NHTSA — Service Brakes Problems

10.0

really awful
Crashes / Fires:
1 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
149,900 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2000 Volvo S40 brakes problems

brakes problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2000 Volvo S40:

Unsubscribe any time. We don't sell/share your email.

2000 Volvo S40 Owner Comments

problem #2

Jul 272018

S40

  • 148,800 miles

A D V E R T I S E M E N T S

The car has problems starting and takes a few tries before starting up. Have also had a problem where the car was in park with the parking brake engaged and the car was revving on its own. There have also been problems while the car has been slowing down on the freeway, specifically when the brakes are being engaged the car will attempt to move forward as though it is trying to push pass the fact that the brakes are being engaged. As well as the car will accelerate faster than the gas pedal is being pushed e.g when the gas pedal is slightly pushed the car will accelerate quickly as though the gas pedal was being pushed upon firmly.

- Wheatland, CA, USA

problem #1

Oct 022012

S40 4-cyl

  • 151,000 miles
I was stopped at a red light behind several cars. The light turned green and I took my foot off the brake, but did not put my foot on the accelerator. The car engine revved up and lurched forward despite me attempting to brake heavily. The brakes would not fully decompress causing me to rear end the vehicle in front of me. I purchased the car used with 134,100 miles. I noticed about 5 months after purchase that the engine would rev and the RPM's would remain high without pressing on the accelerator and the car will move approximately 10-15 mph without pressing on the accelerator. When roads are wet or when it has been raining, the car is difficult in braking and the brakes often "freeze" where the brake pedal cannot be depressed. Brakes were replaced, but the issue persists. Also, at times, the car engine continues to rev when pressing on the brakes. Lastly, the engine light came on, it was indicated via a diagnostic test that there was a misfire with one of the spark plug coils. All spark plugs and coils/ignition coils were replaced, engine light persisted. At the time the temp sensor and the thermostat was replaced as the ignition coils and spark plugs did not alleviate the issue. When a following diagnostic test was performed indicated that the coolant temp sensor has low voltage. Sometimes the car engine will turn, but the car will not fully turn on and I need to wait about 10 minutes (or until the fan turns off) before being able to attempt to start the car. Due to the issues with the car, the car cannot get an inspection sticker, and it does not seem safe to drive. Due to Massachusetts car laws, we cannot sell the car due to lemon law and the car is worth more than scraping. We also had a broken axel and coil that were replaced after hitting a pothole.

- Worcester, MA, USA

Not what you are looking for?