Technical Service Bulletins (TSBs) for the 2005 E320 are official communications between Mercedes-Benz & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
XENTRY: RATTLING/THUMPING NOISES FROM THE AREA OF THE STEERING ON ROUGH ROADS OR WHEN DRIVING OVER ROAD UNDULATIONS. NO MODEL YEARS GIVEN. ALSO INCLUDED MODELS 168 AND 172. *JS Read More »
STEERING WHEEL HEATER NOT OPERATING CORRECTLY OR INOPERATIVE AT COLD TEMPERATURES. MERCEDES BENZ MODEL 211. MODEL YEAR UNKNOWN. *TT MODEL 211 (E SERIES). UPDATE 8/8/2008. *PE Read More »
STEERING WHEEL HEATER NOT OPERATING CORRECTLY OR INOPERATIVE AT COLD TEMPERATURES. MERCEDES BENZ MODEL 211. MODEL YEAR UNKNOWN. *TT MODEL 211 (E SERIES). UPDATE 8/8/2008. *PE Read More »
MERCEDES: FOLLOWING FAULT CODES ARE ENTERED IN THE CONTROL UNIT AND DISPLAYED-FC5320 DRAIN VALVE:OPEN CIRCUIT OR INSUFFICIENT VALVE CURRENT IN MODELS SERIES 211, 219; FC5260 DRAIN VALVE OPEN CIRCUIT OR INSUFFICIENT VALVE CURRENT IN MODEL ... Read More »
SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION:LINES AND FITTINGS
MERCEDES: FOLLOWING FAULT CODES ARE ENTERED IN THE CONTROL UNIT AND DISPLAYED-FC5320 DRAIN VALVE:OPEN CIRCUIT OR INSUFFICIENT VALVE CURRENT IN MODELS SERIES 211, 219; FC5260 DRAIN VALVE OPEN CIRCUIT OR INSUFFICIENT VALVE CURRENT IN MODEL ... Read More »
MERCEDES: THE LIMITED WARRANTY ON THE SBC HYDRAULIC UNIT FOR MODELS 211, MODEL 219 AND MODELS 230 WAS EXTENDED FROM THE ORIGINAL 4 YEARS/50,000 MILES TO 10 YEARS WITH NO MILEAGE LIMITATION. Read More »
If the customer brakes sharply from a speed of > 30mph, without ABS intervention, there is a single cracking noise from the area of the ESP hydraulic unit Read More »
MERCEDES: THE LIMITED WARRANTY ON THE SBC HYDRAULIC UNIT FOR MODELS 211, MODEL 219 AND MODELS 230 WAS EXTENDED FROM THE ORIGINAL 4 YEARS/50,000 MILES TO 10 YEARS WITH NO MILEAGE LIMITATION. Read More »
ACTIVATION OF THE SENSOTRONIC BRAKE CONTROL (SBC) SYSTEM WITH DAS SOFTWARE 02/05. MERCEDES-BENZ MODELS 199, 211, 219, 230 MY 2003-2006. *TT Read More »
MERCEDES: THE LIMITED WARRANTY ON THE SBC HYDRAULIC UNIT FOR MODELS 211, MODEL 219 AND MODELS 230 WAS EXTENDED FROM THE ORIGINAL 4 YEARS/50,000 MILES TO 10 YEARS WITH NO MILEAGE LIMITATION. Read More »
Engine diagnosis warning lamp lights up in instrument cluster, fault code U145400: "Implausible data were received from the ethanol sensor" Read More »
XENTRY (MERCEDES): ENGINE WARNING LAMP IS CURRENTLY ON OR WAS ON AND A DELAY FAULT OF THE CAMSHAFT ADJUST TO CURRENT OR STORED IN THE ENGINE CONTROL UNIT. MODELS 171, 203, 209, 211, 219, 221, 216, 230, 164, 251, AND 403. Read More »
Combination message: "Clean fuel filter" is displayed. The fault code 162500 (water level message - Bosch) or P226997 (water level message - Delphi) or 171600 (filter load - Bosch) is stored in the engine control unit. Read More »
MERCEDES: THE FUEL LEVEL INDICATED IN THE INSTRUMENT CLUSTER DOES NOT MATCH THE ACTUAL FILL LEVEL. THIS MAY BE CAUSED BY A FAULT IN THE FUEL LEVEL SENSOR FUNCTION CHAIN: HYDRAULIC AND ELECTRICAL LINES AND THEIR CONNECTIONS, REAR SAM OR ... Read More »
MERCEDES BENZ SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CHECK FUEL FILTER MODULE ASSEMBLY AND REPAIR OR REPLACE IF NECESSARY. MODELS 211 AND 219 AMG. MODEL YEARS 2003-2006. CSC WAS RECEIVED. Read More »
MERCEDES BENZ SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CHECK FUEL FILTER MODULE ASSEMBLY AND REPAIR OR REPLACE IF NECESSARY. MODELS 211 AND 219 AMG. MODEL YEARS 2003-2006. CSC WAS RECEIVED. Read More »
MERCEDES- BENZ : SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER . IN OUR CONTINUING EFFORTS TO ENHANCE THE SATISFACTION OF OUR CUSTOMERS, MERCEDES- BENZ HAS DECIDED TO EXTEND WARRANTY FOR CERTAIN FUEL TANK COMPONENTS VEHICLES WHICH ... Read More »
MERCEDES BENZ: WORK ON PRESSURE REGULATOR VALVE (AS OF CD13, 1600 BAR SYSTEM). FUEL LOSS AT THE PRESSURE REGULATOR VALVE AND/OR POOR ENGINE RUNNING CHARACTERISTICS (SHAKES, KNOCKS, SURGES, CHANGES TO LIMP HOME MODE, POOR OUTPUT, POOR ... Read More »
MERCEDES: THE FUEL LEVEL INDICATED IN THE INSTRUMENT CLUSTER DOES NOT MATCH THE ACTUAL FILL LEVEL. THIS MAY BE CAUSED BY A FAULT IN THE FUEL LEVEL SENSOR FUNCTION CHAIN: HYDRAULIC AND ELECTRICAL LINES AND THEIR CONNECTIONS, REAR SAM OR ... Read More »
INSPECT TRANSMISSION PILOT BUSHING AT ELECTROCHYDRAULIC UNIT AND REPLACE IF NECESSARY. THE TRANSMISSION PILOT BUSHING MAY HAVE BEEN INSTALLED ON THE CONTROL UNITS WITH NON-TEMPERED SEALING RINGS WHICH MAY CAUSE A SMALL LEAK TO OCCUR. Read More »
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
MERCEDES BENZ: MODELS 203, 209, 211, 219,230, AND 463; MODEL YEARS 2005-2007. REPLACE PILOT BUSHING AT ELECTROHYDRAULIC UNIT. DAIMLER AG HAS DETERMINED THAT ON AFFECTED VEHICLES THE TRANSMISSION PILOT BUSHING MAY LEAK. Read More »
MERCEDES: REPLACE TRANSFER CASE ON AFFECTED VEHICLES OPTIMIZED TRANSFER CASES WILL REDUCE VIBRATIONS WHEN CORNERING OR WHEN PARKING. MODELS 203, 211, 220. *PE Read More »
MERCEDES: CRACKING/CREAKING NOISES FROM FRONT AXLE WHEN VEHICLE IS SUBJECT TO TORSION OR WHEN STEERING WHEEL IS TURNED. THIS IS MAINLY HEARD WHEN THE VEHICLE IS STATIONARY OR WHEN THE VEHICLE IS MOVING SLOWLY. Read More »
Unmotivated Reaction from Park Assist - model series 213 facelift / 238 facelift with option code 235 (active par- king assist) and option code 501 (surround view system) Read More »
XENTRY (MERCEDES): ENGINE WARNING LAMP IS CURRENTLY ON OR WAS ON AND A DELAY FAULT OF THE CAMSHAFT ADJUST TO CURRENT OR STORED IN THE ENGINE CONTROL UNIT. MODELS 171, 203, 209, 211, 219, 221, 216, 230, 164, 251, AND 403. Read More »
MERCEDES: AIR MATIC VISIT WORKSHOP DISPLAYED WITHIN INSTRUMENT CLUSTER. MODELS 164, 211, 219, 221 AND 251. INCLUDED 4MATIC, AMG (COMPRESSOR) AMG, BLUETEC AND WAGON. MODEL YEARS UNKNOWN. *PE UPDATED 9/18/09. Read More »
MERCEDES: AIR MATIC VISIT WORKSHOP DISPLAYED WITHIN INSTRUMENT CLUSTER. MODELS 164, 211, 219, 221 AND 251. INCLUDED 4MATIC, AMG (COMPRESSOR) AMG, BLUETEC AND WAGON. MODEL YEARS UNKNOWN. *PE UPDATED 9/18/09. Read More »
MERCEDES: SRS INDICATOR LAMP ON. THE SRS LIGHT IS ILLUMINATED AND DIAGNOSTIC FAULT CODE(S) B9223 AND/OR B9243 ARE STORED IN THE SRS ECU. THE RESISTANCE OF THE IGNITION SQUIB CIRCUIT FOR THE SIDEBAG MAY BE TOO HIGH. MODEL 211. Read More »
MERCEDES: SRS INDICATOR LAMP ON. THE SRS LIGHT IS ILLUMINATED AND DIAGNOSTIC FAULT CODE(S) B9223 AND/OR B9243 ARE STORED IN THE SRS ECU. THE RESISTANCE OF THE IGNITION SQUIB CIRCUIT FOR THE SIDEBAG MAY BE TOO HIGH. MODEL 211. Read More »
MERCEDES BENZ: FRONT OR REAR SEAT BELT DOES NOT ROLL UP CORRECTLY. DIRT DEPOSITS ON THE SEAT BELT GUIDE DUE TO SOILED SEAT BELT. ALSO INCLUDED MODELS 169, F CELL, 246, AND 231. NO MODEL YEARS GIVEN. Read More »
Noise complaints when load on backrest frame changes. Affects the driver and front passenger seats. Also perform the remedial action if you are performing work on: - backrest frame - backrest cover or - guide rail of head restraint. Read More »
MERCEDES BENZ: TAILGATE DOES NOT OPEN FULLY IN COLD WEATHER. THE TAILGATE NOT OPENING FULLY IN COLD WEATHER, DO NOT REPLACE THE STRUTS. *PE Read More »
MERCEDES-BENZ MODELS E320 AND E500, UP TO OCTOBER 2007 PRODUCTION (OR UP TO B291390). TAILGATE DOES NOT OPEN FULLY IN COLD WEATHER. *TT UPDATED 7/7/08. *NJ Read More »
MERCEDES BENZ: TAILGATE DOES NOT OPEN FULLY IN COLD WEATHER. THE TAILGATE NOT OPENING FULLY IN COLD WEATHER, DO NOT REPLACE THE STRUTS. *PE Read More »
THE TIREFIT HOSE CONNECTOR MAY NOT SCREW ONTO THE TIRE VALVE WITH AN AIR TIGHT SEAL. IN CASE OF A FLAT TIRE, THE CUSTOMER MAY NOT BE ABLE TO INFLATE THE SPARE TIRE USING TIREFIT. *TT Read More »
Crease formation on genuine leather seat covers in vehicles with low mileage ??A?A? Objects left on the seats for extended periods of time (pressure marks). ??A?A? Objects wedged between the seat backrest and seat cushion (e.g. Read More »
Possible complaints: 1. Memory function of electric seat fore/aft adjustment not functioning. 2. Seat fore/aft adjustment with easy entry/exit feature not functioning. 3. Head restraint presetting not functioning. 4. Read More »
If the customer brakes sharply from a speed of > 30mph, without ABS intervention, there is a single cracking noise from the area of the ESP hydraulic unit Read More »
Apple products (iPhone or iPod) are not charged via the serial USB interface of the COMAND Online control unit (A40/3) in the stowage compartment of the center console. Read More »
This Customer 1 Action has been initiated because certain mbrace subscribers were recently contacted by mbrace informing them that they need to have an i-button call performed to ensure their mbrace device has registered with the ... Read More »
