[ switch models ] 2002 Ford E-350 2002 Ford Escape 2002 Ford Escort 2002 Ford Excursion 2002 Ford Expedition 2002 Ford Explorer 2002 Ford Explorer Sport Trac 2002 Ford F-150 2002 Ford F-250 2002 Ford F-450 2002 Ford Focus 2002 Ford Mustang 2002 Ford Ranger 2002 Ford Taurus 2002 Ford Thunderbird 2002 Ford Windstar [ switch years ] 2007 Ford F-350 2006 Ford F-350 2005 Ford F-350 2004 Ford F-350 2003 Ford F-350 2001 Ford F-350 2000 Ford F-350 1999 Ford F-350 1997 Ford F-350 1996 Ford F-350 1994 Ford F-350 1992 Ford F-350 1990 Ford F-350

2002 Ford F-350

Technical Service Bulletins

There are also 2 Ford recalls » 24 defect investigations » 31 TSBs » for the Ford F-350.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB number & contact your local dealer.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING

• TSB #03174 -- STEERING WHEEL FIGHT AFTER RIDING OVER BUMPS/RUTS. 2003, 2004 F450 AND F550 MODELS INCLUDED. *TT (NHTSA ID #10004025, SEPTEMBER 01 2003)
• TSB #16077 -- SOME VEHICLES BUILT AT CUAUTITLAN ASSEMBLY PLANT BETWEEN JANUARY 14, 2002 AND MAY 21, 2002 MAY EXHIBIT A KNOCK NOISE DUE TO AN INCORRECTLY INSTALLED STEERING DAMPER. *TT (NHTSA ID #636275, JULY 01 2002)

SUSPENSION

• TSB #04236 -- VEHICLE LEAN SAG WHEN OBSERVED FROM REAR OF VEHICLE. *EH (NHTSA ID #10013413, NOVEMBER 29 2004)

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

• TSB #18223 -- VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT (NHTSA ID #10010734, OCTOBER 01 2004)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #17554 -- OIL/DUST FILM AT CAC CONNECTIONS. *MJ (NHTSA ID #10008119, FEBRUARY 01 2004)
• TSB #03911 -- ROUGH IDLE AND/OR HESITATION WHEN ACCLERATING ON CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH A 5.4L OR 6.8L ENGINE. *TT (NHTSA ID #10002783, MAY 12 2003)
• TSB #02227 -- ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY. *MJ (NHTSA ID #10008310, NOVEMBER 11 2002)
• TSB #16403 -- ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START. *MJ (NHTSA ID #10008334, NOVEMBER 01 2002)
• TSB #02177 -- COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS. *MJ (NHTSA ID #10008581, SEPTEMBER 02 2002)

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

• TSB #15932 -- SOME VEHICLES EQUIPPED WITH 4.2L, 4.6L AND 5.4L ENGINE MAY EXHIBIT A LACK OF POWER CONDITION. *TT (NHTSA ID #637836, MAY 01 2002)
• TSB #15311 -- SOME 4X4 VEHICLES MAY EXHIBIT A CRANK NO START CONDITION. *TT (NHTSA ID #630218, OCTOBER 01 2001)

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

• TSB #16518 -- ACCESSORY DRIVE BELT SQUEALING NOISE FROM THE ENGINE AREA WHEN THE ENGINE FAN CLUTCH IS ENGAGED WHILE OPERATED IN HOT DUSTY CLIMATES. VARIOUS MODELS INCLUDING 2003 F450/550. *TT (NHTSA ID #10004881, OCTOBER 30 2003)
• TSB #16291 -- LOUD SQUEALING NOISE FROM THE ENGINE AREA WHEN THE ENGINE FAN CLUTCH IS UNDER LOAD WHILE OPERATED IN HOT DUSTY CLIMATES. VEHICLES EQUIPPED WITH A 7.3L ENGINE. *TT (NHTSA ID #10013071, OCTOBER 01 2002)

FUEL SYSTEM, OTHER

• TSB #18217 -- MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT (NHTSA ID #10010731, OCTOBER 01 2004)

POWER TRAIN

• TSB #16915 -- EXCESSIVE DRIVE-AWAY SHUDDER OR VIBRATION UNDER MODERATE TO HEAVY ACCELERATION FROM A STOP. *TT (NHTSA ID #10002626, MAY 01 2004)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #18376 -- A COLD WEATHER REVERSE ENGAGEMENT STALL. *TT (NHTSA ID #10013316, JANUARY 01 2005)

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

• TSB #02E20 -- SUBJECT REGARDING DEMONSTRATION/ DELIVERY HOLD: POWERTRAIN CONTROL MODULE REPROGRAMMING. *JG (NHTSA ID #633564, MAY 01 2002)

POWER TRAIN:AXLE ASSEMBLY

• TSB #031603 -- REAR AXLE POPPING/CHATTER NOISE - DANA 80 MODEL DUAL REAR WHEEL (DRW). *AR (NHTSA ID #10011164, AUGUST 23 2004)
• TSB #03163 -- SOME VEHICLES EQUIPPED WITH THE DUAL REAR WHEEL (DRW) REAR AXLE MAY EXHIBIT A TACTILE POPPING OR AUDIBLE CHATTERING NOISE. THIS POPPING NOISE/FEEL RESULTS FROM THE CLUTCH PLATES AND DISCS (IN THE LIMITED SLIP DIFFERENTIAL CASE) STICKING AN (NHTSA ID #10003117, AUGUST 18 2003)

ELECTRICAL SYSTEM

• TSB #0471 -- WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT (NHTSA ID #10008201, DECEMBER 31 2004)

ELECTRICAL SYSTEM:BATTERY

• TSB #15687 -- CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH LPG ENGINE MAY EXHIBIT A DEAD BATTERY CONDITION AFTER LEAVING THE VEHICLE PARKED FOR 2 OR 3 DAYS. *TT (NHTSA ID #636322, MARCH 01 2002)

ELECTRICAL SYSTEM:IGNITION:MODULE

• TSB #15221 -- SOME VEHICLES EQUIPPED WITH 5.4L GAS ENGINE MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE B1345 RETRIEVED DURING SELF TEST FROM THE TO HEC MODULE (INSTRUMENT PANEL). *TT (NHTSA ID #625767, SEPTEMBER 01 2001)

VISIBILITY:REARVIEW MIRRORS/DEVICES

• TSB #15297 -- SOME VEHICLES MAY EXHIBIT AN INOPERATIVE SIDE POWER MIRROR CONDITION. *TT (NHTSA ID #630198, OCTOBER 01 2001)

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

• TSB #17603 -- AIR BAG LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1871 OR B1935 FOLLOWING ECS/RCM REPLACEMENT. *TT (NHTSA ID #10007395, MARCH 01 2004)

STRUCTURE:BODY

• TSB #18406 -- SERVICE TIPS BEFORE ARC WELDING ON THE FRAME OR BODY OF A UNIT. *TT (NHTSA ID #10012965, FEBRUARY 01 2005)

VEHICLE SPEED CONTROL

• TSB #042411 -- MEMONTARY RETURN TO IDLE DURING AGGRESSIVE ACCELERATION - DIAGNOSTIC TROUBLE CODE (DTC) P0123. *TT (NHTSA ID #10014083, DECEMBER 13 2004)

TIRES:VALVE

• TSB #15240 -- SOME DRWS EQUIPPED WITH ANGLED BRASS VALVE STEMS MAY EXHIBIT A VALVE CORE THAT STICKS OPEN WHEN ACTUATED. *TT (NHTSA ID #625782, SEPTEMBER 01 2001)

SEATS

• TSB #010901 -- SUBJECT PERTAINING TO PASSENGER SEAT MISBUILD.*JB (NHTSA ID #625666, SEPTEMBER 01 2001)

EQUIPMENT

• TSB #15938 -- INFORMATION USED WHEN REPLACING THE DRIVERS SEAT MODULE. *TT (NHTSA ID #637846, MAY 01 2002)

UNKNOWN OR OTHER

• TSB #15574 -- SOME VEHICLES MAY EXHIBIT A DIFFICULTY IN PROGRAMMING THE KEY FOB(S). *TT (NHTSA ID #630020, JANUARY 01 2002)
• TSB #15566 -- SOME VEHICLES MAY EXHIBIT A TACKY SURFACE ON THE INSTRUMENT PANEL (IP). *TT (NHTSA ID #630103, JANUARY 01 2002)