2004 Pontiac Grand Prix
2004 Pontiac Grand Prix TSBs (Technical Service Bulletins)
There are also 6 Pontiac recalls » 1 defect investigations » 152 TSBs » for the Pontiac Grand Prix.
Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.
ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.
STEERING
- TSB #01-02-32-001 -- CONCERNS WITH CLUNK NOISE FROM FRONT OF VEHICLE TURNING MANEUVER / STEERING WHEEL ROTATION.*JB (LUBRICATE OR REPLACE INTERMEDIATE SHAFT AS APPROPRIATE). UPDATED 10/05/07. *NJ UPDATED 4/1/08. *NJ UPDATED 7/1/2008 *PE (NHTSA ID #618086, APRIL 01 2008)
- TSB #060232009 -- OVERVIEW OF STEERING SYSTEM NOISES. *NJ (NHTSA ID #10022924, AUGUST 01 2007)
- TSB #040232001 -- RELEASE OF STEERING GEAR STUB SHAFT BEARING KIT FOR SERVICE. *TT UPDATED 08-15-07. *KB UPDATED 10/09/07. *NJ (NHTSA ID #10012694, AUGUST 01 2007)
- TSB #060232011 -- REVISED POWER STEERING TIGHTENING SPECIFICATIONS. *KB (NHTSA ID #10020817, OCTOBER 01 2006)
- TSB #010232001F -- CLUNK FELT/NOISE HEARD FROM STEERING COLUMN, STEERING GEAR AND/OR FRONT OF VEHICLE DURING TURNING MANEUVER AND/OR STEERING WHEEL ROTATION. *TT (NHTSA ID #10019516, FEBRUARY 01 2006)
- TSB #040235004D -- CLUNK NOISE FROM FRONT OF VEHICLE DURING TURNING MANEUVER/STEERING WHEEL ROTATION. *TT *NM (NHTSA ID #10008657, NOVEMBER 01 2005)
- TSB #050232007 -- POWER STEERING MOAN OR GROAN NOISE WHILE DRIVING. *JB (NHTSA ID #10018690, NOVEMBER 01 2005)
- TSB #050235005 -- REVISED STEERING WHEEL AND COLUMN FASTENER TIGHTENING SPECIFICATIONS. *TT (NHTSA ID #10017368, AUGUST 01 2005)
- TSB #050232003 -- REVISED OUTER TIE ROD END NUT TIGHTENING SPECIFICATION/TIE ROD END JAM NUT TIGHTENING SPECIFICATION ADDED. *TT (NHTSA ID #10017515, JUNE 01 2005)
- TSB #030232048A -- CLICK/POPPING TYPE NOISE COMING FROM FRONT OF VEHICLE WHILE TURNING STEERING WHEEL AT LOW SPEEDS. *TT UPDATED *EH UPDATE. *TT (NHTSA ID #10004764, OCTOBER 01 2004)
- TSB #040235002 -- PAINTED FINISH WEARING OFF STEERING WHEEL SPOKES. *TT UPDATE. *TT (NHTSA ID #10008513, MAY 01 2004)
- TSB #3061A -- SUSPENSION, STEERING OR CRADLE TICK, CLICK, POP NOISE. *TT (NHTSA ID #10009627, JANUARY 01 2004)
- TSB #102103 -- CLICK/TICK NOISE HEARD WHILE TURNING THE STEERING WHEEL AT SLOW SPEEDS. THE NOISE WILL HAPPEN WITH THE VEHICLE STOPPED OR MOVING SLOWLY, WHILE TURNING THE STEERING WHEEL 45 TO 90 DEGREES EITHER DIRECTION. GM VOICEMAIL LOG. *TT (NHTSA ID #10005005, OCTOBER 21 2003)
- TSB #010232001C -- SOME CUSTOMERS MAY COMMENT ON A CLUNK TYPE NOISE COMING FROM THE FRONT OF THE VEHICLE DURING A TURNING MANEUVER. *TT (NHTSA ID #10004280, SEPTEMBER 01 2003)
- TSB #3207 -- REPAIR OF STEERING GEAR CLICK/TICK/POP NOISE AND PART NUMBER CORRECTION. SERVICE BULLETIN 03-02-32-048A. *TT (NHTSA ID #10010874, no date provided)
STEERING:WHEEL AND HANDLE BAR
- TSB #030104 -- SILVER FINISH ON THE STEERING WHEEL SPOKES IS STARTING TO WEAR OFF ESPECIALLY NEAR THE RADIO CONTROL BUTTON. *TT (NHTSA ID #10007372, MARCH 01 2004)
- TSB #01806A -- STEERING WHEEL SPOKE SILVER TRIM WEAR. SERVICE VME. *TT (NHTSA ID #10007310, JANUARY 01 2004)
STEERING:HYDRAULIC POWER ASSIST SYSTEM
SUSPENSION
- TSB #709 -- TIE ROD SPECIFICATIONS REVISED. GM TECH LINK. *TT (NHTSA ID #10018133, SEPTEMBER 01 2005)
- TSB #040308010 -- CHANGES TO LABOR TIME GUIDE RELATING TO FRONT SUSPENSION LABOR OPERATIONS COMPONENTS. *EH (NHTSA ID #10012182, JUNE 01 2004)
- TSB #030310005 -- NEW L/H WHEEL WEIGHTS FOR SEMI-FLANGELESS WHEELS. *TT (NHTSA ID #10002852, JUNE 01 2003)
SUSPENSION:FRONT
SERVICE BRAKES, HYDRAULIC
- TSB #709 -- CAR ISSUES - FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT (NHTSA ID #10018156, SEPTEMBER 01 2005)
- TSB #040523002 -- BRAKE ROTOR MINIMUM ALLOWABLE THICKNESS AFTER REFINISH SPECIFICATION CORRECTION. *TT (NHTSA ID #10012633, AUGUST 01 2005)
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
SERVICE BRAKES, HYDRAULIC:ANTILOCK:ABS WARNING LIGHT
ENGINE AND ENGINE COOLING
- TSB #040601008A -- ENGINE/ACCESSORY DRIVE NOISY, LACK OF POWER, SUPERCHARGER NOT FUNCTIONING PROPERLY. *EH (NHTSA ID #10012590, APRIL 01 2005)
- TSB #040604025 -- CHECK ENGINE LIGHT MALFUNCTION INDICATOR LAMP ON DIAGNOSTIC TROUBLE CODE P0455 SET. *EH (NHTSA ID #10012597, APRIL 01 2004)
- TSB #3141 -- SUPERCHARGER BELTS MAKES NOISE OR SLIP OFF. *TC (NHTSA ID #10010184, JANUARY 01 2004)
ENGINE AND ENGINE COOLING:ENGINE
- TSB #030604030 -- MULTIPLE DRIVEABILITY SYMPTOMS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT (NHTSA ID #10002166, MARCH 01 2007)
- TSB #040604066A -- CLUNK/BANG FROM REAR OF VEHICLE. *TT (NHTSA ID #10011048, SEPTEMBER 01 2005)
- TSB #040604078 -- HESITATION, ROUGHNESS, LIGHT CHUGGLE OR CHECK ENGINE LIGHT, DIAGNOSTIC TROUBLE CODE (DTC) P0300. *TT (NHTSA ID #10012726, OCTOBER 01 2004)
- TSB #0804 -- OIL LIFE SYSTEM RESET PROCEDURES - CARS. *NM (NHTSA ID #10014346, AUGUST 01 2004)
- TSB #040601021 -- NEW REAR MAIN SEAL AND SPECIAL TOOL FOR INSTALLATION. *TT (NHTSA ID #10012148, JUNE 01 2004)
- TSB #3006 -- ENGINE MECHANICAL NOISE. VARIOUS MODELS INCLUDING THE 2005 PONTIAC GRAND PRIX. *TT (NHTSA ID #10008859, JANUARY 01 2004)
- TSB #01855 -- STANDARD SIZE PISTONS FOR 3.8L L32 ENGINE - ARE NOT AVAILABLE. *MR (NHTSA ID #10006614, JANUARY 01 2004)
- TSB #01957 -- ROAD DEBRIS INTO ENGINE AREA THROUGH FENDERS. *MR (NHTSA ID #10006941, JANUARY 01 2004)
- TSB #01353 -- ENGINE MISFIRE DUE TO INJECTOR FRETTING CORROSION. *TT (NHTSA ID #10007937, JANUARY 01 2004)
- TSB #01419 -- ENGINE STUMBLES AND HESITATES WHEN COLD FROM PARK TO DRIVE. *TT (NHTSA ID #10004224, NOVEMBER 18 2003)
- TSB #3157A -- ENGINE WHINE OR BUZZ NOISE SOUNDS LIKE A GENERATOR TYPE NOISE ON 3.1L OR 3.8L ENGINES. *TT (NHTSA ID #10017172, no date provided)
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
FUEL SYSTEM, OTHER
- TSB #01505 -- LOOSE FUEL CAP MESSAGE AND DIAGNOSTIC TROUBLE CODE (DTC) P0440, P0455. *TT *MJ (NHTSA ID #10005487, JANUARY 01 2004)
- TSB #11052003 -- DIAGNOSTIC TROUBLE CODES P0440 AND P0455, ALONG WITH A LOOSE FUEL CAP MESSAGE DISPLAYED ON THE DIC ON VEHICLES WITH 3800 ENGINE APPLICATIONS. *TT (NHTSA ID #10013138, NOVEMBER 05 2003)
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
POWER TRAIN
- TSB #01872 -- 4T65E TRANSMISSION SLIPS IN REVERSE WHEN HOT, OR NO REVERSE. *TT (NHTSA ID #10006468, JANUARY 01 2004)
- TSB #01715 -- 4T65E TRANSMISSION FLUID LEAK FROM THE REVERSE SERVO COVER IN COLD WEATHER. *TT (NHTSA ID #10006247, JANUARY 01 2004)
- TSB #050803 -- WHINE NOISE CONDITION HEARD IN DRIVE OR REVERSE AND NOT PRESENT IN PARK OR NEUTRAL. *TT (NHTSA ID #10003639, MAY 08 2003)
- TSB #3296 -- DRIVE SPROCKET SUPPORT BEARING MISSING OR DTC P0741 AND P0742. *SC (NHTSA ID #10017143, no date provided)
- TSB #3102 -- SERVICE VME 01-04 VEHICLE EQUIPPED WITH 4T65E AUTOMATIC TRANSMISSION 4T65E TRANSMISSION VALVE BODY INSPECTION PROCEDURE. (TO INCLUDE 2004 PONTIAC AZTEC) *SC ALL 2001 - 2006 PASSENGER VEHICLES WITH 4T65E TRANSAXLE. *TT (NHTSA ID #10010237, no date provided)
POWER TRAIN:AUTOMATIC TRANSMISSION
- TSB #080730002 -- INFORMATIONAL ON 4T65-E MN7, M15 AND M76 FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTCS P0741, P0742, P0757, P842, HARSH SHIFTS OR SLIPS. *PE (NHTSA ID #10025065, MARCH 01 2008)
- TSB #060730023 -- 4T65E TRANSMISSION 1-2 SHIFT SHUDDER AT LIGHT TO MODERATE ACCELERATION. REPLACE COMPLETE SECOND CLUTCH ASSEMBLY. *KB (NHTSA ID #10020766, SEPTEMBER 01 2006)
- TSB #020730039E -- FIRM TRANSMISSION SHIFTS, SHUDDER/CHUGGLE, TRANSMISSION WON'T DOWNSHIFT ON DECELERATION, SERVICE ENGINE SOON LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE P0742 SET. *TT UPDATE. *TT (NHTSA ID #10004756, AUGUST 01 2005)
- TSB #020730013D -- INCORRECT TRANSMISSION SHIFTS POOR ENGINE PERFORMANCE HARSH 1-2 UPSHIFTS SLIPS 1ST AND REVERSE TORQUE CONVERTER CLUTCH STUCK OFF ON DIAGNOSTIC TROUBLE CODE P0730, P0756, P0757, P0741, P0742. *EH *TT (NHTSA ID #10012152, MAY 01 2005)
- TSB #040730010 -- REVISED CASE SIDE COVER REPLACEMENT PROCEDURE. *TT (NHTSA ID #10008672, MARCH 01 2004)
- TSB #01232004 -- TRANSMISSION FLUID LEAK FROM REVERSE SERVO COVER AT AMBIENT TEMPERATURES. TRANSMISSION FLUID MAY BE DETECTED ON THE LOWER PAIN RAIL OR CASE SIDE. MOST LEAK REPORTS HAVE BEEN FOUND DURING PREDELIVERY INSPECTION. GM VOICEMAIL EXPRESS. *TT (NHTSA ID #10009104, JANUARY 23 2004)
- TSB #030730029 -- CHANGES FOR 2004 MODEL YEAR FOR 4T65E TRANSAXLE - INTERNAL CHANGES TO VALVE BODY, SPACER PLATE AND CHANNEL PLATE AND TOUCH ACTIVATED POWER (TAP). *TT (NHTSA ID #10012562, JULY 01 2003)
- TSB #060503 -- 4T65E EQUIPPED AUTOMATIC TRANSMISSION VEHICLES MAY HAVE NO REVERSE, SLIPS IN REVERSE WHEN THE TRANSMISSION IS AT OPERATING TEMPERATURE. *TT (NHTSA ID #10003691, JUNE 05 2003)
- TSB #01432 -- AUTOMATIC TRANSMISSION POOR ACCELERATION, PERFORMANCE. *TT (NHTSA ID #10004412, JANUARY 01 2003)
- TSB #3692 -- TICKING OR KNOCKING NOISE, CRACKED OR BROKEN FLEXPLATE. *TT (NHTSA ID #10019447, no date provided)
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
- TSB #053003 -- A REVISION TO THE PARTS RESTRICTION PROGRAM FOR THE POWERTRAIN CONTROL MODULE. THE CURRENT BULLETIN HAS BEEN REVISED TO EXTEND THE PARTS RESTRICTION PROGRAM THROUGH AUGUST 1, 2003. PLEASE DISREGARD CORPORATE BULLETIN NUMBER 03-06-04-027. (NHTSA ID #10003678, MAY 30 2003)
- TSB #030604027A -- PARTS RESTRICTION PROGRAM FOR POWERTRAIN CONTROL MODULE (PCM). *TT (NHTSA ID #10002369, MAY 01 2003)
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
POWER TRAIN:AXLE ASSEMBLY
ELECTRICAL SYSTEM
- TSB #08089-B -- GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE (NHTSA ID #10027804, NOVEMBER 01 2008)
- TSB #050604037 -- CERTAIN INSTRUMENT PANEL GAUGES GO TO ZERO AND/OR INTERMITTENT ENGINE STALL. *TT (NHTSA ID #10017535, JUNE 01 2005)
- TSB #040849024 -- DIC DOES NOT DISPLAY INFORMATION. *TT (NHTSA ID #10011077, MARCH 01 2005)
- TSB #040089022 -- RE-LEARNING ADDITIONAL SPARE KEY TO BCM AFTER BCM SERVICE. *EH (NHTSA ID #10012168, JUNE 01 2004)
- TSB #040856001 -- CLEARING THEFT SYSTEM DIAGNOSTIC TROUBLE CODES (DTCS) IN THE BCM AFTER SYSTEM REPAIR TO REMOVE THEFT SYSTEM MESSAGE. *MJ (NHTSA ID #10008476, JUNE 01 2004)
- TSB #0308116001 -- DIAGNOSTIC TROUBLE CODE (DTC) U1000, U1016, U1064, U1096 OR U1305 SET IN ERROR. *TT THIS BULLETIN REPLACES PREVIOUS BULLETIN DATED 06/01/2003. *TT (NHTSA ID #10002880, FEBRUARY 01 2004)
- TSB #01928 -- DIC GOES BLANK.*MR (NHTSA ID #10007075, JANUARY 01 2004)
- TSB #01965 -- POSSIBLE DIAGNOSTIC TROUBLE CODE SET FOR HARNESS CHAFF ON SUPERCHARGER STUD. *MR (NHTSA ID #10006901, JANUARY 01 2004)
- TSB #01971 -- REPEAT DIAGNOSTIC TROUBLE CODE P0455. *MR (NHTSA ID #10006939, JANUARY 01 2004)
- TSB #3074 -- PERFORMANCE OF XM RADIO SYSTEM WITH SUNROOF FULLY OPEN. *TT (NHTSA ID #10009519, JANUARY 01 2004)
- TSB #02038 -- DIAGNOSTIC TROUBLE CODE B1000. *MR (NHTSA ID #10006946, JANUARY 01 2004)
- TSB #01560A -- MALFUNCTION INDICATOR LAMP (MIL)/DIAGNOSTIC TROUBLE CODE (DTC) P0445. *TT *MJ (NHTSA ID #10005398, JANUARY 01 2004)
- TSB #01412 -- REDUCED POWER POSSIBLE DIAGNOSTIC TROUBLE CODE (DTC). SERVICE VME. *TT (NHTSA ID #10004216, NOVEMBER 18 2003)
- TSB #57 -- PERFORMANCE OF XM RADIO SYSTEM WITH SUNROOF - POOR XM SIGNAL RECEPTION WITH THE SUNROOF FULLY OPENED. GM TECH LINK. *TT (NHTSA ID #10016463, JULY 01 2003)
- TSB #3354 -- ENGINE WIRING HARNESS CAUSING MULTIPLE DRIVEABILITY CONCERNS. *EH (NHTSA ID #10014948, no date provided)
- TSB #3435 -- INTERMITTENT STALL AND/OR INTERMITTENT GAUGE FLUCTUATION. TO INCLUDE 2005 BUICK ALLURE (CANADA ONLY). *TT (NHTSA ID #10017038, no date provided)
ELECTRICAL SYSTEM:WIRING
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
ELECTRICAL SYSTEM: SOFTWARE
EXTERIOR LIGHTING
VISIBILITY
VISIBILITY:SUN ROOF ASSEMBLY
- TSB #040857007 -- HEADLINER WET AROUND SUN ROOF. *EH (NHTSA ID #10013443, JANUARY 01 2005)
- TSB #040867008 -- SUNROOF CREAK. *TT (NHTSA ID #10012746, OCTOBER 01 2004)
VISIBILITY:REARVIEW MIRRORS/DEVICES
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:BLOWER
- TSB #709 -- CAR ISSUES - FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT (NHTSA ID #10018156, SEPTEMBER 01 2005)
- TSB #050139001 -- BLOWER MOTOR INOPERATIVE OR INTERMITTENT, BLOWER SPEED MAY DROP OR BLOWER CONTINUES TO RUN AFTER KEY OFF. *TT REPEAT BLOWER MODULE FAILURE OR LOGIC LOCK AFTER TSB 05-01-39-001A HAS BEEN PERFORMED. TSB 05-01-39-001A NOT YET RECEIVED. (NHTSA ID #10014973, MARCH 01 2005)
VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:REAR WINDOW
STRUCTURE
STRUCTURE:FRAME AND MEMBERS
STRUCTURE:BODY
- TSB #08162004 -- FRONT FRAME REAR BODY MOUNT BRACKET MAY FRACTURE BECAUSE OF CRACKS IN THE ALUMINUM BAR RESULTING IN CREAK, GROAN AND CLICKING NOISES. *TT UPDATE. *TT (NHTSA ID #10013049, AUGUST 16 2004)
- TSB #040847002 -- TONE, WHISTLE, OR HIGH PITCHED HUM HEARD ON THE AM BAND (REPLACE BCM). *MJ THIS BULLETIN REPLACES PREVIOUS BULLETIN NUMBER 04-08-47-002 DATED 04/01/2004. *TT (NHTSA ID #10008684, AUGUST 01 2004)
- TSB #0408110005 -- PAINT DELAMINATION FROM REAR DOOR TRIM PANEL. *TT (NHTSA ID #10012099, JULY 01 2004)
- TSB #05062004 -- REAR STORAGE COMPARTMENT DOOR. *EH (NHTSA ID #10013214, MAY 06 2004)
- TSB #040863004 -- ENGINE COMPARTMENT DIRTY IN FRONT OF SHOCK TOWER. *EH (NHTSA ID #10012629, APRIL 01 2004)
- TSB #040850008 -- DRIVER/PASSENGER SEAT BACK COVER TORN (REPLACE SEAT BACK COVER, FOAM PAD AND ADD SIDE BOLSTER PAD TO SEAT FRAME WIRE). *MJ (NHTSA ID #10008695, MARCH 01 2004)
- TSB #030857006 -- WATER LEAK ON FRONT PASSENGER FLOOR. *TT (NHTSA ID #10005156, MARCH 01 2004)
STRUCTURE:BODY:DOOR
STRUCTURE:BODY:TRUNK LID
- TSB #040866013 -- INSTALLATION STORAGE OF CARGO NET IN THE TRUNK AREA. *EH (NHTSA ID #10011244, AUGUST 01 2004)
- TSB #02067 -- TRUNK STORAGE COMPARTMENT DOOR ELIMINATED. SERVICE VME. *TT (NHTSA ID #10007764, JANUARY 01 2004)
LATCHES/LOCKS/LINKAGES
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
- TSB #611 -- TIRE PRESSURE MONITOR RESET/LEARN-WHEN THE PRESSURE IN THE AFFECTED TIRE WAS SET TO SPECIFICATION ON SOME VEHICLES, THE CHECK TIRE PRESSURE AND OR XX TIRE HIGH/LOW DISPLAY IS CANCELED WITHIN 20 SECONDS OF THE PRESSURE ADJUSTMENT. *SC (NHTSA ID #10016268, NOVEMBER 01 2004)
- TSB #01508 -- TIRE PRESSURE MONITOR SYSTEM MESSAGE DISPLAYED ON DIC. SIT BULLETIN 1403323. *TT (NHTSA ID #10005489, JANUARY 01 2004)
WHEELS
WHEELS:LUGS/NUTS/BOLTS
COMMUNICATIONS:HORN ASSEMBLY
EQUIPMENT
- TSB #050846006A -- INFORMATION ON UPGRADING CERTAIN ONSTAR GENERATION 5 ANALOG/DIGITAL-READY SYSTEMS TO ONSTAR GENERATION 6 DUAL-MODE (ANALOG/DIGITAL). *TT (NHTSA ID #10015018, SEPTEMBER 01 2005)
- TSB #030848005A -- COMPASS ZONE ADJUSTMENT AND CALIBRATION PROCEDURE DURING PRE-DELIVERY INSPECTION. VARIOUS MODELS INCLUDING 2002-2004 LIGHT DUTY TRUCKS. *TT UPDATE TO INCLUDE 2005 BUICK ALLURE. *TT (NHTSA ID #10005564, MARCH 01 2005)
- TSB #3011 -- WHEN USING VOICE RECOGNITION DIALING, SOME NUMBERS OR COMMANDS MAY NOT BE UNDERSTOOD BY THE SYSTEM ESPECIALLY THE NUMBER TWO (2). *TT (NHTSA ID #10008898, JANUARY 01 2004)
- TSB #3047 -- 99 THROUGH 05 YEAR VEHICLES, EQUIPPED WITH THREE-BUTTON ONSTAR SYSTEMS. *TT (NHTSA ID #10009607, JANUARY 01 2004)
- TSB #040849001 -- DAY OF THE WEEK AND DATE DO NOT AGREE ON DRIVER'S INFORMATION CENTER (DIC) ON VEHICLES EQUIPPED WITH 6-DISC CD/RADIO. *TT (NHTSA ID #10011136, JANUARY 01 2004)
- TSB #01739 -- DIC DAY AND DATE DO NOT MATCH - OBTAINING RADIO PART NUMBER. SERVICE VME. SIT BULLETIN 1460220. *TT (NHTSA ID #10006356, JANUARY 01 2004)
- TSB #030846005 -- VERIFICATION OF ONSTAR AUDIO LEVEL (VOLUME ADJUSTMENT) DURING PRE-DELIVERY INSPECTION. *TT (NHTSA ID #10004331, SEPTEMBER 01 2003)
- TSB #082903 -- VME MESSAGE REGARDING A SPEAKER BUZZ THAT OCCURS WITH THE LEFT REAR SPEAKER ON MONSOON SPEAKER EQUIPPED 2003 GRAND PRIXS. *TT (NHTSA ID #10003890, AUGUST 29 2003)
- TSB #082503 -- THE DRIVER MAY BE UNABLE TO HEAR THE CONNECTING TO ONSTAR PROMPT OR ANY SUBSEQUENT CONNECTION TO THE ONSTAR CALL CENTER. THE ONSTAR LED IN THE MIRROR WILL BE GREEN OR FLASHING GREEN FOLLOWING A BUTTON PRESS. *TT (NHTSA ID #10003876, AUGUST 25 2003)
- TSB #030844015 -- BUZZ NOISE HEARD IN LEFT REAR SPEAKER. *TT (NHTSA ID #10004384, AUGUST 01 2003)
- TSB #010846002C -- PROGRAMMING OF REPLACEMENT ONSTAR VEHICLE COMMUNICATION AND INTERFACE MODULES (VCIM). *TT (NHTSA ID #10002836, JUNE 01 2003)
- TSB #050603 -- INFORMATION ON THE TRANSPONDER KEY AND RECOMMENDED SUPPLIERS FOR CUTTING EQUIPMENT. *TT (NHTSA ID #10003634, MAY 06 2003)
EQUIPMENT:ELECTRICAL
- TSB #08-089 -- GM: SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. FCC RULED IN 2002 WIRELESS CARRIERS WOULD NO LONGER RE REQUIRED TO SUPPORT ANALOG WIRELESS NETWORK STARTING IN 2008. *PE CSC LETTER WAS RECEIVED. UPDATED 12/1/08. *PE (NHTSA ID #10026586, JUNE 01 2008)
- TSB #00372D -- ONSTAR SYSTEM IS ATTEMPTING AND/OR COMPLETING PHONE CALLS WHICH THE OPERATOR OF THE VEHICLE DID NOT INITIATE. *TT (NHTSA ID #10007287, JANUARY 01 2004)
EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES
- TSB #02126 -- NO START - PASSKEY III INOPERATIVE AFTER BCM SERVICE. *TT (NHTSA ID #10007802, JANUARY 01 2004)
- TSB #02081 -- SERVICE THEFT SYSTEM MESSAGE ON AFTER REPAIR. *TT (NHTSA ID #10007778, JANUARY 01 2004)
- TSB #3841 -- IPC GAUGES AND WARNING INDICATORS WITH VDR INSTALLED. *AK (NHTSA ID #10019185, no date provided)
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
- TSB #040846004 -- ONSTAR SYSTEM INOPERATIVE ONSTAR SYSTEM STATUS LIGHT IS RED RADIO LOCKED IN PHONE MODE OR DTC B1000. *EH (NHTSA ID #10013440, JANUARY 01 2005)
- TSB #040849001A -- DAY OF THE WEEK AND DATE DO NOT AGREE ON DRIVER'S INFORMATION CENTER ON VEHICLES EQUIPPED WITH 6-DISC CD/RADIO. *MJ (NHTSA ID #10008474, JUNE 01 2004)
- TSB #01662 -- XM ERROR ON A RADIO DISPLAY. *TT (NHTSA ID #10007248, JANUARY 01 2004)
- TSB #01759 -- XM RAPID ACTIVATION UTILIZATION. *MR (NHTSA ID #10006302, JANUARY 01 2004)
- TSB #3106 -- XM RADIO WAS WORKING PRIOR TO JULY 26, 2004 AND IT IS INOPERATIVE NOW. *JB (NHTSA ID #10010132, JANUARY 01 2004)
- TSB #01390 -- XM RADIO MUST BE TUNED TO CHANNEL 1 THROUGH 66 DURING ACTIVATION ATTEMPT. 2004 CHEVROLET CANYON, GMC DENALI, GMC COLORADO ALSO INCLUDED. *TT (NHTSA ID #10004195, NOVEMBER 18 2003)
EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
EQUIPMENT:ELECTRICAL:AIR CONDITIONER
- TSB #040138003 -- HVAC SYSTEM MAY NOT CHANGE MODES AT HIGH BLOWER MOTOR SPEED. *TT (NHTSA ID #10012693, SEPTEMBER 01 2005)
- TSB #040138017 -- AC NOT COLD ENOUGH AC BLOWS WARM AIR AC INOPERATIVE. *EH (NHTSA ID #10012734, OCTOBER 01 2004)
- TSB #040138009 -- POOR A/C PERFORMANCE - A/C WILL NOT BLOW COLD ENOUGH, RECIRCULATION MODE DOOR INOPERATIVE, DIAGNOSTIC TROUBLE CODES (DTCS) B0268 AND B0269 SET. *TT (NHTSA ID #10012105, JULY 01 2004)
- TSB #3129 -- A/C EVAPORATOR FREEZING. *TC (NHTSA ID #10009949, JANUARY 01 2004)
- TSB #01497A -- HVAC SYSTEM RECIRCULATION MODE INOPERATIVE. THE AIR RECIRCULATION DOOR IS NOT MOVING OR MOVING TOO SLOWLY DURING HVAC SYSTEM OPERATION. THE RECIRCULATION DOOR WILL PROBABLY BE FOUND STUCK IN THE OUTSIDE AIR MODE. *TT *MJ (NHTSA ID #10005479, JANUARY 01 2004)
- TSB #3097 -- HVAC SIDE TO SIDE TEMPERATURE DIFFERENCE. *SC (NHTSA ID #10010202, JANUARY 01 2004)
- TSB #01417 -- HVAC WILL NOT CHANGE MODES IN HI BLOW. *TT (NHTSA ID #10004221, NOVEMBER 18 2003)
- TSB #092903 -- HVAC SYSTEM MAY NOT BE CHANGING MODES WHEN THE BLOWER IS AT OR NEAR FULL SPEED. GM VOICEMAIL LOG. *TT (NHTSA ID #10004993, SEPTEMBER 29 2003)
- TSB #070103 -- THIS IS PRODUCT SERVICE MESSAGE GOING TO ALL PONTIAC DEALER SERVICE MANAGERS REGARDING THE LOSS OF LUBRICATION TO THE CVC7 AIR CONDITIONING COMPRESSOR. *TT (NHTSA ID #10003813, JULY 07 2003)
- TSB #070203 -- SERVICING CVC THE AIR CONDITIONER COMPRESSOR. SERVICE TIPS. *TT (NHTSA ID #10003738, JULY 02 2003)
- TSB #030139009 -- PROCEDURE TO PREVENT LACK/LOSS OF LUBRICATION TO CVC7 AIR CONDITION COMPRESSOR FOR VEHICLES IN DEALER INVENTORY. *TT (NHTSA ID #10002942, JULY 01 2003)
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
UNKNOWN OR OTHER
- TSB #020846010E -- PROGRAMMING ONSTAR MODULE FOR CANADIAN FRENCH VOICE RECOGNITION. *TT UPDATE. *TT UPDATED *EH (NHTSA ID #10002998, NOVEMBER 01 2004)
- TSB #020730022B -- SERVICE ENGINE SOON LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0716 AND / OR P0717, P0730, P0753, P0758, P1860, P1887 OR OTHER MISCELLANEOUS TRANSMISSION TROUBLE CODES SET. *TT (NHTSA ID #10004755, OCTOBER 01 2003)
- TSB #01444 -- XM DEALER ASSISTANCE LINE INFORMATION. *TT (NHTSA ID #10004411, JANUARY 01 2003)