Huge win for car owners! All TSBs to be made public. The Center for Auto Safety just made the NHTSA (US Government) make public the full text of all TSBs from now on. They are the same organization that has petitioned the NHTSA & filed lawsuits to protect car owners over exploding gas tanks & other major safety issues. Whenever you drive in your car, you are safer thanks in part to a lot of work over the years by this small but very effective consumer advocacy group.

Please take a moment & say thank you by donating $5 or whatever you can to the Center for Auto Safety.

2.4

hardly worth mentioning
Crashes / Fires:
0 / 2
Injuries / Deaths:
0 / 0
Average Mileage:
65,060 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2002 Jeep Grand Cherokee accessories - exterior problems

accessories - exterior problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2002 Jeep Grand Cherokee:

Unsubscribe any time. We don't sell/share your email.

2002 Jeep Grand Cherokee Owner Comments (Page 4 of 5)

« Read the previous 20 complaints

problem #35

Nov 102005

Grand Cherokee 8-cyl

  • Automatic transmission
  • 47,443 miles

A D V E R T I S E M E N T S

2002 Jeep Grand Cherokee climate control blend door failed. This causes outside air to blow from the passenger side of dash even when heat setting is turned to maximum temperature. Defrosting windshield under winter icing conditions very difficult. Dealer wanted $500 - $1500 for repair, depending on amount of labor required removal of dash.

- Westmoreland, NY, USA

problem #34

Jan 052007

Grand Cherokee 8-cyl

  • Automatic transmission
  • 70,500 miles
The heat in my 2002 Jeep Grand Cherokee limited (72,500 miles) stopped distributing heat. First the heat stopped on the passenger side, then a few weeks later, the heat failed everywhere. I had to get the blender doors, actuator, heater core and evaporator replaced. The cost of the repair at a Jeep dealership cost nearly $1,500. I've heard this is a common problem on this model Jeep.

- Manasquan, NJ, USA

problem #33

Dec 292006

Grand Cherokee

  • miles
Started the car and one day the heater just started blowing cold air. Never made any noise or anything but slowly the passenger side stopped blowing hot air then the driver side and even the windshiled. No repair has been made becuase of the cost ranging from 1,000 to 1,500 dollars. New parts need to be made free of this defect and manufacturer should cover the cost of repair to every owner in which it occurs.

- Lawrenceville, GA, USA

problem #32

Dec 292006

Grand Cherokee 8-cyl

  • Automatic transmission
  • 75,000 miles

A D V E R T I S E M E N T S

1) rapid fogging of front windsheild, (2) fogging of front passenger windows, (3) failure of passenger heat while still maintaining driver heat function, and (4) only cold air release on passenger side of Jeep. Consequently, (1) the windsheild and front windows do not defog, and (2) no heat whatsoever comes from the passenger side floor and dashboard ventilation system. To correct this problem, a "blend air door" is necessary at a cost of approximately $1,200 inclusive of 7 hours of labor. According to the certified service department at the local Jeep dealer and online forums, this has become a very common problem for 2000-2004 Jeep Grand Cherokee limiteds with duel zone ventilation systems. Dealer said no recall due to no safety concern. Isn't a window that can't be defrosted a safty concern?

- Leeds, AL, USA

problem #31

Dec 142006

Grand Cherokee 8-cyl

  • Automatic transmission
  • 51,474 miles
I own a 2002 Jeep Grand Cherokee limited with 51,474 miles. I purchased this as a used car on Nov 30, 2006 from a reputable (?) dealer. To my mistake, we did not check out the heat. We do live in South West fla. Upon needing heat to take the dew off my windshield I found I have none. My windshield and side windows do not clear on mornings that heat would help in that situation. It is extremely dangerous as you would expect. No heat comes from anywhere. The dealer checked it out and said it was a "blend air door" problem and would not be covered under a used auto purchase since we declined the extended warranty. (we took it back on Dec. 12,2006 to be checked out at dealer) the dealer said it was a "common problem that costs a lot of money, usually over $1000 to replace. I then asked my own mechanic his opinion and he said he will not touch the repair because of the time, labor, and money involved in doing this when he thinks it is a dealer issue. If you do an internet search for blend air door problems you will find this a common problem for 2000-2004 Jeep.

- Naples, FL, USA

Search CarComplaints.com for these popular complaint phrases...

problem #30

Jan 262007

Grand Cherokee 4WD 8-cyl

  • Automatic transmission
  • 70,000 miles
Ventilation system does not properly work. 1/2 of system blows cold air when heat is requested of system. Known and widespread issue on vehicle listed. Creates safety issue as defroster does not completely and safely remove frost/fog from windshield.

- Bethel Park, PA, USA

problem #29

Jan 182007

Grand Cherokee 8-cyl

  • Automatic transmission
  • 74,000 miles

A D V E R T I S E M E N T S

The passenger side vents blow cold. Driver side vents work fine.

- Edison, NJ, USA

problem #28

Jan 052007

Grand Cherokee 4WD 8-cyl

  • Automatic transmission
  • 55,000 miles
On my 2002 Jeep Grand Cherokee limited with only 55,000 miles, the defrost / heater does not work properly. From my limited research, it appears the blend door for the dual climate control is an issue for many Jeep owners. Note: Does tsb 2041004 apply to this issue?

- Anthem, AZ, USA

problem #27

Jan 082007

Grand Cherokee 8-cyl

  • Automatic transmission
  • 64,000 miles
My blend doors are broken. I receive no heat from the drivers side. I have searched every Jeep forum I can find and have found this to be a very common issue, not due to usage but poor planning on the manufacturers part by using poor construction.

- Alexandria , VA, USA

problem #26

Nov 302006

Grand Cherokee 8-cyl

  • Automatic transmission
  • 38,500 miles
- the contact stated that while driving his 2002 Jeep grande Cherokee (failure mileage 38500) at 35 mph in the snow at 18 degrees, the defroster failed to operate properly. It began to blow cold air and then stopped functioning. The windows steamed up and visibility was poor. The contact took the vehicle to the dealer and he was notified that the blend doors were sticking, and not opening and closing the way they should be. The contact is concerned about having an crash due to poor visibility.

- Broadview Heights, OH, USA

problem #25

Dec 272006

Grand Cherokee

  • 90,000 miles

A D V E R T I S E M E N T S

No heat on the passenger side. Windshield fogged up on passenger side. Defroster didn't work. Greasy substance on inside windshield and windows. Diagnosis: Shaft on blend door broken ie. No heat. Replace shaft & door. Expensive. Heater core had to be replaced - very expensive. Had to go in through the dash for both repairs. Jeep not interested in talking to us about these problems.

- Eagan, MN, USA

problem #24

Jan 052007

Grand Cherokee 8-cyl

  • Automatic transmission
  • 73,110 miles
2202 Jeep Grand Cherokee. Had only cold air on passenger side; but still had function on driver's side. Now no heat whatsoever. Cannot clear windshield. Estimate for repair at local garage $1500-1800. Told is very common with Cherokee. When will someone take responsibility for this issue?

- New Hope, MN, USA

problem #23

Nov 202006

Grand Cherokee 4WD 8-cyl

  • Automatic transmission
  • 69,500 miles
(1) none that we are aware of. Feature just stopped functioning. (2) the air conditioning and heater does not direct air flow properly. Cold air is directed to the lower passenger side vent regardless of control settings. (3) duct tape placed over passenger lower air outlet. Other: The problem started before our extended 70,000 warranty had expired but we didn't realize there was a problem until just after passing 70,000 miles. We kept trying to adjust the controls until it became obvious there was some problem with the way the controls were responding to settings. We are not sure of all the effects this problem may have, such as loss of control of other air conditioner / heater settings which may affect visibility related to the defroster/defogger system as controled by the windshield blower.

- Mesa, AZ, USA

problem #22

Jun 032006

Grand Cherokee 4WD 8-cyl

  • Automatic transmission
  • 104,000 miles
- dual climate control system on 2002 Jeep Grand Cherokee limited failed. Cold air was blowing from one side despite the settings. Resulted in a $1200 repair at the dealership. -dashboard has a loud creaking sound coming from its underside when I turn on the ventilation. -creaking from the dash seconds after shutting the engine off.

- Edmonton, 00, USA

problem #21

Dec 252006

Grand Cherokee 8-cyl

  • Automatic transmission
  • 125,000 miles
A/C system blows cold air only due to high failure item known to daimler-Chrysler. Results in no defog during cold weather unless you want cold A/C blowing during the winter with sub-freezing temperatures. Problem can be eliminated if you buy a Jeep grande Cherokee in tropical climates only.

- Corpus Christi, TX, USA

problem #20

Feb 102005

Grand Cherokee 8-cyl

  • Automatic transmission
  • 28,900 miles
Dual climate control:passenger side has no control/blows cold air when system is activated. Cold air from all passenger vents. No heat for passenger comfort, or window defog on passenger side.

- Sacramento, CA, USA

problem #19

Dec 202006

Grand Cherokee 4WD 8-cyl

  • Automatic transmission
  • 58,000 miles
Regarding my 2002 Jeep Grand Cherokee ltd....only cold air blows from heater on passenger side of car...have been told this is a very common blend door failure on this model and an extremely labor intensive, expensive repair.

- Dallas, TX, USA

problem #18

Dec 012006

Grand Cherokee 8-cyl

  • Automatic transmission
  • 47,000 miles
Defroster stopped blowing hot air, windshield fogged up, blender door on heating system needed to be replaced.

- Chicago, IL, USA

problem #17

Nov 012005

Grand Cherokee 8-cyl

  • Automatic transmission
  • 80,000 miles
02 Jeep Grand Cherokee blend door failure, heater and defogger failure.

- Maple Ridgebc Canada, 00, USA

problem #16

Nov 202006

Grand Cherokee 4WD 8-cyl

  • Automatic transmission
  • 53,000 miles
2002 Jeep Grand Cherokee - climate control blend door failure. The passenger side temperature blend door failed at 53K miles. This is a known problem with all Jeep Grand Cherokee. The failure was repaired under a self purchased (I.e non-Chrysler) warranty with a $250 deductible. The warranty company would not repair the drivers side bend door, thus this repair will most likely need to be performed again.

- Denver, CO, USA

Read the next 15 complaints »

Not what you are looking for?