2004 Mercury Mountaineer
125 Technical Service Bulletins (TSBs)
TSB List for the 2004 Mercury Mountaineer
Technical Service Bulletins (TSBs) for the 2004 Mountaineer are official communications between Mercury & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #0538
INCREASED TURNING EFFORT DURING LOW SPEED SHARP TURNS FALSE 4X4 ENGAGEMENT. *EH Read More »
SUSPENSION:FRONT:WHEEL BEARING
-
TSB #051710
NOISE FROM REAR WHEEL HUB BEARINGS. *TT Read More »
SUSPENSION:REAR
-
TSB #050618
REAR AXLE NOISE REPAIR. *SC Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
-
TSB #17728
ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B2900, U1900 AND C1805. *TT Read More »
-
TSB #03263
ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODE (DTC) C1235, C1236, C1237 ON VEHICLES WITH DIFFERENTIAL-MOUNTED RAR WHEEL SPEED SENSOR. *TT Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
-
TSB #17626
STANDARD ABS (NOT ADVANCE TRAC/IVD) BUILT PRIOR TO 2/9/2004 MAY EXHIBIT AN INTERMITTENT AMBER ABS LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC'S) B2900, U1900 AND POSSIBLY C1805 STORED IN MEMORY. Read More »
SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
-
TSB #17215
THE AMBER ANTI-LOCK BRAKE SYSTEM (ABS) WARNING LIGHT ON WITH DIAGNOSTIC TROUBLE CODES C1235, C1236/C1237 STORED IN MEMORY. *TT Read More »
ENGINE (PWS)
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #TSB-12-7-4
FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. Read More »
ENGINE AND ENGINE COOLING
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT Read More »
-
TSB #051016
NO START/HARD START ON COLD SOAK - 4.0L ENGINE. *TT Read More »
-
TSB #18573
NO START/HARD START ON COLD SOAK. *TT Read More »
-
TSB #0539
MIL ON AND/ OR RUNS ROUGH/MISFIRE DTCS P0300-P0308 P0316 AND OR P0171/P0174 4.6L ENGINE. *EH Read More »
-
TSB #04225
THROTTLE PEDAL RESPONSE ON TIP IN VEHICLES BUILT BEFORE 10/4/2004 EQUIPPED WITH A 4.0L ENGINE. *EH Read More »
-
TSB #042112
ROUGH IDLE IN DRIVE. *EH Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
-
TSB #0531
MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM). *TT Read More »
-
TSB #041910
OIL LEAK FROM OIL FILTER ADAPTER - 4.0L SOHC ENGINE BUILT BEFORE 4/1/2004. *TT Read More »
-
TSB #031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
-
TSB #17664
INTERMITTENT HARD START, LONG CRANK TIME OR MULTIPLE CRANK ATTEMPTS BEFORE STARTING. *TT Read More »
-
TSB #17666
DIAGNOSTIC TROUBLE CODE (DTC) U0300 (INTERNAL CONTROL MODULE SOFTWARE INCOMPATIBILITY) STORED IN THE PCM WITH NO OTHER DTC'S PRESENT. *TT Read More »
-
TSB #17544
GENERATOR NOISE IN COLD AMBIENT TEMPERATURES. *MJ Read More »
-
TSB #03256
ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ Read More »
-
TSB #17326
ENGINE AUXILIARY OIL COOLER LINE AND THE RIGHT SIDE MOTOR MOUNT SQUEAKING NOISE FROM FRONT EXTERIOR WHILE DRIVING OVER BUMPS. *TT Read More »
-
TSB #03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #03L17
DEMONSTRATION/DELIVERY HOLD - SPECIAL FIELD ACTION 03L17. REVISED SMOG EMISSIONS INFORMATION. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
-
TSB #042115
FUEL GAUGE SLOW TO UPDATE AFTER REFUELING. *EH Read More »
FUEL SYSTEM, OTHER
-
TSB #18719
MALFUNCTION INDICATOR LAMP COMING ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175 (FUEL SYSTEM TOO RICH OR LEAN). *TT Read More »
-
TSB #18217
MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT Read More »
-
TSB #17494
DISTANCE TO EMPTY NOT DISPLAYED. *TT Read More »
-
TSB #17316
FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT Read More »
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
-
TSB #05213
MALFUNCTION INDICATOR LAMP ON WITH PCM DIAGNOSTIC TROUBLE CODE P0463 AND/OR IC DIAGNOSTIC TROUBLE CODE B1201 - FUEL GAUGE DROPS TO EMPTY OR SLOW TO UPDATE AFTER REFUELING. *TT Read More »
-
TSB #18121
FUEL GAUGE SLOW TO UPDATE. *TT Read More »
-
TSB #06167
MIL ON WITH DTC P0463 OR ERRATIC FUEL GAUGE OPERATION. *KB Read More »
POWER TRAIN
-
TSB #05612
DELAYED OR HARSH REVERSE ENGAGEMENTS - 5R55S TRANSMISSION - VEHICLES BUILT PRIOR TO 09/23/2004. *TT Read More »
-
TSB #04268
INCREASED EFFORT DURING LOW SPEED SHARP TURNS ON 4X4 VEHICLES. *TT Read More »
-
TSB #18202
UNINTENDED 4X4 ENGAGEMENT DURING LOW SPEED PARKING LOT TURNS. VARIOUS MODELS INCLUDING THE 2005 EXPLORER AND MOUNTAINEER. *TT Read More »
-
TSB #17555
CERTIFIED REAR AXLE AVAILABLE. *MJ Read More »
-
TSB #17560
REAR AXLE NOISE. ALSO INCLUDES LINCOLN AVIATOR 2002. *MJ Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #04B22
IMPROPERLY FORMULATED TRANSMISSION FLUID THAT, OVER TIME, MAY CAUSE DELAYED/HARSH REVERSE ENGAGEMENTS. CUSTOMER SATISFACTION PROGRAM 04B22. 5R55S/E & 5R44E TRANSMISSION FLUID ADDITIVE. *TT SUPPLEMENT #1. *TT SUPPLEMENT #2. Read More »
-
TSB #17883
DELAYED/HARSH REVERSE ENGAGEMENT. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
-
TSB #042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT Read More »
-
TSB #04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
-
TSB #042212
GEAR SELECTOR LEVER - INCREASED EFFORT TO SHIFT FROM DRIVE TO PARK. *TT Read More »
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
-
TSB #17455
4X4 INOPERATIVE AND/OR INDICATORS BLINKING. *TT Read More »
POWER TRAIN:DRIVELINE
-
TSB #0537
DRIVELINE 1ST ORDER VIBRATION/BOOM/DRONE. *TT Read More »
-
TSB #17107
DRIVELINE VIBRATION ON DRONE/BOOM AT HIGHWAY SPEEDS. *TT Read More »
POWER TRAIN:AXLE ASSEMBLY
-
TSB #06216
LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT Read More »
-
TSB #05618
REAR AXLE NOISE REPAIR. *TT Read More »
-
TSB #18221
REAR AXLE NOISE. OASIS. VARIOUS MODELS INCLUDING 2005 EXPLORER, MOUNTAINEER AND AVIATOR. *TT Read More »
-
TSB #03198
CHATTER, SHUDDER, A BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS ON VEHICLES EQUIPPED WITH THE 9.75 INCH OR 8.8 INCH LIMITED SLIP REAR AXLE. *TT Read More »
-
TSB #041715
FRONT AXLE TUBE LEAK. *EH Read More »
-
TSB #17905
MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT Read More »
-
TSB #04B15
REAR AXLE DATE CODE INSPECTION AND SERVICE. VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER MIX OF REAR AXLE LUBRICANT AND FRICTION MODIFIER ADDITIVE. IF SO, THE CUSTOMER MAY EXPERIENCE NOISE AND VIBRATION WHILE DRIVING. Read More »
-
TSB #17717
REAR AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS. *TT Read More »
-
TSB #17736
REAR AXLE NOISE. *TT Read More »
-
TSB #17641
REAR 3.55 AXLE NOISE. CERTIFIED REAR AXLE OR IMPROVED GEAR SET AVAILABLE. *TT Read More »
-
TSB #17054
AXLE WHINE AT CRUISE OR DURING ACCELERATION/ DECELERATION. *TT Read More »
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-
TSB #TSB-08-19-3
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Read More »
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL
-
TSB #TSB-08-19-3
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Read More »
-
TSB #04105
AXLE SEAL LEAKS. LEAKS FROM REAR HALFSHAFT AXLE SEAL. SERVICE TIPS. *TT Read More »
ELECTRICAL SYSTEM
-
TSB #04219
MALFUNCTION INDICATOR LAMP (MIL) AND ELECTRONIC THROTTLE CONTROL (ETC) LAMPS ON WITH BOTH DIAGNOSTIC TROUBLE CODE (DTC) P2106 AND P2135. *TT Read More »
-
TSB #0561
WRENCH LAMP ON AND NO DIAGNOSTIC TROUBLE CODE (DTC) STORED. *TT Read More »
-
TSB #18381
OPEN FUSE F2.20 (5 AMP) AND/OR F2.1 (30 AMP) WHICH MAY RESULT IN LOSS OF FUNCTION OF SEVERAL SYSTEMS INCLUDING POWER SEATS, ADJUSTABLE PEDALS AND POWER DOOR LOCKS. *TT Read More »
-
TSB #05262
MIL ON WITH DTC P0191 WITH OR WITHOUT VARIOUS DRIVABILITY SYMPTOMS AND/OR ADDITIONAL DTCS. *TT Read More »
-
TSB #0471
WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT Read More »
-
TSB #04197
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTC'S) P0172 AND/OR P0175. *TT Read More »
-
TSB #04174
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
-
TSB #17592
AN INTERMITTENT NO START AND/OR MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC'S) P1233, P1234, P1235, P1236, P1237 OR P1238. *TT Read More »
-
TSB #17670
MALFUNCTION INDICATOR (DTC) LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P2106. *TT Read More »
-
TSB #17558
INTERMITTENT AIR BAG WARNING LAMP ON, MEMORY SEAT, AND/OR ADJUSTABLE PEDAL CONCERNS. *MJ Read More »
-
TSB #17561
DELAYED CRANK WITH NO START, DIAGNOSTIC TROUBLE CODES (DTC) U0300/P0606/P2105/P2107, MALFUNCTION INDICATOR MODULE (MIL) AND WRENCH LIGHT ON. *MJ Read More »
-
TSB #04142
NO CRANK WITH DIAGNOSTIC TROUBLE CODE B1601 AND/OR B1213. PATS SECURITY ACCESS ISSUES WITH 4.0L ENGINE. *TT Read More »
-
TSB #17422
MULTIPLE ELECTRICAL CONCERNS - FUSE 2.17 OPEN. *MJ Read More »
-
TSB #17285
MALFUNCTION INDICATOR LAMP/ETC LAMP LIT WITH P0606 AND ONE OR SEVERAL P21XX-SERIES DIAGNOSTIC TROUBLE CODES AT LOW TIME IN SERVICE. *TT Read More »
-
TSB #17311
MALFUNCTION INDICATOR LAMP ON AND/OR ELECTRONIC THROTTLE CONTROL LAMP (ETC) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P2106. *TT Read More »
-
TSB #03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT Read More »
-
TSB #17165
INTERMITTENT DIAGNOSTIC TROUBLE CODE (DTC) P2106 WITH THE MALFUNCTION INDICATOR LAMP (MIL) ON. *TT Read More »
ELECTRICAL SYSTEM:STARTER ASSEMBLY
-
TSB #18171
NO CRANK/NO START CONDITION WHEN VEHICLE TEMPERATURE IS BELOW FREEZING (32F/0C). *TT Read More »
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
-
TSB #061710
MIL ON WITH P0463 OR ERRATIC FUEL GAUGE OPERATION. *KB Read More »
VISIBILITY
-
TSB #04195
FRONT WINDOW CLUNK NOISE. *TT Read More »
VISIBILITY:GLASS, SIDE/REAR
-
TSB #05136
BACKGLASS DIFFICULT TO CLOSE AND AN INTERMITTENT DOOR AJAR LAMP. *TT Read More »
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
-
TSB #04259
REAR POWER WINDOW(S) INOPERATIVE. *TT Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT
-
TSB #041514
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT Read More »
-
TSB #031501
INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW
-
TSB #04189
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT Read More »
AIR BAGS:FRONTAL
-
TSB #17640
POOR FIT BETWEEN DRIVER AIR BAG AND STEERING WHEEL. *TT Read More »
SEAT BELTS:FRONT:RETRACTOR
-
TSB #042421
SAFETY BELT RETRACTION SPEED. *TT Read More »
STRUCTURE
-
TSB #TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
-
TSB #TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
STRUCTURE:BODY
-
TSB #0485
LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED. SERVICE PROCEDURE. *TT Read More »
-
TSB #04251
ALUMINUM CORROSION - SERVICE TIP. *TT Read More »
-
TSB #04255
RATTLING NOISE - RIGHT FRONT FENDER WHILE DRIVING. *TT Read More »
-
TSB #17276
A POPPING OR CREAKING NOISE THAT APPEARS TO BE COMING FROM THE FRONT EXTERIOR OF THE VEHICLE. *TT Read More »
STRUCTURE:BODY:DOOR
-
TSB #18215
BROKEN REAR CARGO STORAGE DOOR LIFT HANDLE. VARIOUS MODELS INCLUDING 2005 EXPLORER/MOUNTAINEER. *TT Read More »
STRUCTURE:BODY:HATCHBACK/LIFTGATE
-
TSB #17680
REAR LIFTGATE RATTLE / LIGHT POPPING NOISE. *TT Read More »
VEHICLE SPEED CONTROL
-
TSB #18254
SPEED CONTROL INOPERATIVE OR NOT HOLDING THE SET SPEED. OASIS. VARIOUS MODELS INCLUDING 2005 EXPLORER, SPORT TRAC, MOUNTAINEER AND AVIATOR. *TT Read More »
TIRES
-
TSB #0637
LOW TIRE INDICATOR ON - TPMS SYSTEM SENSOR WAKE UP. *TT Read More »
-
TSB #052624
VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT Read More »
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
-
TSB #04B17
SOME OF THE VEHICLES WERE BUILT WITH INSTRUMENT CLUSTERS THAT WERE NOT CONFIGURED PROPERLY FOR USE WITH A REVISED TPMS MODULE. Read More »
-
TSB #17411
TIRE PRESSURE MONITORING SYSTEM (TPMS) MODULE CONFIGURATION - SERVICE TIP. *MJ Read More »
-
TSB #17030
VEHICLES WITH A SILVER VALVE STEM TIRE PRESSURE MONITOR SYSTEM (TPMS) MAY EXHIBIT A WARNING LIGHT/MESSAGE ON. *TT Read More »
WHEELS
-
TSB #052624
VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT Read More »
SEATS
-
TSB #05416
FRONT SEAT(S) SLIGHT MOVEMENT WHEN ACCELERATING AND/OR DECELERATING. *TT Read More »
BACK OVER PREVENTION:WARNINGS:EXTERNAL/PEDESTRIAN ALERT
-
TSB #05419
FALSE PARKING AID WARNINGS. *TT Read More »
-
TSB #04262
FALSE PARKING AID WARNINGS. *TT UPDATE. *TT Read More »
EQUIPMENT
-
TSB #TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #17217
AIR CONDITIONER HOOTING NOISE DURING LIGHT LOAD ACCELERATION AT LOW SPEEDS, FROM 1000-1300 RPM. *TT Read More »