pretty bad
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
6,653 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2004 Kia Sorento brakes problems

brakes problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2004 Kia Sorento:

Unsubscribe any time. We don't sell/share your email.

2004 Kia Sorento Owner Comments

problem #1

Aug 072004

Sorento 4WD 6-cyl

  • Automatic transmission
  • 6,653 miles


I have 3 major failures w/my new Kia Sorento '04 since buying it in Dec '03 from peak Kia in colo.the 1st failure, the anti lock brake control unit was replaced in Dec '03.the brakes engaged when they shouldn't. I have complained many times about a road vibration at 68-72 mph. Dealer has seen my car 5 times for this problem. The 1st time the dealer said they couldn't find anything wrong, but said they had only driven it to 63 mph. The 2nd time I took it in, problem had been noted in a number of Sorento's nationwide & they were going to need to change the drive shaft. 3rd time for this same problem & upon picking up the car found out that they didn't change the drive shaft, but greased it w/special heavy duty grease &turned it 180 degrees. I asked why hadn't changed drive shaft, & they said the manufacturer's technical service bulletin recommended this procedure 1st. The vibration has slowly returned. I called the dealer & they said they would put me on list to drive car w/regional service mgr. They called & said he was in town, so I went to drive car with local service mgr & regional service mgr.they felt there was nothing highly noticeable about vibration & said it could be the roads. They told me to call back if it got worse. In August '04, were driving & my car began to smoke. A huge trail of smoke coming out from under car. We pulled to the side of the road & called 24hr towing from the dealer. Car towed to osborn Kia in colo. & found that the entire rack & pinon steering mechanism & gear box had blown up throwing steering fluid on the engine. So much smoke I thought the car was on fire! what could have happened if our steering would have gone out in a tight turn! the dealer's service mgr said in all of his year's the dealership had never replaced this part. The entire steering system replaced, the car is now vibrating once again at 68-71mph. I am going to contact the dealer but am concerned they will not do anything to fix this.

- Highlands Ranch, CO, USA

Not what you are looking for?