[ switch models ] 2002 Ford E-350 2002 Ford Escape 2002 Ford Escort 2002 Ford Excursion 2002 Ford Expedition 2002 Ford Explorer 2002 Ford Explorer Sport Trac 2002 Ford F-150 2002 Ford F-250 2002 Ford F-350 2002 Ford F-450 2002 Ford Focus 2002 Ford Mustang 2002 Ford Taurus 2002 Ford Thunderbird 2002 Ford Windstar [ switch years ] 2007 Ford Ranger 2006 Ford Ranger 2005 Ford Ranger 2004 Ford Ranger 2003 Ford Ranger 2001 Ford Ranger 2000 Ford Ranger 1999 Ford Ranger 1998 Ford Ranger 1997 Ford Ranger 1996 Ford Ranger 1995 Ford Ranger 1994 Ford Ranger 1993 Ford Ranger 1992 Ford Ranger 1991 Ford Ranger 1990 Ford Ranger 1989 Ford Ranger 1988 Ford Ranger 1987 Ford Ranger 1986 Ford Ranger 1984 Ford Ranger

2002 Ford Ranger

Technical Service Bulletins

There are also 4 Ford recalls » 125 TSBs » for the Ford Ranger.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB number & contact your local dealer.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING

• TSB #17254 -- CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT (NHTSA ID #10004908, OCTOBER 01 2003)
• TSB #16040 -- EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT (NHTSA ID #636235, JULY 01 2002)

SUSPENSION

• TSB #15692 -- SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT (NHTSA ID #636326, MARCH 01 2002)

SUSPENSION:FRONT

• TSB #042419 -- REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS. *TT (NHTSA ID #10014096, DECEMBER 13 2004)

SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

• TSB #17777 -- REAR LEAF SPRING NOISE. *TT (NHTSA ID #10008552, MAY 01 2004)

SERVICE BRAKES, HYDRAULIC

• TSB #041610 -- GRABBING CONDITION FROM REAR DRUM BRAKES. *AR *TT (NHTSA ID #10011169, SEPTEMBER 06 2004)
• TSB #0394 -- PULL TO RIGHT OR LEFT CONDITION WHILE BRAKING ON 4.2 (NON-EDGE) COIL SPRING EQUIPPED VEHICLES. *TT (NHTSA ID #10002777, MAY 12 2003)

SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT

• TSB #02176 -- LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ (NHTSA ID #10008580, SEPTEMBER 02 2002)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

• TSB #021010 -- SOME 4X2 VEHICLES MAY EXHIBIT A PULL TO RIGHT OR LEFT WHILE BRAKING. *TT (NHTSA ID #636087, MAY 27 2002)

SERVICE BRAKES, HYDRAULIC:ANTILOCK

• TSB #16021 -- SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURES) IN SLIPPERY CONDITIONS. *TT (NHTSA ID #636212, JULY 01 2002)
• TSB #15859 -- SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURE). *TT (NHTSA ID #637710, MAY 01 2002)
• TSB #15813 -- SOME VEHICLES EQUIPPED WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURE). *TT (NHTSA ID #637542, APRIL 01 2002)

ENGINE AND ENGINE COOLING

• TSB #052212 -- BUCK/JERK AND MISS DURING DRIVE CYCLE ABOVE 3000 RPM - NO DTC - 3.0L 2V GAS AND FFV ENGINE. *TT (NHTSA ID #10018746, NOVEMBER 14 2005)
• TSB #0361 -- MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB (NHTSA ID #10001855, MARCH 31 2003)
• TSB #15314 -- ON SOME VEHICLES, THE ENGINE TEMPERATURE GAUGE MAY EXHIBIT A DOWNWARD MOVEMENT TO THE COOL REGION OF THE GAGE. *TT (NHTSA ID #630225, OCTOBER 01 2001)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #06116 -- POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT - SERVICE TIP. *TT (NHTSA ID #10020173, JANUARY 01 2006)
• TSB #18375 -- HIGH IDLE AT COLD START. *TT (NHTSA ID #10013315, JANUARY 01 2005)
• TSB #020801 -- RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA 2000-3000 RPM - 4.0L SOHC ENGINE. *TT (NHTSA ID #10011150, AUGUST 09 2004)
• TSB #0486 -- BOOM/VIBRATION AT 1800-2200 RPM, ROUGH IDLE. *TT (NHTSA ID #10008547, MAY 03 2004)
• TSB #0415 -- LOWER ENGINE OIL LEAKS 3.0L 2V VULCAN ENGINE. DIAGNOSTIC SERVICE TIPS. *TT (NHTSA ID #10007358, JANUARY 26 2004)
• TSB #17255 -- HARD START/LONG CRANK WHEN COLD OR STUMBLES/SURGES DURING DRIVE-AWAY. POSSIBLE DIAGNOSTIC TROUBLE CODES P0171, AND P0174 OR P0172 AND P0175. *TT (NHTSA ID #10004909, OCTOBER 01 2003)
• TSB #17234 -- ENGINE OIL LEAKS FROM THE FILTER AREA ON VEHICLES WITH A 3.0L 2-VALVE ENGINE. *TT (NHTSA ID #10004089, SEPTEMBER 01 2003)
• TSB #17221 -- SPARK KNOCK, DETONATION, OR PING CONDITION ON TIP-IN OR DURING STEADY STATE OPERATION AT OR NEAR WIDE OPEN THROTTLE. *TT (NHTSA ID #10004080, SEPTEMBER 01 2003)
• TSB #0335 -- IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT (NHTSA ID #10002482, FEBRUARY 17 2003)
• TSB #0322 -- STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT (NHTSA ID #10002472, FEBRUARY 03 2003)
• TSB #16610 -- NO START, NO COMMUNICATION WITH POWER TRAIN CONTROL MODULE (PCM) USING WDS/NGS OR A MISS/BUCK/JERK WHILE DRIVING. *TT (NHTSA ID #10002495, FEBRUARY 01 2003)
• TSB #16626 -- HESITATION OR SURGE CONDITION DURING CRUISE WITH THE AIR CONDITIONER ON. *TT (NHTSA ID #10002504, FEBRUARY 01 2003)
• TSB #16461 -- TOOL KIT CONTAINS THE TIMING PEG USED TO LOCK THE CRANKSHAFT IN PLACE WHEN PERFORMING CRANKSHAFT PULLEY OR ENGINE TIMING SERVICE. *TT (NHTSA ID #10008146, DECEMBER 01 2002)
• TSB #02221 -- ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ (NHTSA ID #10008304, NOVEMBER 11 2002)
• TSB #02224 -- VIBRATION-ENGINE VIBRATION AT IDLE-VEHICLES EQUIPPED WITH 3.0L ENGINE-VEHICLES BUILT BEFORE 11/26/2001 ONLY. *MJ (NHTSA ID #10008307, NOVEMBER 11 2002)
• TSB #870197 -- INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT (NHTSA ID #10000592, OCTOBER 22 2002)
• TSB #16305 -- ENGINE TIMING SERVICE TOOLS / SERVICE TIP. *TT (NHTSA ID #10013075, OCTOBER 01 2002)
• TSB #15290 -- SOME 4.0L SOHC MAY EXHIBIT AN ENGINE OIL LEAK CONDITION, COMING FROM THE OIL PAN OR LADDER FRAME AREA. *TT (NHTSA ID #630190, OCTOBER 01 2001)
• TSB #06166 -- POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT. *KB (NHTSA ID #10021051, no date provided)

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

• TSB #16110 -- SOME VEHICLES EQUIPPED WITH A 2.3L ENGINE MAY EXHIBIT AN ENGINE OIL LEAK CONDITION. *TT (NHTSA ID #636130, AUGUST 01 2002)
• TSB #16091 -- SOME VEHICLES EQUIPPED WITH A 3.0L EFI (NON-FFV) ENGINE, MAY EXHIBIT AN ENGINE QUIT CONDITION UPON DECELERATION AND / OR AT A STOP. *TT (NHTSA ID #636108, AUGUST 01 2002)
• TSB #16020 -- SOME VEHICLES EQUIPPED WITH PASIVE ANTI-THEFT SYSTEM MAY EXHIBIT A NO CRANK / NO START CONDITION AND NO COMMUNICATION WITH NGS OR WDS FROM THE POWER TRAIN CONTROL MODULE (PCM). *TT (NHTSA ID #636210, JULY 01 2002)
• TSB #0281 -- SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC (SINGLE OVER-HEAD CAM) ENGINE MAY EXHIBIT A PRIMARY TIMING CHAIN RATTLE NOISE. *TT (NHTSA ID #637920, APRIL 29 2002)
• TSB #0276 -- INFORMATION ON DIAGNOSING ENGINE RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA BETWEEN 2000-3000 RPM ON COLD ENGINE OPERATION ONLY. *TT (NHTSA ID #636013, APRIL 15 2002)
• TSB #01246 -- ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT (NHTSA ID #630515, DECEMBER 10 2001)
• TSB #15470 -- CONCERNS WITH SPARK KNOCK NOISE OR CHAIN RATTLE NOISE BETWEEN 2000-3000 RPM, DURING COLD ENGINE OPERATION ONLY. *TT (NHTSA ID #630576, DECEMBER 01 2001)
• TSB #15378 -- SOME VEHICLES WITH THE 4.0L ENGINE MAY EXHIBIT AN ENGINE FLUTTER NOISE. *TT (NHTSA ID #630388, NOVEMBER 01 2001)
• TSB #15381 -- SOME VEHICLES WITH A MANUAL TRANSMISSION MAY EXHIBIT AN ENGINE LOSS OR REDUCTION IN POWER CONDITION ON DECELERATION, BUT WILL IMMEDIATELY RESTART. *TT (NHTSA ID #630391, NOVEMBER 01 2001)
• TSB #01205 -- SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT (NHTSA ID #627927, OCTOBER 15 2001)
• TSB #15313 -- SOME VEHICLES EQUIPPED WITH A 2.3L ENGINE MAY EXHIBIT POOR IDLE QUALITY, HESITATION/SURGE ON LIGHT ACCELERATION. *TT (NHTSA ID #630223, OCTOBER 01 2001)
• TSB #14868 -- SOME VEHICLES EQUIPED WITHT HE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT (NHTSA ID #619337, APRIL 01 2001)

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

• TSB #17227 -- ACCESSORY DRIVE BELT NOISE ON 3.0L VEHICLES BUILT PRIOR TO 9/18/2003. *TT (NHTSA ID #10004083, SEPTEMBER 01 2003)

ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

• TSB #16743 -- COOLANT LEAK DUE TO A BROKEN RADIATOR HOSE CLAMP(S). *TT (NHTSA ID #10002647, APRIL 01 2003)

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

• TSB #17604 -- COOLING SYSTEM FAN NOISE WHEN COLD. *TT (NHTSA ID #10007396, MARCH 01 2004)
• TSB #15880 -- SOME VEHICLES MAY EXHIBIT A DISENGAGED FAN CLUTCH BEARING SQUEAL NOISE IN COLD WEATHER. *TT (NHTSA ID #637744, MAY 01 2002)

ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSE

• TSB #17198 -- WEAR-THROUGH CONDITION ON THE ABRASION SLEEVE OF THE UPPER RADIATOR HOSE NEAR THE AIR CONDITIONING ACCUMULATOR OR TRANSMISSION FLUID DIPSTICK. *TT (NHTSA ID #10004069, SEPTEMBER 01 2003)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

• TSB #16094 -- SOME VEHICLES MAY EXHIBIT FUEL DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, P0175 OR MASS AIR FLOW DIAGNOSTIC TROUBLE CODES P0102, P0103, P0112, P0113. *TT (NHTSA ID #636110, AUGUST 01 2002)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

• TSB #02M01 -- CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 (NHTSA ID #10007207, JUNE 01 2004)

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

• TSB #15532 -- INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT (NHTSA ID #630018, JANUARY 01 2002)

FUEL SYSTEM, OTHER

• TSB #0398 -- MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT (NHTSA ID #10002780, MAY 12 2003)

POWER TRAIN

• TSB #0332 -- THUMP TYPE NOISE/VIBRATION HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. *TT (NHTSA ID #10002479, FEBRUARY 17 2003)
• TSB #0258 -- INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT (NHTSA ID #636052, NOVEMBER 25 2002)
• TSB #02109 -- A THUMP OR BUMP SENSATION FELT IMMEDIATELY ON ACCELERATION FROM A STOP OR UPON BRAKING WHEN COMING TO A COMPLETE STOP. *TT (NHTSA ID #636085, MAY 27 2002)
• TSB #15887 -- SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT (NHTSA ID #637755, MAY 01 2002)
• TSB #0282 -- SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT (NHTSA ID #637922, APRIL 29 2002)
• TSB #0283 -- SOME VEHICLES EQUIPPED WITH A 2.3L, 3.0L OR 4.0L ENGINE AND 5R44E OR 5R55E AUTOMATIC TRANSMISSION MAY EXHIBIT A FLUID LEAK AT THE TRANSMISSION SERVO COVERS IN COLD CLIMATES. *TT (NHTSA ID #637924, APRIL 29 2002)

POWER TRAIN:CLUTCH ASSEMBLY

• TSB #16113 -- SOME VEHICLES BUILT AFTER 03/04/2002 AND EQUIPED WITH A MANUAL TRANSMISSION MAY EXHIBIT A HARD TO SHIFT CONDITION. *TT (NHTSA ID #636135, AUGUST 01 2002)

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/LINKAGE

• TSB #15869 -- SOME VEHICLES MAY EXHIBIT AN INTERMITTENT SOFT CLUTCH PEDAL WHICH MAY CAUSE DIFFICULTY IN SHIFTING GEARS (A NOTCHY FEEL). *TT (NHTSA ID #637726, MAY 01 2002)
• TSB #0255 -- HOOTING, EEKING OR MOANING NOISE COMING FROM THE CLUTCH WHEN SHIFTING GEARS. *TT (NHTSA ID #636047, MARCH 18 2002)

POWER TRAIN:MANUAL TRANSMISSION

• TSB #02138 -- LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT (NHTSA ID #635998, NOVEMBER 10 2003)
• TSB #17127 -- TRANSMISSION WHINE IN 5TH GEAR. *TT (NHTSA ID #10004048, SEPTEMBER 01 2003)
• TSB #0393 -- BUZZ/HOWL IN THE TRANSFER CASE SHIFT LEVER WHILE DRIVING, AND/OR SHIFT LEVER BOOT DETACHMENT DUE TO INSUFFICIENT RETENTION OF THE BOOT(S). *TT (NHTSA ID #10002776, MAY 12 2003)
• TSB #022110 -- MANUAL SHIFT LEVER OUTER BOOT DETACHMENT - FX4 MODELS EQUIPPED WITH MANUAL TRANSMISSION ONLY. *TT (NHTSA ID #10013088, OCTOBER 01 2002)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #02222 -- NOISE-GEAR WHINE NOISE IN 1ST AND 2ND GEAR ONLY-VEHICLES EQUIPPED WITH 5R55E TRANSMISSION AND 4.0L ENGINE ONLY. *MJ (NHTSA ID #10008305, NOVEMBER 11 2002)
• TSB #02191 -- THUMP/BUMP ON ACCELERATION FROM A STOP OR WHEN BRAKING FROM DRIVESHAFT AREA-4X2 AUTOMATIC TRANSMISSION SUPER CAB EDGE MODELS ONLY. *MJ (NHTSA ID #10008586, SEPTEMBER 30 2002)
• TSB #16148 -- SOME VEHICLES MAY AN AUTOMATIC TRANSMISSION MAY EXHIBIT A SHIFT LEVER THAT WILL NOT RELEASE OUT OF THE PARK POSITION. *TT (NHTSA ID #636170, AUGUST 01 2002)
• TSB #16038 -- SOME VEHICLES EQUIPPED WITH A 5R55E AUTOMATIC TRANSMISSION MAY EXHIBIT A GEAR WHINE TYPE NOISE IN 1ST AND / OR 2ND GEARS ONLY. *TT (NHTSA ID #636233, JULY 01 2002)
• TSB #15785 -- SOME VEHICLES EQUIPPED WITH 5R55E/5R44E TRANSMISSION MAY EXHIBIT A WHINE NOISE IN 1ST GEAR THAT GOES AWAY AFTER THE 1-2 OR 1-3 SHIFT IS COMPLETED. *TT (NHTSA ID #637478, APRIL 01 2002)
• TSB #15625 -- CONCERNS WITH 5R44E AUTOMATIC TRANSMISSION FLUID LEAK. *TT (NHTSA ID #630672, FEBRUARY 01 2002)

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

• TSB #042107 -- GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT (NHTSA ID #10014086, DECEMBER 13 2004)
• TSB #04217 -- GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT (NHTSA ID #10013369, NOVEMBER 01 2004)
• TSB #16396 -- NO START/NO COMMUNICATION-CONTACT REQUEST. *MJ (NHTSA ID #10008329, NOVEMBER 01 2002)

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

• TSB #16064 -- SOME VEHICLES WITH MANUAL TRANSMISSION MAY EXHIBIT A DIFFICULT TO ENGAGE INTO 4X4 LOW CONDITION WHEN THE AMBIENT TEMPERATURE IS 0 DEGREES F (-18 C) OR COLDER. *TT (NHTSA ID #636260, JULY 01 2002)

POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

• TSB #03148 -- NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT (NHTSA ID #10003748, JULY 21 2003)

POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START SWITCH

• TSB #01181 -- BRAKE SHIFT INTERLOCK.*JB (NHTSA ID #625715, SEPTEMBER 17 2001)

POWER TRAIN:DRIVELINE:DRIVESHAFT

• TSB #04237 -- DRIVESHAFT THUMP CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP. *EH (NHTSA ID #10013414, NOVEMBER 29 2004)
• TSB #030302 -- DRIVESHAFT - THUMP/CLUNK HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. *TT (NHTSA ID #10002516, FEBRUARY 01 2003)
• TSB #03048 -- THUMP/CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP ON CERTAIN 4X4 SUPER CAB EQUIPPED WITH AUTOMATIC TRANSMISSION AND STEEL DRIVESHAFT. *TT (NHTSA ID #10008280, JANUARY 05 2003)
• TSB #02192 -- DRIVESHAFT-THUMP/CLUNK HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. (NHTSA ID #10008587, SEPTEMBER 30 2002)
• TSB #0196 -- SOME 4X4 SUPER CAB VEHICLES MAY EXHIBIT A LOW FREQUENCY THUMP TYPE NOISE / VIBRATION ON LIGHT ACCELERATION FROM A STOP, AND / OR WHEN COMING TO A STOP WITH LIGHT TO MODERATE BRAKING. *TT (NHTSA ID #620159, MAY 14 2001)

POWER TRAIN:AXLE ASSEMBLY

• TSB #030508 -- FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT (NHTSA ID #10017891, APRIL 01 2005)
• TSB #0358 -- FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB (NHTSA ID #10001922, MARCH 17 2003)
• TSB #0242 -- CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT (NHTSA ID #636056, MARCH 04 2002)
• TSB #0186 -- ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT (NHTSA ID #619276, APRIL 30 2001)

ELECTRICAL SYSTEM

• TSB #04174 -- MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT (NHTSA ID #10013116, SEPTEMBER 06 2004)
• TSB #04111 -- STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. (NHTSA ID #10008252, JUNE 14 2004)
• TSB #17718 -- MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0171, P0172, P0174 OR P0175. *TT (NHTSA ID #10008223, APRIL 01 2004)
• TSB #0369 -- SAFETY BELT PRETENSIONER DIAGNOSTIC TROUBLE CODES (DTC) B1877 AND/OR B1881. *TT (NHTSA ID #10007366, FEBRUARY 09 2004)
• TSB #03223 -- STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT (NHTSA ID #10007360, JANUARY 26 2004)
• TSB #03203 -- MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT (NHTSA ID #10004886, OCTOBER 13 2003)
• TSB #03181 -- REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT (NHTSA ID #10004027, SEPTEMBER 15 2003)
• TSB #16889 -- AN RCM DIAGNOSTIC TROUBLE CODE B1881, B1882, OR B1883. *TT (NHTSA ID #10002605, JUNE 01 2003)
• TSB #0327 -- DIAGNOSTIC TROUBLE CODES (DTC) B1877 (DRIVER PRETENSIONER CIRCUIT RESISTANCE HIGH) AND/OR B1881 (PASSENGER PRETENSIONER CIRCUIT RESISTANCE HIGH), INDICATING A HIGH RESISTANCE IN THE SAFETY BELT PRETENSIONER CIRCUIT. *TT (NHTSA ID #10002477, FEBRUARY 03 2003)
• TSB #16437 -- DIAGNOSTIC TROUBLE CODE (DTC) C1233 & C1234 - REPLACE ANTI-LOCK BRAKE SYSTEM EUC. *MJ (NHTSA ID #10008359, NOVEMBER 01 2002)

ELECTRICAL SYSTEM:BATTERY

• TSB #0245 -- INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT (NHTSA ID #636065, MARCH 04 2002)

ELECTRICAL SYSTEM:WIRING

• TSB #04147 -- SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS. *TT (NHTSA ID #10017923, JUNE 01 2005)

ELECTRICAL SYSTEM:IGNITION:SWITCH

• TSB #012113 -- SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL (NHTSA ID #627774, OCTOBER 29 2001)

ELECTRICAL SYSTEM:IGNITION:MODULE

• TSB #16099 -- SOME VEHICLES EQUIPPED WITH A 2.3L ENGINE AND NO AIR CONDITIONING, MAY SET DIAGNOSTIC TROUBLE CODES P1460 (WIDE OPEN THROTTLE AIR CONDITIONER OUTPUT PRIMARY CIRCUIT MALFUNCTION) AND P1474 (LOW FAN CONTROL (LFC) PRIMARY CIRCUIT FAILURE. *T (NHTSA ID #636116, AUGUST 01 2002)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:HEATER CORE

• TSB #01156 -- SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC (NHTSA ID #623944, AUGUST 06 2001)

SEAT BELTS

• TSB #0369 -- DIAGNOSTIC TROUBLE CODE B1877 AND/OR B1881 INDICATING A HIGH RESISTANCE IN THE SAFETY BELT PRETENSIONER CIRCUIT. *TT *JB (NHTSA ID #10001860, MARCH 31 2003)

SEAT BELTS:FRONT:RETRACTOR

• TSB #042421 -- SAFETY BELT RETRACTION SPEED. *TT (NHTSA ID #10014138, JUNE 07 2005)

STRUCTURE:BODY

• TSB #04251 -- ALUMINUM CORROSION - SERVICE TIP. *TT (NHTSA ID #10014165, DECEMBER 27 2004)
• TSB #03235 -- BED EXTENDER COMPONENT REPLACEMENT SERVICE TIP. *TT (NHTSA ID #10008154, NOVEMBER 24 2003)
• TSB #16424 -- NEW TONNEAU COVER LOCK CYLINDER RETAINER CLIPS RELEASED FOR SERVICE. *MJ (NHTSA ID #10008351, NOVEMBER 01 2002)

STRUCTURE:BODY:BUMPERS

• TSB #02232 -- FRAME MOUNTED FRONT BUMPER BRACKETS SERVICE KIT. *TT (NHTSA ID #10008311, NOVEMBER 25 2002)

STRUCTURE:BODY:ROOF AND PILLARS

• TSB #03231 -- INOPERABLE LATCHES, LOCKS AND/OR LIFT STRUTS ON VEHICLES EQUIPPED WITH A HARD TONNEAU COVER. *TT (NHTSA ID #10008153, NOVEMBER 24 2003)
• TSB #16253 -- EQUIPPED WITH A HARD TONNEAU COVER. * MJ (NHTSA ID #10008608, SEPTEMBER 01 2002)

TIRES

• TSB #17490 -- EXCESSIVE FRONT TIRE HEAL AND TOE WEAR AT LOW MILEAGE. ON GOODYEAR P245/75R16 TIRES. *TT (NHTSA ID #10007331, JANUARY 01 2004)
• TSB #16510 -- P225/70R15 FIRESTONE WILDERNESS HT TIRE MAY EXHIBIT EXCESSIVE TIRE CUPPING/FEATHERING ON THE OUTSIDE EDGES OF THE FRONT TIRES. OASIS. *TT (NHTSA ID #10005088, JANUARY 01 2003)

SEATS

• TSB #15929 -- SOME XLT MODLES MAY EXHIBIT WRINKLED, LOOSE, OR BAGGY FABRIC ON THE FRONT SEATING SURFACE. *TT (NHTSA ID #637835, MAY 01 2002)

EQUIPMENT:ELECTRICAL

• TSB #0513 -- INSIDE DOOR PULL HANDLE LOOSE - VEHICLES BUILT BEFORE 11/15/2002 AND EQUIPPED WITH POWER WINDOWS/DOOR LOCKS. *TT (NHTSA ID #10013300, JANUARY 24 2005)

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

• TSB #15905 -- SUBJECT REGARDING PIONEER TREMOR / ULTIMATE 450 WATT AUDIO SYSTEM WHINE NOISE. *TT (NHTSA ID #637794, MAY 01 2002)
• TSB #15863 -- SUBJECT REGARDING A WHINE NOISE CONDITION FROM THE SPEAKERS WHEN USING THE RADIO OR THE CD WITH THE PIONEER TREMORE / PIONEER ULTIMATE 450 WATT AUDIO SYSTEM. *TT (NHTSA ID #637719, MAY 01 2002)

UNKNOWN OR OTHER

• TSB #0256 -- THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT (NHTSA ID #636049, MARCH 18 2002)
• TSB #0232 -- SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT (NHTSA ID #630636, FEBRUARY 18 2002)
• TSB #15605 -- SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT (NHTSA ID #630653, FEBRUARY 01 2002)
• TSB #15504 -- SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT (NHTSA ID #630026, JANUARY 01 2002)
• TSB #15563 -- INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH (NHTSA ID #630097, JANUARY 01 2002)
• TSB #15486 -- SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457 (GROSS LEAK AFTER FUEL FILL). *TT (NHTSA ID #630595, DECEMBER 01 2001)
• TSB #01157 -- INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC (NHTSA ID #623988, AUGUST 06 2001)