Huge win for car owners! All TSBs to be made public. The Center for Auto Safety just made the NHTSA (US Government) make public the full text of all TSBs from now on. They are the same organization that has petitioned the NHTSA & filed lawsuits to protect car owners over exploding gas tanks & other major safety issues. Whenever you drive in your car, you are safer thanks in part to a lot of work over the years by this small but very effective consumer advocacy group.

Please take a moment & say thank you by donating $5 or whatever you can to the Center for Auto Safety.

NHTSA — Engine And Engine Cooling: Exhaust System: Emission Control: Catalytic Convertor Problems Seal Of Avoid Like The Plague Notes: The 2006 Pontiac G6 has major problems with two areas fairly critical to the act of driving... steering & safety.

The 2006 G6 has a major defect trend with electronic power-assisted steering failure. The power steering cuts out while driving, making it extremely difficult to steer. G6 owners typically report spending $600 - $1,200+ to fix the problem, replacing either the entire steering column or the power assist motor.

In March 2010, GM recalled 1.3 million vehicles for this exact problem "...after receiving 1,100 complaints of power steering failures." However the 2006 G6 wasn't included in that recall.

In July 2010, GM issued a "Special Coverage Adjustment" — TSB #10183 — covering "certain" (not all) 2005, 2006 & 2008 Pontiac G6's for this power steering issue, up to 10 years/100k miles. However a large number of 2006 G6 owners have reported they were not covered by this campaign, based on VIN#.

As of late 2013 the NHTSA had well over 700 steering complaints on file for the 2006 G6, with 21 crashes & 12 injuries. The NHTSA closed their initial investigation in 2007, having determined that losing your power steering going over 15-20 mph isn't a big deal & that most crashes occurred at slow speeds, so not a safety risk. Ridiculous? Yep, we think so too.

The 2006 G6 also has an expensive problem with "popping" or "clunking" noises when turning, & that issue extends to newer model years as well.

Factor in the 2006 Pontiac G6's poor side impact protection & you end up with a vehicle you should steer clear of.


definitely annoying
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
41,500 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2006 Pontiac G6 exhaust system problems

exhaust system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2006 Pontiac G6:

Unsubscribe any time. We don't sell/share your email.

2006 Pontiac G6 Owner Comments

problem #2

Jun 012015

G6 4-cyl

  • miles


Letter from senator gillibrand on behalf of constituent re 2006 Pontiac G6 catalytic converter. The consumer stated his mother was driving the vehicle, when the service engine light illuminated. The consumer stated on the way to the dealer, the service engine light went out. However, the transmission was shifting hard. According to the dealer, the exhaust cam solenoid needed to be replaced. However, a month later the vehicle was exhibiting the issue. The dealer determined the catalytic converter needed to be replaced.

- Olean, NY, USA

problem #1

May 142010


  • 83,000 miles
The contact owns a 2006 Pontiac G6. While traveling at 40 mph, the check engine warning light illuminated. The dealer advised that the catalytic converter had failed and would need to be replaced. The vehicle was not repaired. The VIN was not available. The failure mileage was 83,000 and the current mileage was 85,000.

- Bradford, RI, USA

Not what you are looking for?