Print this page

5.4

fairly significant
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
17,143 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

1995 Ford F-250 exhaust system problems

exhaust system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 1995 Ford F-250:

Unsubscribe any time. We don't sell/share your email.

1995 Ford F-250 Owner Comments

problem #7

Nov 152004

F-250 4WD 8-cyl

  • Automatic transmission
  • 120,000 miles

A D V E R T I S E M E N T S

The exhaust manifold had a broken bolt which caused fumes to enter into the vehicle. Consumer has not been involved in any accident to cause the bolt to break. Exhaust manifold warped causing an exhaust leak which resulted in all exhaust to enter the vehicle's cab.

- Seattle, WA, USA

problem #6

Sep 191996

F-250

  • miles
The "Y" pipe has failed twice, allowing exhaust to enter the engine compartment. First took it to an out of town dealer who said he did not have parts to fix but warned me to keep fresh air coming into the cab.. the local dealer replaced once and the second time said it was no longer covered and besides did not know how to fix the problem. Suggested I take it to a private muffler shop who told me that Ford was well aware of the problem, that it was dangerous because it would leak carbon monoxite into the cab and suggested I take it back to the dealer and push for a replacement. Dealer gave me a form to fill out but have never heard back. I took vehicle to another dealer, and they told me a similar story and said if it was a California vehicle Ford would stand by it, but because it was not, I would have to take it to a muffler shop and have a custom one built. They also warned me to be careful to keep air coming in thru the heater/ac so I would not get carbon monoxide poisoning and/or fall asleep.

- Azalea, OR, USA

problem #5

Nov 152000

F-250

  • miles
Cracked manifold on each side in three places.

- Washington, DC, USA

problem #4

Apr 132000

F-250 4WD

  • miles

A D V E R T I S E M E N T S

The vehicle is not provided with exhaust manifold gaskets which causes fastener failures causing exhaust leakage directly from the cylinders. The exhaust then enters the cab of the truck.

- Greenwood, AR, USA

problem #3

Oct 221999

(reported on)

F-250 4WD

  • miles
The dealer has replaced left and right manifols. This occured in 1997, 1998, and now in 1999. I was told by other ownners this may happen on my vehicle before it happened. This is third time, once just the gasket, one side was covered by dealership, the other side I had to pay out of my pocket @ $449.

- Norwalk, OH, USA

problem #2

Jul 241997

F-250

  • Automatic transmission
  • miles
When driving the exhaust manifold starts to make a hissing noise. The manifold has been replaced 3 times. Dealer says that there is a bad batch of manifolds.

- Malabar, FL, USA

problem #1

Sep 071997

F-250

  • miles
Exhaust manifold has a leak, located on the inside by the motor, not near muffler. When sitting fumes come through the air conditioner. Dealer contacted, and stated repairs can be made at consumer's expense.

- Grant, FL, USA

Not what you are looking for?