
• TSB #05173 -- MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1131 AND/OR P1151 - 4.2L ENGINE. *TT (NHTSA ID #10018741, NOVEMBER 14 2005)
• TSB #05215 -- BUCK/JERK OR SURGE - 6.0L VEHICLES BUILT BEFORE 8/22/2005. *TT (NHTSA ID #10017806, OCTOBER 31 2005)
• TSB #051713 -- COOLANT DEGAS BOTTLE OVERFLOW. *TT (NHTSA ID #10018062, OCTOBER 07 2005)
• TSB #18734 -- DIAGNOSTIC TROUBLE CODE P0488 SET AFTER REFLASH. *TT (NHTSA ID #10017864, JULY 01 2005)
• TSB #04221 -- MALFUNCTION INDICATOR LAMP ON WITH MISFIRE DTC'S SPARK KNOCK PISTON SCUFFING. *EH VEHICLES BUILT THROUGH 4/25/2005 - 5.4L 3V ENGINE. *TT (NHTSA ID #10013393, JUNE 07 2005)
• TSB #18342 -- TICKING NOISE FROM UPPER ENGINE. *EH (NHTSA ID #10014608, DECEMBER 01 2004)
• TSB #042114 -- HESITATION ON ACCELERATION AND OR ERRATIC IDLE WHEN COMING TO A STOP. *EH (NHTSA ID #10013387, NOVEMBER 01 2004)
• TSB #04209 -- LOW POWER - COLD SIDE CHARGE AIR COOLER (CAC) DISCONNECTED - OIL LEAK AT COLD SIDE CAC CONNECTIONS - 6.0L ENGINE - VEHICLES BUILT 12/15/2003 THROUGH 4/1/2004. *TT (NHTSA ID #10010724, OCTOBER 18 2004)
• TSB #18449 -- ENGINE VIBRATION DURING NETURAL RUN UP. *EH (NHTSA ID #10014637, MARCH 01 2004)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #05255 -- 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK. *TT (NHTSA ID #10019383, JANUARY 01 2006)
• TSB #05515 -- ROUGH IDLE - 5.4L AND 4.6L ENGINES. *TT (NHTSA ID #10014700, MARCH 21 2005)
• TSB #0531 -- MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM). *TT (NHTSA ID #10012947, FEBRUARY 21 2005)
• TSB #051015 -- 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK. *TT (NHTSA ID #10018935, JANUARY 01 2005)
• TSB #042424 -- CAMSHAFT AND LASH ADJUSTER DESIGN CHANGE ON A 5.4L 3V ENGINE. *TT (NHTSA ID #10014152, DECEMBER 13 2004)
• TSB #031404 -- ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. (NHTSA ID #10011162, AUGUST 23 2004)
• TSB #18091 -- TICKING NOISE FROM UPPER ENGINE. *TT (NHTSA ID #10013241, AUGUST 01 2004)
• TSB #17666 -- DIAGNOSTIC TROUBLE CODE (DTC) U0300 (INTERNAL CONTROL MODULE SOFTWARE INCOMPATIBILITY) STORED IN THE PCM WITH NO OTHER DTC'S PRESENT. *TT (NHTSA ID #10007423, MARCH 01 2004)
• TSB #03256 -- ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ (NHTSA ID #10008278, DECEMBER 22 2003)
• TSB #06152 -- SPARK PLUG REMOVAL INSTRUCTIONS - 5.4 3V. *KB (NHTSA ID #10021048, no date provided)
• TSB #061912 -- DIAGNOSTIC TROUBLE CODES (DTC) P0340, P0344, P0345, P0349. ARE FOUND. *KB (NHTSA ID #10020792, no date provided)

ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO-CHARGER

• TSB #20228 -- 1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ (NHTSA ID #10024865, APRIL 01 2008)

ENGINE AND ENGINE COOLING:COOLING SYSTEM

• TSB #17781 -- HOOT, MOAN, OR WHISTLE FROM COOLING SYSTEM AT 2200 RPM. *TT (NHTSA ID #10008555, MAY 01 2004)

ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

• TSB #040205 -- MAGNESIUM ALLOW RADIATOR CORE SUPPORT - UNIQUE HANDLING AND REPAIR PROCEDURES - SERVICE TIPS. *TT (NHTSA ID #10014270, DECEMBER 27 2004)
• TSB #0425 -- MAGNESIUM ALLOY RADIATOR CORE SUPPORT. UNIQUE HANDLING AND REPAIR PROCEDURES. SERVICE TIPS. *TT (NHTSA ID #10007367, FEBRUARY 09 2004)

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

• TSB #0543 -- COOLING FAN CLUTCH NOISE - VEHICLES BUILT PRIOR TO 10/1/2004 - 5.4L AND 4.6L ENGINES. *TT (NHTSA ID #10014643, MARCH 07 2005)
• TSB #17759 -- ENGINE COOLING FAN NOISE THAT SOUNDS LIKE A ROLLING IDLE. *TT (NHTSA ID #10008249, APRIL 01 2004)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

• TSB #17655 -- EVIDENCE OF OIL IN THE AIR INTAKE SYSTEM. *TT (NHTSA ID #10007419, MARCH 01 2004)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

• TSB #03L17 -- DEMONSTRATION/DELIVERY HOLD - SPECIAL FIELD ACTION 03L17. REVISED SMOG EMISSIONS INFORMATION. *TT (NHTSA ID #10008284, DECEMBER 01 2003)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

• TSB #05417 -- INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT (NHTSA ID #10014666, MARCH 07 2005)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

• TSB #0554 -- USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT (NHTSA ID #10014685, MARCH 21 2005)

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

• TSB #020503 -- GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT (NHTSA ID #636417, MARCH 21 2005)

FUEL SYSTEM, OTHER

• TSB #18217 -- MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT (NHTSA ID #10010731, OCTOBER 01 2004)
• TSB #17316 -- FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT (NHTSA ID #10008166, NOVEMBER 01 2003)

FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM

• TSB #08-2-9 -- ERRATIC FUEL GAUGE OPERATION - MIL ON --DTCS P040/P0463 OR INSTRUMENT CLUSTER MODULE DTC B1201--VEHICLES BUILT BEFORE 12/3/2007. *NJ (NHTSA ID #10024324, FEBRUARY 01 2008)

POWER TRAIN

• TSB #0645 -- NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS. *TT (NHTSA ID #10019947, JANUARY 01 2006)
• TSB #052118 -- SERVICE PROCEDURE FOR REPAIR OR REPLACEMENT OF COLUMN SHIFT CABLE. *TT (NHTSA ID #10017807, OCTOBER 31 2005)
• TSB #18250 -- INTERMITTENT CLUNK ON 3-2 DOWNSHIFT DURING COASTDOWN/TIP-IN. OASIS. TO INCLUDE 2005 F-150, E-SERIES AND EXPEDITION. *TT (NHTSA ID #10010743, OCTOBER 01 2004)
• TSB #18209 -- HARSH/SLIPPING SHIFTS AND/OR HARSH/DELAYED ENGAGEMENT INTO DRIVE OR REVERSE. *TT (NHTSA ID #10010727, OCTOBER 01 2004)
• TSB #17305 -- SOME VEHICLES BUILT BEFORE 9/16/03 EQUIPPED WITH A 4.6L/5.4L ENGINE AND 4R75E TRANSMISSION MAY EXHIBIT THE TRANSMISSION CONCERN INDICATOR LAMP (TCIL) ON WITH DIAGNOSTIC TROUBLE CODE P0733 (3RD GEAR RATIO ERROR) AND/OR P0734 (4TH GEAR RATIO (NHTSA ID #10004946, OCTOBER 01 2003)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #17440 -- CAN NOT SHIFT TRANSMISSION OUT OF PARK CAUSED BY AN OPEN FUSE F2.14. *TT (NHTSA ID #10008299, DECEMBER 01 2003)

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

• TSB #08-5-13 -- 4.6L/5.4L--MIL P0506 AND/OR P0505--HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM. *NJ (NHTSA ID #10024828, MARCH 01 2008)
• TSB #042107 -- GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT (NHTSA ID #10014086, DECEMBER 13 2004)
• TSB #04217 -- GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT (NHTSA ID #10013369, NOVEMBER 01 2004)

POWER TRAIN:DRIVELINE

• TSB #04258 -- 1ST ORDER VIBRATION FROM THE DRIVELINE AT HIGHWAY SPEEDS. *TT (NHTSA ID #10014256, JANUARY 01 2006)
• TSB #04266 -- A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT (NHTSA ID #10014275, JANUARY 01 2005)
• TSB #0416 -- DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELREATION AND/OR BRAKING. *TT (NHTSA ID #10007359, JANUARY 26 2004)

POWER TRAIN:DRIVELINE:DRIVESHAFT

• TSB #052611 -- DRIVESHAFT SLIP-BUMP ON DECELERATION OR ACCELERATION FROM A STOP. *TT (NHTSA ID #10018951, JANUARY 01 2005)

POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

• TSB #061112 -- 4X4 FRONT DIFFERENTIAL BRACKET REPAIR. *TT (NHTSA ID #10020175, JANUARY 01 2006)

POWER TRAIN:AXLE ASSEMBLY

• TSB #06216 -- LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT (NHTSA ID #10014100, JANUARY 01 2006)
• TSB #05618 -- REAR AXLE NOISE REPAIR. *TT (NHTSA ID #10017892, APRIL 01 2005)
• TSB #18466 -- AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES. *EH (NHTSA ID #10014659, MARCH 01 2005)
• TSB #03198 -- CHATTER, SHUDDER, A BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS ON VEHICLES EQUIPPED WITH THE 9.75 INCH OR 8.8 INCH LIMITED SLIP REAR AXLE. *TT (NHTSA ID #10004037, SEPTEMBER 06 2004)
• TSB #17905 -- MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT (NHTSA ID #10009332, JULY 01 2004)
• TSB #17931 -- ENGINEERING IS CURRENTLY INVESTIGATING A REAR AXLE WHINE CONDITION. *TT (NHTSA ID #10009341, JULY 01 2004)
• TSB #17702 -- AXLE WHINE 40-60 MPH. *TT (NHTSA ID #10008216, APRIL 01 2004)
• TSB #17466 -- CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION FROM LIMITED SLIP REAR AXLE DURING LOW SPEED TURNS. *TT (NHTSA ID #10007318, JANUARY 01 2004)
• TSB #17372 -- HERITAGE F-150 4X2 WITH 8.8 INCH REAR AXLE - WHINE/HOWL NOISE FROM REAR AXLE. *MJ (NHTSA ID #10008285, DECEMBER 01 2003)

ELECTRICAL SYSTEM

• TSB #052317 -- DIAGNOSTIC TROUBLE CODES P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V. *TT (NHTSA ID #10019378, JANUARY 01 2006)
• TSB #04219 -- MALFUNCTION INDICATOR LAMP (MIL) AND ELECTRONIC THROTTLE CONTROL (ETC) LAMPS ON WITH BOTH DIAGNOSTIC TROUBLE CODE (DTC) P2106 AND P2135. *TT (NHTSA ID #10013371, JUNE 07 2005)
• TSB #18384 -- POPPING OR QUAVERING FROM RADIO ON THE AM BAND. *TT (NHTSA ID #10013322, JANUARY 01 2005)
• TSB #0471 -- WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT (NHTSA ID #10008201, DECEMBER 31 2004)
• TSB #042110 -- MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0354. *TT (NHTSA ID #10013372, NOVEMBER 01 2004)
• TSB #0483 -- SPLICING NEW WIRE(S) INTO EXISTING ELECTRICAL HARNESS. SERVICE PROCEDURE. *TT (NHTSA ID #10008544, MAY 03 2004)
• TSB #17646 -- MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P2106. *TT (NHTSA ID #10007415, MARCH 01 2004)
• TSB #17483 -- MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODE (DTC) P2106. *TT (NHTSA ID #10007327, JANUARY 01 2004)
• TSB #17513 -- CHARGING SYSTEM WARNING INDICATOR ON WITH POSSIBLE DIAGNOSTIC TROUBLE CODE (DTC) P0622. *TT (NHTSA ID #10007345, JANUARY 01 2004)
• TSB #0312 -- CERTIFICATE OF COMPLETION. FORD HARNESS REWORK - KIT 28400. FISHER. *TT *MJ (NHTSA ID #10007303, DECEMBER 18 2003)
• TSB #17233 -- CHARGING SYSTEM WARNING INDICATOR ON INTERMITTENTLY ON VEHICLES BUILT BEFORE 9/30/2003. *TT *MJ (NHTSA ID #10004088, DECEMBER 01 2003)
• TSB #0311 -- RECOMMENDED 12V SWITCHED ACCESSORY SOURCES. THIS IS A FISHER SERVICE BULLETIN. *MR (NHTSA ID #10006305, NOVEMBER 25 2003)
• TSB #17294 -- CHARGING SYSTEM WARNING INDICATOR ON FOLLOWING ALTERNATOR REPLACEMENT. *TT (NHTSA ID #10004936, OCTOBER 01 2003)
• TSB #17262 -- CHARGING SYSTEM WARNING INDICATOR ON WITH POSSIBLE DIAGNOSTIC TROUBLE CODE P0622. *TT (NHTSA ID #10004915, OCTOBER 01 2003)
• TSB #17308 -- MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0606 WITH/WITHOUT OTHER DTCS. *TT (NHTSA ID #10004949, OCTOBER 01 2003)
• TSB #17238 -- MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P1233, WITH OR WITHOUT ANY DRIVEABILITY CONCERNS. *TT (NHTSA ID #10004092, SEPTEMBER 01 2003)

ELECTRICAL SYSTEM:WIRING

• TSB #04147 -- SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS. *TT (NHTSA ID #10017923, JUNE 01 2005)
• TSB #768 -- ISOLATION MODULE PLUG IN HARNESS KIT. REWORK OF INSTALLED KITS. THIS IS A WESTERN PRODUCTS SERVICE BULLETIN. *MR (NHTSA ID #10006410, DECEMBER 18 2003)
• TSB #767 -- RETURN OF INVENTORY. ISOLATION MODULE PLUG IN HARNESS KIT. WESTERN PRODUCTS SERVICE BULLETIN. *MR (NHTSA ID #10006567, DECEMBER 16 2003)

ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT CONTROLLER

• TSB #19010 -- VSM PROGRAMMING - SERVICE PROCEDURE UPDATE. *TT (NHTSA ID #10019074, JANUARY 01 2006)
• TSB #16914 -- 5.4L B-FUEL ENGINE MAY EXHIBIT A NO START CONDITION WHEN PROGRAMMING PASSIVE ANTI-THEFT SYSTEM (PATS) KEYS. *TT THIS OASIS UPDATES OASIS 16914 DATED 06/01/2003. *TT (NHTSA ID #10002625, AUGUST 01 2004)

VISIBILITY:GLASS, SIDE/REAR

• TSB #0426 -- RATTLING AND/OR SQUEAKING NOISE COMING FROM THE POWER SLIDING REAR WINDOW. *TT (NHTSA ID #10007368, FEBRUARY 09 2004)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:CONTROLS/WIRING

• TSB #041514 -- REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT (NHTSA ID #10011159, AUGUST 09 2004)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:REAR WINDOW

• TSB #04189 -- REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT (NHTSA ID #10014062, DECEMBER 13 2004)

SEAT BELTS:FRONT:RETRACTOR

• TSB #042421 -- SAFETY BELT RETRACTION SPEED. *TT (NHTSA ID #10014138, JUNE 07 2005)

STRUCTURE

• TSB #04B23 -- AN ALUMINUM-BACKED BUTYL PAD MAY HAVE BEEN ADDED TO THE INSIDE SURFACE OF THE RIGHT HAND SIDE BOX OUTER PANEL IN FRONT OF THE TAIL LAMP. CUSTOMER SATISFACTION PROGRAM 04B23. BUTYL PAD REMOVAL. *TT SUPPLEMENT #1. *TT SUPPLEMENT #2. (NHTSA ID #10012943, DECEMBER 07 2005)
• TSB #18158 -- WATER LEAK FROM HIGH MOUNT STOP LAMP. *TT (NHTSA ID #10011338, SEPTEMBER 01 2004)

STRUCTURE:BODY

• TSB #04251 -- ALUMINUM CORROSION - SERVICE TIP. *TT (NHTSA ID #10014165, DECEMBER 27 2004)
• TSB #18278 -- PAINT BUBBLING ON PASSENGER SIDE OF PICKUP BED. *EH (NHTSA ID #10013421, NOVEMBER 01 2004)
• TSB #042120 -- WATER LEAK AT PASSENGER SIDE LOWER A PILLAR. *EH (NHTSA ID #10013392, NOVEMBER 01 2004)
• TSB #03235 -- BED EXTENDER COMPONENT REPLACEMENT SERVICE TIP. *TT (NHTSA ID #10008154, NOVEMBER 24 2003)
• TSB #17309 -- WHISTLING NOISE FROM FRONT OF VEHICLE ABOVE 50 MPH. *TT (NHTSA ID #10004950, OCTOBER 01 2003)

STRUCTURE:BODY:DOOR

• TSB #03204 -- UNABLE TO OPEN THE DOOR WITH THE INSIDE DOOR HANDLE CONDITION, ALTHOUGH THE EXTERIOR HANDLE WORKS PROPERLY. *TT (NHTSA ID #10004887, OCTOBER 13 2003)
• TSB #17161 -- INSIDE DOOR HANDLE INOPERATIVE. *TT (NHTSA ID #10004055, SEPTEMBER 01 2003)

STRUCTURE:BODY:HOOD

• TSB #04188 -- HOOD FLUTTER AT HIGHWAY SPEEDS. *TT (NHTSA ID #10013111, JANUARY 01 2004)

STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS

• TSB #02012004 -- SOME LUND INTERNATIONAL BRAND HOOD SHIELDS MAY CONTRIBUTE EXCESSIVE NOISE AND ON OCCASION, UNACCEPTABLE HOOD VIBRATIONS. (NHTSA ID #10007260, FEBRUARY 01 2004)

VEHICLE SPEED CONTROL

• TSB #05192 -- ROUGH IDLE-5.4L 3V 4X2 SUPERCAB AND SUPERCREW. *TT (NHTSA ID #10017803, OCTOBER 03 2005)
• TSB #042001 -- SPEED CONTROL INOPERATIVE/INTERMITTENT OPERATION - VEHICLES BUILT BEFORE 5/17/2004. *TT (NHTSA ID #10017900, APRIL 01 2005)
• TSB #04201 -- SPEED CONTROL INOPERATIVE/INTERMITTENT OPERATION. *TT (NHTSA ID #10010721, OCTOBER 18 2004)

TIRES

• TSB #052220 -- ALTERNATE TIRES APPROVED FOR OFF ROAD USE. *TT (NHTSA ID #10019916, JANUARY 01 2006)
• TSB #052624 -- VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT (NHTSA ID #10018938, JANUARY 01 2005)
• TSB #04L24 -- LABEL PROGRAM 04L24. TIRE WARRANTY COVERAGE CHANGE. *TT (NHTSA ID #10014707, DECEMBER 01 2004)

WHEELS

• TSB #052624 -- VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT (NHTSA ID #10018938, JANUARY 01 2005)

WHEELS:LUGS/NUTS/BOLTS

• TSB #99263 -- CORRECT LUG NUT TORQUE SPECIFICATIONS - INCREASE WHEEL NUT AND STUD SIZE - SERVICE TIP. *TT (NHTSA ID #10008157, NOVEMBER 10 2003)

TRAILER HITCHES

• TSB #05252 -- NEUTRAL TOW CAPABILITY -- SERVICE KIT REQUIREMENTS. *TT (NHTSA ID #10018934, JANUARY 01 2006)

COMMUNICATIONS:BACK UP ALARM

• TSB #05419 -- FALSE PARKING AID WARNINGS. *TT (NHTSA ID #10017904, APRIL 01 2005)
• TSB #04262 -- FALSE PARKING AID WARNINGS. *TT UPDATE. *TT (NHTSA ID #10014671, MARCH 07 2005)

EQUIPMENT:ELECTRICAL

• TSB #0555 -- KEYLESS ENTRY KEYPAD INOPERATIVE. *TT (NHTSA ID #10014686, MARCH 21 2005)

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

• TSB #17656 -- CD OR CD6 RADIO OVERHEATING. *TT (NHTSA ID #10007420, MARCH 01 2004)

EQUIPMENT:ELECTRICAL:AIR CONDITIONER

• TSB #17261 -- INACCURATE AMBIENT TEMPERATURE READING AND/OR POOR AIR CONDITIONING PERFORMANCE. *TT (NHTSA ID #10004914, OCTOBER 01 2003)

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

• TSB #06012005 -- LABEL PROGRAM 04L24-SUPPLEMENT#1-TIRE WARRANTY COVERAGE CHANGE. *SC (NHTSA ID #10016807, JUNE 01 2005)