2002 Volkswagen Golf
64 Technical Service Bulletins (TSBs)
TSB List for the 2002 Volkswagen Golf
Technical Service Bulletins (TSBs) for the 2002 Golf are official communications between Volkswagen & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
ENGINE (PWS)
-
TSB #V171404 2012855
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality ... Read More »
ENGINE AND ENGINE COOLING
-
TSB #11292005
ENGINE PRE-HEATER INSTALLATION. CALIX. *TT Read More »
-
TSB #004
ENGINE COOLANT TEMPERATURE (ECT) SENSOR. *TC Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #TB-01-12-04
VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE. *PE Read More »
-
TSB #SAC-28F3/P1-REV
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
-
TSB #SB-28F3
VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN ... Read More »
-
TSB #0403
ENGINE, FLUCTUATING IDLE OR IDLE SPEED TOO LOW. *MJ Read More »
-
TSB #0402
ENGINE, FLUCTUATING IDLE OR IDLE SPEED TOO LOW. *MJ Read More »
-
TSB #0409
EVALUATING FUEL MIXTURE DIAGNOSTIC TROUBLE CODES- HOW TO PERFORM EFFECTIVE DIAGNOSIS RELATED TO FUEL SYSTEM ADAPTATION - SYSTEM TOO RICH/TOO LEAN. VOLKSWAGEN. *MJ Read More »
-
TSB #0207
MISFIRE, INCORRECT CYLINDER FAULT CODES P0301, P0302, P0303 OR P0304 IDENTIFIED BY ECM SOFTWARE. *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
-
TSB #SA-28F3
VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
-
TSB #010702
DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
-
TSB #2015831
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
-
TSB #SAC-28F3/P1-REV
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
-
TSB #ESA-26E1
VOLKSWAGEN: THE CATALYTIC CONVERTER MONITORING SYSTEM, WITH THE ECM SOFTWARE, IS TOO SENSITIVE AND CAUSES THE MALFUNCTION INDICATOR LAMP (MIL) TO COME ON AND EXCEED EMISSIONS STANDARDS FOR FEDERAL AND/OR CALIFORNIA. Read More »
FUEL SYSTEM, GASOLINE
-
TSB #V011602 2014815
Technical tips on what to do if improper gasoline has been added to the vehicle. Read More »
-
TSB #V011503 2014815
Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers Read More »
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
-
TSB #TT 20-13-01
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
-
TSB #TT 32-14-01
Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. Read More »
ELECTRICAL SYSTEM
-
TSB #0502
DIAGNOSTIC TROUBLE CODE (DTC) P1603 (18011) STORED IN DTC MEMORY. *TT Read More »
-
TSB #0420
MALFUNCTION INDICATOR LIGHT IS ON IN THE INSTRUMENT CLUSTER. *TT Read More »
-
TSB #0401
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC) P1347/17755 AND P1340/17748 STORED IN MEMORY. INCLUDING VARIOUS MODELS VOLKSWAGEN 2002-2003. *MJ Read More »
-
TSB #0412
MALFUNCTION INDICATOR LIGHT (MIL) ON, DIAGNOSTIC TROUBLE CODES (DTCS) STORED IN DIAGNOSTIC TROUBLE CODE (DTC) MEMORY. *MJ Read More »
-
TSB #0402
MALFUNCTION INDICATOR LIGHT (MIL) ON WITH DIAGNOSTIC TROUBLE CODE P0300, P0301, P0302, P0303, OR P0304 STORED. IGNITION COIL OVERLAY HARNESS, INSTALLING. *TT Read More »
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
-
TSB #V271503 2016076
Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw Read More »
-
TSB #V271501 2011894
Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger Read More »
ELECTRICAL SYSTEM:IGNITION
-
TSB #SAC-28F3/P1-REV
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
-
TSB #SA-28F3
VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
-
TSB #SB-28F3
VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN ... Read More »
-
TSB #WG
REPLACEMENT OF THE IGNITION COILS. IT IS POSSIBLE THAT IF ONE OF THE VEHICLE'S IGNITION COIL FAILS, ROUGH IDLING OR REDUCED DRIVING POWER COULD OCCUR IN ADDITION TO ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP LIGHT. Read More »
-
TSB #0401
IGNITION COIL OVERLAY HARNESS, INSTALLING. MALFUNCTION INDICATOR LIGHT (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, OR P0304 STORED. *TT Read More »
ELECTRICAL SYSTEM:SOFTWARE
-
TSB #Quick Reference
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
-
TSB #ESA-26E1
VOLKSWAGEN: THE CATALYTIC CONVERTER MONITORING SYSTEM, WITH THE ECM SOFTWARE, IS TOO SENSITIVE AND CAUSES THE MALFUNCTION INDICATOR LAMP (MIL) TO COME ON AND EXCEED EMISSIONS STANDARDS FOR FEDERAL AND/OR CALIFORNIA. Read More »
EXTERIOR LIGHTING
-
TSB #V941501 2011521
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
-
TSB #V941403 2011521
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-
TSB #0401
NEW STYLE BRAKE LIGHT SWITCH REQUIRES CARE DURING INSTALLATION TO PREVENT DAMAGE TO SWITCH. *TT Read More »
VISIBILITY:GLASS, SIDE/REAR
-
TSB #0501
DOOR WINDOW, SEPARATES FROM WINDOW REGULATOR CLAMPS. *JB Read More »
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
-
TSB #0603
DOOR WINDOWS, MAY SEPERATE FROM WINDOW REGULATOR CLAMPS. *KB Read More »
-
TSB #0307
DRIVER AND PASSENGER DOOR WINDOW REGULATOR REPAIRS. *TT Read More »
VISIBILITY:SUN/MOON ROOF ASSEMBLY
-
TSB #SA-60A7-S9
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INSPECT, CLEAN AND MODIFY SUNROOF DRAINS FOR CERTAIN VOLKSWAGEN VEHICLES AND REVISED MAINTENANCE SCHEDULE; SUNROOF DRAIN INSPECTION AND CLEANING. Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
-
TSB #0201
FRESH AIR BLOWER MOTOR, INOPERATIVE AT AMBIENT AIR TEMPERATURES NEAR OR BELOW FREEZING. *TT Read More »
STRUCTURE
-
TSB #0402
DRIVER AND PASSENGER DOOR WINDOW REGULATOR REPAIRING. *MJ ADDITIONAL INFORMATION REGARDING DOOR WINDOW, SEPARATES FROM WINDOW REGULATOR CLAMPS. *TT Read More »
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
-
TSB #2015831
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
STRUCTURE:BODY
-
TSB #V551613_2039446
TO UPDATE MODEL TABLE TO CLARIFY JETTA WAGON APPLICABILITY TO TB CONTENT. Read More »
-
TSB #V501604 2014370
Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
-
TSB #V501602 2011761
Document refers to Surface corrosion or corrosion perforation that can occur on various locations around the front wheel arch. Read More »
-
TSB #V501601 2011761
Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace Read More »
STRUCTURE:BODY:BUMPERS
-
TSB #V501606_2011761
TO UPDATE CLAIM PROCESSING STATEMENT. Read More »
STRUCTURE:BODY:DOOR
-
TSB #V641501 2039887
Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not ... Read More »
-
TSB #2038887
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
TIRES
-
TSB #TT 50-14-01
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
WHEELS
-
TSB #V501602 2011761
Document refers to Surface corrosion or corrosion perforation that can occur on various locations around the front wheel arch. Read More »
-
TSB #Elsa Newsletter
Summary of Technical Bulletin to include additional model and model year applicability. Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) Read More »
-
TSB #V501601 2011761
Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace Read More »
-
TSB #TT 50-14-01
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
EQUIPMENT
-
TSB #V941403 2011521
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
EQUIPMENT:ELECTRICAL
-
TSB #TT 20-13-01
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-
TSB #V941501 2011521
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
-
TSB #V551501 2039446
Technical Bulletin (Corrosion Hood Edge ): Document discusses diagnosis, and potential remedy of issue. The document also has example claim forms for repears. Read More »
-
TSB #V501501 2011761
Technical Bulletin Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) ): Document discusses diagnosis, and potential remedy of issue. Read More »
EQUIPMENT ADAPTIVE/MOBILITY
-
TSB #V551603 2039446
Document discusses Corrosion that may be found on the folded edge of the hood. The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #V871409 2019947
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is ... Read More »
CHILD SEAT:LATCH CONNECTOR/CLIP
-
TSB #TB-00-10-06
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
CHILD SEAT:LATCH STRAP
-
TSB #TB-00-10-06
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
Browse Other Golf Years
- 2022 Volkswagen Golf
- 2021 Volkswagen Golf
- 2020 Volkswagen Golf
- 2019 Volkswagen Golf
- 2018 Volkswagen Golf
- 2017 Volkswagen Golf
- 2016 Volkswagen Golf
- 2015 Volkswagen Golf
- 2014 Volkswagen Golf
- 2013 Volkswagen Golf
- 2012 Volkswagen Golf