1997 Mercury Mountaineer
297 Technical Service Bulletins (TSBs)
TSB List for the 1997 Mercury Mountaineer
Technical Service Bulletins (TSBs) for the 1997 Mountaineer are official communications between Mercury & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #16040
EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT Read More »
STEERING: STEERING WHEEL/HANDLE BAR
-
TSB #BC9682961001
CONCERNS FOR THE LABOR TIME STANDARD IN TBS 96-19-02 (STEERING - GRUNT NOISE DURING STEERING WHEEL RETURN FROM FULL RIGHT TURN) IS INCORRECT. *TT Read More »
STEERING:RACK AND PINION:RACK
-
TSB #13049
EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT Read More »
STEERING:HYDRAULIC POWER ASSIST SYSTEM
-
TSB #13440
EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT Read More »
STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID
-
TSB #996777
EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT Read More »
SUSPENSION
-
TSB #15692
SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT Read More »
-
TSB #14371
SUBJECT REGARDING POP / CREAK NOISE FROM THE REAR UNDERBODY WHILE DRIVING. *JB Read More »
-
TSB #13426
EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT Read More »
-
TSB #5249
INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT Read More »
-
TSB #4634
STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT Read More »
-
TSB #97050110613
WHEN PERFORMING TSB 97-4-9, DO NOT USE A BAFFLE TO CORRECT HTE ISSUE, USE THE REVISED AXLE COVER PLATE. *TW Read More »
SUSPENSION:FRONT
-
TSB #985045
REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01. *TT Read More »
-
TSB #98-4732
STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS.. Read More »
-
TSB #98021698311
SOME VEHICLES MAY EXHIBIT A DRIFT/PULL, SHOW SIGNS OF TIRE WEAR, OR EXHIBIT POOR RIDE QUALITY. *YC Read More »
-
TSB #BC3493972301
VEHICLES EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD Read More »
-
TSB #BC1019197230
EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD Read More »
-
TSB #BC5231961101
VEHICLE LEAN. *TW Read More »
SUSPENSION:FRONT:STABILIZER BAR
-
TSB #7360
SOME VEHICLES MAY EXHIBIT A SQUEAK NOISE FROM THE REAR WHILE DRIVING, ESPECIALLY WHEN GOING BUMPS. *TT Read More »
-
TSB #BC1032497020
MODIFICATIONS HAVE BEEN MADE TO THE FRONT STABILIZER LINKS. *JD Read More »
SUSPENSION:FRONT:SPRINGS:TORSION BAR
-
TSB #00M11
INFORMATION REGARDING FRONT SWAY BAR LINK . *YH Read More »
SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM
-
TSB #BC1019497230
VEHICLES MAY EXHIBIT REVERSE OPERATING CHARACTERISTICS WHEN SWITCHING THE AIR SUSPENSION SWITCH FROM NORMAL TO OFF ROAD. *JD Read More »
SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION:LINES AND FITTINGS
-
TSB #9749
AXLE- FRONT AXLE LEAKS FLUID FROM VENT TUBE- VEHICLES BUILT THROUGH 8/96 EQUIPPED WITH 4X4 AND AWD. *JD Read More »
SUSPENSION:REAR
-
TSB #16735
VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING. *TT Read More »
-
TSB #00M11
SUBJECT REGARDING ADDITIONAL COVERAGE PROGRAM FOR SWAY BAR LINKS. *JB Read More »
-
TSB #0083
SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A RUBBING NOISE DURING RIGHT HAND TURNS FROM THE REAR OF THE VEHICLE. **MR Read More »
SUSPENSION:REAR:SPRINGS:COIL SPRINGS
-
TSB #13415
EXHIBITING A SQUEAK TYPE NOISE FROM THE REAR STABILIZER BAR WHILE DRIVING, ESPECIALLY WHEN GOING OVER BUMPS. *TT Read More »
-
TSB #BC0881961004
THUMP/CLUNK NOISE IN TURNS OR OVER BUMPS MAY BE CAUSED BY THE KEVLAR PATCH WEARING THROUGH ON THE TORSION BAR ADJUSTERS. *TT Read More »
SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-
TSB #9889
SOME CUSTOMERS NOTICE A GRINDING, WHINING, PULSING, OR FLUTTERING AT THE BRAKE PEDAL AT SPEEDS BELOW 19 KM/H (12 MPH). *YC Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
-
TSB #15910
CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT Read More »
-
TSB #15249
CONCERNS WITH HIGH BRAKE PEDAL FORCE TO STOP AFTER ROTOR MACHINING. *TT Read More »
-
TSB #15168
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HIGH FREQUENCY BRAKE SQUEAL NOISE. *YH Read More »
-
TSB #99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT Read More »
-
TSB #985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC Read More »
-
TSB #96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-
TSB #985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC Read More »
-
TSB #9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
-
TSB #7367
SOME VEHICLES EQUIPPED WITH FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT WHEEL SPEED PARAMETER IDENTIFICATIONS (PIDS) WHICH READ N/A IMMEDIATELY OR ABOVE 7 MPH WHEN VIEWED USING THE NEW GENERATION STAR (NGS) TESTER. Read More »
-
TSB #13424
SOME VEHICLES EQUIPPED WITH FOUR WHEEL ANTI LOCK BRAKES MAY EXHIBIT WHEEL SPEED PARAMETER IDENTIFICATIONS WHICH READ N/A IMMEDIATELY OR ABOVE 7 MPH. *TT Read More »
-
TSB #12216
THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. Read More »
-
TSB #980319
CONCERNS WITH FALSE ABS ACTIVATION WHILE LIGHT BRAKING AT LOW SPEEDS. *YC Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
-
TSB #BC0533961108
INSTRUCTIONS FOR DIAGNOSING FAULTY ABS SENSORS. *TW Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
-
TSB #980319
CONCERNS WITH FALSE ABS ACTIVATION WHILE LIGHT BRAKING AT LOW SPEEDS. *YC Read More »
SERVICE BRAKES, AIR:DISC:ROTOR
-
TSB #9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC Read More »
PARKING BRAKE:CONVENTIONAL
-
TSB #BC9672961001
PROCEDURE FOR BRAKE WARNING INDICATOR STAYS ON RED IN CLUSTER. *TT Read More »
ENGINE AND ENGINE COOLING
-
TSB #12150
INFORMATION CONCERNING THE REPLACEMENT OF THE ENGINES ON VEHICLES EQUIPPED WITH A 4.0L SOHC THAT REQUIRE SERVICE. *MJS Read More »
-
TSB #BC0190970201
VEHICLES BUILT PRIOR TO 10/1/96 MAY HAVE BEEN BUILT WITH WRONG TEMP GAUGE SYSTEM PARTS. *JD Read More »
-
TSB #BC1009597020
VEHICLES BUILT PRIOR TO 10/1/96 MAY HAVE BEEN BUILT WITH WRONG TEM GAUGE SYSTEM PARTS. *JD Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ Read More »
-
TSB #870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. Read More »
-
TSB #01M01
OWNER NOTIFICATION PROGRAM REGARDING ADDITIONAL COVERAGE PROGRAM FOR FRONT CAM CHAIN GUIDE ASSEMBLY WHICH MAY WEAR OR BREAK AND CAUSE EXCESSIVE CAM CHAIN NOISE THAT DOES NOT GO AWAY AFTER FIVE MINUTES OF ENGINE OPERATION. Read More »
-
TSB #01M01
SUBJECT REGARDING ADVANCE NOTICE ON UPCOMING OWNER NOTIFICATION PROGRAM WHICH WILL PROVIDE ADDITIONAL COVERAGE ON THE FRONT CAM CHAIN GUIDE ASSEMBLY ON CERTAIN VEHICLES. *TT Read More »
-
TSB #14560
VEHICLES MAY EXPERIENCE START UP TIMING CHAIN NOISE. *JB Read More »
-
TSB #00M12
FORD MOTOR COMPANY IS PROVIDING ADDITIONAL COVERAGE FOR THE 4.0L SOHC CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET. *TT Read More »
-
TSB #8493
SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR Read More »
-
TSB #14048
SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR Read More »
-
TSB #7138
SERVICE TIP INFORMATION WHEN SERVICING THE 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT Read More »
-
TSB #6986
INFORMATION REGARDING 4.0L SOHC CAMSHAFT BOLT TORQUE. *TT Read More »
-
TSB #6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT Read More »
-
TSB #13170
INFORMATION REGARDING 4.0 L SOHC CAMSHAFT BOLT TORQUE. *MJS Read More »
-
TSB #13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS Read More »
-
TSB #13260
SERVICE TIPS INFORMATION PROVIDED TO ASSIST WHEN SERVICING VEHICLES WITH SHORT BLOCK ASSEMBLY. *TT Read More »
-
TSB #985144
ALL VEHICLES EQUIPPED WITH 4.0L SOHC THAT REQUIRE ENGINE SERVICE PLEASE NOTE THAT THE XL2Z-6M289-AA (DRIVE ASSEMBLY-CAMSHAFT-LH) MUST BE USED ON 4.0L SOHC ENGINES IF REPLACEMENT IS REQUIRED. Read More »
-
TSB #9874
A NEW SILICONE GASKET AND SEALANT. *YC Read More »
-
TSB #983092
REAR CRANKSHAFT SEAL OIL LEAK. *AK Read More »
-
TSB #BC3092970225
REAR CRANKSHAFT SEAL OIL LEAKS. *TW Read More »
-
TSB #BC1033197020
VEHICLES WITH REAR CRANKSHAFT SEAL OIL LEAKS. *JD Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
-
TSB #0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
-
TSB #01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT Read More »
-
TSB #01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
-
TSB #070101
SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 SUPPLEMENT #2: REVISED TECHNICAL INSTRUCTIONS AND NEW LABOR OPERATION. NLM Read More »
-
TSB #01M01
SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 REGARDING ADDITIONAL COVERAGE FOR FRONT CAM CHAIN GUIDE ASSEMBLY. *TT Read More »
-
TSB #14868
SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT Read More »
-
TSB #01M01
SUBJECT REGARDING ADDITIONAL COVERAGE ON THE FRONT CAM CHAIN GUIDE ASSEMBLY FOR RENTAL VEHICLES WITH 4.0L SINGLE OVERHEAD CAM (SOHC) ENGINES. *TT Read More »
-
TSB #00M12
SUBJECT REGARDING OWNER NOTIFICATION SUPPLLEMENTAL PROGRAM FOR VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES - CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET ADDITIONAL COVERAGE. *TT Read More »
-
TSB #13527
SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT AN OVERHEAT CONDITION THAT MAY BE ATTRIBUTED TO THE THERMOSTAT. Read More »
-
TSB #99223
A NO START CONDITION WHEN VEHICLE IS PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL MAY OCCUR. *TT Read More »
-
TSB #7270
SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT Read More »
-
TSB #13300
SOME VEHICLES WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT Read More »
-
TSB #6987
SOME VEHICLES MAY EXHIBIT ENGINE NOISE(CAM CHAIN NOISE). *TT Read More »
-
TSB #6993
SUBJECT REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *TT Read More »
-
TSB #13171
INFORMATION REGARDING 4.0L SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS Read More »
-
TSB #13172
INFORMATION REGARDING SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS Read More »
-
TSB #13177
INFORMATION REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *MJS Read More »
-
TSB #13261
SERVICE TIPS WHEN SERVICING A 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT Read More »
-
TSB #99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT Read More »
-
TSB #12624
SOME VEHICLES MAY EXHIBIT A HESITATION / LACK OF POWER ON RE-ACCELERATION AFTER DECELERATING FROM 45 - 65 MPH TO A SLOW ROLL CONDITION. *TT Read More »
-
TSB #5256
INFORMATION ON VEHICLES EXHIBITING UPPER ENGINE NOISE. *TT Read More »
-
TSB #5272
BRIEF INFORMATION REGARDING ENGINE STALL CONDITION. *TT Read More »
-
TSB #5049
BRIEF INFORMATION REGARDING UPPER ENGINE NOISE. *TT Read More »
-
TSB #985064
REPEAT MESSAGE REGARDING ENGINE STALLING *TT Read More »
-
TSB #12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS Read More »
-
TSB #98211
EXPERIENCING A NOISE AND VIBRATION DURING IDLE. Read More »
-
TSB #4623
BRIEF INFORMATION FOR VEHICLES EXHIBITING ENGINE STALL. *TT Read More »
-
TSB #BC3092970501
ENGINEERING IS INVESTIGATING REAR CRANKSHAFT OIL LEAKS. *TW Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
-
TSB #BC0755961017
TENSIONER RATTLE . INSTALL A 1 INCH SHORTER MOTORCRAFT BELT (P/N F19Z-8620-C). *TT Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
-
TSB #14583
CONCERNS WITH BROKEN THERMOSTATS ON ENGINES. *JB Read More »
-
TSB #14617
SUBJECT PERTAINING TO BROKEN THERMOSTAT. *JB Read More »
-
TSB #BC1035597020
RADIATORS MAY EXHIBIT A COOLANT LEAK AT THE END TANK SEALS IN COLD TEMPERATURES. *JD Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
-
TSB #98R03
SUBJECT REGARDING POSITIVE CRANKCASE VENTILATION (PCV) TUBE MODIFICATION. *TT Read More »
-
TSB #982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC Read More »
-
TSB #980313
EXPERIENCING IDLE VIBRATION / EXHAUST BOOM. *YC Read More »
-
TSB #BC9668961001
CONCERN FOR VEHICLES EXHIBITING LEAN CODES P0171 & P0174 (VACUUM LEAK). *TT Read More »
-
TSB #BC9671961001
PUSH CONNECTION BETWEEN THE FLEXIBLE FUEL VAPOR LINE AT THE CARBON CANISTER & THE METAL FUEL VAPOR LINE MAY NOT SEAT FULLY ON THE FUEL VAPOR LINE. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
-
TSB #982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK Read More »
-
TSB #981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
-
TSB #98R03
SAFETY RECALL LETTER INFORMING OWNERS OF MODIFICATION TO THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM. *TT Read More »
-
TSB #BC2237970501
RECALL 97S67 - MODIFICATION OF THE PCV VALVE REQUIRES A SPECIAL TOOL WHICL WILL SENT TO LISTED PARTS MANAGERS. *TW Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-
TSB #BC3481972301
EXHAUST NOISE HEARD IN THE PASSENGER COMPARTMENT MOST PRESENT AT TIP-IN A ND CRUISE AFTER SSM 5238 HAS BEEN PERFORMED. *JD Read More »
-
TSB #BC3494972301
VARIOUS VEHICLES MAY EXPERIENCE A HIGH PITCHED WHISTLE DURING HEAVY ACCELERATION AT 3800-5000 RPM WHEN ENGINE IS WARM- TO FIX, REMOVE EXISTING MUFFLER AND REPLACE WITH SAME PART. *JD Read More »
-
TSB #BC1019297230
VEHICLES MAY EXPERIENCE A HIGH PITCHED WHISTLE DURING HEAVY ACCELERATION AT 3800-5000 RPM WHEN ENGINE IS WARM. *JD Read More »
-
TSB #BC1019597230
EXHAUST NOISE HEARD IN THE PASSENGER COMPARTMENT MOST PRESENT A TIP-IN A ND CRUISE AFTER SSM 5238 HAS BEEN PERFORMED. *JD Read More »
-
TSB #BC0481961113
VEHICLES MAY EXHIBIT AN EXHAUST MANIFOLD IMPINGEMENT NOISE. *TW Read More »
-
TSB #BC5238961101
VEHICLE MAY EXHIBIT AN EXHAUST MANIFOLD IMPINGEMENT NOISE. *TW Read More »
FUEL SYSTEM, GASOLINE
-
TSB #6203
SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT Read More »
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
-
TSB #12710
SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOISE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-
TSB #00201
SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING. *JB Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-
TSB #15532
INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT Read More »
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
-
TSB #BC5221961001
REVISED HOSE PART# F6HZ-9J291-A HAS BEEN DEVELOPED TO REPLACE HOSE THAT SHOWS SIGNS OF DETERIORATION, CRACKS MAY APPEAR IN THE OUTER COVERING OF THE HOSE. *TT Read More »
FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
-
TSB #96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW Read More »
-
TSB #BC9676961001
IMPROPER RTV APPLICATION AT THE FRONT/REAR LOWER INTAKE MANIFOLD END SEALS & SIDE GASKETS MAY CAUSE AN OIL/COOLANT LEAK. *TT Read More »
FUEL SYSTEM, OTHER
-
TSB #0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT Read More »
POWER TRAIN
-
TSB #16935
AN UNCOMMANDED SHIFT TO 4X4 LOW. *TT Read More »
-
TSB #15887
SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). Read More »
-
TSB #0282
SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. Read More »
-
TSB #9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT Read More »
POWER TRAIN:MANUAL TRANSMISSION
-
TSB #02138
LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. Read More »
-
TSB #12512
BRIEF INFORMATION ON CHECKING TRANSMISSION FLUID LEVEL. *T Read More »
-
TSB #BC9694961001
INFORMATION ON VEHICLES THAT MAY EXHIBIT A SLIGHT DELAY IN THE FIRST DRIVE AWAY AFTER THE VEHICLE HAS BEEN PARKED OVERNIGHT, OR FOR A LONGER PERIOD OF TIME. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT Read More »
-
TSB #0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS Read More »
-
TSB #7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT Read More »
-
TSB #7468
SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE OFF. Read More »
-
TSB #13482
SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE-OFF DUE TO THE REAR TRANSMISSION MOUNT BEING TWISTED AND ALLOWING A GROUND OUT CONDITION TO OCCUR. *TT Read More »
-
TSB #13412
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT Read More »
-
TSB #99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT Read More »
-
TSB #9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. Read More »
-
TSB #5814
SERVICE TIPS FOR CHECKING TRANSMISSION FLUID LEVEL. *TT Read More »
-
TSB #982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC Read More »
-
TSB #9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC Read More »
-
TSB #962410
TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
-
TSB #042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT Read More »
-
TSB #04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT Read More »
-
TSB #00E11
SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT Read More »
-
TSB #7494
ALL VEHICLES WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF WHAT THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. Read More »
-
TSB #9987
SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING, HESITATION AFTER ACCELERATION FROM STOP AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP ON VEHICLES WITH 4.0L OR 5.0L ENGINES. Read More »
-
TSB #9987
SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING; HESITATION AFTER ACCELERATION FROM STOP; AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
-
TSB #13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. Read More »
-
TSB #980318
CONDITIONS WITH AXLE WIND-UP ON TIGHT TURNS WITH CONTROL TRAC TRANSFER CASE. *YC Read More »
-
TSB #BC3484972301
WHEN PERFORMING TSB 96-24-16, THE EXISTING TRANSFER CASE VIBRATION DAMPER SHOULD NOT BE ADAPTED AND REINSTALLED TO THE SERVICE REPLACEMENT TRANSFER CASE. *JD Read More »
-
TSB #BC1019897230
PERFORMING TSB 96-24-16, THE EXISTING TRANSFER CASE VIBRATION DAMPER SHOULD NOT BE ADAPTED AND REINSTALLED TO THE SERVICE REPLACEMENT TRANSFER CASE. Read More »
-
TSB #962526
AXLE - FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES BUILT THROUGH 8/96 EQUIPPED WITH 4X4 AND AWD. *TW Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
-
TSB #03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT Read More »
-
TSB #002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
-
TSB #962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW Read More »
-
TSB #96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
-
TSB #01181
BRAKE SHIFT INTERLOCK.*JB Read More »
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
-
TSB #13723
SOME ALL WHEEL DRIVE VEHICLES MAY EXPERIENCE A LOW SPEED WHINING NOISE FROM THE TRANSFER CASE. *MJS Read More »
-
TSB #12571
EXPERIENCING A WHINNING NOISE FROM THE TRANSFER CASE. *TT Read More »
-
TSB #BC0133970201
REVISED VENT TUBE FOR 1995-97 EXPLORERS & MOUNTAINEERS WITH WATER INGESTION INTO TRANSFER CASE. *JD Read More »
-
TSB #BC1012797020
REVISED VENT TUBE FOR VEHICLES WITH WATER INGESTION INTO TRANSFER CASE. *JD Read More »
POWER TRAIN:DRIVELINE
-
TSB #98514
CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES. *TT Read More »
POWER TRAIN:DRIVELINE:DRIVESHAFT
-
TSB #962416
VIBRATION - IN FLOOR PAN - AT WIDE OPEN THROTTLE (WOT) AND/OR STEADY HIGHWAY SPEEDS (70+ mph) - 5.0L VEHICLES WITH ALL WHEEL DRIVE (AWD) - EXPLORERS AND MOUNTAINEERS BUILT IN LOUISVILLE THROUGH 7/29/96 AND/OR ST. LOUIS THROUGH 8/12/96. Read More »
-
TSB #BC0534961108
DRIVESHAFT DESIGN MAY CAUSE FLOORPAN VIBRATION WHILE AT HIGHWAY SPEEDS OR WITH THROTTLE WIDE OPEN. *TW Read More »
-
TSB #BC5225961001
VEHICLES MAY EXPERIENCE A VIBRATION DURING WIDE OPEN THROTTLE ACCELERATION OR WHILE CRUISING AT HIGHWAY SPEEDS. REVISED FRONT DRIVESHAFT. *TT Read More »
POWER TRAIN:AXLE ASSEMBLY
-
TSB #030508
FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT Read More »
-
TSB #0358
FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB Read More »
-
TSB #0242
CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT Read More »
-
TSB #0186
ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT Read More »
-
TSB #14819
SOME 4X4 VEHICLES MAY EXHIBIT A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT Read More »
-
TSB #14847
CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT Read More »
-
TSB #0083
SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A RUBBING NOISE DURING RIGHT HAND TURNS FROM THE REAR OF THE VEHICLE. **MR Read More »
-
TSB #12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT Read More »
-
TSB #5369
SOME VEHICLES MAY EXHIBIT A FLUID LEAK CONCERN FROM THE FRONT AXLE VENT TUBE. *TT Read More »
-
TSB #12283
SOME VEHICLES MAY EXHIBIT A FLUID LEAK CONCERN FROM THE FRONT AXLE VENT TUBE. *TT Read More »
-
TSB #983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT Read More »
-
TSB #BC0318961101
VIBRATION/SHUDDER AT 4000 - 5000 RPM WIDE OPEN THROTTLE. *TW Read More »
-
TSB #BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT Read More »
-
TSB #BC9674961001
LIGHT TO MODERATE AXLE NOISE (AXLE WHINE) AT 50 TO 65 MPH (80 TO 105 KPH) DURING ACCELS, DECELS OR CRUISE MAY BE DUE TO AXLE NOISE BEING TRANSMITTED FROM THE AXLE INTO THE VEHICLE. *TT Read More »
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL
-
TSB #13752
SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT Read More »
-
TSB #8512
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR Read More »
-
TSB #14056
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR Read More »
-
TSB #13504
CONCERNS WITH VEHICLES EXHIBITING AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. ENGINEERING IS CURRENTLY ADDRESSING THIS ISSUE THROUGH THE HIGH MILAGE / TIME-IN-SERVICE CONCERN RESOLUTION PROCESS. Read More »
-
TSB #7316
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT Read More »
-
TSB #13404
SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT Read More »
ELECTRICAL SYSTEM
-
TSB #03203
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »
-
TSB #03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT Read More »
-
TSB #13879
INFORMATION ON REPLACING A GEM MODULE ON 4X4 VEHICLES EQUIPPED WITH 4.0L SOHC, OHV AND THE NEUTRAL TOW KIT. *TT Read More »
-
TSB #98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
-
TSB #12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
ELECTRICAL SYSTEM:WIRING
-
TSB #99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT Read More »
-
TSB #BC0012970201
CUSTOMERS REPORT INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. THE CAUSE HAS BEEN IDENTIFIED AS A STATIC BUILD-UP ON THE SEAT THAT DAMAGES THE RAP MODULE. *JD Read More »
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
-
TSB #BC5200961001
VEHICLES MAY EXPERIENCE UNEXPLAINED MIL LIGHT CODES &/OR IRREGULAR SHIFTING (A4LD). THE -12A581- (95-96) OR -12B637- (97) WIRE LOOM IS COMING INTO CONTACT W/ THE CENTER WIPER ACCESS PLATE LWR CTR. Read More »
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
-
TSB #98-4817
SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH Read More »
ELECTRICAL SYSTEM:IGNITION:MODULE
-
TSB #9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT Read More »
-
TSB #BC2302970501
DTC P0402 IN MEMORY UNDER INVESTIGATION BY ENGINEERING. *TW Read More »
-
TSB #BC3282970206
GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW Read More »
-
TSB #BC3363972301
THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD Read More »
-
TSB #BC1022797230
THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD Read More »
-
TSB #962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW Read More »
ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
-
TSB #12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS Read More »
EXTERIOR LIGHTING
-
TSB #98117
SOME VEHICLE MAY EXHIBIT MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) PO171, PO174, P1131 AND / OR P1151 STORED IN MEMORY. *TT Read More »
EXTERIOR LIGHTING:HEADLIGHTS
-
TSB #BC3274970207
REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS ... Read More »
EXTERIOR LIGHTING:BRAKE LIGHTS
-
TSB #99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT Read More »
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-
TSB #02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ Read More »
-
TSB #BC9673961001
PROCEDURE FOR BRAKE EXTERIOR LIGHTS STAY ON (TAIL & HIGH MOUNT STOP LIGHT). *TT Read More »
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
-
TSB #BC9680961001
CONCERN WHERE THE DOOR GLASS DROPS WHEN CYCLED DOWN ON VEHICLES WITH THE POWER DOOR OPTION. *TT Read More »
VISIBILITY:WINDSHIELD WIPER/WASHER
-
TSB #BC2246970501
VEHICLES BUILT ON OR AFTER 4/14/97 WILL NO LONGER HAVE A REAR WASHER BOTTLE - A REDESIGNED FRONT WASHER BOTTLE WILL SUPPLY THE FLUID TO BOTH WASHERS. *TW Read More »
-
TSB #BC9696961001
VEHICLES MAY EXHIBIT A CONDITION WHERE THE WINDSHIELD WIPERS COME IN CONTACT W/ THE 'A' PILLARS (& EACH OTHER) DURING OPERATION. MAY BE DUE TO WIPER ARMS HAVING BEEN REVERSED DURING INSTALLATION. *TT Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
-
TSB #982320
SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL. *YC Read More »
-
TSB #BC9695961001
ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) INVALID DIAGNOSTIC CODES U1235 & 155 MAY BE STORED IF THE IGNITION SWITCH IS CYCLED FROM 'OFF' TO 'RUN' EXTREMELY SLOWLY. *TT Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
-
TSB #01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
-
TSB #11512
ENGINEERING IS INVESTIGATING CONCERNS OF NOISY FRONT SYSTEM BLOWER MOTORS ON CERTAIN VEHICLES. *TT Read More »
AIR BAGS
-
TSB #6640
EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT Read More »
-
TSB #5852
VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924. *TT Read More »
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
-
TSB #6640
EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT Read More »
-
TSB #12529
SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924. *TT Read More »
STRUCTURE:FRAME AND MEMBERS
-
TSB #BC2306970501
SOME RUNNING BOARD PADS MAY WARPED. *TW Read More »
-
TSB #BC2384970501
LIFTGATE LOCK CONCERNS ON VEHICLES BUILT THROUGH 12/96. *TW Read More »
-
TSB #BC105829705
SOME RUNNING BOARD PADS MAY BE WARPED. *TW Read More »
STRUCTURE:BODY
-
TSB #6429
INFORMATION ON REFILLING TISSUES FOR THE CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT Read More »
-
TSB #12852
USE KLEENEX BRAND JUNIORS OR LI'L TRAVELERS TO REFILL TISSUES FOR CERTAIN VEHICLES WITH THE HIGH SERIES CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT Read More »
-
TSB #982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC Read More »
-
TSB #9831
REPAIRS TO VINYL COVERED SURFACES. *YC Read More »
-
TSB #9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC Read More »
-
TSB #BC2236970501
VEHICLES MAY EXHIBIT A CENTER CONSOLE SQUEAK OR RATTLE. *TW Read More »
-
TSB #97050110611
VEHICLES MAY EXHIBIT A CENTER CONSOLE SQUEAK. *TW Read More »
STRUCTURE:BODY:BUMPERS
-
TSB #99203
INFORMATION ON REPLACING THE FRONT BUMPER BRACKET. *TT Read More »
STRUCTURE:BODY:DOOR
-
TSB #99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT Read More »
-
TSB #99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT Read More »
-
TSB #BC2442970501
LIFTGATE LOCKS WILL NOT LOCK/UNLOCK WHEN ACTUATED BY THE POWER SWITCHES. *TW Read More »
-
TSB #9738
REMOTE KEYLESS ENTRY- RKE INOPERATIVE- VEHICLES BUILT THROUGH 10/30/96. *JD Read More »
-
TSB #BC0012972301
CUSTOMERS REPORT INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. *JD Read More »
-
TSB #BC0257970201
POWER LOCKS CYCLE BY THEMSELVES REMOVE EACH POWER LOCK SWITCH AND MEASURE THE OPEN RESISTANCE. *JD Read More »
-
TSB #BC1016497020
INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. THE CAUSE HAS BEEN IDENTIFIED AS A STATIC BUILD-UP ON THE SEAT THAT DAMAGES THE RAP MODULE. *JD Read More »
STRUCTURE:BODY:TAILGATE
-
TSB #97050110634
ENGINEERING IS INVESTIGATING CONCERNS OF BROKEN LIFTGATE GLASS. *YC Read More »
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
-
TSB #BC3283970206
DOOR LATCH SWITCH IS CAUSING THE DOOR AJAR LIGHT/CHIME NOT TO WORK PROPERLY. *TW Read More »
VEHICLE SPEED CONTROL
-
TSB #14265
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION OR WHILE TURNING. *TT Read More »
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
-
TSB #00243
ON SOME VEHICLES, THE ACCELERATOR PEDAL BRACKET MAY BECOME LOOSE OR SEPARATED FROM THE DASH PANEL. THIS MAY BE CAUSED BY REPEATED EXCESSIVE FORCE ON THE ACCELERATOR PEDAL, RESULTING IN CRACKING OF THE DASH PANEL SHEET METAL AT THE ... Read More »
VEHICLE SPEED CONTROL:LINKAGES
-
TSB #9913035
VEHICLES MAY EXPERIENCE A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT Read More »
VEHICLE SPEED CONTROL:CRUISE CONTROL
-
TSB #5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT Read More »
TIRES
-
TSB #01B77
OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT Read More »
-
TSB #995157
INFORMATION ON MAINTAINING TIRE PRESSURE. *TT Read More »
-
TSB #985157
INFORMATION ON SETTING THE TIRE INFLATION PRESSURE FOR 1991 THROUGH 1999 MODEL YEAR VEHICLES IN THE PRE-DELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *TT Read More »
-
TSB #9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC Read More »
-
TSB #BC0744961018
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT Read More »
-
TSB #BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT Read More »
SEATS
-
TSB #7079
INFORMATION REGARDING SEAT THAT WILL NOT MOVE FORWARD. *MJS Read More »
-
TSB #13218
INFORMATION REGARDING SEAT THAT WILLL NOT MOVE FORWARD. *MJS Read More »
-
TSB #982515
CONDITIONS WITH THE FRONT SEAT BACK LEVER BENT. *YC Read More »
-
TSB #11759
SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER. *TT Read More »
-
TSB #9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD Read More »
SEATS:FRONT ASSEMBLY:RECLINER
-
TSB #4642
SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER. *TT Read More »
SEATS:FRONT ASSEMBLY:POWER ADJUST
-
TSB #982019
CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC Read More »
INTERIOR LIGHTING
-
TSB #8119
SOME VEHICLES EQUIPPED WITH 5.0L ENGINE AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT Read More »
EQUIPMENT
-
TSB #00E11
SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT Read More »
-
TSB #8164
INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS. *TT Read More »
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
-
TSB #99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
-
TSB #5652
COMPLAINTS THAT THE IN-DASH CD STOPS OPERATING WHEN HOT. *TT Read More »
-
TSB #12518
CONCERNS WITH THE IN-DASH CD STOPS OPERATING WHEN HOT / RADIO DISPLAY READS CD TOO HOT. *TT Read More »
-
TSB #97514
CD PLAYER- "SKIPS"- HIGH SERIES CONSOLE- NORMAL DRIVING CONDITIONS. *JD Read More »
-
TSB #97312
CD PLAYER- "SKIPS"- HIGH SERIES CONSOLE- NORMAL DRIVING CONDITIONS. *JD Read More »
EQUIPMENT:MECHANICAL:WRECKER AND WHEEL LIFT DEVICES
-
TSB #8149
SUBJECT REGARDING NEUTRAL TOW INOPERATIVE AFTER GEM REPLACEMENT. *TT Read More »
-
TSB #13388
VEHICLES EQUIPPED THE NEUTRAL TOW FEATURE, BE AWARE THAT WHEN THE NEUTRAL TOW FEATURE IS ENABLED AND THE CUSTOMER PLACES THE VEHICLE INTO THE NEUTRAL MODE, THE NEUTRAL TOW INDICATOR WILL GO OUT WHEN THE GEM GOES TO SLEEP. Read More »
-
TSB #7083
INFORMATION REGARDING NEUTRAL TOW KIT AVAILABILITY. *MJS Read More »
-
TSB #13222
INFORMATION REGARDING NEUTRAL TOW KIT AVAILABLE. *MJS Read More »
-
TSB #985A12
RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT Read More »
EQUIPMENT:OTHER:LABELS
-
TSB #00L09
SUBJECT PERTAINING TO SUPPLEMENTAL TIRE INFLATION LABEL. *JB Read More »
-
TSB #BC3132970221
INCORRECT OIL VISCOSITY LABEL IN ENGINE COMPARTMENT. *TW Read More »
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-
TSB #96L11
SPECIAL FIELD ACTION 96L11 - AUDIO GUIDES PLACED IN THE MOUNTAINEERS DID NOT INCLUDE INSTRUCTIONS FOR THE OPERATION OF THE OPTIONAL JBL/LUXURY AUDIO SYSTEM - THE WARRANTY INFORMATION BOOKLETS IN THE AFFECTED E AND F SERIES TRUCKS DO NOT ... Read More »
-
TSB #BC0752961017
OWNERS GUIDE ADVISES TO USE FL-1A OIL FILTER, WHICH IS INCORRECT. THE CORRECT OIL FILTER IS AN FL-820. *TT Read More »
-
TSB #BC5180961001
OWNERS GUIDE ADVISES TO USE A FL-1A OIL FILTER, FL-1A IS INCORRECT. THE CORRECT FILTER IS FL-820. *TT Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH Read More »
-
TSB #00213
SUBJECT REGARDING CLIMATE CONTROL - EATC - BLOWER MOTOR CONTROL SERVICE TIPS. *JB Read More »
-
TSB #99206
CONCERNS WITH BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE WHILE BLOWER MOTOR IS ON. *TT Read More »
-
TSB #99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
-
TSB #99156
SOME VEHICLES MAY EXHIBIT A BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE OCCURING WHEN THE BLOWER MOTOR IS RUNNING IF LEAVES OR FOREIGN MATERIAL ENTERS THE BLOWER CASE. *TT Read More »
-
TSB #9988
CONCERNS OR ERRATIC OR INSUFFICIENT TEMPERATURE CONTROL. *TT Read More »
-
TSB #98238
CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES. *YC Read More »
-
TSB #9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD Read More »
-
TSB #96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW Read More »
CHILD SEAT
-
TSB #982540
CONCERNS WITH BUILT-IN REAR CHILD SAFETY SEAT MAY NOT EASILY ACCOMMODATE SOME CHILDREN. *YC Read More »
UNKNOWN OR OTHER
-
TSB #0232
SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT Read More »
-
TSB #15563
INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH Read More »
-
TSB #01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC Read More »
-
TSB #8164
INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR Read More »
-
TSB #14061
SOME VEHICLES MAY COME IN FOR A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE P0171 AND/OR P0174 IN SELF TEST. **MR Read More »
-
TSB #13857
SOME VEHICLES EQUIPPED WITH 5.0L ENGINES AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT Read More »
-
TSB #99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »
-
TSB #99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. Read More »
-
TSB #6980
SOME VEHICLES MAY EXHIBIT THE CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODE PO420. *TT Read More »
-
TSB #99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT Read More »
-
TSB #991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT Read More »
-
TSB #99104
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0174, P1131, AND / OR P1151 MAY BE PRESENT WITH OR WITHOUT MISFIRE, ROLLING IDLE, ROUGH IDLE, ETC. Read More »
-
TSB #98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. Read More »
-
TSB #BC2440970501
1997 4.0L SOHC 4X4 EXPLORERS AND 1997 5.0L AWD EXPLORERS/MOUNTAINEERS SHOULD NOT BE EQUIPPED WITH A VIBRATION DAMPER ON THE TRANSFER CASE. *TW Read More »
-
TSB #9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD Read More »
-
TSB #BC1031297020
SOME VEHICLE ENGINE COMPARTMENT DECALS MAY INCORRECTLY LIST 10W30 FOR OIL VISCOSITY. *JD Read More »