The contact owns a 1996 Ford Mustang. The contact stated that on June 4, 2010, while driving at 25 mph, the intake manifold cracked, the antifreeze spilled and he lost control of the vehicle. The contact had to use the emergency brake to stop the vehicle. The current and failure mileages were approximately 136,000.

- Spokane, WA, USA

Consumer 1996 Ford Mustang intake manifold cracked and could not be repaired under warranty. The consumer felt that Ford should cover the entire cost of repair plus the monies spent on borrowing vehicles to get to work.

- Chisholm, MN, USA

I have 96 Mustang GT, at 21000 miles intake manifold cracked in the rear, Ford replaced for free, now at 79000K the intake has cracked again in the front, the first time I was told it was a silent recall, before I go back to Ford, again does Ford have to fix it or do I?

- Covina, CA, USA

Consumer was driving approximately 35 mph when suddenly the head gasket blew out. Antifreeze started to pour out of the muffler.

- Lewisville, TX, USA

While driving the intake manifold blew. This problem was caused by antifreeze leaking from the intake manifold. Smoke started to accumulate inside the vehicle from the A/C vents. The dealership was notified, but did not resolve the problem.

- Wyandotte, MI, USA

I purchased a 96 Mustang GT 4.6, in 1998 and in 2001 the plastic intake manifold cracked so I did some research into this problem and it turns out 90% of all 96 and 97 Mustangs with the junk plastic intake manifold cracked. I call my local Ford dealer and it costs $904 that is outrageous. Why was there never a recall and why do you charge such an un comprehendable ammount of money to replace it"??"

- Kihei, HI, USA

Consumer was complaining about plastic intake manifold. It just didn't stand up to the heat that was created when in use. Consumer made several attempts to get this resolved. However, the consumer had not received any assistance from the manufacturer.

- Holly Springs, MS, USA

Consumer was unable to start vehicle. Dealerships mechanic determined that the problem pertained to an intake manifold leak. The problem was not resolved. Vehicle originally lost power at 55 mph, vehicle didn't restart. Vehicle was towed and found that one valve was leaking and head gasket was blown. Vehicle has 100,000 miles on it.

- Jasonville, IN, USA

Engine front cover gasket issues. My 1996 V6-3.8L with approximately 57,000 miles required a new front gasket cover. This is the same issue owners of 1994-1995 models had and filed suit against Ford for and won.

- Raleigh, NC, USA

The plastic intake? cracked Ford recall repaired it. 1st dealership notified wayne morris Ford in perry, ga would not help at all. 2nd dealership notified warner robins Ford found the recall and repaired it a no charge. Also have problems with the front end and steering wheel vibrating/shaking at various speeds. I have replaced the rotors and brake pads which has helped a little. But can not get any answers or a resolution from any mechanic to date.

- Perry, GA, USA

Started car, check engine light came on, then smoke came out of tail pipe. Dealer told consumer he needed a lifter and a rocker, however parts fell off when they did a test drive, dealer found a new motor was needed.

- Chicago, IL, USA