[ switch models ] 2003 Saturn Ion 2003 Saturn L200 [ switch years ] 2006 Saturn Vue 2004 Saturn Vue 2002 Saturn Vue

2003 Saturn Vue

2003 Saturn Vue TSBs (Technical Service Bulletins)

There are also 3 defect investigations » 164 TSBs » for the Saturn Vue.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING

• TSB #070235001 -- INFORMATION ON SERVICING VEHICLES USING NEW IGNITION START SWITCH HOUSING (IGNITION LOCK MODULE) WITHOUT STEERING COLUMN LOCK. *KB (NHTSA ID #10021338, FEBRUARY 01 2007)
• TSB #060232002 -- NORMAL OPERATING CHARACTERISTICS OF ELECTRIC POWER STEERING (EPS) SYSTEM DURING EXTENDED LOCK-TO-LOCK (MAXIMUM STEERING WHEEL ROTATION) USAGE. *TT (NHTSA ID #10019478, DECEMBER 01 2006)
• TSB #030234002 -- SQUEAK OR SQUEAL NOISE WHILE TURNING VEHICLE. *TT (NHTSA ID #10004488, NOVEMBER 01 2003)
• TSB #030941002 -- NOISE FROM UPPER STEERING COLUMN BEHIND STEERING WHEEL. *TT (NHTSA ID #10001666, MAY 01 2003)

STEERING:COLUMN

• TSB #040235006 -- RATTLE NOISE FROM STEERING COLUMN. *MR (NHTSA ID #10006421, APRIL 01 2004)
• TSB #020235008A -- FLUID DRIPPING ON DRIVER'S FLOORMAT. *PH (NHTSA ID #10005288, NOVEMBER 01 2003)
• TSB #02T80 -- FLUID DRIPPING ON DRIVER'S FLOORMAT. *TT (NHTSA ID #10000379, NOVEMBER 01 2002)

SUSPENSION

• TSB #050308011 -- INFORMATION ON IDENTIFYING PROPER DESIGN LEVEL AND TORQUE SPEC CHANGE FOR FRONT LOWER CONTROL ARM. *TT (NHTSA ID #10017501, SEPTEMBER 01 2005)
• TSB #050308003 -- SERVICE MANUAL UPDATE - LOWER CONTROL ARM BALL STUD NUT TORQUE SPECIFICATION CHANGES. *TT (NHTSA ID #10017447, FEBRUARY 01 2005)
• TSB #02T47A -- SERVICE MANUAL UPDATE FOR 2002/2003 VUE CHASSIS SERVICE MANUALS REGARDING FRONT AND REAR ALIGNMENT SPECIFICATIONS. *TT (NHTSA ID #10000954, JANUARY 20 2003)
• TSB #02T47 -- SUBJECT REGARDING SERVICE MANUAL UPDATE FOR CHASSIS SERVICE MANUALS REGARDING FRONT AND REAR ALIGNMENT SPECIFICATIONS. *JG (NHTSA ID #633503, JUNE 01 2002)

SUSPENSION:FRONT

• TSB #030308001 -- SQUEAK NOISE FROM FRONT OF VEHICLE. *TT *MJ (NHTSA ID #10002176, FEBRUARY 01 2004)

SUSPENSION:REAR

• TSB #050309004 -- REAR SUSPENSION TORQUE SPECIFICATIONS. *TT (NHTSA ID #10017347, MAY 01 2005)
• TSB #04067 -- REPLACEMENT OF REAR LATERAL LINK ASSEMBLIES. *TT PARTS UPDATE. *TT MESSAGE UPDATE. *TT (NHTSA ID #10010623, NOVEMBER 05 2004)

SERVICE BRAKES, HYDRAULIC

• TSB #050523005 -- RATTLE NOISE FROM FRONT OF VEHICLE AT SLOW SPEEDS ON ROUGH SURFACES WHEN BRAKE PEDAL IS NOT APPLIED. *TT (NHTSA ID #10017374, JANUARY 01 2006)
• TSB #02T72 -- SERVICE INFORMATION ABOUT FIRST AND SECOND DESIGN BRAKE PIPE FLARES, UPDATED SERVICE PROCEDURES AND NEW TOOL FOR BRAKE PIPE REPAIR. *TT (NHTSA ID #10000196, OCTOBER 01 2002)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE

• TSB #3122 -- DELAY INTO REVERSE OR NO REVERSE AFTER VALVEBODY REPLACEMENT. *SC (NHTSA ID #10009968, JANUARY 01 2004)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS

• TSB #030524001 -- SERVICE INFORMATION REGARDING SATURN REAR DRUM WHEEL CYLINDER INSPECTIONS. *TT UPDATE. *TT (NHTSA ID #10005175, MARCH 01 2005)

SERVICE BRAKES, HYDRAULIC:ANTILOCK

• TSB #3690 -- ANTI-LOCK BRAKING SYSTEM (ABS) LIGHT ON DIAGNOSTIC TROUBLE CODE (DTC) C0551 AFTER REPLACING THE EBCM. *TT (NHTSA ID #10016557, no date provided)

ENGINE AND ENGINE COOLING

• TSB #040604008 -- SERVICE ENGINE SOON (SES) LAMP ILLUMINATED WITH DTC P0135 HO2S HEATER CIRCUIT PERFORMANCE BANK 1 SENSOR 1 AND/OR DTC P0155 HO2S HEATER PERFORMANCE BANK 2 SENSOR 1. *MR THIS BULLETIN REPLACES PREVIOUS 04-06-04-008. *EH (NHTSA ID #10006167, OCTOBER 01 2004)
• TSB #3116 -- SES ILLUMINATED ENGINE MISS/MISFIRE FEEL OR ROUGH IDLE. *SC (NHTSA ID #10009971, JANUARY 01 2004)
• TSB #3135 -- POP NOISE FROM ENGINE AREA DURING HEAVY THROTTLE INPUT. *TC (NHTSA ID #10010045, JANUARY 01 2004)
• TSB #0306123001 -- SLIGHT LOSS OF COOLANT OR LOW COOLANT LIGHT COMING ON WITH NO SIGNS OF EXTERNAL LEAKS. ALSO THE ENGINE MAY BE DIFFICULT TO START; ENGINE MISFIRE FOR SEVERAL SECONDS; AND/OR WHITE SMOKE OR COOLANT ODOR FROM THE TAILPIPE. *TT (NHTSA ID #10005574, NOVEMBER 01 2003)
• TSB #030602002 -- INSUFFICIENT HEAT, SERVICE ENGINE SOON (MALFUNCTION INDICATOR LAMP) TELLTALE ON, DIAGNOSTIC TROUBLE CODE P0128 SET. *TT (NHTSA ID #10001193, MARCH 01 2003)
• TSB #030602001 -- DESIGN CHANGE TO WATER PUMP USED ON L61 ENGINE. *TT (NHTSA ID #10001188, MARCH 01 2003)
• TSB #3117 -- REAR TOE CAM ADJUSTMENT NUT FOR SERVICE APPLICATIONS. *SC (NHTSA ID #10010098, no date provided)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #040603007 -- CRANK NO START, HARD START, STALLING, OR FRONT LAMPS INTERMITTENTLY INOPERATIVE SETTING ANY OF THE FOLLOWING DIAGNOSTIC TROUBLE CODES (DTCS) - P0629, B2752, B3722, N3717, B2717, B2600, B2722. *TT (NHTSA ID #10010449, OCTOBER 01 2004)
• TSB #040604074 -- SERVICE ENGINE SOON (SES) AND/OR REDUCED POWER LAMP ILLUMINATED, LIMITED THROTTLE RESPONSE FOLLOWING COLD ENGINE START UP, DIAGNOSTIC TROUBLE CODE (DTC) P0638. *TT (NHTSA ID #10010509, OCTOBER 01 2004)
• TSB #040601004 -- SERVICE INFORMATION REGARDING ENGINE SUPPORT DURING REMOVAL OF RIGHT FRONT ENGINE MOUNT ASSEMBLY. *TT (NHTSA ID #10006088, SEPTEMBER 01 2004)
• TSB #040604033 -- CHECK ENGINE LIGHT ON WITH P0440 OR P0442 STORED. *TT THIS BULLETIN REPLACES PREVIOUS BULLETIN DATED 05/01/2004. *TT (NHTSA ID #10007087, SEPTEMBER 01 2004)
• TSB #040605009 -- SERVICE INFORMATION REGARDING A POP/CLUNK NOISE FROM THE REAR OF THE VEHICLE ON INITIAL COLD START AND/OR DURING THE WARM-UP DRIVE CYCLE. *TT (NHTSA ID #10009360, JULY 01 2004)
• TSB #040601011 -- SERVICE MANUAL UPDATE FOR ENGINE BLOCK CLEARANCE, CYLINDER HEAD CLEARANCE AND FASTENER TORQUE SPECIFICATIONS. *TT (NHTSA ID #10006979, MAY 01 2004)
• TSB #040601010 -- BLUE SMOKE AT ENGINE START-UP. *TT (NHTSA ID #10006740, APRIL 01 2004)
• TSB #040604027 -- SERVICE MANUAL UPDATE - ADD DIAGNOSTIC TROUBLE CODE (DTC) P0504. *TT (NHTSA ID #10006725, APRIL 01 2004)
• TSB #040601009 -- OIL LEAK FROM FRONT COVER SEAL DURING EXTREMELY COLD WEATHER. *TT (NHTSA ID #10006739, APRIL 01 2004)
• TSB #040601001 -- OIL LEAKS FROM ENGINE AFTER SUB-FREEZING TEMPERATURES. *TT (NHTSA ID #10005199, JANUARY 01 2004)
• TSB #03065 -- ON-BOARD DIAGNOSTIC (OBD) SYSTEM SOFTWARE UPGRADE. *TT (NHTSA ID #10005158, DECEMBER 01 2003)
• TSB #030604043 -- MALFUNCTION INDICATOR LAMP (MIL) SERVICE ENGINE SOON TELLTALE LAMP ON, REDUCED POWER LAMP MAY ILLUMINATE WITH DIAGNOSTIC TROUBLE CODES P0121, P0221, AND/OR P2135. *TT (NHTSA ID #10003592, SEPTEMBER 01 2003)
• TSB #030090003 -- OIL FILTER CAP ASSEMBLY AND OIL FILTER ELEMENT DESIGN CHANGE. *TT (NHTSA ID #10003976, SEPTEMBER 01 2003)
• TSB #030601021 -- CRANK NO START AFTER BACKFIRE OR ROUGH RUN/HIGH IDLE AFTER ENGINE START. *TT (NHTSA ID #10003411, JULY 01 2003)
• TSB #030601017 -- TIMING CHAIN DESIGN CHANGE AND REVISED SERVICE PROCEDURES. *TT (NHTSA ID #10002122, JUNE 01 2003)
• TSB #030601014 -- SERVICE MANUAL UPDATE REGARDING THE USE OF SATURN SPECIAL TOOL J-42065 CRANK HUB HOLDING TOOL. *TT (NHTSA ID #10001667, MAY 01 2003)
• TSB #030601015 -- SERVICE MANUAL UPDATE FOR REMOVAL OF THE SEALER USED ON OIL PUMP GASKET DURING OIL PUMP INSTALLATION. *TT (NHTSA ID #10001668, MAY 01 2003)
• TSB #030604023 -- INTERMITTENT WHISTLE/CHIRP NOISE FROM ENGINE COMPARTMENT. *TT (NHTSA ID #10001202, MARCH 01 2003)
• TSB #030604016 -- SERVICE INFORMATION REGARDING THE ENGINE CONTROL MODULE (ECM) CONNECTOR AND TERMINAL LOCATIONS ON SATURN V6 ENGINES. *TT (NHTSA ID #10001199, MARCH 01 2003)
• TSB #020601016A -- (MIL) SERVICE ENGINE SOON TELLTALE ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTC) P0171 AND/OR P0174. *TT (NHTSA ID #10001540, MARCH 01 2003)
• TSB #030601007 -- BUZZING, GRINDING, OR GROWLING NOISE OR VIBRATION FROM REAR OF VEHICLE WHEN FUEL PUMP IS RUNNING. *TT (NHTSA ID #10001187, MARCH 01 2003)
• TSB #02T67 -- ROUGH IDLE, MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTC) P0171 FUEL TRIM SYSTEM LEAN AND / OR P0172 FUEL TRIM SYSTEM RICH. *TT (NHTSA ID #10000200, OCTOBER 01 2002)
• TSB #3433 -- SERVICE ENGINE SOON (SES) LIGHT AND SEVERE ENGINE MISFIRE ON CYLINDERS 1 AND 4 OR CYLINDERS 2 AND 3. *TT UPDATED 08-15-07. *KB (NHTSA ID #10017032, no date provided)
• TSB #3859 -- LOW OIL PRESSURE - INSPECT OIL FILTER FOR DAMAGE. *KB UPDATED 10/18/07. *NJ (NHTSA ID #10020923, no date provided)

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

• TSB #040137006 -- HEATER-VENTILATION-AIR CONDITIONING (HVAC) HISS-TYPE NOISE. *MR (NHTSA ID #10007551, MAY 01 2004)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

• TSB #050604059 -- FUEL NOZZLE SHUTS OFF INTERMITTENTLY OR PREMATURELY DURING FUEL FILL AND/OR SES LAMP ON WITH DTC P0446 EVAP VENT SYSTEM PERFORMANCE SET. *TT (NHTSA ID #10017570, SEPTEMBER 01 2005)

FUEL SYSTEM, OTHER

• TSB #701 -- FUEL FILTER REPLACEMENT. GM TECH LINK. *TT (NHTSA ID #10015762, JANUARY 01 2005)

FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM

• TSB #020604021A -- THE FUEL GAUGE IS DISPLAYING A FALSE LOW READING OR STUCK ON EMPTY. THIS CONDITION MAY BE INTERMITTENT. A DIAGNOSTIC TROUBLE CODE P0461 - FUEL LEVEL SENSOR PERFORMANCE MAY ALSO BE SET IN ECM MEMORY. *TT (NHTSA ID #10001544, MARCH 01 2003)
• TSB #02T38 -- FUEL GAUGE IS DISPLAYING A FALSE LOW READING OR STUCK ON EMPTY. THIS MAY BE INTERMITTENT. A DIAGNOSTIC TROUBLE CODE P0461 - FUEL LEVEL SENSOR PERFORMANCE- MAY ALSO BE SET IN ELECTRONIC CONTROL MODULE MEMORY. *JG (NHTSA ID #633464, JUNE 01 2002)

POWER TRAIN

• TSB #040730024A -- NO MOVEMENT IN DRIVE OR REVERSE WITH OR WITHOUT DIAGNOSTIC TROUBLE CODES (DTCS) P1758, P1758, P1882, P0841, P0741, P0742. *MJ THIS BULLETIN REPLACED PREVIOUS 04-07-30-024. *TT (NHTSA ID #10008481, NOVEMBER 01 2005)
• TSB #010418001C -- DRIVELINE CHARACTERISTICS FOR ALL-WHEEL DRIVE (AWD) AND FOUR-WHEEL DRIVE (4WD) SYSTEMS. *TT UPDATED *EH (NHTSA ID #10004281, JUNE 01 2005)
• TSB #050730003 -- INTERMITTENT HESITATION DURING VEHICLE LAUNCH. *TT (NHTSA ID #10017446, FEBRUARY 01 2005)
• TSB #040730036 -- REVISED VT25E (VTI) SPACER PLATE AVAILABLE. *TT (NHTSA ID #10009534, SEPTEMBER 01 2004)
• TSB #040417002 -- VIBRATION FELT IN SEATBACK OR ARMREST AT VEHICLE SPEEDS BETWEEN 48 TO 89 KM/H (30 TO 55 MPH). *TT (NHTSA ID #10009417, AUGUST 01 2004)
• TSB #040730011 -- ANAEROBIC SEALANT APPLICATION REQUIREMENTS FOR VT25E TRANSAXLE. SERVICE MANUAL UPDATE. *TT *MJ (NHTSA ID #10005977, APRIL 01 2004)
• TSB #030420003 -- MOAN / GROWL NOISE / VIBRATION FROM REAR OF VEHICLE WHEN TURNING. *TT (NHTSA ID #10002121, APRIL 01 2004)
• TSB #3035 -- NO FORWARD OR REVERSE GEARS OR LINE PRESSURE AFTER A VALVE BODY REPLACEMENT ON A VT25E TRANSAXLE. *TT (NHTSA ID #10009650, JANUARY 01 2004)
• TSB #3034 -- NO REVERSE AFTER CASE COVER ASSEMBLY REPLACED. *TT (NHTSA ID #10009583, JANUARY 01 2004)
• TSB #030730055 -- SERVICE INFORMATION REGARDING 2002 AND 2003 MODEL YEAR VT25E TRANSAXLE REPLACEMENT WITH 2004 MODEL YEAR VT25E TRANSAXLE. *TT (NHTSA ID #10004610, NOVEMBER 01 2003)
• TSB #030730034 -- REVISION TO SECOND COAST CLUTCH DISASSEMBLE/ASSEMBLE PROCEDURE. *TT (NHTSA ID #10004403, AUGUST 01 2003)
• TSB #020729004A -- IDLE VIBRATION AT IDLE AND/OR CLUNK AT START-UP. *TT (NHTSA ID #10003062, AUGUST 01 2003)
• TSB #030730026 -- SERVICE MANUAL UPDATE - REVISED TORQUE SPECIFICATION FOR VT23E (VTI) TRANSAXLE VARIABLE DRIVEN PULLEY BEARING RETAINER BOLTS. *TT (NHTSA ID #10002883, JUNE 01 2003)
• TSB #030730022 -- SERVICE MANUAL UPDATE ON TRANSAXLE OIL COOLER FLUSHING PROCEDURE FOR VTI TRANSAXLES. *TT (NHTSA ID #10002123, JUNE 01 2003)
• TSB #030730019 -- SPEEDOMETER FLUCTUATION AND VEHICLE HESITATION AT LAUNCH. *TT (NHTSA ID #10002349, MAY 01 2003)
• TSB #030729003 -- VIBRATION WITH THE TRANSMISSION IN PARK WHEN PARKED ON AN INCLINE. *TT (NHTSA ID #10002186, APRIL 01 2003)
• TSB #030730010 -- VT25E (VTI) TRANSAXLE OFF-VEHICLE REPAIR AUTHORIZATION. *TT (NHTSA ID #10001672, APRIL 01 2003)
• TSB #030731002 -- TORQUE CONVERTER CLUTCH (TCC) SHUDDER/VIBRATION AT 60-65 MPH. *TT (NHTSA ID #10001201, MARCH 01 2003)
• TSB #03T06 -- TRANSAXLE SHIFTER CABLE WHINE NOISE. *TT (NHTSA ID #10001126, FEBRUARY 01 2003)
• TSB #02T63 -- POWERTRAIN VIBRATION AT IDLE WITH THE AIR CONDITIONER ON AND TRANSMISSION IN REVERSE OR DRIVE. *TT (NHTSA ID #10000138, SEPTEMBER 01 2002)
• TSB #02T63 -- SUBJECT REGARDING POWERTRAIN VIBRATION AT IDLE WITH THE AIR CONDITIONER ON AND TRANSMISSION IN REVERSE OR DRIVE. *TT (NHTSA ID #635737, SEPTEMBER 01 2002)
• TSB #3251 -- TRANSAXLE SLIPS, NO THIRD GEAR, ENGINE FLARE DURING SHIFT AFTER TRANSAXLE SERVICE. *SC (NHTSA ID #10017133, no date provided)
• TSB #3400 -- VIBRATION FROM 30 MPH OR FASTER FELT IN THE DRIVERS SEAT OR FLOORBOARD AREA. *TT (NHTSA ID #10013535, no date provided)

POWER TRAIN:MANUAL TRANSMISSION

• TSB #070729001 -- MG3, M86 TRANSAXLE GRINDING/WHINING NOISE IN 3RD OR 4TH GEAR, EXCESSIVE ENGAGEMENT OR DISENGAGEMENT EFFORT WHILE SHIFTING INTO 3RD OR 4TH GEAR, WILL NOT SHIFT INTO EITHER 3RD OR 4TH GEAR. (REPLACE COMPLETE OUTPUT SHAFT ASSEMBLY). *KB (NHTSA ID #10021453, APRIL 01 2007)
• TSB #030729007 -- SERVICE INFORMATION REGARDING DESIGN CHANGE TO THE MANUAL TRANSMISSION SHIFT CONTROL HOUSING AND THE MANUAL TRANSMISSION SELECT AND SHIFT LEVER CABLES. *TT (NHTSA ID #10003994, OCTOBER 01 2003)
• TSB #030729001 -- SHUDDER/VIBRATION IN REVERSE. *TT (NHTSA ID #10001200, MARCH 01 2003)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #060730001 -- TRANSMISSION FLUID LEAK FROM RIGHT HAND AXLE SEAL AREA. *TT (NHTSA ID #10019511, JANUARY 01 2006)
• TSB #030730023A -- VEHICLE DOES NOT SHIFT OR MOVE AFTER RUNNING FOR A PERIOD OF TIME AND/OR CHECK ENGINE LIGHT IS ON AND DTC P0741 IS SET. *PH *SC (NHTSA ID #10005283, DECEMBER 01 2004)
• TSB #030730051 -- LOW SPEED COAST GRINDING NOISE AND/OR HESITATION AT VEHICLE LAUNCH - TECHNICAL SERVICE BULLETIN. *TT TO INCLUDE 2005 SATURN VUE. *EH (NHTSA ID #10004486, OCTOBER 01 2004)
• TSB #030730052A -- ENGINE FLARE DURING 2-3 SHIFT, MOST NOTICEABLE DURING LIGHT TO MODERATE ACCELERATION. THE CONDITION MAY BE CAUSED BY AERATION OF TRANSAXLE FLUID, RESULTING IN A DELAYED APPLY OF 3RD CLUTCH. CORPORATE BULLETIN NUMBER 03-07-30-052 *M (NHTSA ID #10005541, SEPTEMBER 01 2004)
• TSB #040730032 -- GRIND/RATTLE NOISE FROM TRANSAXLE IN PARK AND NEUTRAL AFTER AN EXTENDED COLD SOAK FOLLOWING CASE COVER REPLACEMENT OR OTHER INTERNAL TRANSAXLE OVERHAUL. *TT (NHTSA ID #10009420, AUGUST 01 2004)
• TSB #040730007 -- ON WHEEL MOVEMENT IN SNOW OR SLIPPERY SURFACES. *EH (NHTSA ID #10012701, FEBRUARY 01 2004)
• TSB #040730005 -- HISS/CHIRP NOISE IN PARK OR NEUTRAL. *MN (NHTSA ID #10005546, FEBRUARY 01 2004)
• TSB #030730041 -- SERVICE MANUAL UPDATE FOR VT25E (VTI) TRANSMISSION FRONT DIFFERENTIAL CARRIER THRUST WASHER. *TT (NHTSA ID #10004351, SEPTEMBER 01 2003)
• TSB #030730018 -- ENHANCED AUTOMATIC TRANSAXLE FLUID FILL PROCEDURE AND PLUG LOCATION/ IDENTIFICATION. *TT (NHTSA ID #10001669, MAY 01 2003)
• TSB #030730013 -- SERVICE MANUAL UPDATE FOR VT25E (VTI) TRANSMISSION FLUID PUMP PRESSURE RELIEF VALVE. *TT (NHTSA ID #10001546, MAY 01 2003)
• TSB #03C01 -- VTI TRANSAXLE SOFTWARE UPGRADE AND WIRING MODIFICATION. *TT (NHTSA ID #10000191, OCTOBER 01 2002)
• TSB #3669 -- M86/M94 TRANSMISSION INFORMATION TO DISASSEMBLE THIRD FOURTH AND FIFTH GEAR. *AK (NHTSA ID #10019228, no date provided)
• TSB #3633 -- REMANUFACTURED VT25E TRANSMISSION QUALITY ISSUES. INOPERATIVE, NOISE, SLIP, LOW PRESSURE OR LEAK RELATED CONCERN. *TT (NHTSA ID #10018547, no date provided)

POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

• TSB #030730016 -- TORQUE CONVERTER CLUTCH (TCC) SHUDDER/VIBRATION AT 40-45 MPH DURING LIGHT THROTTLE APPLICATION. *TT (NHTSA ID #10001548, MAY 01 2003)

POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

• TSB #040420002 -- SERVICE MANUAL UPDATE FOR RTV SEALANT USAGE ON THE REAR DRIVE MODULE. *TT (NHTSA ID #10006600, APRIL 01 2004)

POWER TRAIN:AXLE ASSEMBLY

• TSB #04020 -- SPECIAL POLICY ADJUSTMENT - EXTENDED TRANSMISSION WARRANTY COVERAGE FOR THE VARIABLE TRANSMISSION WITH INTELLIGENCE (VTI) TRANSMISSION. *MR (NHTSA ID #10006485, MARCH 01 2004)
• TSB #040420001 -- DRONE NOISE BETWEEN 50-75 MPH (80-120 KM/H). *MR (NHTSA ID #10006222, FEBRUARY 01 2004)
• TSB #030730048 -- SERVICE INFORMATION REGARDING TRANSAXLE POOR PERFORMANCE AFTER CASE COVER REPLACEMENT, DIAGNOSTIC TROUBLE CODE P1882 SET. *TT (NHTSA ID #10003944, OCTOBER 01 2003)
• TSB #03C05 -- LOOSE VTI TRANSAXLE CONVERTER HOUSING BOLTS FOR POTENTIAL EXTERNAL FLUID LEAK. *TT (NHTSA ID #10001195, MARCH 01 2003)
• TSB #02T32A -- SUBJECT REGARDING SERVICE INFORMATION ON TRANSAXLE ASSEMBLY REPLACEMENT PROGRAM. *JG (NHTSA ID #633428, AUGUST 01 2002)

ELECTRICAL SYSTEM

• TSB #030845003C -- REDUCED VEHICLE POWER, NO TRANSAXLE DOWN SHIFT, SES LIGHT ON, BUZZ NOISE FROM DOOR SPEAKERS/SPEAKERS INOPERATIVE, HEATER BLOWER MOTOR INOPERATIVE, VARIOUS DIAGNOSTIC TROUBLE CODES (DTC) SET. *TT (NHTSA ID #10003066, FEBRUARY 01 2006)
• TSB #050730006 -- SERVICE ENGINE SOON TELLTALE ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0742. *EH (NHTSA ID #10015047, MARCH 01 2005)
• TSB #01802A -- APP SENSOR 2 AND/OR TP SENSOR 2 SIGNAL CIRCUIT VOLTAGES DROP. *TT (NHTSA ID #10007965, JANUARY 01 2004)
• TSB #010104 -- SPEEDOMETER FLUCTUATION. *TT (NHTSA ID #10005198, JANUARY 01 2004)
• TSB #04E01 -- SPARK PLUG INSPECT/REPLACE - PRODUCT EMISSION RECALL. *TT (NHTSA ID #10003507, AUGUST 01 2003)
• TSB #030845002 -- REVISED 2.2L ENGINE CONTROL MODULE J1 & J2 CONNECTOR FACE DIAGRAM. *TT (NHTSA ID #10003503, AUGUST 01 2003)
• TSB #02T60 -- SUBJECT REGARDING STARTER REMAINING ENGAGED AFTER ENGINE START UP AND/OR ELECTRICAL ACCESSORIES BEING INOPERATIVE INTERMITTENTLY. *JG (NHTSA ID #633510, AUGUST 01 2002)

ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

• TSB #3648 -- HESITATION ON ACCELERATION AFTER INTERNAL ENGINE REPAIRS - CHECK INJECTOR HARNESS ORIENTATION. *TT (NHTSA ID #10018915, no date provided)

EXTERIOR LIGHTING

• TSB #07-08-42-002 -- DAYTIME RUNNING LAMPS (DRL) INOPERATIVE (INSPECT/REPLACE DRL RESISTOR). *KB UPDATED 7/11/08. *NJ (NHTSA ID #10021332, APRIL 01 2008)

EXTERIOR LIGHTING:HEADLIGHTS

• TSB #030842013 -- HEADLAMP ASSEMBLY LENS WITH HAZY OR CLOUDY COSMETIC APPEARANCE. *PH (NHTSA ID #10005284, NOVEMBER 01 2003)

VISIBILITY

• TSB #030864030 -- AFTERMARKET WINDOW TINTING SCRATCHED OR TORN. *TT (NHTSA ID #10003596, SEPTEMBER 01 2003)

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

• TSB #030864020 -- LEFT FRONT DOOR POWER WINDOW WILL NOT GO UP OR WORKS INTERMITTENTLY. *TT (NHTSA ID #10002884, JUNE 01 2003)

VISIBILITY:SUN ROOF ASSEMBLY

• TSB #02T79 -- SUNROOF MODULE DESIGN MODIFICATION. *TT (NHTSA ID #10000378, NOVEMBER 01 2002)

VISIBILITY:REARVIEW MIRRORS/DEVICES:INTERIOR

• TSB #030848003 -- INSIDE REAR VIEW MIRROR COMPASS WILL NOT DISPLAY ALL 8 COMPASS DIRECTIONS. *TT (NHTSA ID #10001670, MAY 01 2003)
• TSB #03T08 -- INSIDE REAR VIEW MIRROR COMPASS WILL NOT DISPLAY ALL 8 COMPASS DIRECTIONS. *TT (NHTSA ID #10001130, FEBRUARY 01 2003)

VISIBILITY:WINDSHIELD WIPER/WASHER

• TSB #030843003 -- WINDSHIELD WASHER NOZZLES DO NOT SPRAY WASHER FLUID. *TT (NHTSA ID #10002126, JUNE 01 2003)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM

• TSB #040138007 -- INFORMATION ON PROPER MODE SWITCH SETTING (BETWEEN DEFROST AND HEATER/DEFROST) TO PREVENT WINDOW MOISTURE AND HVAC CONTROLLER ASSEMBLY LOGIC REVISION. *TT (NHTSA ID #10010388, JUNE 01 2004)
• TSB #030138010 -- DEFROST MODE NOT CLEARING CONDENSATION IN LOWER RIGHT AND LEFT CORNERS OF WINDSHIELD. *TT (NHTSA ID #10002881, JUNE 01 2003)

STRUCTURE

• TSB #030730049 -- SPEEDOMETER FLUCTUATION. *TT (NHTSA ID #10004749, OCTOBER 01 2003)
• TSB #030138002 -- CONDENSATION FORMING ON THE INSTRUMENT PANEL (I/P) TOP COVER AND I/P ACCESSORY BEZEL. *TT (NHTSA ID #10001542, APRIL 01 2003)

STRUCTURE:BODY

• TSB #030858005 -- WIND NOISE AT HIGHWAY SPEEDS FROM BASE OF DRIVER SIDE (LEFT) A-PILLAR NEAR VIN PLATE AREA. *TT (NHTSA ID #10003993, AUGUST 01 2004)
• TSB #040864008 -- LEFT SIDE (DRIVER'S SIDE) OUTSIDE REARVIEW MIRROR CRACKING. *TT (NHTSA ID #10006982, MAY 01 2004)
• TSB #040850004 -- FRONT SEAT ARMREST ANGLED DOWN WHEN SEAT IS IN UPRIGHT POSITION. *TT (NHTSA ID #10006130, MARCH 01 2004)
• TSB #040864006 -- WIND AND/OR WHISTLE NOISE COMING FROM THE OUTSIDE REARVIEW MIRROR. *TT (NHTSA ID #10006085, MARCH 01 2004)
• TSB #040849004 -- SQUEAK OR RATTLE NOISE FROM INSTRUMENT CLUSTER. THE INSTRUMENT CLUSTER BEZEL MAY MAKE CONTACT WITH THE INSTRUMENT CLUSTER LENS, WHICH MAY CAUSE A SQUEAK OR RATTLE NOISE. *MN (NHTSA ID #10005542, FEBRUARY 01 2004)
• TSB #02T88 -- INFORMATION ON REMOVAL OF LUGGAGE CARRIER RAIL ASSEMBLY BOLTS STRIP OUT AND / OR HEADS BREAK OFF WHEN REMOVING WHILE INSTALLING RIA LUGGAGE CARRIERS. *TT (NHTSA ID #10000026, DECEMBER 01 2002)
• TSB #02T88 -- INFORMATION ON REMOVAL OF LUGGAGE CARRIER RAIL ASSEMBLY BOLTS STRIP OUT AND / OR HEADS BREAK OFF WHEN REMOVING WHILE INSTALLING RIA LUGGAGE CARRIERS. *TT (NHTSA ID #10000790, DECEMBER 01 2002)
• TSB #02T52A -- CLUNK POP OR CLICK NOISE WHEN TRANSITIONING BETWEEN ACCELERATION AND DECELERATION. *TT (NHTSA ID #10000203, OCTOBER 01 2002)
• TSB #02T65 -- LIFTGATE OUTSIDE HANDLE GASKET IS PROTRUDING OUT BETWEEN THE HANDLE AND BASE. *TT (NHTSA ID #10000202, OCTOBER 01 2002)
• TSB #02T73 -- FRONT CARPET EDGE EXPOSED NEAR FRONT DOOR HINGE PILLAR GARNISH MOLDING. *TT (NHTSA ID #10000195, OCTOBER 01 2002)
• TSB #02T56 -- SUBJECT REGARDING SERVICE INFORMATION REGARDING INSTALLATION OF 12V ACCESORY OUTLET TO LEFT REAR INTERIOR WHEEL OPENING SERVICE REPLACEMENT PANEL ASSEMBLY. *JG (NHTSA ID #633535, JULY 01 2002)

STRUCTURE:BODY:DOOR

• TSB #020864019 -- SQUEAK NOISE FROM FRONT INNER DOOR ARMREST/PULL HANDLE. *JG (NHTSA ID #633512, JUNE 01 2004)
• TSB #02T85 -- FOAM GASKET MATERIAL PROTRUDING OUT AND AROUND OUTSIDE DOOR HANDLE BASE. *TT (NHTSA ID #10000788, DECEMBER 01 2002)
• TSB #02T85 -- FOAM GASKET MATERIAL PROTRUDING OUT AND AROUND OUTSIDE DOOR HANDLE BASE. *TT (NHTSA ID #10000027, DECEMBER 01 2002)

LATCHES/LOCKS/LINKAGES

• TSB #03T09 -- DUE TO A DESIGN CHANGE IN THE DOOR AND LIFTGATE LATCHING SYSTEM, A SECOND DESIGN LATCH KIT IS USED TO SERVICE FIRST DESIGN 2002 AND 2003 INTERIM DOOR AND LIFTGATE LATCHING SYSTEMS. *TT (NHTSA ID #10001198, MARCH 01 2003)

LATCHES/LOCKS/LINKAGES:HOOD:LATCH

• TSB #040863003 -- SERVICE MANUAL UPDATE - HOOD OPENING PROCEDURE FOR INOPERATIVE HOOD LATCH. *TT (NHTSA ID #10006108, MARCH 01 2004)

SEATS

• TSB #030850009 -- FRONT SEAT CUSHION COVER LOWER EDGE LOOSE DUE TO BROKEN CUSHION DRAWSTRING. *TT (NHTSA ID #10001191, MARCH 01 2003)
• TSB #030850007 -- ARMREST ANGLED DOWN ON FRONT DRIVER OR PASSENGER SEAT WHEN SEAT IS IN UPRIGHT POSITION. *TT (NHTSA ID #10001186, MARCH 01 2003)

EQUIPMENT

• TSB #3050A -- 02-05 ONSTAR EQUIPPED VEHICLES EMITTING BEEPING NOISE BEFORE CONNECTING TO ONSTAR. *TT (NHTSA ID #10009623, JANUARY 01 2004)
• TSB #030852007 -- REMOTE KEYLESS ENTRY (RKE) TRANSMITTER RANGE POOR. *TT (NHTSA ID #10003901, OCTOBER 01 2003)
• TSB #3044 -- GENERATION 5 ONSTAR STEERING WHEEL CONTROL FUNCTION. *TT (NHTSA ID #10010363, no date provided)

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

• TSB #040844015 -- RETURN FORM FOR COMPACT DISCS (CDS) OR DIGITAL VERSATILE DISCS (DVDS) THAT ARE STUCK IN CD PLAYER WHEN RETURNED AS A CORE RETURN. *TT (NHTSA ID #10009362, JULY 01 2004)
• TSB #030844019 -- LOW VOLUME TICKING NOISE, RADIO VOLUME RESOLUTION OR CD WILL NOT LOAD/EJECT. *TT (NHTSA ID #10003911, MARCH 01 2004)
• TSB #040846001 -- SERVICE SUPPORT AND TECHNICAL ASSISTANCE FOR ONSTAR AND/OR XM RADIO. *MJ (NHTSA ID #10008703, MARCH 01 2004)
• TSB #030844016A -- COMPACT DISCS (CDS) SKIP IN SINGLE CD PLAYER. *TT (NHTSA ID #10005191, DECEMBER 01 2003)
• TSB #030844017 -- CHANGES TO THE AM/FM STEREO AND AUDIO DISC PLAYER RADIO ON-BOARD DIAGNOSTIC MODES AND CD LOAD OPERATION. *TT (NHTSA ID #10003588, SEPTEMBER 01 2003)
• TSB #030844010 -- SIX-DISC RADIO WILL NOT LOAD, EJECT AND/OR PLAY COMPACT DISCS (CDS). *TT (NHTSA ID #10002952, JULY 01 2003)

EQUIPMENT:ELECTRICAL:AIR CONDITIONER

• TSB #030137003 -- INOPERATIVE HVAC REAR DEFROST, RECIRC, OR AIR CONDITION (AC) MODE SWITCHES AND/OR REDUCED OR NO AIRFLOW FROM VENTS. *TT (NHTSA ID #10005190, DECEMBER 01 2003)
• TSB #030138017 -- SERVICE MANUAL UPDATE - REVISED AIR CONDITIONING COMPRESSOR DOES NOT OPERATE (CHART 6 ) DIAGNOSTIC FLOW CHART. *TT (NHTSA ID #10003977, SEPTEMBER 01 2003)
• TSB #030138014 -- SERVICE MANUAL UPDATE FOR AIR CONDITIONING EVAPORATOR TEMPERATURE SENSOR PERFORMANCE - CHART 11. *TT (NHTSA ID #10004349, SEPTEMBER 01 2003)
• TSB #030139003A -- INSUFFICIENT AIR CONDITIONER COOLING DURING PERIODS OF HIGH HUMIDITY. *TT (NHTSA ID #10002124, JUNE 01 2003)
• TSB #030139003 -- INSUFFICIENT AIR CONDITIONER COOLING DURING PERIODS OF HIGH HUMIDITY. *TT (NHTSA ID #10001192, MARCH 01 2003)

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

• TSB #040843008 -- SERVICE MANUAL UPDATE-WIPER/WASHER SYSTEMS SCHEMATICS. *SC (NHTSA ID #10016790, DECEMBER 01 2004)
• TSB #07012004 -- OIL LIFE SYSTEM RESET PROCEDURES-TRUCKS. BUICK TERAZZA 2005, GMC SIERRA DENALI 2002-2003, GMC B7 CHASSIS MEDIUM DUTY 2003-2005 AND GMC 560 C-SERIES 2003-2005 *SC (NHTSA ID #10014251, JULY 01 2004)

UNKNOWN OR OTHER

• TSB #03-00-89-033 -- TRAILER, RECREATIONAL AND DISABLED VEHICLE TOWING INFORMATION. *KB UPDATED 08-15-07. *KB UPDATED 10/09/07. *NJ UPDATED 4/3/08. *NJ (NHTSA ID #10021114, FEBRUARY 01 2008)
• TSB #030089033A -- TRAILER, RECREATIONAL AND DISABLED VEHICLE TOWING INFORMATION. *TT *SC (NHTSA ID #10003910, SEPTEMBER 01 2005)
• TSB #030089032 -- RECREATIONAL AND DISABLED VEHICLE TOWING INFORMATION. *TT (NHTSA ID #10003912, DECEMBER 01 2004)
• TSB #040089012 -- SATURN FIELD PRODUCT REMINDER- VEHICLE FIX IT RIGHT THE FIRST TIME ISSUES, PARTS RESTRICTION INFORMATION AND TECHNICAL BULLETINS RELEASED IN JANUARY, FEBRUARY, AND MARCH 2004. *MR (NHTSA ID #10006520, APRIL 01 2004)
• TSB #3119 -- NO SELECTION FIR SATURN WHEN PROGRAMMING A SATURN VEHILCLE. *SC (NHTSA ID #10010010, JANUARY 01 2004)
• TSB #030089025 -- CLARIFICATION OF LABOR CODES USED FOR REPROGRAMMING VEHICLE CONTROLLERS. VARIOUS MODELS INCLUDING THE 2004 L-SERIES. *TT (NHTSA ID #10004402, SEPTEMBER 01 2003)
• TSB #02SE03 -- SUBJECT REGARDING RECREATIONAL AND DISABLED VEHICLE TOWING INFORMATION. *JG (NHTSA ID #633520, JUNE 06 2002)
• TSB #02I09 -- SUBJECT REGARDING CALIFORNIA VEHICLE CODE REQUIREMENTS REGARDING TIRE CHAIN DISCLOSURE. VEHICLES THAT SHOULD NOT BE OPERATED WITH CHAINS. *JG (NHTSA ID #633369, JUNE 01 2002)
• TSB #4014 -- PARTS UPDATE - TIMING CHAIN TENSIONER DESIGN CHANGE. *KB (NHTSA ID #10021074, no date provided)