2011 Mercury Milan
69 Technical Service Bulletins (TSBs)
TSB List for the 2011 Mercury Milan
Technical Service Bulletins (TSBs) for the 2011 Milan are official communications between Mercury & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #SSM 51666
Some 2010-2012 Fusion/Milan and 2011-2012 MKZ vehicles equipped with a 2.5L or 3.0L engine and electronic power assist steering (EPAS), a remanufactured replacement steering gear (MU2Z-3V504-ARM) is available which is significantly less ... Read More »
-
TSB #SSM 46210
SOME 2010-2016 EPAS EQUIPPED VEHICLES MAY EXHIBIT STEERING RELATED NOISES. THE WORKSHOP MANUAL (WSM) DIAGNOSTIC PROCEDURES HAVE BEEN UPDATED IN SECTION 211-02. WHEN DIAGNOSING AND REPAIRING EPAS STEERING NOISES USE THE UPDATED PROCEDURES. Read More »
-
TSB #AS-21778
FORD: THERE MAY BE A STEERING DRIFT WHILE DRIVING ON A FLAT OR UNEVEN ROAD SURFACE. 2010-2011 FUSION/MILAN/MKZ. THIS COULD BE NORMAL. *RM Read More »
BRAKES (PWS)
-
TSB #SSM 46132
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. Read More »
-
TSB #SSM 46132
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. Read More »
ENGINE (PWS)
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #ASI-32332
FORD: DUE TO AN INTERMITTENT LOSS OF RPM OR LACK OF ACCELERATION, IN SOME VEHICLES, WITH ILLUMINATED WRENCH LIGHT, DIAGNOSTIC TROUBLE CODES (DTCS) P2111, P2112 MAY OR MAY NOT BE STORED IN POWERTRAIN CONTROL MODULE (PCM). Read More »
-
TSB #SB-32167-70
FORD/LINCOLN/MERCURY: SOME VEHICLES MAY EXPERIENCE AN ILLUMINATED MIL OR SAFETY STOP NOW MESSAGE, OR A NO START CONDITION OR POSSIBLE MISFIRE OR ROUGHNESS AT IDLING THROUGH 2000RPM OR A LACK OF ACCELERATION. Read More »
-
TSB #ASI-22285
FORD/MERCURY/LINCOLN: SOME VEHICLES EXHIBIT A COLD WEATHER PHENOMENON WHERE FLUID HAS EXPELLED OUT OF VENT ON REAR DRIVE UNITS (RDU) AND FLUID, ON OCCASION, WOULD BURP OUT. *PE Read More »
ENGINE AND ENGINE COOLING
-
TSB #SSM 52243
When performing any transmission fluid change or topoff involving MotorcraftA? Premium ATF, MERCONA? V has replaced all versions of MotorcraftA? Premium ATF and can be used going forward. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #TSB-12-1-18
FORD/MERCURY/LINCOLN: SOME MODEL YEAR VEHICLES MAY EXHIBIT A MESSAGE WITH A RED TRIANGLE ON AND STOP SAFELY NOW, AND/OR HAVE A DIAGNOSTIC TROUBLE CODE, NO START CONDITION. *PE Read More »
-
TSB #ASI-22173
FORD: THE VARIABLE CAMSHAFT TIMING VCT) SOLENOID MOVEMENT MAY BE TEMPORARILY RESTRICTED DUE TO DEBRIS IN ENGINE OIL THAT IS CAUSING DIAGNOSTIC TROUBLE CODES (DTCS). *PE Read More »
-
TSB #TSB-11-3-22
FORD: THERE MAY BE A LEAKING/STUCK CANISTER PURGE VALVE WHICH CAN CAUSE MULTIPLE DRIVING SYSTEMS. THE MALFUNCTION LIGHT MAY BE ON WITH OR WITHOUT STORED TROUBLE CODES. *RM Read More »
-
TSB #TSB-11-2-10
FORD: THERE MAY BE A HARD START OR ROUGH IDLE ACCOMPANIED WITH TWO TROUBLE CODES. THE PROBLEM MAY HAVE TO DO WITH CAMSHAFT TIMING. 2010-2011 FUSION/ESCAPE/MILAN/MARINER. *RM Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
POWER TRAIN
-
TSB #SSM 47976
On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Read More »
-
TSB #16-0043
6F35 TRANSMISSION - FLUID LEAK AT LEFT SIDE HALFSHAFT SEAL BUILT ON OR BEFORE 10/14/2013 ISSUE Some 2009-2014 Escape, 2009-2011 Mariner, 2010-2014 Fusion, 2010-2011 Milan, 2012-2014 Edge/Explorer, and 2013-2014 Taurus/MKT/MKZ vehicles ... Read More »
-
TSB #TSB160043
6F35 Transmission - Fluid leak at left side halfshaft seal - built on or before 10/14/2013 Read More »
HYBRID PROPULSION SYSTEM
-
TSB #TSB 23-2098
Some 2010-2012 Fusion hybrid electric vehicles (HEV), 2010-2011 Milan HEV and 2011-2012 MKZ HEV vehicles may experience reduced electric vehicle operation and increased gasoline engine operation around 10 years of vehicle age and beyond. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #TSB-14-0056
MERCURY/FORD: ON SOME VEHICLES, THERE IS A FLUID LEAKAGE, COMING FROM LEFT HAND (LH) HALFSHAFT SEAL OF THE AUTOMATIC TRANSMISSION AND A SERVICE KIT IS AVAILABLE NOW, FOR REPAIR. MODEL 2009-2012 ESCAPE, MARINER, FUSION, MILAN. Read More »
-
TSB #SB-44300
FORD: ON THE LEFT HAND HALF SHAFT SEAL, THERE IS A FLUID LEAK FROM THE TRANSMISSION BECAUSE OF WEAR ON CASE BUSHING. MODEL 2009-2012 ESCAPE, 2009-2011 MARINER, 2010-2012 FUSION, 2010-2011 MILAN. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
-
TSB #TSB 23-2098
Some 2010-2012 Fusion hybrid electric vehicles (HEV), 2010-2011 Milan HEV and 2011-2012 MKZ HEV vehicles may experience reduced electric vehicle operation and increased gasoline engine operation around 10 years of vehicle age and beyond. Read More »
-
TSB #ASI-32332
FORD: DUE TO AN INTERMITTENT LOSS OF RPM OR LACK OF ACCELERATION, IN SOME VEHICLES, WITH ILLUMINATED WRENCH LIGHT, DIAGNOSTIC TROUBLE CODES (DTCS) P2111, P2112 MAY OR MAY NOT BE STORED IN POWERTRAIN CONTROL MODULE (PCM). Read More »
-
TSB #TSB-11-5-2
FORD: ENGINE POWER MAY BE REDUCED WITH A HIGH IDLE SPEED. THE ENGINE LIGHT MAY ALSO BE ON WITH A STORED TROUBLE CODE. PROGRAMMING ISSUE. 2010-2011 FUSION/MERUCRY MILAN/LINCOLN MKZ. *RM Read More »
ELECTRICAL SYSTEM
-
TSB #TSB 20-2142
Some 2010-2012 Fusion hybrid electric vehicles (HEV), 2010-2011 Milan HEV and 2011-2012 MKZ HEV vehicles may experience reduced electric vehicle operation and increased gasoline engine operation around 10 years of vehicle age and beyond. Read More »
-
TSB #CSP-13N03
FORD: THROTTLE BODY WILL DEVELOP CONTAMINATION ON INTERNAL MOTOR CONTACTS RESULTING IN AN INTERMITTENT ELECTRICAL CONNECTIVITY AND MALFUNCTION INDICATOR LAMP (MIL) OR WRENCH LIGHT WILL ILLUMINATE. Read More »
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
-
TSB #ASI-45147
LINCOLN/FORD: SOME VEHICLES WILL EXPERIENCE, IN HOT EXTREME AMBIENT TEMPERATURES, A STOP SAFELY NOW OR A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED IN PRESENT OF BATTERY ENERGY CONTROL MODULE (BECM) DTC P0A7E AND BECM NEEDS REPLACED, ... Read More »
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
-
TSB #TSB-11-5-2
FORD: ENGINE POWER MAY BE REDUCED WITH A HIGH IDLE SPEED. THE ENGINE LIGHT MAY ALSO BE ON WITH A STORED TROUBLE CODE. PROGRAMMING ISSUE. 2010-2011 FUSION/MERUCRY MILAN/LINCOLN MKZ. *RM Read More »
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
-
TSB #CSP-13N03
FORD: THROTTLE BODY WILL DEVELOP CONTAMINATION ON INTERNAL MOTOR CONTACTS RESULTING IN AN INTERMITTENT ELECTRICAL CONNECTIVITY AND MALFUNCTION INDICATOR LAMP (MIL) OR WRENCH LIGHT WILL ILLUMINATE. Read More »
-
TSB #TSB-12-1-18
FORD/MERCURY/LINCOLN: SOME MODEL YEAR VEHICLES MAY EXHIBIT A MESSAGE WITH A RED TRIANGLE ON AND STOP SAFELY NOW, AND/OR HAVE A DIAGNOSTIC TROUBLE CODE, NO START CONDITION. *PE Read More »
-
TSB #11-7-31
FUSION HYBRID, LINCOLN MKZ, MERCURY MILAN 2010-2011 MAY EXHIBIT WRENCH LIGHT ON WITH NO DRIVEABILITY CONCERNS, NO DIAGNOSTIC TROUBLE CODE. *LJ Read More »
ELECTRICAL SYSTEM:SOFTWARE
-
TSB #ASI-45147
LINCOLN/FORD: SOME VEHICLES WILL EXPERIENCE, IN HOT EXTREME AMBIENT TEMPERATURES, A STOP SAFELY NOW OR A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED IN PRESENT OF BATTERY ENERGY CONTROL MODULE (BECM) DTC P0A7E AND BECM NEEDS REPLACED, ... Read More »
-
TSB #14M03
FORD 2010-2011 MILAN AND MKZ VEHICLES: CUSTOMER SATISFACTION PROGRAM REGARDING TAIL LAMP ASSEMBLY EXTENDED COVERAGE TO 10 YEARS OR 150,000 MILES WARRANTY. *LJ Read More »
-
TSB #TSB-11-5-2
FORD: ENGINE POWER MAY BE REDUCED WITH A HIGH IDLE SPEED. THE ENGINE LIGHT MAY ALSO BE ON WITH A STORED TROUBLE CODE. PROGRAMMING ISSUE. 2010-2011 FUSION/MERUCRY MILAN/LINCOLN MKZ. *RM Read More »
ELECTRICAL SYSTEM:PROPULSION SYSTEM:HYBRID MANAGEMENT:POWER CONTROL UNIT/MODULE (HPCU)
-
TSB #TSB 23-2098
Some 2010-2012 Fusion hybrid electric vehicles (HEV), 2010-2011 Milan HEV and 2011-2012 MKZ HEV vehicles may experience reduced electric vehicle operation and increased gasoline engine operation around 10 years of vehicle age and beyond. Read More »
EXTERIOR LIGHTING:TAIL LIGHTS
-
TSB #14M03
FORD 2010-2011 MILAN AND MKZ VEHICLES: CUSTOMER SATISFACTION PROGRAM REGARDING TAIL LAMP ASSEMBLY EXTENDED COVERAGE TO 10 YEARS OR 150,000 MILES WARRANTY. *LJ Read More »
EXTERIOR LIGHTING:BRAKE LIGHTS
-
TSB #TSB-11-11-10
MERCURY/LINCOLN/FORD: THE RED BRAKE LAMP WILL ILLUMINATE WITH NO CHANGE IN BRAKE PEDAL FEEL. *PE Read More »
VISIBILITY
-
TSB #SSM 48130
Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Read More »
VISIBILITY:GLASS, SIDE/REAR
-
TSB #SSM 48130
Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Read More »
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
-
TSB #44863
FORD: NO SERVICE ACTION IS RECOMMENDED FOR THIS CONDITION. PLEASE USE AT YOUR DISCRETION. VARIOUS 2010-2015 VEHICLES MAY EXPERIENCE A TURBULENCE NOISE, SIMILAR TO AN HELICOPTER NOISE, AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOW(S) OR ... Read More »
AIR BAGS
-
TSB #22B05 S1
Certain 2005-2014 Mustang, 2005-2006 GT, 2004-2011 Ranger, 2006-2012 Fusion and MKZ/Zephyr, 2006-2011 Milan, and 2007-2010 Edge & MKX Vehicles Driver & Passenger Airbag Module Quality Control Inspection REASON FOR THIS SUPPLEMENT ... Read More »
-
TSB #22B05
Certain 2005-2014 Mustang, 2005-2006 GT, 2004-2011 Ranger, 2006-2012 Fusion & MKZ/Zephyr, 2006-2011 Milan, and 2007-2010 Edge & MKX Vehicles Driver & Passenger Airbag Module Quality Control Inspection: Ford Motor Company has determined ... Read More »
STRUCTURE:BODY
-
TSB #13N03
FORD FUSION, MILAN, ESCAPE, MARINER 2009-2013: CUSTOMER SATISFACTION PROGRAM THROTTLE BODY EXTENDED COVERAGE. *LJ Read More »
STRUCTURE:BODY:DOOR
-
TSB #TSB-11-3-11
FORD: 2011 FUSION/MKZ/MILAN. EXTERIOR DOOR HANDLE MAY STICK WHEN OPENING OR WILL NOT BE FLUSH WHEN CLOSED. *RM Read More »
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
-
TSB #TSB-11-3-11
FORD: 2011 FUSION/MKZ/MILAN. EXTERIOR DOOR HANDLE MAY STICK WHEN OPENING OR WILL NOT BE FLUSH WHEN CLOSED. *RM Read More »
EQUIPMENT
-
TSB #SSM 47201
Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or ... Read More »
-
TSB #SSM 47009
The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). Read More »
-
TSB #SSM 46332
REPLACING THE ORIGINAL EQUIPMENT SYNC/NAVIGATION SYSTEM WITH EITHER AN AFTERMARKET SYNC/NAVIGATION KIT OR MODIFYING ORIGINAL SYNC/NAVIGATION PARTS TO PROVIDE ADDITIONAL FEATURES IS NOT RECOMMENDED NOR SUPPORTED ON ANY FORD, MERCURY OR ... Read More »
-
TSB #TSB 16-0143
SOME 2010-2012 FUSION HYBRID, MILAN HYBRID AND MKZ HYBRID VEHICLES MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0030 AND/OR P0130. Read More »
-
TSB #CSP-13B17
FORD: THE THROTTLE BODY INTERNAL MOTOR CONTACTS MAY BE CONTAMINATED, RESULTING IN AN ELECTRICAL, INTERMITTENT, CONNECTIVITY, CAUSING MALFUNCTION INDICATOR LAMP (MIL) OR WRENCH LIGHT TO BE ILLUMINATED. Read More »
EQUIPMENT:ELECTRICAL
-
TSB #SSM 47009
The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). Read More »
-
TSB #SSM 47009
The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). Read More »
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
-
TSB #SSM 47080
2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. Read More »