2018 Mini Cooper

97 Technical Service Bulletins (TSBs)

TSB List for the 2018 Mini Cooper

The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.

STEERING

  • TSB #M320117

    NHTSA ID #10146728

    • Date Announced: JUNE 01 2017
    • Additional Info: How to Fix

    Summary: "CHECK ENGINE LIGHT (MIL) IS ON. The Check Engine Light (MIL) is on. SAE (Society of Automotive Engineers) fault C0526 ""Steering Angle Sensor Module"" will be stored in the fault memory (readable only with an aftermarket OBD scan tool). On

    More Information »

BRAKES (PWS)

  • TSB #M340317

    NHTSA ID #10138415

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: PREMATURE REAR BRAKE WEAR: ehicles with total mileage below approx. 12,500 may experience premature wear of the rear brakes.

    More Information »

ENGINE (PWS)

  • TSB #M120618

    NHTSA ID #10143573

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: JCW ENGINE TUNING KIT - ENGINE LOSS OF POWER IN STOP-AND-GO DRIVING: The engine may lose power if the vehicle is decelerated, in gear, to a near stop and then accelerated again.

    More Information »

  • TSB #M120917

    NHTSA ID #10143575

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: THE ENGINE STARTER INTERMITTENTLY DOES NOT CRANK OVER: The engine will not start, either consistently or intermittently.

    More Information »

  • TSB #M120818

    NHTSA ID #10138412

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: DRIVE WARNING CCM MESSAGES: Check Control Massages (CCM) displayed:

    More Information »

  • TSB #M111316

    NHTSA ID #10146800

    • Date Announced: DECEMBER 01 2016
    • Additional Info: How to Fix

    Summary: Service Action: B38 Engine - Check and Replace Crankshaft Guide Bearing. The upper crankshaft guide bearing may wear out prematurely. The wear on the guide bearing can cause the clutch pedal to malfunction during shifting. The Engine Malfun

    More Information »

ENGINE AND ENGINE COOLING

  • TSB #M121318

    NHTSA ID #10150059

    • Date Announced: SEPTEMBER 01 2018
    • Additional Info: How to Fix

    Summary: ?SERVICE ACTION: REPLACE THE DME CONTROL UNIT. The damaged Digital Motor Electronics (DME) control unit may fail. The printed circuit board may be damaged due to a fault in the production of the DME control unit

    More Information »

  • TSB #M620218

    NHTSA ID #10145373

    • Date Announced: JULY 01 2018
    • Additional Info: How to Fix

    Summary: VEHICLE CHECK DISPLAYS DUE IN CBS DATA AFTER RESET FOR 2ND OIL SERVICE: After reset of service interval (e.g. oil change), the vehicle check is displayed as “Due” (yellow).

    More Information »

  • TSB #M610318

    NHTSA ID #10145372

    • Date Announced: JULY 01 2018
    • Additional Info: How to Fix

    Summary: THE DISPLAY GOES BLACK, VEHICLE DOESNT START AGAIN AFTER SWITCHING THE ENGINE OFF.: On board computer and navigation system goes black or resets.

    More Information »

  • TSB #M12118

    NHTSA ID #10143576

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: DME FC 135608 - VALVETRONIC: NO MOVEMENT IDENTIFIED: Fault Code “135608 - Valvetronic: No movement identified” stored in the Digital Motor Electronics (DME).

    More Information »

  • TSB #M120318

    NHTSA ID #10136002

    • Date Announced: MARCH 01 2018
    • Additional Info: How to Fix

    Summary: BUZZING NOISE FROM VALVETRONIC MOTOR BEFORE OR AFTER ENGINE OPERATION: Buzzing noise may be heard from the Valvetronic motor when the vehicle is unlocked, before the engine is started, or after engine is turned off.

    More Information »

  • TSB #M120618

    NHTSA ID #10136004

    • Date Announced: MARCH 01 2018
    • Additional Info: How to Fix

    Summary: JCW ENGINE TUNING KIT SHOULD NOT BE PROGRAM WITH ISTA 4.10.1X: Vehicles with the John Cooper Works (JCW) Tuning Kit should not be programmed with ISTA 4.10.1x.

    More Information »

  • TSB #M120718

    NHTSA ID #10136005

    • Date Announced: MARCH 01 2018
    • Additional Info: How to Fix

    Summary: ROUGH RUNNING WITH VARIOUS VANOS FAULTS: The check engine light is illuminated and the vehicle may run rough.

    More Information »

  • TSB #M120418

    NHTSA ID #10136003

    • Date Announced: MARCH 01 2018
    • Additional Info: How to Fix

    Summary: NOISE COMING FROM OIL FILTER AREA AFTER A COLD START: repeating fizzing noise may be heard from the engine oil filter area after a cold start.

    More Information »

  • TSB #M120318

    NHTSA ID #10135059

    • Date Announced: FEBRUARY 01 2018
    • Additional Info: How to Fix

    Summary: BUZZING NOISE FROM VALVETRONIC MOTOR BEFORE OR AFTER ENGINE OPERATION: Buzzing noise may be heard from the Valvetronic motor when the vehicle is unlocked, before the engine is started, or after engine is turned off.

    More Information »

  • TSB #M110117

    NHTSA ID #10142946

    • Date Announced: JANUARY 01 2018
    • Additional Info: How to Fix

    Summary: FAULT 118002 - MIXTURE TOO RICH SETS DURING WINTER WITH COLD AMBIENT TEMPERATURES: The Service Engine Soon (MIL) light is on with the following fault stored in the DME.

    More Information »

  • TSB #M220317

    NHTSA ID #10142949

    • Date Announced: JANUARY 01 2018
    • Additional Info: How to Fix

    Summary: CREAKING NOISE FROM THE LOWER ENGINE AREA: During load reversal or taking off from a stop there is a creaking or droning noise heard from the lower engine area

    More Information »

  • TSB #M220217

    NHTSA ID #10146727

    • Date Announced: JUNE 01 2017
    • Additional Info: How to Fix

    Summary: KNOCKING NOISE FROM THE ENGINE COMPARTMENT. There is a knocking noise coming from the engine compartment or the engine shakes during: z Engine start z When driving off from a stop z When applying brakes CAUSE Damage to the right side engine

    More Information »

FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM

  • TSB #M620217

    NHTSA ID #10134998

    • Date Announced: FEBRUARY 01 2018
    • Additional Info: How to Fix

    Summary: FUEL GAUGE ERRONEOUS DISPLAY: Vehicle runs out of fuel but the instrument cluster still displays fuel remaining in the tank.

    More Information »

POWER TRAIN

  • TSB #M610118

    NHTSA ID #10145309

    • Date Announced: JUNE 01 2018
    • Additional Info: How to Fix

    Summary: HIGH VOLTAGE SYSTEM: ISOLATION FAULTS: The Check Control message (CCM), "Powertrain malfunction!" is displayed.

    More Information »

  • TSB #M120618

    NHTSA ID #10143573

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: JCW ENGINE TUNING KIT - ENGINE LOSS OF POWER IN STOP-AND-GO DRIVING: The engine may lose power if the vehicle is decelerated, in gear, to a near stop and then accelerated again.

    More Information »

  • TSB #M610118

    NHTSA ID #10138417

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: HIGH VOLTAGE SYSTEM: ISOLATION FAULTS: The Check Control message (CCM), "Powertrain malfunction!" is displayed.

    More Information »

  • TSB #M240118

    NHTSA ID #10134994

    • Date Announced: FEBRUARY 01 2018
    • Additional Info: How to Fix

    Summary: AISIN AUTOMATIC TRANSMISISON: RIGHT SIDE OUTPUT SHAFT SEAL REPLACEMENT

    More Information »

  • TSB #M111316

    NHTSA ID #10146800

    • Date Announced: DECEMBER 01 2016
    • Additional Info: How to Fix

    Summary: Service Action: B38 Engine - Check and Replace Crankshaft Guide Bearing. The upper crankshaft guide bearing may wear out prematurely. The wear on the guide bearing can cause the clutch pedal to malfunction during shifting. The Engine Malfun

    More Information »

ELECTRICAL SYSTEM

  • TSB #M610318

    NHTSA ID #10149554

    • Date Announced: OCTOBER 01 2018
    • Additional Info: How to Fix

    Summary: THE DISPLAY GOES BLACK, THE ENGINE CAN BE SWITCHED OFF ONLY VIA THE EMERGENCY-OFF.. * On board computer and navigation system goes black or resets. * The engine can only be switched off by pressing the START/STOP button three times (Emergen

    More Information »

  • TSB #M510817

    NHTSA ID #10149552

    • Date Announced: OCTOBER 01 2018
    • Additional Info: How to Fix

    Summary: TRUNK OPEN MESSAGE ON CLUSTER. Check Control Message (CCM) "Trunk Open" message is displayed. Trunk is closed and latched. Improper attachment of trunk lock connector.

    More Information »

  • TSB #M121318

    NHTSA ID #10150059

    • Date Announced: SEPTEMBER 01 2018
    • Additional Info: How to Fix

    Summary: ?SERVICE ACTION: REPLACE THE DME CONTROL UNIT. The damaged Digital Motor Electronics (DME) control unit may fail. The printed circuit board may be damaged due to a fault in the production of the DME control unit

    More Information »

  • TSB #M120917

    NHTSA ID #10143575

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: THE ENGINE STARTER INTERMITTENTLY DOES NOT CRANK OVER: The engine will not start, either consistently or intermittently.

    More Information »

  • TSB #M120918

    NHTSA ID #10138413

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: DIAGNOSING NON-FUNCTIONING EDRIVE: Vehicle will not go into “eDrive”

    More Information »

  • TSB #M660218

    NHTSA ID #10138420

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: CHECK CONTROL STATES REMOTE KEY IS MISSING WHEN THE KEY IS LOCATED IN THE VEHICLE: Only vehicles that have been programmed with ISTA 4.10.1x and I-level 18-03-511 or 18-03-512.

    More Information »

  • TSB #M610118

    NHTSA ID #10138417

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: HIGH VOLTAGE SYSTEM: ISOLATION FAULTS: The Check Control message (CCM), "Powertrain malfunction!" is displayed.

    More Information »

  • TSB #M840418

    NHTSA ID #10138421

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: IPHONE: CALL LIST MISSING AFTER RESTART: The call list from iPhone 8 or iPhone X, that is displayed, is missing after cycling the ignition.

    More Information »

  • TSB #M630118

    NHTSA ID #10136308

    • Date Announced: MARCH 01 2018
    • Additional Info: How to Fix

    Summary: SERVICE ACTION: REPLACE THE LEFT FRONT LIGHT ELECTRONICS CONTROL MODULE: The FLE_L (Front Light Electronic _ Left) module - left side malfunctions.

    More Information »

  • TSB #M630318

    NHTSA ID #10136309

    • Date Announced: MARCH 01 2018
    • Additional Info: How to Fix

    Summary: SERVICE ACTION: REPLACE THE LIGHT ELECTRONICS CONTROL MODULES ON BOTH SIDES: The FLE (Front Light Electronic) module on both sides malfunctions.

    More Information »

  • TSB #M840318

    NHTSA ID #10136311

    • Date Announced: MARCH 01 2018
    • Additional Info: How to Fix

    Summary: BLUETOOTH AND USB AUDIO PLAYBACK FUNCTIONS MISSING - IPHONE: aylists, song titles, etc. from iPhone do not display on Head Unit Basic 2.

    More Information »

  • TSB #M650617

    NHTSA ID #10136310

    • Date Announced: MARCH 01 2018
    • Additional Info: How to Fix

    Summary: NBT-EVO NEXT GENERATION NAVIGATION PROFESSIONAL: HEAD UNIT CANNOT BE SWAPPED BETWEEN VEHICLES FOR TESTING. COMPONENT PROTECTION ACTIVE: If either the NBT-EVO head unit or Body Domain Controller (BDC) are swapped into a different vehicle the

    More Information »

  • TSB #M120717

    NHTSA ID #10146748

    • Date Announced: AUGUST 01 2017
    • Additional Info: How to Fix

    Summary: SERVICE ACTION: REPLACE THE INTEGRATED SUPPLY MODULE. The integrated supply module installed at production may not meet the service life quality requirements. This could cause the engine not to start.

    More Information »

  • TSB #M620117

    NHTSA ID #10146751

    • Date Announced: AUGUST 01 2017
    • Additional Info: How to Fix

    Summary: ERRONEOUS SERVICE INCLUSIVE CBS DISPLAY. After pre-delivery check or after instrument cluster exchange, MINI Service Inclusive is displayed although the vehicle does not feature the optional Service Inclusive coverage. Instrument Cluster di

    More Information »

  • TSB #M720117

    NHTSA ID #10146731

    • Date Announced: JUNE 01 2017
    • Additional Info: How to Fix

    Summary: NOISE FROM HEAD AIR BAG. During low outdoor temperatures, with the doors and windows closed, a metallic whirring noise is detected in the area of the head air bag (HPS).

    More Information »

  • TSB #M610217

    NHTSA ID #10146730

    • Date Announced: JUNE 01 2017
    • Additional Info: How to Fix

    Summary: "MIL ACTIVE - EME FC 222F96. Malfunction Indicator Lamp (MIL) is illuminated. Electrical Machine Electronics (EME) has stored fault code FC 222F96. CC Message ""Malfunction Indicator Lamp"" (CCM ID:34) is displayed."

    More Information »

  • TSB #M620515

    NHTSA ID #10151389

    • Date Announced: JUNE 01 2016
    • Additional Info: How to Fix

    Summary: The Clock in the Instrument Cluster Loses time This Service Information Bulletin supersedes SI M62 05 15 dated June 2016. The time displayed in the instrument cluster (KOMBI) may lose a few minutes each week and the clock needs to be adjust

    More Information »

  • TSB #M840114

    NHTSA ID #10151349

    • Date Announced: MAY 01 2016
    • Additional Info: How to Fix

    Summary: Bluetooth Connection Failures This Service Information bulletin supersedes SI M84 01 14 dated February 2016.. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Connectivity failure

    More Information »

ELECTRICAL SYSTEM:BATTERY

  • TSB #M610218

    NHTSA ID #10143578

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: SME FCS 21F156 21F1F7: The following codes are saved in the battery management electronics (SME) fault memory:

    More Information »

  • TSB #M120918

    NHTSA ID #10138413

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: DIAGNOSING NON-FUNCTIONING EDRIVE: Vehicle will not go into “eDrive”

    More Information »

DIGITAL INSTRUMENT PANEL

  • TSB #M620415

    NHTSA ID #10138419

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: INSTRUMENT CLUSTER OUTSIDE TEMPERATURE DISPLAY IMPLAUSIBLE: In the Instrument Cluster (Kombi) display you may observe an implausible outside temperature reading.

    More Information »

  • TSB #M620515

    NHTSA ID #10151389

    • Date Announced: JUNE 01 2016
    • Additional Info: How to Fix

    Summary: The Clock in the Instrument Cluster Loses time This Service Information Bulletin supersedes SI M62 05 15 dated June 2016. The time displayed in the instrument cluster (KOMBI) may lose a few minutes each week and the clock needs to be adjust

    More Information »

ELECTRICAL SYSTEM: SOFTWARE

  • TSB #M840518

    NHTSA ID #10143580

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: HEAD UNIT HIGH 2 RESET WHILE BLUETOOTH IS CONNECTED: The following event may cause an unexpected reset of the Head Unit High 2 (NBT EVO) when:

    More Information »

  • TSB #M650610

    NHTSA ID #10143579

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: NAVIGATION SYSTEM HAS MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:

    More Information »

  • TSB #M12118

    NHTSA ID #10143576

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: DME FC 135608 - VALVETRONIC: NO MOVEMENT IDENTIFIED: Fault Code “135608 - Valvetronic: No movement identified” stored in the Digital Motor Electronics (DME).

    More Information »

VISIBILITY:GLASS, SIDE/REAR

  • TSB #M540217

    NHTSA ID #10145371

    • Date Announced: JULY 01 2018
    • Additional Info: How to Fix

    Summary: CONVERTIBLE TOP REAR WINDOW DAMAGE: When opening the convertible top, the rear window and the luggage compartment cover or convertible top linkage collide causing damage to the rear window.

    More Information »

VISIBILITY:SUN ROOF ASSEMBLY

  • TSB #M540218

    NHTSA ID #10150062

    • Date Announced: SEPTEMBER 01 2018
    • Additional Info: How to Fix

    Summary: ?RATTLE NOISE FROM SUNROOF WHILE CLOSED. When driving over rough road surfaces, a rattle noise is present from the roof when the sunroof is closed. Grease was not correctly applied to the sunroof mechanism during production.

    More Information »

STRUCTURE

  • TSB #M510118

    NHTSA ID #10149551

    • Date Announced: OCTOBER 01 2018
    • Additional Info: How to Fix

    Summary: RATTLE NOISE FROM THE TAILGATE. There is a rattle noise present from the lower right area of the tailgate, heard from inside the vehicle. Refer to the video link demonstrating the noise: https://tinyurl.com/yaqqhvev An unused electrical plu

    More Information »

  • TSB #M510715

    NHTSA ID #10143577

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: PAINT ON THE B-PILLAR IS SCRATCHED/DAMAGED: The paint finish of the door jamb (above the door striker) is scratched due to the inner door cavity window seal.

    More Information »

STRUCTURE:BODY:DOOR

  • TSB #M510715

    NHTSA ID #10143577

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: PAINT ON THE B-PILLAR IS SCRATCHED/DAMAGED: The paint finish of the door jamb (above the door striker) is scratched due to the inner door cavity window seal.

    More Information »

STRUCTURE:BODY:TAILGATE

  • TSB #M510916

    NHTSA ID #10150060

    • Date Announced: SEPTEMBER 01 2018
    • Additional Info: How to Fix

    Summary: ?TAILGATE UNINTENTIONALLY OPENS. Customer inquires about tailgate opening process, mentioning: * Trunk/tailgate may open when vehicle is locked. * Trunk/tailgate may open while the vehicle is in motion. * Vehicle key trunk/tailgate button

    More Information »

STRUCTURE:BODY:TRUNK LID

  • TSB #M510817

    NHTSA ID #10149552

    • Date Announced: OCTOBER 01 2018
    • Additional Info: How to Fix

    Summary: TRUNK OPEN MESSAGE ON CLUSTER. Check Control Message (CCM) "Trunk Open" message is displayed. Trunk is closed and latched. Improper attachment of trunk lock connector.

    More Information »

STRUCTURE:BODY:HOOD

  • TSB #M510417

    NHTSA ID #10146773

    • Date Announced: SEPTEMBER 01 2017
    • Additional Info: How to Fix

    Summary: SERVICE ACTION: HOOD RELEASE BOWDEN CABLE POSITIONING. Tank ventilation line and/or hood release Bowden cable may have been damaged. The hood release Bowden cable is unsecured and in contact with the tank ventilation line.

    More Information »

STRUCTURE:BODY:ROOF AND PILLARS

  • TSB #M540218

    NHTSA ID #10150062

    • Date Announced: SEPTEMBER 01 2018
    • Additional Info: How to Fix

    Summary: ?RATTLE NOISE FROM SUNROOF WHILE CLOSED. When driving over rough road surfaces, a rattle noise is present from the roof when the sunroof is closed. Grease was not correctly applied to the sunroof mechanism during production.

    More Information »

LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

  • TSB #M660217

    NHTSA ID #10146777

    • Date Announced: SEPTEMBER 01 2017
    • Additional Info: How to Fix

    Summary: (SMART OPENER) CONTACTLESS TAILGATE NOT ABLE TO BE DEACTIVATED. Customer desires to have contactless tailgate opening and closing (Smart Opener) deactivated. Function not included in software released.

    More Information »

WHEELS

  • TSB #M511616

    NHTSA ID #10146774

    • Date Announced: SEPTEMBER 01 2017
    • Additional Info: How to Fix

    Summary: CAVITY PROTECTION WAX LEAKING OUT OF HOOD. Cavity protection applied to underside of hood is leaking out onto wheel arch trim and grille. Improper application of Cavity Protection Wax.

    More Information »

SEATS

  • TSB #M520218

    NHTSA ID #10150061

    • Date Announced: SEPTEMBER 01 2018
    • Additional Info: How to Fix

    Summary: ?SEAT HEATING DOES NOT GET SUFFICIENTLY WARM. The seat heating in the sports seat may not heat up sufficiently Software error in the climate control panel (IHKA)

    More Information »

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  • TSB #M520218

    NHTSA ID #10150061

    • Date Announced: SEPTEMBER 01 2018
    • Additional Info: How to Fix

    Summary: ?SEAT HEATING DOES NOT GET SUFFICIENTLY WARM. The seat heating in the sports seat may not heat up sufficiently Software error in the climate control panel (IHKA)

    More Information »

FORWARD COLLISION AVOIDANCE

  • TSB #M660216

    NHTSA ID #10151348

    • Date Announced: MAY 01 2016
    • Additional Info: How to Fix

    Summary: Collision warning and Pedestrian Warning Failed. While driving, a Check Control Message (CCM) is displayed advising of the following: Front collision warning failed Pedestrian detection failed The following fault code is stored in the KAFAS

    More Information »

BACK OVER PREVENTION

  • TSB #M120418

    NHTSA ID #10136003

    • Date Announced: MARCH 01 2018
    • Additional Info: How to Fix

    Summary: NOISE COMING FROM OIL FILTER AREA AFTER A COLD START: repeating fizzing noise may be heard from the engine oil filter area after a cold start.

    More Information »

  • TSB #M120318

    NHTSA ID #10136002

    • Date Announced: MARCH 01 2018
    • Additional Info: How to Fix

    Summary: BUZZING NOISE FROM VALVETRONIC MOTOR BEFORE OR AFTER ENGINE OPERATION: Buzzing noise may be heard from the Valvetronic motor when the vehicle is unlocked, before the engine is started, or after engine is turned off.

    More Information »

COMMUNICATIONS:HORN ASSEMBLY

  • TSB #M610216

    NHTSA ID #10134996

    • Date Announced: FEBRUARY 01 2018
    • Additional Info: How to Fix

    Summary: HORN DOES NOT WORK: Horn operation is difficult or impossible.

    More Information »

EQUIPMENT

  • TSB #M640318

    NHTSA ID #10149556

    • Date Announced: OCTOBER 01 2018
    • Additional Info: How to Fix

    Summary: STATIONARY CLIMATE CONTROL NOT WORKING AFTER CHARGING PROCEDURE. After the high voltage (HV) charging procedure, the stationary climate control (aka preconditioning) does not work. This is part of the normal design. There is no fault or def

    More Information »

  • TSB #M540318

    NHTSA ID #10149553

    • Date Announced: OCTOBER 01 2018
    • Additional Info: How to Fix

    Summary: RATTLE NOISE FROM SUNSHADE WHILE DRIVING. With either of the sunshades fully opened, there is a rattle noise present when driving over rough road surfaces The sunshade is contacting the roof liner trim.

    More Information »

  • TSB #M840818

    NHTSA ID #10150063

    • Date Announced: SEPTEMBER 01 2018
    • Additional Info: How to Fix

    Summary: ?CONNECTEDDRIVE/MINI ASSIST SYSTEM DIAGNOSIS INFORMATION. ConnectedDrive/MINI Assist features are partially or completely inoperative. This Service Information bulletin is being published because vehicles are down for an extended period of

    More Information »

  • TSB #M840718

    NHTSA ID #10145375

    • Date Announced: JULY 01 2018
    • Additional Info: How to Fix

    Summary: PHONE CONTACTS: HEADUNIT BASIC 2 SORTING ORDER: Improper sorting of phone contacts, in the on-board computer or in the Central Information Display (CID), upon connecting to the vehicle:

    More Information »

  • TSB #M650617

    NHTSA ID #10145312

    • Date Announced: JUNE 01 2018
    • Additional Info: How to Fix

    Summary: COMPONENT PROTECTION ACTIVE. HEAD UNITS CANNOT BE SWAPPED BETWEEN VEHICLES FOR TESTING.

    More Information »

  • TSB #M650610

    NHTSA ID #10145311

    • Date Announced: JUNE 01 2018
    • Additional Info: How to Fix

    Summary: NAVIGATION SYSTEM HAS MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:

    More Information »

  • TSB #M840418

    NHTSA ID #10138421

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: IPHONE: CALL LIST MISSING AFTER RESTART: The call list from iPhone 8 or iPhone X, that is displayed, is missing after cycling the ignition.

    More Information »

  • TSB #M840518

    NHTSA ID #10138422

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: HEAD UNIT HIGH 2 RESET WHILE BLUETOOTH IS CONNECTED: The following event may cause an unexpected reset of the Head Unit High 2 (NBT EVO) when:

    More Information »

  • TSB #M660218

    NHTSA ID #10138420

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: CHECK CONTROL STATES REMOTE KEY IS MISSING WHEN THE KEY IS LOCATED IN THE VEHICLE: Only vehicles that have been programmed with ISTA 4.10.1x and I-level 18-03-511 or 18-03-512.

    More Information »

  • TSB #M540417

    NHTSA ID #10136007

    • Date Announced: MARCH 01 2018
    • Additional Info: How to Fix

    Summary: SERVICE ACTION: REWORKING THE SOFT TOP BOW BEARING: The adjusting element interferes with the soft top and it may or may not cause chafing of the convertible top fabric at the c-pillar area as shown below.

    More Information »

  • TSB #M640217

    NHTSA ID #10146775

    • Date Announced: SEPTEMBER 01 2017
    • Additional Info: How to Fix

    Summary: AIR CONDITIONING COOLING IS INSUFFICIENT. * With option code SA 530 air conditioning or SA 534 Automatic air conditioning Produced from 2/1/2016 through 9/30/2016. * A/C system contains little or no A/C refrigerant. Contaminants under O-ri

    More Information »

  • TSB #M650717

    NHTSA ID #10146776

    • Date Announced: SEPTEMBER 01 2017
    • Additional Info: How to Fix

    Summary: "NAVIGATION PRO (NBT EVO) MAP UPDATE NOT POSSIBLE, NAVIGATION DOES NOT START. A. Navigation system will not start at all or the ""Navigation system starts"" message is permanently displayed. B. While attempting to update the Navigation syst

    More Information »

  • TSB #M720117

    NHTSA ID #10146731

    • Date Announced: JUNE 01 2017
    • Additional Info: How to Fix

    Summary: NOISE FROM HEAD AIR BAG. During low outdoor temperatures, with the doors and windows closed, a metallic whirring noise is detected in the area of the head air bag (HPS).

    More Information »

  • TSB #M640216

    NHTSA ID #10151390

    • Date Announced: JUNE 01 2016
    • Additional Info: How to Fix

    Summary: Air Conditioning Refrigerant R1234yf Introduction. INFORMATION Several precautions need to be observed when working on automotive air conditioning systems: Always wear eye protection and gloves while handling refrigerant or servicing air c

    More Information »

  • TSB #M110916

    NHTSA ID #10151386

    • Date Announced: JUNE 01 2016
    • Additional Info: How to Fix

    Summary: VANOS AND VANOS CENTRAL BOLT IDENTIFICATION. INFORMATION Replacing the VANOS gear central bolts or the VANOS gear will require a component inspection when the engine assembly has been previously replaced in one of the vehicles listed above.

    More Information »

  • TSB #M840114

    NHTSA ID #10151349

    • Date Announced: MAY 01 2016
    • Additional Info: How to Fix

    Summary: Bluetooth Connection Failures This Service Information bulletin supersedes SI M84 01 14 dated February 2016.. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Connectivity failure

    More Information »

EQUIPMENT:ELECTRICAL

  • TSB #M640318

    NHTSA ID #10149556

    • Date Announced: OCTOBER 01 2018
    • Additional Info: How to Fix

    Summary: STATIONARY CLIMATE CONTROL NOT WORKING AFTER CHARGING PROCEDURE. After the high voltage (HV) charging procedure, the stationary climate control (aka preconditioning) does not work. This is part of the normal design. There is no fault or def

    More Information »

  • TSB #M610318

    NHTSA ID #10149554

    • Date Announced: OCTOBER 01 2018
    • Additional Info: How to Fix

    Summary: THE DISPLAY GOES BLACK, THE ENGINE CAN BE SWITCHED OFF ONLY VIA THE EMERGENCY-OFF.. * On board computer and navigation system goes black or resets. * The engine can only be switched off by pressing the START/STOP button three times (Emergen

    More Information »

  • TSB #M840818

    NHTSA ID #10150063

    • Date Announced: SEPTEMBER 01 2018
    • Additional Info: How to Fix

    Summary: ?CONNECTEDDRIVE/MINI ASSIST SYSTEM DIAGNOSIS INFORMATION. ConnectedDrive/MINI Assist features are partially or completely inoperative. This Service Information bulletin is being published because vehicles are down for an extended period of

    More Information »

  • TSB #M840418

    NHTSA ID #10138421

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: IPHONE: CALL LIST MISSING AFTER RESTART: The call list from iPhone 8 or iPhone X, that is displayed, is missing after cycling the ignition.

    More Information »

  • TSB #M840518

    NHTSA ID #10138422

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: HEAD UNIT HIGH 2 RESET WHILE BLUETOOTH IS CONNECTED: The following event may cause an unexpected reset of the Head Unit High 2 (NBT EVO) when:

    More Information »

  • TSB #M660218

    NHTSA ID #10138420

    • Date Announced: APRIL 01 2018
    • Additional Info: How to Fix

    Summary: CHECK CONTROL STATES REMOTE KEY IS MISSING WHEN THE KEY IS LOCATED IN THE VEHICLE: Only vehicles that have been programmed with ISTA 4.10.1x and I-level 18-03-511 or 18-03-512.

    More Information »

  • TSB #M840114

    NHTSA ID #10151349

    • Date Announced: MAY 01 2016
    • Additional Info: How to Fix

    Summary: Bluetooth Connection Failures This Service Information bulletin supersedes SI M84 01 14 dated February 2016.. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Connectivity failure

    More Information »

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

  • TSB #M840218

    NHTSA ID #10135000

    • Date Announced: FEBRUARY 01 2018
    • Additional Info: How to Fix

    Summary: HEAD UNIT HIGH RESETS WITH CONNECTION OF IPHONE 8, IPHONE 8 PLUS OR IPHONE X

    More Information »

  • TSB #M650118

    NHTSA ID #10142950

    • Date Announced: JANUARY 01 2018
    • Additional Info: How to Fix

    Summary: NO AUDIO PLAYBACK AFTER REPLACING THE HEAD UNIT HIGH 2 (HU-H2): After replacing the Head Unit High (HU-H2) and performing ISTA4 programming there is no audio playback.

    More Information »

EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

  • TSB #M650610

    NHTSA ID #10143579

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: NAVIGATION SYSTEM HAS MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:

    More Information »

  • TSB #M650617

    NHTSA ID #10136310

    • Date Announced: MARCH 01 2018
    • Additional Info: How to Fix

    Summary: NBT-EVO NEXT GENERATION NAVIGATION PROFESSIONAL: HEAD UNIT CANNOT BE SWAPPED BETWEEN VEHICLES FOR TESTING. COMPONENT PROTECTION ACTIVE: If either the NBT-EVO head unit or Body Domain Controller (BDC) are swapped into a different vehicle the

    More Information »

EQUIPMENT:AIR CONDITIONER

  • TSB #M640117

    NHTSA ID #10145310

    • Date Announced: JUNE 01 2018
    • Additional Info: How to Fix

    Summary: FOUL, MUSTY ODOR FROM HVAC: WET FOOTWELL CARPET: The customer reports one, or both, of the following:

    More Information »

  • TSB #M640216

    NHTSA ID #10151390

    • Date Announced: JUNE 01 2016
    • Additional Info: How to Fix

    Summary: Air Conditioning Refrigerant R1234yf Introduction. INFORMATION Several precautions need to be observed when working on automotive air conditioning systems: Always wear eye protection and gloves while handling refrigerant or servicing air c

    More Information »

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

  • TSB #M120518

    NHTSA ID #10135060

    • Date Announced: FEBRUARY 01 2018
    • Additional Info: How to Fix

    Summary: DME FAULT CODE CDC203: One or more of the following Check Control messages (CCM) is displayed:

    More Information »

EQUIPMENT ADAPTIVE

  • TSB #M840518

    NHTSA ID #10143580

    • Date Announced: MAY 01 2018
    • Additional Info: How to Fix

    Summary: HEAD UNIT HIGH 2 RESET WHILE BLUETOOTH IS CONNECTED: The following event may cause an unexpected reset of the Head Unit High 2 (NBT EVO) when:

    More Information »

Browse Other Cooper Years

Become a Fan & Spread the Word