[ switch models ] 2003 Pontiac Aztek 2003 Pontiac Bonneville 2003 Pontiac Grand Am 2003 Pontiac Grand Prix 2003 Pontiac Montana 2003 Pontiac Vibe [ switch years ] 2005 Pontiac Sunfire 2004 Pontiac Sunfire 2002 Pontiac Sunfire 2001 Pontiac Sunfire 2000 Pontiac Sunfire 1999 Pontiac Sunfire 1998 Pontiac Sunfire 1997 Pontiac Sunfire 1996 Pontiac Sunfire 1995 Pontiac Sunfire 1990 Pontiac Sunfire

2003 Pontiac Sunfire

Technical Service Bulletins

There are also 1 Pontiac recalls » 2 defect investigations » 143 TSBs » for the Pontiac Sunfire.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB number & contact your local dealer.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING

• TSB #01-02-32-001 -- CONCERNS WITH CLUNK NOISE FROM FRONT OF VEHICLE TURNING MANEUVER / STEERING WHEEL ROTATION.*JB (LUBRICATE OR REPLACE INTERMEDIATE SHAFT AS APPROPRIATE). UPDATED 10/05/07. *NJ UPDATED 4/1/08. *NJ UPDATED 7/1/2008 *PE (NHTSA ID #618086, APRIL 01 2008)
• TSB #040232001 -- RELEASE OF STEERING GEAR STUB SHAFT BEARING KIT FOR SERVICE. *TT UPDATED 08-15-07. *KB UPDATED 10/09/07. *NJ (NHTSA ID #10012694, AUGUST 01 2007)
• TSB #010232001F -- CLUNK FELT/NOISE HEARD FROM STEERING COLUMN, STEERING GEAR AND/OR FRONT OF VEHICLE DURING TURNING MANEUVER AND/OR STEERING WHEEL ROTATION. *TT (NHTSA ID #10019516, FEBRUARY 01 2006)
• TSB #040235004D -- CLUNK NOISE FROM FRONT OF VEHICLE DURING TURNING MANEUVER/STEERING WHEEL ROTATION. *TT *NM (NHTSA ID #10008657, NOVEMBER 01 2005)
• TSB #030232001B -- MOMENTARY REDUCTION OF POWER STEERING PS ASSIST ON INITIAL START UP WITH LOW AMBIENT TEMPERATURES. THIS SERVICE BULLETIN REPLACES 030232001A. *EH (NHTSA ID #10012093, JULY 01 2004)
• TSB #010232001C -- SOME CUSTOMERS MAY COMMENT ON A CLUNK TYPE NOISE COMING FROM THE FRONT OF THE VEHICLE DURING A TURNING MANEUVER. *TT (NHTSA ID #10004280, SEPTEMBER 01 2003)
• TSB #032403 -- A RATTLE /THUMPING TYPE NOISE HEARD AND SOMETIMES FELT THROUGH THE FLOORBOARD, PRIMARILY ON THE PASSENGER SIDE, WHEN TRAVELING OVER ROUGH ROADS. *TT *JB (NHTSA ID #10001864, MARCH 24 2003)

STEERING:COLUMN

• TSB #070232006 -- CLUNK FELT/NOISE HEARD FROM STEERING COLUMN, STEERING GEAR AND/OR FRONT OF VEHICLE DURING TURNING MANEUVER AND/OR STEERING WHEEL ROTATION (LUBRICATE INTERMEDIATE SHAFT [I-SHAFT]). *NJ (NHTSA ID #10022926, AUGUST 01 2007)

STEERING:HYDRAULIC POWER ASSIST SYSTEM

• TSB #030232001A -- MOMENTARY REDUCTION ON POWER STEERING (P/S) ASSIST ON INITIAL START UP WITH LOW AMBIENT TEMPERATURES. *TT (NHTSA ID #10004762, OCTOBER 01 2003)
• TSB #022403 -- INTERMITTENT CONDITION OF A MOMENTARY REDUCTION IN POWER STEERING ASSIST AT STARTUP. *TT *JB (NHTSA ID #10001842, FEBRUARY 24 2003)

SUSPENSION

• TSB #040308015A -- SQUEAKING NOISE IN FRONT END ON TURNS. *TT (NHTSA ID #10011062, MAY 01 2005)
• TSB #040308010 -- CHANGES TO LABOR TIME GUIDE RELATING TO FRONT SUSPENSION LABOR OPERATIONS COMPONENTS. *EH (NHTSA ID #10012182, JUNE 01 2004)
• TSB #010310005C -- WHEEL SQUEAK ON VEHICLES WITH 14 AND 15 INCH WHEEL COVERS. *TT (NHTSA ID #10004752, OCTOBER 01 2003)
• TSB #010310005B -- WHEEL SQUEAK ON VEHICLES WITH 14 AND 15 INCH WHEEL COVERS. *TT (NHTSA ID #10001257, MARCH 01 2003)
• TSB #020308008 -- RATTLE, CREAK, POPPING TYPE NOISE FROM FRONT OF VEHICLE WHEN TURNING. *TT (NHTSA ID #10000465, NOVEMBER 01 2002)
• TSB #3263 -- FRONT SUSPENSION NOISE ON TURNS. *EH (NHTSA ID #10011819, no date provided)

SUSPENSION:FRONT

• TSB #01967 -- FRONT SUSPENSION STEER NOISE SMOOTH ROAD TURNS. *MR (NHTSA ID #10006895, JANUARY 01 2004)
• TSB #02139 -- SQUEAK OR RUB TYPE NOISE ON TURNS COMING FROM THE FRONT SUSPENSION AS IF IT IS COMING FROM THE SHOCK ABSORBER OR THE TOP MOUNT. *TT (NHTSA ID #10008871, JANUARY 01 2004)

SERVICE BRAKES, HYDRAULIC

• TSB #709 -- CAR ISSUES - FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT (NHTSA ID #10018156, SEPTEMBER 01 2005)

SERVICE BRAKES, HYDRAULIC:ANTILOCK:ABS WARNING LIGHT

• TSB #040525007 -- ANTI-LOCK BRAKE SYSTEM (ABS) WARNING LIGHT ON, TRACTION OFF WARNING LIGHT ON, DIAGNOSTIC TROUBLE CODES (DTCS) C1223 AND C1225 SET. *TT (NHTSA ID #10008469, JUNE 01 2004)

SERVICE BRAKES, AIR

• TSB #4615 -- ABS PUMP RUNNING WHEN NOT NEEDED. *NJ (NHTSA ID #10023171, no date provided)

SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

• TSB #04152004 -- VEHICLES MAY SET ANYONE OR A COMBINATION OF FRONT-WHEEL SPEED SENSOR ANTI-LOCK BRAKE SYSTEM CODES AS INTERMITTENT OR HARD FAILURES. GM VOICEMAIL EXPRESS. *TT (NHTSA ID #10009220, APRIL 15 2004)
• TSB #00966B -- ABS FRONT WHEEL SPEED CODES - JUMPER HARNESS. *TT (NHTSA ID #10007293, JANUARY 01 2004)
• TSB #00966 -- ANTI-LOCK BRAKING SYSTEM (ABS) FRONT WHEEL SPEED CODES - JUMPER HARNESS. *TT (NHTSA ID #10007816, JANUARY 01 2004)
• TSB #3477 -- TECH 2 DISPLAYS ASTERISK FOR THE LEFT FRONT WHEEL SPEED SENSOR. *TT (NHTSA ID #10014875, no date provided)

PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE

• TSB #09122002 -- PARKING BRAKE DRAG CONDITION, LOW POWER CONDITION OR COMPLAINTS OF A REAR VEHICLE SQUAWK ON TAKEOFF. *TT (NHTSA ID #10009445, SEPTEMBER 12 2002)

ENGINE AND ENGINE COOLING

• TSB #050601003A -- HIGHER THAN EXPECTED OIL CONSUMPTION BLUE SMOKE ON ACCELERATION. *EH (NHTSA ID #10013473, AUGUST 01 2005)
• TSB #050601002 -- ENGINE FAILURE DUE TO WATER INGESTION HYDRO LOCK. *EH (NHTSA ID #10013471, JANUARY 01 2005)
• TSB #610 -- ENGINE IDLE FLARE WHEN THE CLUTCH IS DEPRESSED. ALSO LOW SPEED ENGINE DECEL STALL WHEN COMING TO A STOP. GM TECH LINK. *TT (NHTSA ID #10015768, OCTOBER 01 2004)
• TSB #030601018 -- NEW CYLINDER BORE LINER REPLACEMENT PROCEDURE. THIS SERVICE BULLETIN REPLACES 030601018A. *EH (NHTSA ID #10012103, JULY 01 2004)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #030604030 -- MULTIPLE DRIVEABILITY SYMPTOMS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT (NHTSA ID #10002166, MARCH 01 2007)
• TSB #050604026 -- VEHICLE HESITATES, NO START, LACK OF POWER, LOW FUEL PRESSURE. *TT (NHTSA ID #10017407, MAY 01 2005)
• TSB #040604063 -- ENGINE IDLE FLAIR WHEN CLUTCH DEPRESSED OR DECEL STALL. *TT (NHTSA ID #10011046, SEPTEMBER 01 2004)
• TSB #05202004 -- INTERMITTENT IDLE CONCERNS. *TT (NHTSA ID #10013273, MAY 20 2004)
• TSB #00434 -- ENGINE WILL CRANK BUT NOT START, ALSO MAKES NOISE WHILE CRANKING. 2.2 L61 ENGINE. *TT (NHTSA ID #10007528, JANUARY 01 2004)
• TSB #030601022 -- GUIDELINES FOR CYLINDER BORE LINER/PISTON SLEEVE REPLACEMENT ON THE L4 ECOTEC ENGINE. *TT (NHTSA ID #10011117, JANUARY 01 2004)
• TSB #3014 -- STALL, HESITATION, STUMBLE WITH NO DIAGNOSTIC TROUBLE CODES (DTCS). *TT (NHTSA ID #10008776, JANUARY 01 2004)
• TSB #01525 -- ENGINE STALL HESITATION STUMBLE WITH NO DIAGNOSTIC TROUBLE CODES (DTCS). *TT (NHTSA ID #10005461, JANUARY 01 2004)
• TSB #01353 -- ENGINE MISFIRE DUE TO INJECTOR FRETTING CORROSION. *TT (NHTSA ID #10007937, JANUARY 01 2004)
• TSB #01995 -- REPLACING A 02 OR 03 2.2L L61 WITH A 04 2.2L L61 ENGINE REPLACEMENT.*MR (NHTSA ID #10007055, JANUARY 01 2004)
• TSB #03064 -- ON-BOARD DIAGNOSTIC SYSTEM SOFTWARE UPGRADE - OBD SYSTEM IMPROVEMENTS. *TT (NHTSA ID #10005744, DECEMBER 01 2003)
• TSB #071103 -- THIS VME MESSAGE CONCERNS A CYLINDER BORELINER TOOL NOW AVAILABLE FOR THE L61 2.2 LITER ENGINE. THE TOOL IS REFERENCED IN SERVICE BULLETIN 030601018. THE PURPOSE OF THE TOOL IS TO EXTEND THE TOTAL SERVICE LIFE OF THE BLOCK. *TT (NHTSA ID #10003816, JULY 11 2003)
• TSB #030601018 -- NEW CYLINDER BORE LINER REPLACEMENT PROCEDURE. *TT (NHTSA ID #10002130, JUNE 01 2003)
• TSB #3433 -- SERVICE ENGINE SOON (SES) LIGHT AND SEVERE ENGINE MISFIRE ON CYLINDERS 1 AND 4 OR CYLINDERS 2 AND 3. *TT UPDATED 08-15-07. *KB (NHTSA ID #10017032, no date provided)
• TSB #1749019 -- INFORMATION ON TRANSFERRING ORIGINAL FUEL RAIL TO GOODWRENCH ENGINE. *AK (NHTSA ID #10019208, no date provided)
• TSB #3859 -- LOW OIL PRESSURE - INSPECT OIL FILTER FOR DAMAGE. *KB UPDATED 10/18/07. *NJ (NHTSA ID #10020923, no date provided)

ENGINE AND ENGINE COOLING:COOLING SYSTEM

• TSB #071503 -- COOLANT LOSE, EVIDENCE FLUID ON THE GARAGE FLOOR, ETC., OR COOLANT WARNING LIGHT COMING ON. *TT (NHTSA ID #10003789, JULY 15 2003)
• TSB #071003 -- THIS VME MESSAGE IS A WATER PUMP REPLACEMENT DUE TO A KNOWN CAM DRIVELINE. SOME CUSTOMERS MAY QUESTION ABOUT WHINE NOISE COMING FROM THE FRONT ENGINE AREA. *TT (NHTSA ID #10003815, JULY 10 2003)

FUEL SYSTEM, GASOLINE

• TSB #031103 -- COMPLAINTS THAT ARE ROOT CAUSED TO THE FUEL MODULE AND COMPLAINTS OF GAUGE ACCURACY THAT ARE ROOT CAUSED TO THE FUEL LEVEL SENSOR. *TT *JB (NHTSA ID #10001904, MARCH 11 2003)

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL

• TSB #3670 -- INFORMATION ON TRANSFERRING ORIGINAL FUEL RAIL TO GOODWRENCH ENGINE. *AK (NHTSA ID #10019240, no date provided)

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

• TSB #709 -- CAR ISSUES - FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT (NHTSA ID #10018156, SEPTEMBER 01 2005)

FUEL SYSTEM, OTHER

• TSB #3189 -- CRANK NO START, LOW OR NO FUEL PRESSURE. *TT (NHTSA ID #10010629, no date provided)

POWER TRAIN

• TSB #01604 -- 4T40E, 4T45E CHANGE IN APPEARANCE OF FORWARD, SECOND AND REVERSE CLUTCH WAVE PLATE. *TT (NHTSA ID #10007135, JANUARY 01 2004)
• TSB #030729005A -- CLUNK NOISE FROM FRONT END DURING LOW SPEED TURNS OR MANEUVERS. *TT (NHTSA ID #10004732, OCTOBER 01 2003)
• TSB #030730036 -- TRANSMISSION SLIPS IN 4TH GEAR, STUCK IN 2ND GEAR OR SES/TCS LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P0753, P0758, P1860, C1223, C1224 OR C1275 MAY BE SET. *TT (NHTSA ID #10004381, AUGUST 01 2003)
• TSB #030729005 -- CLUNK NOISE FROM FRONT END DURING LOW SPEED TURNS OR MANEUVERS. *TT (NHTSA ID #10002861, JUNE 01 2003)
• TSB #030730021 -- NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P1810, DIAGNOSTIC TROUBLE CODE P1815 SET. *TT (NHTSA ID #10002392, MAY 01 2003)
• TSB #020730050 -- ENGINEERING CHANGES TO THE VALVE BODY, PRESSURE REGULATOR VALVE, 2-3 ACCUMULATOR VALVE AND BORE FOR 2002-2003 MODEL YEAR 4T45E TRANSAXLES AND SUBSEQUENT OVERHAUL PROCEDURES WHICH AFFECT 1995-2001 MODEL YEAR TRANSAXLES. *TT (NHTSA ID #10000759, DECEMBER 01 2002)
• TSB #3447 -- 4T40E OR 4T45E WILL NOT SHIFT NO DIAGNOSTIC TROUBLE CODES. *TT (NHTSA ID #10017086, no date provided)

POWER TRAIN:CLUTCH ASSEMBLY

• TSB #01476 -- GRINDING/RATTLE NOISE WITH CLUTCH FULLY DISENGAGED. *TT (NHTSA ID #10004277, NOVEMBER 18 2003)

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/LINKAGE

• TSB #020731003A -- CLUTCH PEDAL BUZZ OR VIBRATION. *TT (NHTSA ID #10004285, MARCH 01 2004)
• TSB #020731003 -- CLUTCH PEDAL BUZZ OR VIBRATION. *TT (NHTSA ID #634966, MAY 01 2002)
• TSB #3915 -- CLUTCH PEDAL STAYS TO FLOOR. *TT (NHTSA ID #10019423, no date provided)

POWER TRAIN:MANUAL TRANSMISSION

• TSB #030731005 -- GRIND NOISE FROM MANUAL TRANSMISSION WHEN CLUTCH IS RELEASED. *TT (NHTSA ID #10004738, NOVEMBER 01 2003)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #070730025 -- INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. *NJ (NHTSA ID #10023942, OCTOBER 01 2007)
• TSB #020730039E -- FIRM TRANSMISSION SHIFTS, SHUDDER/CHUGGLE, TRANSMISSION WON'T DOWNSHIFT ON DECELERATION, SERVICE ENGINE SOON LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE P0742 SET. *TT UPDATE. *TT (NHTSA ID #10004756, AUGUST 01 2005)
• TSB #030730012A -- TRANSAXLE OR TRANSMISSION SLIPS, WON'T SHIFT, NO REVERSE, 2ND, 3RD OR OVERDRIVE, ERRATIC SHIFTS. *TT (NHTSA ID #10004722, AUGUST 01 2005)
• TSB #030729005 -- CLUNK NOISE FROM FRONT END DURING LOW SPEED TURNS OR MANEUVERS. THIS SERVICE BULLETIN REPLACES 030729005A. *EH (NHTSA ID #10012102, JULY 01 2004)
• TSB #030730021A -- NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P1810, DIAGNOSTIC TROUBLE CODE P1815 SET. *TT (NHTSA ID #10005579, NOVEMBER 01 2003)
• TSB #020730039C -- FIRM TRANSMISSION SHIFTS, SHUDDER/CHUGGLE, TRANSMISSION WON'T DOWNSHIFT ON DECELERATION, SERVICE ENGINE SOON LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE P0742 SET. *TT (NHTSA ID #10002840, JUNE 01 2003)
• TSB #01432 -- AUTOMATIC TRANSMISSION POOR ACCELERATION, PERFORMANCE. *TT (NHTSA ID #10004412, JANUARY 01 2003)
• TSB #020730039A -- FIRM TRANSMISSION SHIFTS, SHUDDER/CHUGGLE, TRANSMISSION WON'T DOWNSHIFT ON DECELERATION, SERVICE ENGINE SOON LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODE P0742 SET. *TT (NHTSA ID #10000773, DECEMBER 01 2002)
• TSB #3669 -- M86/M94 TRANSMISSION INFORMATION TO DISASSEMBLE THIRD FOURTH AND FIFTH GEAR. *AK (NHTSA ID #10019228, no date provided)
• TSB #3253 -- VEHICLE WILL NOT MOVE IN EITHER DIRECTION. TRANSMISSION MAY SHOW OVER FULL. P90 4T40E 4T45E NO MOVEMENT DRIVE OR REVERSE. CONVERTER MAY BE EMPTY OF FLUID. *TT (NHTSA ID #10017096, no date provided)

POWER TRAIN:AXLE ASSEMBLY

• TSB #020730048 -- PRESSURE CONTROL SOLENOID REPLACEMENT FOR 4T65-E, 4T40-E, AND 4T45-E TRANSAXLE/TRANSMISSION.*MR (NHTSA ID #10006166, NOVEMBER 02 2002)

ELECTRICAL SYSTEM

• TSB #04083 -- NO DIELECTRIC GREASE BEING APPLIED TO REAR LIGHT BULB SOCKET. *EH (NHTSA ID #10014001, NOVEMBER 01 2004)
• TSB #01592 -- 2003-2004 GENERATION 5 ONSTAR STEERING WHEEL CONTROL FUNCTION EXPLANATION. SIT BULLETIN 1416474. *TT (NHTSA ID #10005438, JANUARY 01 2004)
• TSB #01411 -- FALSE CODE B3785. SERVICE VME. *TT (NHTSA ID #10004215, NOVEMBER 18 2003)
• TSB #090903 -- THE BODY CONTROL MODULE (BCM) MAY SET A FALSE CODE OF B3785. GM VOICEMAIL LOG. *TT (NHTSA ID #10005059, SEPTEMBER 09 2003)
• TSB #03018 -- CUSTOMER SATISFACTION RECALL 03029 REGARDING FORWARD ELECTRICAL HARNESS WATER INTRUSION. *TT (NHTSA ID #10003492, JULY 18 2003)
• TSB #071703 -- PRODUCT FIELD ACTION 03029 - THE FORWARD ELECTRICAL HARNESS IS NOT ADEQUATELY SEALED. VME MESSAGE. *TT (NHTSA ID #10003796, JULY 17 2003)
• TSB #03029 -- FORWARD ELECTRICAL HARNESS WATER INTRUSION. *TT (NHTSA ID #10003393, JULY 01 2003)

ELECTRICAL SYSTEM:BATTERY:CABLES

• TSB #010803 -- POSITIVE BATTERY CABLE COULD INTERFERE WITH THE COOLANT FAN. GM VOICEMAIL EXPRESS. *TT (NHTSA ID #10005129, JANUARY 08 2003)

ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

• TSB #3648 -- HESITATION ON ACCELERATION AFTER INTERNAL ENGINE REPAIRS - CHECK INJECTOR HARNESS ORIENTATION. *TT (NHTSA ID #10018915, no date provided)

EXTERIOR LIGHTING

• TSB #3054 -- 04-08-42-004A. ADDITIONAL INFORMATION. LEFT OR RIGHT TAIL LAMP, BRAKE LAMP OR TURN SIGNAL IS INOPERATIVE. *TT (NHTSA ID #10009594, JANUARY 01 2004)

EXTERIOR LIGHTING:FOG LIGHTS

• TSB #030842002 -- FOG LAMPS DIM OR INOPERATIVE. *TT (NHTSA ID #10001262, MARCH 01 2003)
• TSB #021903 -- FRONT FOG LAMPS INOPERATIVE CAUSED BY CORROSION BUILDUP ON SPLICE NUMBER 113 AND/OR SPLICE NUMBER 213. *TT (NHTSA ID #10002558, FEBRUARY 19 2003)

EXTERIOR LIGHTING:TAIL LIGHTS

• TSB #071503 -- SERVICING THE REAR TAIL LAMP BULB OR SOCKET ASSEMBLY. *TT (NHTSA ID #10003790, JULY 15 2003)

EXTERIOR LIGHTING:TURN SIGNAL

• TSB #04083 -- REAR STOP/TURN SIGNAL LAMPS INOPERATIVE. PRODUCT SAFETY RECALL. *TT (NHTSA ID #10013519, JANUARY 01 2005)

VISIBILITY

• TSB #709 -- CAR ISSUES - FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT (NHTSA ID #10018156, SEPTEMBER 01 2005)

VISIBILITY:SUN ROOF ASSEMBLY

• TSB #030867009 -- SUNROOF WILL NOT OPEN OR CLOSE COMPLETELY DUE TO THE SUNROOF MOTOR. *TT (NHTSA ID #10005595, MARCH 01 2004)
• TSB #01598 -- SUNROOF SUPPLEMENTAL INFORMATION TO 03-08-67-009.*MR (NHTSA ID #10007178, JANUARY 01 2004)
• TSB #100703 -- JAMMED SUNROOF THAT WILL NOT OPEN OR A CLOSE COMPLETELY. GM VOICEMAIL LOG. *TT (NHTSA ID #10004981, OCTOBER 07 2003)
• TSB #030867004 -- PARTS AVAILABILITY FOR SUNROOF REPAIRS. *TT (NHTSA ID #10002878, JUNE 01 2003)

VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

• TSB #030864009A -- LEFT OUTSIDE BREAKAWAY MIRROR INOPERATIVE. *TT UPDATE. *TT (NHTSA ID #10004338, MARCH 01 2005)
• TSB #030864011A -- MIRROR VIBRATES AT HIGHWAY SPEEDS. *TT (NHTSA ID #10004339, SEPTEMBER 01 2003)
• TSB #022703 -- INOPERATIVE MANUAL OUTSIDE REARVIEW MIRROR(S). *TT *JB (NHTSA ID #10001851, FEBRUARY 27 2003)
• TSB #022503 -- OUTSIDE REARVIEW MIRROR ASSEMBLY APPEARING TO BE LOOSE OR A VIBRATION COMPLAINT. *TT *JB (NHTSA ID #10001845, FEBRUARY 25 2003)

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

• TSB #020843005 -- NEW WINDSHIELD WIPER MOTOR ASSEMBLY. *TT (NHTSA ID #10000727, DECEMBER 01 2002)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:BLOWER

• TSB #709 -- CAR ISSUES - FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT (NHTSA ID #10018156, SEPTEMBER 01 2005)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:HEATER CORE

• TSB #611 -- BINDING MODE VALVE-HVAC. *SC (NHTSA ID #10016265, NOVEMBER 01 2004)

STRUCTURE

• TSB #510 -- RIGHT FRONT SPEAKER RATTLE. *SC (NHTSA ID #10016221, OCTOBER 01 2003)
• TSB #081903 -- SCREW MISSING FROM THE A-PILLAR CEILING STRIP FRONT DOOR AUXILIARY. *TT (NHTSA ID #10003822, AUGUST 19 2003)

STRUCTURE:BODY

• TSB #040842004 -- TAIL LAMP BRAKE INOPERATIVE. THIS SERVICE BULLETIN REPLACES 040842004. *EH (NHTSA ID #10012606, APRIL 01 2004)
• TSB #040842004 -- TAIL LAMP/BRAKE LAMP INOPERATIVE (REPLACE BULB AND SOCKET). *MJ *TT (NHTSA ID #10008682, MARCH 01 2004)
• TSB #030859003 -- RIGHT FRONT SPEAKER RATTLE. *TT (NHTSA ID #10004781, OCTOBER 01 2003)
• TSB #071603 -- RATTLE OR BUZZ FROM THE RIGHT FRONT SPEAKER. *TT (NHTSA ID #10003793, JULY 16 2003)
• TSB #030863002 -- CARPET WET ON DRIVER'S SIDE. *TT (NHTSA ID #10012570, JULY 01 2003)
• TSB #030859001 -- RATTLE NOISE FROM FRONT CENTER OF DASH AREA. *TT (NHTSA ID #10001119, FEBRUARY 01 2003)
• TSB #11042002 -- PAINT APPEARING NOT TO MATCH ON THE FRONT AND/OR REAR FASCIA ASSEMBLY. *TT (NHTSA ID #10008612, NOVEMBER 04 2002)

VEHICLE SPEED CONTROL

• TSB #3115 -- HIGH IDLE WHEN CLUTCH IS DEPRESSED. *SC (NHTSA ID #10010198, JANUARY 01 2004)

VEHICLE SPEED CONTROL:CABLES

• TSB #012803 -- THROTTLE CABLE RATTLE NOISE HEARD IN THE FRONT OF DASH AREA, MOST NOTICEABLE AT THE CENTER DEFROSTER DUCT. GM VOICEMAIL EXPRESS. *TT (NHTSA ID #10005112, JANUARY 28 2003)

VEHICLE SPEED CONTROL:CRUISE CONTROL

• TSB #3481 -- CRUISE CONTROL SHUTS OFF WHEN THE HAZARDS ARE SWITCHED ON. *TT (NHTSA ID #10016717, no date provided)

EQUIPMENT

• TSB #050846006A -- INFORMATION ON UPGRADING CERTAIN ONSTAR GENERATION 5 ANALOG/DIGITAL-READY SYSTEMS TO ONSTAR GENERATION 6 DUAL-MODE (ANALOG/DIGITAL). *TT (NHTSA ID #10015018, SEPTEMBER 01 2005)
• TSB #3050A -- 02-05 ONSTAR EQUIPPED VEHICLES EMITTING BEEPING NOISE BEFORE CONNECTING TO ONSTAR. *TT (NHTSA ID #10009623, JANUARY 01 2004)
• TSB #3047 -- 99 THROUGH 05 YEAR VEHICLES, EQUIPPED WITH THREE-BUTTON ONSTAR SYSTEMS. *TT (NHTSA ID #10009607, JANUARY 01 2004)
• TSB #010846002C -- PROGRAMMING OF REPLACEMENT ONSTAR VEHICLE COMMUNICATION AND INTERFACE MODULES (VCIM). *TT (NHTSA ID #10002836, JUNE 01 2003)
• TSB #052903 -- CLARIFICATION OF SERVICE BULLETIN 02-08-44-012. CERTAIN STEPS IN THE SERVICE BULLETIN TO DISABLE OR ENABLE THE REMOTE KEYLESS ENTRY RADIO PERSONALIZATION FEATURE HAS BEEN DELETED IN THE TECH 2 SOFTWARE. CONCERN WILL BE UPDATED IN JULY REL (NHTSA ID #10003676, MAY 29 2003)
• TSB #10082002 -- THIS MESSAGE IS TO PROVIDE DEALERS WITH AN AWARENESS OF TWO NEW COMMANDS AVAILABLE VIA VOICE RECOGNITION IN THE ONSTAR GENERATION FIVE EQUIPPED VEHICLES. THE TWO COMMANDS ARE ONSTAR AND EMERGENCY. *TT (NHTSA ID #10013128, OCTOBER 08 2002)
• TSB #3044 -- GENERATION 5 ONSTAR STEERING WHEEL CONTROL FUNCTION. *TT (NHTSA ID #10010363, no date provided)

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

• TSB #040846004 -- ONSTAR SYSTEM INOPERATIVE ONSTAR SYSTEM STATUS LIGHT IS RED RADIO LOCKED IN PHONE MODE OR DTC B1000. *EH (NHTSA ID #10013440, JANUARY 01 2005)
• TSB #01759 -- XM RAPID ACTIVATION UTILIZATION. *MR (NHTSA ID #10006302, JANUARY 01 2004)
• TSB #01662 -- XM ERROR ON A RADIO DISPLAY. *TT (NHTSA ID #10007248, JANUARY 01 2004)
• TSB #09262002 -- CONCERNS THAT INVOLVE THE DISPLAY OF NO SIGNAL ON THE RADIO HEAD IN AN AREA THAT IS KNOWN TO HAVE GOOD XM RECEPTION. *MJ (NHTSA ID #10008629, SEPTEMBER 26 2002)

EQUIPMENT:ELECTRICAL:AIR CONDITIONER

• TSB #611 -- BINDING MODE VALVE-HVAC. *SC (NHTSA ID #10016265, NOVEMBER 01 2004)
• TSB #030138005A -- HARD TO CHANGE HVAC MODE OR TEMPERATURE SETTINGS. *TT UPDATE. *AR (NHTSA ID #10002377, AUGUST 01 2004)
• TSB #030138012 -- UNDERHOOD RATTLE OR GROWL NOISE WITH AIR CONDITIONER ON. *TT (NHTSA ID #10004363, MARCH 01 2004)
• TSB #01682 -- HVAC MODE CONTROL HARD TO CHANGE SETTINGS. *TT (NHTSA ID #10007242, JANUARY 01 2004)
• TSB #01685 -- HVAC MODE CONTROL HARD TO CHANGE SETTINGS. *TT (NHTSA ID #10006374, JANUARY 01 2004)
• TSB #01289 -- CHIRP OR SQUEAK ON ACCELERATION FROM STOP. SERVICE VME. *TT (NHTSA ID #10004098, NOVEMBER 18 2003)
• TSB #062703 -- FOLLOW UP TO A SERVICE VME SENT OUT ON MAY 29TH REGARDING THE AIR CONDITIONER SIX CVC COMPRESSORS AND POSSIBLE NOISES ASSOCIATED WITH THEM. *TT (NHTSA ID #10003724, JUNE 27 2003)
• TSB #061903 -- TROUBLESHOOTING/REPAIRING AIR CONDITIONING CHIRP OR SQUEAK DURING INITIAL ACCELERATION. *TT (NHTSA ID #10003707, JUNE 19 2003)
• TSB #060303 -- CONCERNS WITH REPLACEMENT OF THE 6CVC AIR CONDITIONER COMPRESSOR FOR A NOISE COMPLAINT. *TT (NHTSA ID #10003688, JUNE 03 2003)

UNKNOWN OR OTHER

• TSB #000089008E -- SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LI (NHTSA ID #10005527, OCTOBER 01 2005)
• TSB #020846010E -- PROGRAMMING ONSTAR MODULE FOR CANADIAN FRENCH VOICE RECOGNITION. *TT UPDATE. *TT UPDATED *EH (NHTSA ID #10002998, NOVEMBER 01 2004)
• TSB #04059 -- EMISSION LABEL - REPLACE - VEHICLE EMISSION CONTROL LABELS THAT ARE WRINKLED, DAMAGED, OR COMPLETELY MISSING. *NM (NHTSA ID #10010178, SEPTEMBER 01 2004)
• TSB #020730022B -- SERVICE ENGINE SOON LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0716 AND / OR P0717, P0730, P0753, P0758, P1860, P1887 OR OTHER MISCELLANEOUS TRANSMISSION TROUBLE CODES SET. *TT (NHTSA ID #10004755, OCTOBER 01 2003)
• TSB #000089008B -- SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LI (NHTSA ID #10004278, SEPTEMBER 01 2003)
• TSB #020844012A -- ENABLE OR DISABLE REMOTE KEYLESS ENTRY (RKE) RADIO PERSONALIZATION FEATURE. *TT (NHTSA ID #10002841, JUNE 01 2003)
• TSB #022803 -- CONCERN OF THE HEATER NOT BLOWING COLD AIR, THE MODE SETTING NOT OPERATING OR AIR SEEMINGLY ONLY TO COME OUT OF CERTAIN VENTS. *TT *JB (NHTSA ID #10001853, FEBRUARY 28 2003)
• TSB #01444 -- XM DEALER ASSISTANCE LINE INFORMATION. *TT (NHTSA ID #10004411, JANUARY 01 2003)
• TSB #020730022A -- SERVICE ENGINE SOON LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0716 AND / OR P0717, P0730, P0753, P0758, P1860, P1887 OR OTHER MISCELLANEOUS TRANSMISSION TROUBLE CODES SET. *TT (NHTSA ID #634931, SEPTEMBER 01 2002)
• TSB #4014 -- PARTS UPDATE - TIMING CHAIN TENSIONER DESIGN CHANGE. *KB (NHTSA ID #10021074, no date provided)