[ switch models ] 2003 Pontiac Aztek 2003 Pontiac Bonneville 2003 Pontiac Grand Am 2003 Pontiac Grand Prix 2003 Pontiac Montana 2003 Pontiac Sunfire [ switch years ] 2006 Pontiac Vibe 2005 Pontiac Vibe 2004 Pontiac Vibe 2000 Pontiac Vibe

2003 Pontiac Vibe

Technical Service Bulletins

There are also 2 Pontiac recalls » 6 defect investigations » 54 TSBs » for the Pontiac Vibe.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB number & contact your local dealer.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

ENGINE AND ENGINE COOLING

• TSB #030601020 -- AVOIDING OIL BAFFLE DAMAGE DURING OIL FILL PROCESS. *EH (NHTSA ID #10012558, NOVEMBER 01 2005)
• TSB #030605006 -- SULFUR ROTTEN EGG ODOR FROM EXHAUST SYSTEM. *EH (NHTSA ID #10012564, JULY 01 2003)
• TSB #3162 -- TECH 2 EVAP PURGE SEAL TEST INFORMATION. *EH (NHTSA ID #10010549, no date provided)
• TSB #3171 -- HIGH RPM POWER LOSS AFTER A COLD START. *EH (NHTSA ID #10010578, no date provided)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #02109 -- NO TECH 2 COMMUNICATION WITH ANY MODULES. *MJ (NHTSA ID #10007451, JANUARY 01 2004)
• TSB #01711 -- SLOW CRANK, HARD OR NO START. SERVICE VME. SIT BULLETIN 1458972. *TT (NHTSA ID #10006360, JANUARY 01 2004)
• TSB #1531076 -- REPLACEMENT ENGINES WILL HAVE AIR PORTS. *MJ (NHTSA ID #10008774, JANUARY 01 2004)
• TSB #3049 -- CRANKSHAFT MAIN BEARING SELECTION INFORMATION. *TT (NHTSA ID #10009655, JANUARY 01 2004)
• TSB #02127 -- SERVICE ENGINE SOON (SES) LIGHT DUE TO A REPEAT P1349 DIAGNOSTIC TROUBLE CODE (DTC). *TT (NHTSA ID #10007803, JANUARY 01 2004)
• TSB #01375 -- DRIVEABILITY ISSUES AFTER SHORT BLOCK REPLACEMENT. *TT (NHTSA ID #10004158, NOVEMBER 18 2003)
• TSB #3333 -- MISFIRE ON TURNS DUE TO FUEL CONTAMINATION. *TT (NHTSA ID #10017220, no date provided)

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

• TSB #180202 -- CUSTOMERS MAY COMMENT THAT THE ENGINE BREAKS UP OR LACKS PERFORMANCE ABOVE 7,000 RPMS. *TT (NHTSA ID #629810, FEBRUARY 18 2002)

ENGINE AND ENGINE COOLING:COOLING SYSTEM

• TSB #020602005 -- INFORMATION PERTAINING TO ENGINE COOLANT AND POWER STEERING FLUID USAGE. *TT (NHTSA ID #634772, JUNE 01 2002)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

• TSB #040605011A -- SULFUR (ROTTEN EGG) SMELL COMING FROM EXHAUST. *TT *JB (NHTSA ID #10014960, NOVEMBER 01 2005)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

• TSB #3202 -- EXHAUST ODOR (NHTSA ID #10010664, no date provided)

FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK

• TSB #03082005 -- INACCURATE FUEL TANK PRESSURE SENSOR READING. *EH (NHTSA ID #10014837, MARCH 08 2005)

FUEL SYSTEM, OTHER

• TSB #701 -- FUEL FILTER REPLACEMENT. GM TECH LINK. *TT (NHTSA ID #10015762, JANUARY 01 2005)

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

• TSB #3046 -- FUEL TANK PRESSURE PARAMETER INFORMATION. *TT (NHTSA ID #10009581, JANUARY 01 2004)
• TSB #3248 -- WITH TECH 2 SOFTWARE VERSION 24.009, 24.010, OR 25.001 INSTALLED, INACCURATE FUEL TANK PRESSURE SENSOR READINGS MAY BE NOTED DURING EVAP SYSTEM DIAGNOSIS. *TT (NHTSA ID #10014860, no date provided)

POWER TRAIN

• TSB #3117 -- MU4 MU5 TRANSMISSION CHARACTERISTIC UPSHIFT OR DOWNSHIFT ON GRADES. *SC (NHTSA ID #10009962, JANUARY 01 2004)
• TSB #01458 -- FWD SNAP CLICK CLUNK NOISE WHEN SHIFTING INTO REVERSE OR DRIVE. *TT (NHTSA ID #10004260, NOVEMBER 18 2003)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #100103 -- SNAPPING OR CLICKING NOISE WHEN THE TRANSMISSION IS SHIFTED FROM PARK TO REVERSE OR REVERSE TO DRIVE. GM VOICEMAIL LOG. *TT (NHTSA ID #10004998, OCTOBER 01 2003)
• TSB #01432 -- AUTOMATIC TRANSMISSION POOR ACCELERATION, PERFORMANCE. *TT (NHTSA ID #10004412, JANUARY 01 2003)
• TSB #280202 -- OWNERS MAY COMMENT THAT THEIR TRANSMISSION SHIFTS TOO EARLY WHEN ACCELERATING AT FULL THROTTLE WHEN THE ENGINE IS COLD. *TT (NHTSA ID #629850, FEBRUARY 28 2002)
• TSB #180202 -- INFORMATION ON USING T4 AUTOMATIC TRANSMISSION FLUID TO REDUCE HARSH SHIFT COMPLAINTS. *TT (NHTSA ID #629809, FEBRUARY 18 2002)
• TSB #3344A -- MU4 MU5 AUTOMATIC TRANSMISSION FLUID COLOR. *TT (NHTSA ID #10017238, no date provided)
• TSB #01183B -- MU4 MU5 AUTOMATIC TRANSMISSION FLUID COLOR. *MJ (NHTSA ID #10007621, no date provided)

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT

• TSB #010302 -- SUBJECT REGARDING REAR BEARING HUB BOLT TORQUE SAFETY RECALL. *TT (NHTSA ID #629861, MARCH 01 2002)

ELECTRICAL SYSTEM

• TSB #3052 -- PERFORMANCE PARTS SUPERCHARGER INSTALLATION INSTRUCTIONS SUPPLEMENT. *TT (NHTSA ID #10009661, JANUARY 01 2004)
• TSB #01625 -- 1.8 LV6 SUPERCHARGER ECU DIAGNOSTIC TROUBLE CODES AND P0115 STORED IN THE FACTORY POWER TRAIN CONTROL MODULE (PCM). *MR (NHTSA ID #10007180, JANUARY 01 2004)
• TSB #100103 -- NO AM RECPTION OR NO AM AND POOR FM RADIO RECEPTION. GM VOICEMAIL LOG. *TT (NHTSA ID #10004999, OCTOBER 01 2003)

ELECTRICAL SYSTEM:STARTER ASSEMBLY

• TSB #01202004 -- HARD TO START, SLOW CRANKING CONDITION IN AMBIENT TEMPERATURE BELOW 20 DEGREES F. GM VOICEMAIL EXPRESS. *TT (NHTSA ID #10009095, JANUARY 20 2004)

ELECTRICAL SYSTEM:WIRING

• TSB #01600 -- ADDITIONAL WIRING/CONNECTORS NOT USED FOR SUPERCHARGER INSTALLATION. *MJ (NHTSA ID #10007674, JANUARY 01 2004)

EXTERIOR LIGHTING

• TSB #290102 -- SUBJECT REGARDING AUTOMATIC LIGHT CONTROL OPERATION. *TT (NHTSA ID #629728, JANUARY 29 2002)

EXTERIOR LIGHTING:HEADLIGHTS

• TSB #611 -- AUTOMATIC HEADLAMP-OWNERS MAY COMMENT THAT THE AUTOMATIC HEADLAMP SYSTEM DOES NOT TURN THE HEADLAMPS ON WHEN THE VEHICLE IS STARTED DURING LOW LIGHT CONDITIONS. *SC (NHTSA ID #10016257, NOVEMBER 01 2004)

VISIBILITY:SUN ROOF ASSEMBLY

• TSB #040857001 -- SUNROOF WATER MANAGEMENT. *TT (NHTSA ID #10011134, JANUARY 01 2004)

STRUCTURE

• TSB #040849014 -- CIGAR LIGHTER HOUSING PULLS OUT OF DASH. *MJ (NHTSA ID #10008488, MAY 01 2004)

STRUCTURE:BODY

• TSB #0208111005A -- WHEEL HOUSE OPENING MOLDING DISCOLORED. *TT THIS SERVICE BULLETIN REPLACES 0208111005A. *EH (NHTSA ID #10000078, APRIL 01 2004)
• TSB #082603 -- THIS SERVICE VME CONCERNS CUSTOMERS COMMENTS THAT THE REAR WHEELHOUSE OPENING MOLDING OR THE REAR DOOR LOWER MOLDING IS DISCOLORED OR IT LOOKS LIKE IT'S BEEN SANDBLASTED. *TT (NHTSA ID #10003883, AUGUST 26 2003)
• TSB #0208110007 -- RATTLE FROM MULTI-PURPOSE TRUNK ORGANIZER. *TT (NHTSA ID #10000772, DECEMBER 01 2002)
• TSB #050202 -- SOME MODELS EQUIPPED WITH A SUNROOF MAY ENCOUNTER A WATER LEAK FROM THE A-PILLAR OR HEADLINER AREA. *TT (NHTSA ID #629757, FEBRUARY 05 2002)

STRUCTURE:BODY:DOOR

• TSB #040849002 -- CENTER CONSOLE DOOR WILL NOT STAY CLOSED. *TT (NHTSA ID #10011137, JANUARY 01 2004)

STRUCTURE:BODY:HATCHBACK/LIFTGATE

• TSB #050851002 -- REAR HATCH RUST. *TT (NHTSA ID #10017330, APRIL 01 2005)

VEHICLE SPEED CONTROL

• TSB #050302 -- CUSTOMERS MAY COMMENT THAT THE CRUISE INDICATOR IN THE INSTRUMENT CLUSTER COMES ON WHEN THE CRUISE SWITCH IS PUSHED ON, BUT THE SYSTEM WILL NOT SET WHEN THE LEVER IS PRESSED TO THE SET POSITION. *TT (NHTSA ID #636591, MAY 03 2002)
• TSB #042202 -- INFORMATIN ON THE CRUISE CONTROL RESUME FEATURE. *TT (NHTSA ID #636572, APRIL 22 2002)

VEHICLE SPEED CONTROL:CRUISE CONTROL

• TSB #3507 -- CRUISE CONTROL RESUME FUNCTION INTERMITTENTLY INOPERATIVE. *MJ (NHTSA ID #10007619, no date provided)

TIRES

• TSB #3801 -- PREMATURE OR IRREGULAR REAR TIRE WEAR. *TT (NHTSA ID #10018911, no date provided)

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

• TSB #040602 -- CUSTOMERS MAY COMMENT THAT THE SINGLE DISK CD PLAYER MAKES A SCRAPING NOISE WHILE THE CUSTOMERS EITHER BRAKING OR TURNING THEIR VEHICLE. *TT (NHTSA ID #637183, JUNE 04 2002)

EQUIPMENT:ELECTRICAL:AIR CONDITIONER

• TSB #082703 -- THIS VME STATES IF HVAC SYSTEM IS NOT GETTING COOL ENOUGH TO REFER TO SERVICE BULLETIN 02-01-37-006. *TT (NHTSA ID #10003884, AUGUST 27 2003)
• TSB #020137006 -- HVAC SYSTEM (HEATING, VENTILATION AND AIR CONDITIONING) SYSTEM DOES NOT GET COLD ENOUGH. *TT (NHTSA ID #10000188, OCTOBER 01 2002)
• TSB #050302 -- CUSTOMERS MAY COMMENT THAT THE AIR CONDITIONING SYSTEM DOES GET COLD ENOUGH. *TT (NHTSA ID #636592, MAY 03 2002)

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

• TSB #05062004 -- CIGARETTE LIGHTER HOUSING PULLING OUT OF THE DASH. *EH (NHTSA ID #10013213, MAY 06 2004)

UNKNOWN OR OTHER

• TSB #071203 -- EMERGING ISSUES TELECAST REGARDING THE AIRBAG WIRE TRAP; PAINT FLAKING OFF SEAT FRAMES; HVAC CLICKING; OIL CHANGES WITH POWER OIL MACHINE; WATER LEAKS; RATTLE NOISE; BACK BUMPER RUST; ETC. *TT (NHTSA ID #10003818, JULY 12 2003)
• TSB #100602 -- INFORMATION REGARDING THE JUNE EDITION OF EMERGING ISSUES FOR VARIOUS MODELS. *TT (NHTSA ID #637216, JUNE 10 2002)