Print this page


really awful
Crashes / Fires:
21 / 0
Injuries / Deaths:
8 / 0
Average Mileage:
36,046 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2002 Chevrolet Silverado brakes problems

brakes problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2002 Chevrolet Silverado:

Unsubscribe any time. We don't sell/share your email.

2002 Chevrolet Silverado Owner Comments (Page 4 of 7)

« Read the previous 20 complaints

problem #74

Aug 042005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 19,600 miles


ABS sensors have failed on front wheels causing ABS to engage each time the vehicle slows to a stop. Stopping is unpredictable. One crash was narrowly avoided when the front brakes did lock up at the last second. Appointment has been scheduled to replace both front hubs at my cost.

- Montpelier, VT, USA

problem #73

Aug 012005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 2,500 miles
2002 Chevy 1500 Silverado anti lock brake slow speed stoping brake pedal goes to the floor, anti lock brakes activate, truck won't stop, grinding type noises coming from brakes, at 25,000 miles all 4 rotors were badly rusted and worn.replace all rotors and shoes, still had problem. Had all speed sensors on meter, shows no problem.have read articles and complaints about this problem with this model and year and that Chevy had recall in Canada but not U.S. I have came close to rear ending cars in front of me.this vehicle is a hazzard and should be recalled.

- West Newton, PA, USA

problem #72

Aug 062005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 75,700 miles
Upon stopping at very slow speed, the ABS brakes felt like they activated, causing loss of braking power, causing collision with parked vehicle. Vehicle was brought into shop, diagnostic showed faulty front/left speed sensor. This part was replaced, vehicle was road tested, and all appeared to be okay. After driving less than 300 miles, vehicle is experiencing same problems.

- Hamden, CT, USA

problem #71

Aug 082005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 15,000 miles


2002 Chevy Silverado 4X4, 60,000 miles, anti-lock brakes activate at low speeds (5-0 mph)when stopping. Was to the dealer several times for this problem when vehicle was new, with unsatisfactory results, (problem was temporarily fixed, but ultimately returned). The problem remains to this day. I have heard of many others with this same problem, even a recall in Canada to correct this problem. Jeff plungis of the detroit news wrote an article in late may/early June about this ongoing problem GM has. So far there has been no damage or accidents because of this problem, just a few close calls. But my wife refuses to drive the truck. What are the chances GM will own up to this failure and recall these vehicles to finally make the correct repairs.

- Ray, MI, USA

problem #70

May 262004

Silverado 4WD 8-cyl

  • Automatic transmission
  • 32,000 miles
The brakes are working poorly. Pedal goes to the floor before it stops the vehicle. The caller says it has been like that since he purchased the vehicle. Dealer will not fix it for free. Manufacturer has not been contacted yet. When the brakes were applied the consumer felt a vibration as if the ABS activated.

- Roanoke, VA, USA

problem #69

Jul 012005

Silverado 6-cyl

  • Automatic transmission
  • 45,000 miles
I currently am having problems with the ABS sensor on my 2002 Chevy Silverado 1500 pickup truck. I have done some research and found an investigation that is open on this problem. The truck is having the same problems as described in the investigation report, and on several occasions in the past month or so the truck has had trouble stopping. I am taking it in for service tomorrow, as there is no recall on this. I would like add my complaint to the file to make you aware of another person experiencing this problem. There are currently 45,000 miles on this truck. I am submitting 15 failures, but it has trouble almost every time I stop, and has for the past month. Unfortunately I didn't have the money to fix it until now, so I only drove it sparingly.

- Beaver Falls, PA, USA

problem #68

Jun 172005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 19,300 miles


In may of 2005 while approaching a stop light at slow speed, on dry pavement, the ABS brakes, in my 2002 Chevrolet Silverado, activated causing the vehicle to require a greater than normal stopping distance. No accident occurred. The incident seemed isolated. Then in June, the problem continued and became more and more frequent. When pulling into a parking space at a slow speed I was just barely able to come to a stop within the confines of the parking space. Although no particular accident has occurred I strongly feel that this is a very unsafe and potentially dangerous problem. The vehicle has only 19,000 miles on it. The vehicle was brought to hadad Chevrolet in pittsfield, MA where we were told it would cost between $270 and $920 to fix. We have called Chevrolet to see if the manufacturer is responsible for fixing the problem but they had not even heard of the problem. The problem has not yet been corrected as we are investigated the manufacturer's responsibility and the most economical repair for our problem.

- Pittsfield, MA, USA

problem #67

Jun 242005

Silverado 4WD

  • Automatic transmission
  • miles
Anti-lock brakes are kicking in at low rate of speed making it nearly impossible to stop quickly.

- Sanford, MI, USA

problem #66

Jul 202005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 30,000 miles
At low speeds the front anti-lock brakes on my 2002 cheverlot Silverado 4WD truck engage making it very difficult to stop. If not for the emergency brake I would have hit a car pulling into the gas station.

- Williamsville, NY, USA

problem #65

Jul 142005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 14,000 miles
Contact stated brakes were not working correctly. All 4 rotors were rusted after 14,000 miles. He noticed this approximately 2 weeks ago after taking the truck on a trip. When he took vehicle to service dealer he was told that all of the rotors were rusted. He did not notice any problems prior to this because he did not drive this truck very much. A 2002 Chevrolet Silverado with only 14,000 miles on it. Has been on the internet and saw where he saw similar complaints about brakes failing.

- Baltimore, MD, USA

problem #64

Feb 212002

Silverado 6-cyl

  • Automatic transmission
  • 800 miles


The consumer states that the brakes on his 2002 Chevrolet Silverado are sluggish and making noise and they feel like they are grabbing. The vehicle has been in the shop 3 times for the brakes. They brakes feel like they do not stop when applying brake pressure. The brake pedal feels spongy. The dealer changed three rotors and brakes pads. The dealer could not get the rotor off on the back and the consumer did not know what was wrong with it. The dealership broke the ABS sensor. The consumer took the truck back to the dealership and they replaced the sensor. The owner of the truck has never contacted GM. The vehicle is regularly maintained and serviced. The consumer has expericined brake problems for 3 years.

- Mantua, OH, USA

problem #63

Jun 242005


  • miles
2002 Chevrolet Silverado developed a problem with the anti lock brake system.

- Kinsman, OH, USA

problem #62

Jun 212005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 46,000 miles
The consume states that the parking brake is not holding on 2002 Chevrolet Silverado. This has been an issue for about a month. The owner has taken the truck to the dealership, and they classified it as a normal wear item. They dealer is not going to replace this for free. There is a recall on the manual transmissions but not the automatic. But the owner says that they share the same parking brake system. The owner has contacted the manufacturer, and they were aware of the problem, , and stated that there was no recall. NHTSA recall 05V161000. On manual transmission. The owner was going to have this fixed, but it will be at his expense. There were no prior problems with the truck. There is about 60% of the brake lining left on the back brakes. The owner is pushing the brake to the floor and it is not working.

- Carnation, WA, USA

problem #61

Jun 272005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 36,000 miles
When applying the brakes, the pedal kicks up and the vehicle is difficult to stop. The stopping distance has at least doubled. I found that the anti-lock brake speed sensor quit working with 37000 miles on the truck. I unplugged the sensor and the brakes are working fine (without anti lock brakes).

- Rixford, PA, USA

problem #60

Mar 102005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 50,615 miles
Prior to the crash I'll describe, I noticed that the antilock brakes on my truck would engage randomly at low speeds, even though the road was clear and dry. I never received any indication from indicator lights or the truck's status display that there was a malfunction in progress. Until the incident below, braking control always returned within a few seconds and seemed to pose no safety threat. On this particular evening, they had performed without incident all the way home from work. I pulled into my driveway and into my garage. Upon entering the garage proper, the antilock brakes engaged. The garage floors (and driveway) were both clear of any snow, ice, or liquids. When the antilock brakes took control, it released the brakes and locked the brake pedal in such a way that I could not regain control. This time, I was unable to push the pedal down. My vehicle subsequently stuck the workbench along the back wall of my garage. The impact pushed the entire garage wall out almost 12 inches, including the cement block foundation. Fortunately, there was no damage to the vehicle. However, the damage to the garage remains. To correct the failure, a mechanic at a local dealership removed the fuse that controls the antilock brake functions, essentially disabling the antilock system. Due to the nature and location of the antilock sensors (in the wheel bearings), repairs are not financially feasible at this time. The truck's brakes function normally with the antilock system disabled. I believe that this complaint directly relates to NHTSA action number PE05020.

- Manlius, NY, USA

problem #59

Jun 052005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 38,000 miles
The anti- lock brake system activated at low speeds when there were no slippery conditions. Consumer can hear the ABS when it comes on. It results in extended stopping distance.

- Rome, NY, USA

problem #58

Nov 152004

Silverado 4WD 8-cyl

  • Automatic transmission
  • miles
The cosumer owns a 2002 Chevrolet Silverado 1500. The problem is the ABS. When getting down to 2-3 mph the ABS comes on, and will almost cause an accident. There is an open NHTSA investigation, PE05020. Parts in the ABS have replaced.

- Oswego, NY, USA

problem #57

Mar 012005

Silverado 4WD 8-cyl

  • Automatic transmission
  • miles
The consumer stated the ABS failed. The ABS kicked in when it was not needed at low speeds. No warning lights illuminated. The vehicle has not been to a service dealer yet. The consumer was waiting to see what happens with the investigation of the ABS system.

- Fulton, NY, USA

problem #56

Feb 262005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 19,900 miles
Per NHTSA action number PE05-020, I have experienced on more than one occaision the failures described in the aforementioned bulletin. Failures occurred subsequent to dealership's performing the following work under warranty: Replacement of failed front end bearings, seals, pinions and related components. Dealership's position has been one of denial and dismissal of the complaint. Chevrolet only offers reimbursement for repairs if this becomes a recall issue. Because this is a braking issue and a safety issue not only for my family and self, but other motorists, it obviates justification of recall status.

- Superior, WI, USA

problem #55

Jun 282005

Silverado 4WD 8-cyl

  • Automatic transmission
  • 112,000 miles
2002 Chevrolet Silverado 1500, the vehicle brakes and rotors are excessively worn out and corroded to the point of failure, the emergency brake will not stop or hold the vehicle in place, and the consumer has only put 12,000 miles on the vehicle, consumer has contacted the manufacturer. They told consumer that there was no recall on this issue, the manufacturer gave the consumer a service request order # 1-346253-537. There were no other safety issues with the vehicle at this time.

- Hartford, CT, USA

Read the next 20 complaints »

Not what you are looking for?