- May 30: Toyota Tundra and Lexus LX Recall Issued For Engine Problems recalls | 2 days ago
- May 28: Toyota Tacoma Paint and Clear Coat Problems Cause Lawsuit news | 4 days ago
- May 18: Zoox Car Accidents Lead to Investigation of Automated Systems investigations | 14 days ago
- May 14: Toyota RAV4 Sunroof Recall Needed, Alleges Class Action Lawsuit news | 18 days ago
- April 18: Toyota Prius Rear Door Latch Recall Announced recalls | 44 days ago
2007 Toyota RAV4
138 Technical Service Bulletins (TSBs)
TSB List for the 2007 Toyota RAV4
Technical Service Bulletins (TSBs) for the 2007 RAV4 are official communications between Toyota & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #T-TT-0255-13
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #T-TT-0255-13
Customer experiences a clunk, pop, or knock-type noise when turning the steering wheel left or right on a 2006-2008 RAV4. Read More »
-
TSB #TSB-0318-08 REV1
TOYOTA: STEERING INTERMEDIATE SHAFT NOISE. MAY HEAR A CLUNK, POP, OR KNOCK TYPE NOISE WHEN TURN IN THE STEERING WHEEL LEFT OR RIGHT. A NEW INTERMEDIATE SHAFT HAS BEEN DEVELOPED TO ADDRESS THIS CONDITION. *PE UPDATED 5/22/2012. Read More »
-
TSB #00501
REPAIR MANUAL SUPPLEMENT: VEHICLE PULLING TO ONE SIDE. TOYOTA ALL MODEL YEARS. *MJ 2002 - 2007 MODEL YEARS. TOYOTA/SCION MODELS. *TT Read More »
STEERING:GEAR BOX:SHAFT SECTOR
-
TSB #ST001-08
STEERING INTERMEDIATE SHAFT NOISE - WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT. *NJ Read More »
STEERING:LINKAGES:TIE ROD ASSEMBLY
-
TSB #TSB-0157-12
TOYOTA: PROCEDURAL INFORMATION PROVIDED FOR REAR TIE ROD ADJUSTMENT TO ASSURE PROPER SEQUENCE OF TIGHTENING AND USE WHENEVER PERFORMING TOE ADJUSTMENT DURING WHEEL ALIGNMENT. MODELS 2006-11 RAV4. Read More »
SUSPENSION
-
TSB #T-SB-0381-09 Rev
TSB: The only acceptable towing method for vehicles equipped with an Active Torque Control 4WD system is to have all four wheels off the ground. Read More »
SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
-
TSB #ER11_Re-Notifica
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
-
TSB #ER9_Remail_Regio
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Read More »
-
TSB #ER9_Remail_Deale
Dealer Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
SUSPENSION:FRONT:WHEEL BEARING
-
TSB #TSB-0080-13
TOYOTA: THE REAR DIFFERENTIAL COUPLING, WHEN DRIVING SOME VEHICLES, MAY EXHIBIT A GROWL NOISE, DUE TO CONTAMINATION TO FRONT BEARING. MODEL 2006-2012 RAV4 (42WD). *PE Read More »
SUSPENSION:REAR
-
TSB #T-SB-0042-14
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #TSB-0187-13
TOYOTA: THERE IS A CLUNKING NOISE HEARD COMING FROM REAR OF VEHICLE AND ONE OR BOTH REAR STABILIZER LINKS ARE DAMAGED. MODEL 2006-2012 RAV4. *PE Read More »
ENGINE (PWS)
-
TSB #ZE7_Warranty Pol
Warranty Policy Bulletin (POL14-12): Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Read More »
-
TSB #ZE7_Warranty Pol
Warranty Policy Bulletin (POL14-12): Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Read More »
-
TSB #ZE7_Warranty Pol
Warranty Policy Bulletin (POL14-12): Added the Short Block Release Authorization Flow Chart. Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Read More »
-
TSB #POL14-12
WARRANTY POLICY BULLETIN (POL14-12): TOYOTA HAS RECEIVED SOME REPORTS WHERE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. Read More »
-
TSB #T-TT-0372-15 REV
"TT: IN CERTAIN CASES, VEHICLES UNDERGOING THE ZE7 AZ OIL CONSUMPTION REPAIR PROCEDURE WILL REQUIRE A SHORT BLOCK REPLACEMENT. Read More »
-
TSB #ZE7_PHASE2 11/18
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
-
TSB #ZE7_PHASE2 11/17
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
-
TSB #T-TT-0372-15
"TT: IN CERTAIN CASES, VEHICLES UNDERGOING THE ZE7 AZ OIL CONSUMPTION REPAIR PROCEDURE WILL REQUIRE A SHORT BLOCK REPLACEMENT. Read More »
-
TSB #ZE7_IMP 11/12
DD: IN LIMITED CASES VEHICLES BEING SERVICED FOR ZE7 WILL REQUIRE A REPLACEMENT SHORT BLOCK. DEALERS WILL NEED TO INSTALL THE DOWEL PINS BETWEEN THE SHORT BLOCK AND LOWER CRANKCASE WHEN PERFORMING THIS REPAIR. Read More »
-
TSB #ZE7_Important Do
DD: In limited cases vehicles being serviced for ZE7 will require a replacement short block. Dealers will need to install the dowel pins between the short block and lower crankcase when performing this repair. Read More »
-
TSB #T-TT-0361-15 REV
"TT: BASED ON CURRENT PART ORDER ALLOCATION, SOME PISTON TYPES HAVE BEEN INCORRECTLY IDENTIFIED WHILE UNDERGOING THE ZE7 2AZ OIL CONSUMPTION REPAIR PROCEDURE. Read More »
-
TSB #T-SB-0030-15
"TSB: SOME 2006 ? 2013 MODEL YEAR VEHICLES EQUIPPED WITH THE 2AZ ENGINE MAY EXHIBIT ENGINE OIL CONSUMPTION. THE PISTON ASSEMBLY HAS BEEN CHANGED TO MINIMIZE OIL CONSUMPTION. USE THE FOLLOWING REPAIR PROCEDURE TO ADDRESS THIS CONDITION. Read More »
-
TSB #POL 14-12
WPB: TOYOTA HAS RECEIVED SOME REPORTS WHERE THE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. Read More »
-
TSB #T-TT-0353-15 REV
TT: THERE HAS BEEN SOME CONCERN WITH 3 PIECE RING INSTALLATIONS FOR 2AZ-FE AND 2AZ-FXE ENGINES. THIS TECH TIP CONTAINS THE ACCEPTED INSTALLATION METHOD REQUIRED FOR TOYOTA VEHICLES. Read More »
-
TSB #T-TT-353-15 REV1
TT: THERE HAS BEEN SOME CONCERN WITH 3 PIECE RING INSTALLATIONS FOR 2AZ-FE AND 2AZ-FXE ENGINES. THIS TECH TIP CONTAINS THE ACCEPTED INSTALLATION METHOD REQUIRED FOR TOYOTA VEHICLES. Read More »
-
TSB #T-TT-0361-15
TT: BASED ON CURRENT PART ORDER ALLOCATION, SOME PISTON TYPES HAVE BEEN INCORRECTLY IDENTIFIED WHILE UNDERGOING THE ZE7 2AZ OIL CONSUMPTION REPAIR PROCEDURE. Read More »
-
TSB #WPB (POL 14-12)_
WPB: TOYOTA HAS RECEIVED SOME REPORTS WHERE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. TOYOTA IS NOW ANNOUNCING THE PART REPLACEMENT PHASE OF WARRANTY ENHANCEMENT PROGRAM ZE7 FOR VEHICLES EXHIBITING EXCESSIVE ENGINE OIL ... Read More »
-
TSB #T-SB-0012-13 REV
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
-
TSB #TC-14-036
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN VEHICLES THE RUBBER OIL SUPPLY HOSE, FOR VVT-I ACTUATOR, IS DEGRADING OVER TIME AND CAUSING A LEAKAGE OF OIL, FROM OIL HOSE, PRODUCING AN ILLUMINATION OF OIL PRESSURE ... Read More »
-
TSB #TSB-0001-10
TOYOTA: UPDATED INFORMATION REGARDING THE RESPONSE OF THE AIR FUEL RATIO SENSOR, THAT IS INCORRECT AND ALSO, AN INCORRECT OXYGEN SENSOR OPERATION MAY BE PRESENT, DUE TO ECM/PCM PROCESSOR P0606 DTC. Read More »
-
TSB #TSB-0192-12
TOYOTA: INTAKE CAMSHAFT GEAR ASSEMBLY WAS IMPROVED TO PREVENT CONDITION OF ENGINE EXHIBITING INTERMITTENT MIL ON. MODEL 2006-2012 CAMRY, CAMRY HV, COROLLA, MATRIX, RAV4, SOLARA. *PE Read More »
ENGINE AND ENGINE COOLING
-
TSB #ZE7_Phase 2_Warr
WPB: The engine is covered under the Toyota New Vehicle Limited Warranty for 5 years from the date of first use or 60,000 miles (whichever occurs first). Read More »
-
TSB #ZE7_Phase 2_Warr
WPB: The engine is covered under the Toyota New Vehicle Limited Warranty for 5 years from the date of first use or 60,000 miles (whichever occurs first). Read More »
-
TSB #T-TT-0372-15
TT: In certain cases, vehicles undergoing the ZE7 AZ Oil Consumption repair procedure will require a short block replacement. Read More »
-
TSB #T-TT-0361-15 Rev
TT: Based on current part order allocation, some piston types have been incorrectly identified while undergoing the ZE7 2AZ Oil Consumption repair procedure. Read More »
-
TSB #T-SB-0030-15
TSB: Some 2006 - 2013 model year vehicles equipped with the 2AZ engine may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Use the following Repair Procedure to address this condition. Read More »
-
TSB #ZE7_Phase 2_WPB(
WPB: Toyota has received some reports where the vehicles may exhibit excessive engine oil consumption. Read More »
-
TSB #ZE7_Service Cons
DL: As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive Engine Oil Consumption on ... Read More »
-
TSB #ZE7_Service Cons
DL: As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive Engine Oil Consumption on ... Read More »
-
TSB #ZE7_WPB_WEP_Publ
WPB: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Toyota is now announcing the part replacement phase of Warranty Enhancement Program ZE7 for vehicles exhibiting excessive engine oil ... Read More »
-
TSB #ZE7_WPB_WEP_Publ
WPB: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Toyota is now announcing the part replacement phase of Warranty Enhancement Program ZE7 for vehicles exhibiting excessive engine oil ... Read More »
-
TSB #T-SB-0030-15
TSB: NOTE-Service Bulletin No. T-SB-0158-14, "2AZ Engine Oil Consumption Inspection Procedure," MUST be performed first BEFORE continuing with the procedure in this bulletin. Read More »
-
TSB #T-SB-0094-11 Rev
TSB: OBSOLETE NOTICE-May 26, 2015: This bulletin is now obsolete. Please see T-SB-0030-15. Read More »
-
TSB #T-SB-0030-15
TSB: NOTE-Service Bulletin No. T-SB-0158-14, "2AZ Engine Oil Consumption Inspection Procedure," MUST be performed first BEFORE continuing with the procedure in this bulletin. Read More »
-
TSB #T-SB-0094-11 Rev
TSB: OBSOLETE NOTICE-May 26, 2015: This bulletin is now obsolete. Please see T-SB-0030-15. Read More »
-
TSB #ZE7_POL14-12_WEP
WPB: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. This Warranty Enhancement Program will be launched in two phases due to current part production capacity limitations. Read More »
-
TSB #ZE7_POL14-12_WEP
WPB: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. This Warranty Enhancement Program will be launched in two phases due to current part production capacity limitations. Read More »
-
TSB #ZE7_VIN Expansio
DL: As part of our continual efforts to ensure the best in customer satisfaction, Toyota is preparing a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive Engine Oil Consumption on Certain ... Read More »
-
TSB #ZE7_VIN Expansio
DL: As part of our continual efforts to ensure the best in customer satisfaction, Toyota is preparing a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive Engine Oil Consumption on Certain ... Read More »
-
TSB #T-SB-0158-14 Rev
TSB: Some 2006 - 2013 model year vehicles equipped with 2AZ-FE or 2AZ-FXE engines may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Read More »
-
TSB #T-SB-0158-14 Rev
TSB: Some 2006 - 2013 model year vehicles equipped with 2AZ-FE or 2AZ-FXE engines may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Read More »
-
TSB #T-SB-0094-11 Rev
TSB: Some 2006 - 2011 model year vehicles have equipped with the 2AZ-FE engine may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Read More »
-
TSB #T-SB-0094-11 Rev
TSB: Some 2006 - 2011 model year vehicles have equipped with the 2AZ-FE engine may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Read More »
-
TSB #ZE7_WEP_Updated_
EC: The Tamper Tape recommended for the 2AZ-FE Engine Oil Consumption Inspection Procedure found in T-SB-0158 (Toyota) and S-SB-0031-14 (Scion) is now available at the MDC. Read More »
-
TSB #ZE7_WEP_Updated_
EC: The Tamper Tape recommended for the 2AZ-FE Engine Oil Consumption Inspection Procedure found in T-SB-0158 (Toyota) and S-SB-0031-14 (Scion) is now available at the MDC. Read More »
-
TSB #T-SB-0094-11 Rev
TSB: Some 2006 - 2011 model year vehicles equipped with the 2AZ-FE engine may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Use the following Repair Procedure to address this condition. Read More »
-
TSB #T-SB-0094-11 Rev
TSB: Some 2006 - 2011 model year vehicles equipped with the 2AZ-FE engine may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Use the following Repair Procedure to address this condition. Read More »
-
TSB #90K_LSC_Extensio
Region Letter: On certain vehicles equipped with a 2GR-FE (V6) engine, the rubber portion of the oil supply hose for the VVT-i actuator may degrade over time. Read More »
-
TSB #90K_LSC_Extensio
Dealer Letter: On certain vehicles equipped with a 2GR-FE (V6) engine, the rubber portion of the oil supply hose for the VVT-i actuator may degrade over time. Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #TSB-0056-11
TOYOTA: 2006-2008 RAV4. ABNORMAL NOISE FROM THE IDLER PULLEY ASSEMBLY. *RM Read More »
-
TSB #TSB-0111-10
TOYOTA: 2AZ-FE & 2AZ-FXE THROTTLE BODY. ENGINE CONTROL. PROVIDE UPDATED THROTTLE BODY PART NUMBER INFORMATION FOR CERTAIN VEHICLES. THE DRAIN PIPE HAS BEEN ELIMINATED ON THROTTLE BODY SERVICE PARTS. Read More »
-
TSB #TC-10-010
TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN MODEL VEHICLES EQUIPPED WITH A 2GR-FE (VE) ENGINE, THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR THE VVT-I ACTUATOR MAY DEGRADE OVER TIME. Read More »
-
TSB #LSC-90-K
TOYOTA: ON CERTAIN MODEL VEHICLES,EQUIPPED WITH A 2GR-FE (VE) ENGINE, AN INITIATED PHASE 3 WILL REPLACE THE VVT-I OIL HOSE DUE TO THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR THE VVT-I ACTUATOR MAY DEGRADE OVER TIME. Read More »
-
TSB #TSB-0064-10
TOYOTA: TECHSTREAM ECU FLASH REPROGRAMMING PROCEDURE. FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. Read More »
-
TSB #TSB-0184-09
TOYOTA: VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A MIL ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0505 STORED IN THE ENGINE CONTROL MODULE OR ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM). Read More »
-
TSB #TSB-0094-09
TOYOTA: SOME VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A TICKING/CLICKING TYPE NOISE FROM THE CYLINDER HEAD COVER AREA WHICH MAY BE ACCOMPANIED BY A MIL ON AND ONE OR MORE VVT-I RELATED DIAGNOSTIC TROUBLE CODES (DTCS). Read More »
-
TSB #000607
DRONE NOISE & VIBRATION AT HIGHWAY SPEEDS. *KB Read More »
-
TSB #01507
2AZ-FE ENGINE BLOCK. *KB Read More »
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
-
TSB #TSB-0046-10
TOYOTA: MIL ON; FUEL IN EVAP SYSTEM. SOME VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING CONDITIONS DUE TO FUEL IN THE EVAP SYSTEMS: MIL ON WITH THE FOLLOWING DTCS STORED: P043E, P043F, P2401, P2401, AND P2419; INTERMITTENT ROUGH ... Read More »
FUEL SYSTEM, OTHER:FUEL FILTER
-
TSB #TSB-0046-10
TOYOTA: MIL ON; FUEL IN EVAP SYSTEM. SOME VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING CONDITIONS DUE TO FUEL IN THE EVAP SYSTEMS: MIL ON WITH THE FOLLOWING DTCS STORED: P043E, P043F, P2401, P2401, AND P2419; INTERMITTENT ROUGH ... Read More »
POWER TRAIN
-
TSB #T-SB-0080-13 REV
TSB: SOME 2006 - 2012 MODEL YEAR 4WD RAV4 VEHICLES MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. Read More »
-
TSB #ZF4_DEALER 12/3
"DL: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 ... Read More »
-
TSB #ZF4_DEALERD 12/3
"DD: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 ... Read More »
-
TSB #POL15-04
WPB: IN CERTAIN 2006 TO 2012 MODEL YEAR RAV4 4WD VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS WHERE THE VEHICLE MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. Read More »
-
TSB #T-SB-0006-11 Rev
TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Read More »
-
TSB #T-SB-0134-14
TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL "ON" shifting issues and/or transmission damage. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #T-SB-0006-11 Rev
TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Read More »
-
TSB #T-SB-0014-11 Rev
TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Read More »
-
TSB #T-SB-0260-08 Rev
TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions. Read More »
-
TSB #T-SB-0134-14
TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL "ON" shifting issues and/or transmission damage. Read More »
-
TSB #T-SB-0200-08 Rev
TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
-
TSB #TSB-0184-09
TOYOTA: VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A MIL ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0505 STORED IN THE ENGINE CONTROL MODULE OR ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM). Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
-
TSB #T-SB-0006-11 Rev
TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
-
TSB #T-SB-0014-11 Rev
TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Read More »
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
-
TSB #T-SB-0080-13 REV
TSB: SOME 2006 - 2012 MODEL YEAR 4WD RAV4 VEHICLES MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. Read More »
-
TSB #ZF4_DEALER 12/3
"DL: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 ... Read More »
-
TSB #ZF4_DEALERD 12/3
"DD: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 ... Read More »
-
TSB #POL15-04
WPB: IN CERTAIN 2006 TO 2012 MODEL YEAR RAV4 4WD VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS WHERE THE VEHICLE MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. Read More »
-
TSB #TSB-0080-13
TOYOTA: THE REAR DIFFERENTIAL COUPLING, WHEN DRIVING SOME VEHICLES, MAY EXHIBIT A GROWL NOISE, DUE TO CONTAMINATION TO FRONT BEARING. MODEL 2006-2012 RAV4 (42WD). *PE Read More »
ELECTRICAL SYSTEM
-
TSB #ZE7_Important Do
DD: In limited cases vehicles being serviced for ZE7 will require a replacement short block. Dealers will need to install the dowel pins between the short block and lower crankcase when performing this repair. Read More »
-
TSB #T-SB-0101-11 Rev
TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Read More »
-
TSB #T-SB-0101-11 Rev
TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Read More »
-
TSB #T-SB-0012-13 REV
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
-
TSB #TSB-0047-09
TOYOTA: MULTIPLE WARNING LIGHTS ILLUMINATED, VEHICLE NOT SHIFTING FROM PARK TO DRIVE, AND OTHER ACCESSORIES BECOMING INOPERATIVE AFTER VEHICLE HAS COLD SOAKED IN SUBFREEZING AMBIENT AIR TEMPERATURES. Read More »
AIR BAGS
-
TSB #TSB-0122-11
TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Read More »
SEAT BELTS
-
TSB #00906
SEAT BELT EXTENDER. *TT Read More »
STRUCTURE:BODY
-
TSB #T-SB-0040-08
TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. Read More »
-
TSB #T-SB-0040-08
TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. Read More »
STRUCTURE:BODY:DOOR
-
TSB #ER11_Re-Notifica
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
-
TSB #TSB-0087-12
TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE Read More »
TIRES
-
TSB #T-TT-0124-11
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #T-SB-0187-12
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
-
TSB #00406
DIRECT-TYPE TIRE PRESSURE WARNING SYSTEM DIAGNOSTIC TIPS. *KB Read More »
WHEELS
-
TSB #T-SB-0381-09 Rev
TSB: The only acceptable towing method for vehicles equipped with an Active Torque Control 4WD system is to have all four wheels off the ground. Read More »
SEATS
-
TSB #TSB-0122-11
TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Read More »
EQUIPMENT
-
TSB #POL14-12
WARRANTY POLICY BULLETIN (POL14-12): TOYOTA HAS RECEIVED SOME REPORTS WHERE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. Read More »
-
TSB #T-TT-0381-16
TECH TIP: SOME CUSTOMERS MAY EXPERIENCE DIFFICULTY PROGRAMMING HOMELINK. Read More »
-
TSB #ZE7_PHASE2 11/18
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
-
TSB #ZE7_PHASE2 11/17
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
-
TSB #ZE7_IMP 11/12
DD: IN LIMITED CASES VEHICLES BEING SERVICED FOR ZE7 WILL REQUIRE A REPLACEMENT SHORT BLOCK. DEALERS WILL NEED TO INSTALL THE DOWEL PINS BETWEEN THE SHORT BLOCK AND LOWER CRANKCASE WHEN PERFORMING THIS REPAIR. Read More »
-
TSB #POL 14-12
WPB: TOYOTA HAS RECEIVED SOME REPORTS WHERE THE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. Read More »
-
TSB #T-TT-0360-15
TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
-
TSB #TC-14-032
TOYOTA: ON SOME VEHICLES, INFORMATION BEING SENT OUT REGARDING INSTALLATION OF SMART STOP TECHNOLOGY. MODEL YEARS 2003-2010 COROLLA, COROLLA MATRIX, LAND CRUISER, HIGHLANDER RAV4, 4RUNNER, TUNDRA. Read More »
EQUIPMENT:ELECTRICAL
-
TSB #T-SB-0043-14 Rev
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
-
TSB #T-SB-0043-14 Rev
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
-
TSB #T-SB-0101-11 Rev
TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Read More »
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
-
TSB #T-TT-0360-15
TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. Read More »
-
TSB #T-TT-0268-13
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
-
TSB #T-TT-0226-13
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-
TSB #ZE7
WARRANTY POLICY BULLETIN (POL14-12): ADDED THE SHORT BLOCK RELEASE AUTHORIZATION FLOW CHART. TOYOTA HAS RECEIVED SOME REPORTS WHERE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. Read More »
-
TSB #TSR-13V383
TOYOTA/LEXUS: INFORMATION REGARDING DEALER RE-NOTIFICATION, ON CERTAIN VEHICLES, OF REMEDY INSTRUCTIONS (DVD) VIA SEPARATE COVER. MODELS 2006-2011 RAV4, 2010 HS250TH. *PE Read More »
-
TSB #TC13-019
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #T-SB-0083-13 Rev
TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Read More »
-
TSB #T-SB-0083-13 Rev
TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Read More »
-
TSB #T-SB-0142-13 Rev
TSB: Some 2004 - 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Read More »
-
TSB #T-SB-0142-13 Rev
TSB: Some 2004 - 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Read More »
-
TSB #T-TT-0051-10
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
UNKNOWN OR OTHER
-
TSB #00307
TOWING HITCH INSTALLATION INSTRUCTIONS REVISION. *KB Read More »
-
TSB #00207
TECHSTREAM ECU FLASH REPROGRAMMING PROCEDURE. *KB Read More »
Browse Other RAV4 Years
- 2023 Toyota RAV4
- 2022 Toyota RAV4
- 2021 Toyota RAV4
- 2020 Toyota RAV4
- 2019 Toyota RAV4
- 2018 Toyota RAV4
- 2017 Toyota RAV4
- 2016 Toyota RAV4
- 2015 Toyota RAV4
- 2014 Toyota RAV4