NHTSA Campaign #07E064000 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

AUGUST 27
2007

34,000 vehicles recalled

1984 FORD RANGER -- Certain federal-mogul aftermarket fuel pumps sold under the brand names of carter, accuflow, Napa, truflow, parts depo, and parts master, shipped between August 2006 and July 2007 for use on the vehicles listed above. The fuel pump diaphragm in certain production runs may have been improperly installed or inadequately tested which may cause the fuel pump to leak.

A leaking fuel pump could create a vehicle fire hazard.

Federal-mogul will notify owners and replace the defective fuel pumps free of charge. The recall began on October 15, 2007. Owners can contact federal-mogul at 248-354-7700. For detailed information & supporting documents, see the official NHTSA page concerning recall #07E064000 »

NHTSA Campaign #98E010000 SERVICE BRAKES, AIR:DISC:ROTOR

APRIL 08
1998

23,500 vehicles recalled

1984 FORD RANGER -- Equipment description: Aftermarket brake rotors for use on certain Ford and Mazda trucks. Cracked castings caused cracks to appear on the outer diameter of the rotor hat or around the stud hole.

Loss of braking can result.

Aimco will reimburse consumers/installers for the cost of replacement rotors and installation. Consumers are requested to return to the location where the rotors were originally purchased/installed for replacement. For detailed information & supporting documents, see the official NHTSA page concerning recall #98E010000 »

NHTSA Campaign #84V111000 LATCHES/LOCKS/LINKAGES:HOOD:LATCH

SEPTEMBER 25
1984

460,918 vehicles recalled

1984 FORD RANGER -- Secondary hood latch components may have been improperly positioned during assembly. If the hood is not closed tightly, or is inadvertently released, the secondary latch may not work and the hood may fly up without prior warning.

The hood assembly will be inspected and the hood and latch components will be adjusted, if necessary, without charge to the owner. For detailed information & supporting documents, see the official NHTSA page concerning recall #84V111000 »

NHTSA Campaign #84V104000 SUSPENSION

SEPTEMBER 06
1984

19 vehicles recalled

1984 FORD RANGER -- Weight rating information is incorrect on vehicle manual labels and rating decals.

Dealers will be provided with the revised vehicle information. If vehicle weight is found to be greater than that specified on weight rating, the affected vehicle"S rear axle may be repurchased from Ford. A price adjustment will also be made if appropriate. For detailed information & supporting documents, see the official NHTSA page concerning recall #84V104000 »

NHTSA Campaign #84V082000 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

JULY 09
1984

302,500 vehicles recalled

1984 FORD RANGER -- If truck is struck from the side, the cap on the fuel tank could become unsealed, allowing unsafe leakage of fuel. This is a failure to comply with the requirements of Federal Motor Vehicle Safety Standard 301, "Fuel System Integrity". leakage can be caused by an orange-colored plastic diesel fuel information ring which is found around the fuel tank neck, or by the tether.

Upon inspection, fuel cap tethers will be replaced or diesel fuel information rings will be removed. For detailed information & supporting documents, see the official NHTSA page concerning recall #84V082000 »

NHTSA Campaign #84V023000 WHEELS:LUGS/NUTS/BOLTS

MARCH 06
1984

3,320 vehicles recalled

1984 FORD RANGER -- Components in the locking hubs were improperly heat-treated and may crack or fracture upon engagement of the front drive axles. The broken component on the left front wheel may become jammed against the nut.

Cam assemblies in front wheel automatic locking hubs will be replaced. For detailed information & supporting documents, see the official NHTSA page concerning recall #84V023000 »

NHTSA Campaign #83V134000 SEAT BELTS:FRONT:ANCHORAGE

DECEMBER 20
1983

530,000 vehicles recalled

1984 FORD RANGER -- The bolts that attach the D-shaped ring for the shoulder belt are inadequately supported by the material in which they are mounted. The attachment does not comply with the requirements of Federal Motor Vehicle Safety Standard no. 210, "Seat Belt Assembly Anchorages".

Dealers will install new attaching hardware to improve the strength of the mounting. For detailed information & supporting documents, see the official NHTSA page concerning recall #83V134000 »

NHTSA Campaign #83V115000 FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK

NOVEMBER 07
1983

1,548 vehicles recalled

1984 FORD RANGER -- Vehicles may have fuel or vapor line damage caused when an incorrect procedure was used in tightening bolts on adjacent components during assembly. The fuel tank may become damaged due to a loose cross member that supports it.

Vehicles will be inspected and, when necessary, fuel and vapor lines will be replaced and the cross member will be tightened. For detailed information & supporting documents, see the official NHTSA page concerning recall #83V115000 »