2010 Volkswagen Golf
180 Technical Service Bulletins (TSBs)
TSB List for the 2010 Volkswagen Golf
Technical Service Bulletins (TSBs) for the 2010 Golf are official communications between Volkswagen & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #TT 45-09-04
Tech Tips (2009-2015 Jetta, Eos, Rabbit, Golf, GTI, Passat, CC, and Tiguan Equipped with Electromechanical Power Steering ? G85 Location Identification Tip): Ths document informs of the location of the G85 steering sensor. Read More »
-
TSB #48-13-02
VOLKSWAGEN: SOME VEHICLES MAY EXHIBIT POOR POWER STEERING ASSISTANCE. DTCS MAY BE STORED IN POWER STEERING CONTROL MODULE J500. ALSOINCLUDED MODEL JETTA SPORTWAGEN MODEL YEAR 2010-2012. *JS UPDATED 12/4/13. Read More »
-
TSB #TT-45-09-03
VOLKSWAGEN: STEERING RACK. AFTER REPLACING THE STEERING RACK THE FAULT CODE 01309 008 IS SET IN ABS/ESP MODULE. Read More »
STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
-
TSB #TB-35-11-01
VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM Read More »
SUSPENSION:FRONT:SHOCK ABSORBER
-
TSB #V401601 2043146
Technical Bulletin about a customer concern stating that customer observed one or more of the shocks/struts appearing to have an oil leak. Read More »
SUSPENSION:REAR:SHOCK ABSORBER
-
TSB #V401601 2043146
Technical Bulletin about a customer concern stating that customer observed one or more of the shocks/struts appearing to have an oil leak. Read More »
BRAKES (PWS)
-
TSB #V451703_2046841
To update brake bleed labor operation time units. Read More »
-
TSB #V451702_2046841
Update warranty table to better align the labor operation labor with campaign 45F2 Read More »
SERVICE BRAKES, AIR:SUPPLY:LOW PRESSURE WARNING:SWITCH
-
TSB #V261403 2028415
Technical Bulletin (Secondary Air Injection System Air Flow/Pressure): This document informs the Secondary Air Pressure Sensor may be contaminated by foreign particles during secondary air injection. Read More »
PARKING BRAKE
-
TSB #SB-90-11-01
VOLKSWAGEN: WHEN THE WARNING LIGHTS ARE USED FOR AN EXTENDED TIME THERE MAY BE MULTIPLE PROBLEMS DUE TO A SOFTWARE CONCERN: WARNING LIGHT SYMBOL STAYS ON AFTER THEY ARE TURNED OFF. Read More »
ENGINE (PWS)
-
TSB #V011613_2033805
"ENGINE, MISFIRE DIAGNOSTIC AID THE MIL IS FLASHING OR ILLUMINATED." Read More »
-
TSB #V231604_2041063
UPDATED TECHNICAL BULLETIN TO ADD INJECTOR SEAL PLATE TO PARTS TABLE. Read More »
-
TSB #VWS-15-01
THIS COMMUNICATION INFORMS DEALERS OF THE WARRANTY CLAIM CODING FOR 30-DAY INVENTORY MAINTENANCES ON 2.0L AND 3.0L TDI VEHICLES. Read More »
-
TSB #Revised_Oil_Capa
Job Aid ? VW Engine Oil Capacities (Gasoline, Diesel, Hybrid Engines) Read More »
-
TSB #V211501 2026771
Technical Bulletin: Discussion on engine issues lacking performance. The document covers diagnosis of the engine and the codes that are meant to describe the issues. Read More »
-
TSB #TT 23-10-02
Tech Tips (Common Rail TDI ? Fuel Filter Replacement and Prime/Bleed Procedure): This document informs when replacing fuel system components on the Common Rail TDI engine (including the fuel filter), the fuel system must be primed. Read More »
-
TSB #V151403 2032173
Technical Bulletin (Camshaft Adjustment Valve 1 -N205- Diagnosis): Completing the GFF function test and performing basic settings on the camshaft adjustment valve are essential to diagnose proper operation and to avoid unnecessary ... Read More »
-
TSB #V011422 2035464
Technical Bulletin (Cylinder Contribution/Balance Faults): This document informs that the diagnostic strategy for zero fuel calibration too sensitive. The production solution for this issue was new Software implemented. Read More »
-
TSB #V171404 2012855
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality ... Read More »
-
TSB #TB-21-14-03
VOLKSWAGEN: SOME VEHICLES FAIL TO HAVE ANY POWER OR THE CHECK ENGINE WARNING LIGHT IS ON. *PE Read More »
-
TSB #TB-20-13-06
VOLKSWAGEN: ACTIVATED CHARCOAL FILTER SYSTEM, SOLENOID VALVE AND PERFORMING GFF FUNCTION TEST A VACUUM CHECK ON CANISTER PURGE VALVE N80 ARE ESSENTIAL TO DIAGNOSE PROPER OPERATION. MODEL 2009-14 ALL BUT ROUTAN. Read More »
-
TSB #01-13-14
VOLKSWAGEN: SOME VEHICLES MAY EXPERIENCE A MISFIRE AND/OR REDUCED ENGINE PERFORMANCE. *JS Read More »
-
TSB #151204
VOLKSWAGEN: CAMSHAFT ADJUSTMENT VALVE 1-N205-DIAGNOSIS. ONE OR MORE SPECIFIC FAULT CODES MAY BE STORED IN THE ECM FAULT MEMORY. *JS Read More »
-
TSB #TB-15-12-01
VOLKSWAGEN: ALL MODELS EXPERIENCE THE TIMING CHAIN SLIPPING, RATTLING NOISES OF THE ENGINE AFTER STARTING, AND ENGINE FAILS TO START. 2008-13 ALL MODELS. *PE Read More »
ENGINE AND ENGINE COOLING
-
TSB #V191601 2022549
Tech Bullentin concerning Electric Coolant Fans that Continue to Run after Ignition is Switched OFF Read More »
-
TSB #V191401 2022549
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ... Read More »
-
TSB #TSB-21-13-01
VOLKSWAGEN: DURING COLD WEATHER, ENGINE FAILS TO START, AFTER STANDING, AND IF MOISTURE, FROM INTAKE AIR, CONDENSES, WOULD FREEZE AND BLOCK INTAKE AIR SYSTEM, IN CHARGE AIR COOLER. *PE Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #TB-15-11-04
VOLKSWAGEN: CERTAIN MODEL YEAR VEHICLES ARE EXPERIENCING ENGINE NOT STARTING, MAKING A RATTLING NOISE WHEN ENGINE HAS STARTED, TIMING CHAIN KEEPS SLIPPING AND EXHAUST LIGHT COMES ON. *PE Read More »
-
TSB #TB-24-11-03
VOLKSWAGEN: UNDER HIGH ELECTRIC POWER CONSUMPTION, VEHICLE WOULD RUN ROUGH AND HAVE COLD STARTS. *PE Read More »
-
TSB #TB-21-11-08
VOLKSWAGEN: IN SOME VEHICLES, THE WARNING LIGHT FOR ENGINE MAY BE ON AND THE ENGINE POWER HAS FAILED. *PE Read More »
-
TSB #SB-10-11-01
VOLKSWAGEN: MALFUNCTION LIGHT IS ON AND THERE IS NOISE WITH THE ENGINE RUNNING ROUGH. MULTIPLE TROUBLE CODES POSSIBLY STORED. ALL MODELS 2008-2012. *RM Read More »
-
TSB #TB-01-10-11
VOLKSWAGEN: MIL ON; NO START OR ROUGH RUNNING (DTC P0087-RAIL FUEL PRESSURE TOO LOW). CONTAMINATED OR INCORRECT FUEL CAN CAUSE PERFORMANCE, DRIVABILITY, AND/OR FUEL DELIVERY PROBLEMS. *PE Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
-
TSB #TT 27-13-01
Tech Tips: Generator Charging Concern Diagnosis Tip - One Way Clutch Pulley Testing Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM
-
TSB #TT 19-13-02
Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): Inspect the water pump for signs of contact with engine oil. Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
-
TSB #TT 19-13-02
Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): Inspect the water pump for signs of contact with engine oil. Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-
TSB #TB-19-13-01
VOLKSWAGEN: IT IS A NORMAL OCCURRENCE FOR THE ELECTRIC COOLANT FANS TO CONTINUE TO RUN AFTER THE IGNITION IS SWITCHED OFF. *JS Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
-
TSB #V011609_2034898
TO UPDATE GOLF (EXCHANGE PARTS) TIME UNITS DUE TO SAGA/ELSA UPDATES 6/13/16. MIL ON, DTC P0401 Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be accompanied with Fault P2463 DPF Soot Accumulation. Read More »
-
TSB #2031583
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
-
TSB #TDI EMISSIONS SE
THIS COMMUNICATION INFORMS OF THE TDI EMISSIONS SETTLEMENT AGREEMENT WITH REGARDS TO 2.0L TDI VEHICLES. Read More »
-
TSB #DEALER LETTER -
THIS DEALER LETTER GIVES AN UPDATE ON THE CURRENT EMISSIONS ISSUES WITH REGARDS TO 2.0L TDI VEHICLES. Read More »
-
TSB #DEALER LETTER -
THIS DEALER LETTER GIVES AN UPDATE ON THE CURRENT EMISSIONS ISSUES WITH REGARDS TO 2.0L TDI VEHICLES. Read More »
-
TSB #DEALER LETTER -
THIS DEALER LETTER GIVES AN UPDATE ON THE CURRENT EMISSIONS ISSUES WITH REGARDS TO 2.0L TDI VEHICLES. Read More »
-
TSB #ESA-23O6
VOLKSWAGEN: TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. TO ENSURE EMISSIONS OF TAILPIPE IS OPTIMIZED AND EFFICIENTLY OPERATING, THE ENGINE MANAGEMENT SOFTWARE WAS IMPROVE DUE TO AN UPDATED ECM ... Read More »
-
TSB #V201203
VOLKSWAGEN:EVAPORATIVE (EVAP) EMISSION SYSTEM, DIAGNOSTIC TROUBLE CODE DIAGNOSIS. REVISED PROCEDURE DEVELOPED TO TEST EVAP SYSTEM WITHOUT FUEL CAP. *JS Read More »
-
TSB #SB-28E6
VOLKSWAGEN: THERE IS A WARRANTY EXTENSION ON HARD START CONDITIONS FOR CUSTOMERS WHO HAD AN EARLIER CAMPAIGN ADDRESSED ON THEIR VEHICLES. *RM Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
-
TSB #V011609_2034898
TO UPDATE GOLF (EXCHANGE PARTS) TIME UNITS DUE TO SAGA/ELSA UPDATES 6/13/16. MIL ON, DTC P0401 Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be accompanied with Fault P2463 DPF Soot Accumulation. Read More »
-
TSB #V011608_2034898
TO UPDATE WARRANTY LABOR OPERATIONS DUE TO ELSA UPDATES, AND TO INCLUDE AN ADDITIONAL PARTS TABLE FOR REPLACING A ONE PIECE SYSTEM WITH A TWO PIECE SYSTEM. Read More »
-
TSB #V011421 2034898
Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient, and Soot Accumulation issues): This document informs of high soot loads prior to regeneration which can cause possible restrictions in the EGR filter. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-
TSB #ESA-23O6
VOLKSWAGEN: TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. TO ENSURE EMISSIONS OF TAILPIPE IS OPTIMIZED AND EFFICIENTLY OPERATING, THE ENGINE MANAGEMENT SOFTWARE WAS IMPROVE DUE TO AN UPDATED ECM ... Read More »
-
TSB #V241403 2038161
Technical Bulletin (Intake Manifold Faults Stored in ECM Fault Memory issues): This document informs of a failure of Intake manifold causing fault codes to be stored in the ECM. The production solution improved intake manifold design. Read More »
-
TSB #V241402 2038161
Technical Bulletin (Intake Manifold Fault issues): This document informs of Intake Manifold issues that are recognized in the ECM fault memory. The Production Solution to this issue was an improved intake manifold design. Read More »
-
TSB #V241401 2038161
Technical Bulletin (Intake Manifold issues): This document informs of a failure of Intake manifold causing fault codes to be stored in the ECM. The fault codes are written in the document. Read More »
FUEL SYSTEM, GASOLINE
-
TSB #V011602 2014815
Technical tips on what to do if improper gasoline has been added to the vehicle. Read More »
-
TSB #V201501 2031426
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
-
TSB #V011503 2014815
Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers Read More »
-
TSB #TT 20-13-02
Tech Tips (Fuel line connections): Be aware that fuel lines are color coded on vehicles with return fuel pressure lines. The black line is for fuel pressure supply and the blue line is for fuel pressure return. Read More »
-
TSB #TT 23-14-01
Tech Tips (2009-2014 All TDI (2.0L, 3.0L) Common Rail models Passat, Golf, Jetta, Jetta SportWagen, Touareg Adapting Injector Quantity adjustment correction values (IMA/IVA)): This document informs When replacing or adapting fuel ... Read More »
-
TSB #TT 00-14-02
Tech Tips (Adapting Injector Quantity adjustment correction values (IMA/IVA)): When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize this documents procedure Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-
TSB #TB-23-15-03
VOLKSWAGEN: VEHICLE IS ROUGH RUNNING, FAILS TO START AND MALFUNCTION INDICATOR LAMP (MIL) BE ON AND AFTER CHECKING COMPONENTS AND NO ROOT CAUSE IS FOUND, NEED TO CHECK HIGH PRESSURE FUEL PUMP FOR METALLIC PARTICLES. Read More »
-
TSB #TB-20-13-05
VOLKSWAGEN: ON SOME VEHICLES, LOW FUEL STORED IN ECM PRESSURE, ENGINE WOULD CRANK BUT NOT START LONG PERIODS WITHOUT DRIVING, MAY RUN ROUGH AND/OR MIL ON. ALL MODELS 2008-2013. *PE Read More »
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
-
TSB #V001602 2033846
Fuel Additive to Help Prevent Sporadic Misfire Faults A Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves. Read More »
-
TSB #TT 00-14-02
Tech Tips (Adapting Injector Quantity adjustment correction values (IMA/IVA)): When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize this documents procedure Read More »
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
-
TSB #V231505 2041063
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #TB-23-15-03
VOLKSWAGEN: VEHICLE IS ROUGH RUNNING, FAILS TO START AND MALFUNCTION INDICATOR LAMP (MIL) BE ON AND AFTER CHECKING COMPONENTS AND NO ROOT CAUSE IS FOUND, NEED TO CHECK HIGH PRESSURE FUEL PUMP FOR METALLIC PARTICLES. Read More »
-
TSB #TB-20-10-02
VOLKSWAGEN: MIL ON; DTC P0087 AND/OR P0192 STORED IN ECM FAULT MEMORY. ONE OR MORE OF THE FOLLOWING CODES MAY BE STORED IN THE ECM FAULT MEMORY-LOW FUEL RAIL PRESSURE DETECTED; FUEL RAIL PRESSURE SENSOR CIRCUIT LOW. Read More »
-
TSB #TB-01-10-11
VOLKSWAGEN: MIL ON; NO START OR ROUGH RUNNING (DTC P0087-RAIL FUEL PRESSURE TOO LOW). CONTAMINATED OR INCORRECT FUEL CAN CAUSE PERFORMANCE, DRIVABILITY, AND/OR FUEL DELIVERY PROBLEMS. *PE Read More »
FUEL SYSTEM, DIESEL
-
TSB #V231703_2041063
Update fuel sampling requirement. Read More »
-
TSB #Customer Letter
2009-2015 Model Year Volkswagen TDI? Clean Diesel Vehicles Registered in Minnesota Engine Codes CBEA, CJAA, CKRA, CATA, CNRB Using Biodiesel Blend Fuels: Biodiesel is a domestically produced, clean-burning and renewable partial ... Read More »
-
TSB #Dealer Letter -
Upcoming Communication to Owners of 2009-2015 MY Volkswagen TDI Clean Diesel Engine Vehicles Registered in the State of Minnesota Engine Codes CBEA, CJAA, CKRA, CATA, CNRB Using Biodiesel Fuel Blends: This document informs that Due to ... Read More »
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-
TSB #V231505 2041063
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
-
TSB #TT 20-13-01
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP
-
TSB #V231604_2041063
UPDATED TECHNICAL BULLETIN TO ADD INJECTOR SEAL PLATE TO PARTS TABLE. Read More »
-
TSB #TB-20-13-05
VOLKSWAGEN: ON SOME VEHICLES, LOW FUEL STORED IN ECM PRESSURE, ENGINE WOULD CRANK BUT NOT START LONG PERIODS WITHOUT DRIVING, MAY RUN ROUGH AND/OR MIL ON. ALL MODELS 2008-2013. *PE Read More »
POWER TRAIN
-
TSB #TT 45-09-04
Tech Tips (2009-2015 Jetta, Eos, Rabbit, Golf, GTI, Passat, CC, and Tiguan Equipped with Electromechanical Power Steering ? G85 Location Identification Tip): Ths document informs of the location of the G85 steering sensor. Read More »
-
TSB #TT 01-14-01
Tech Tips (Lean Fuel Trim Readings): This document informs to recheck the crankcase vacuum at idle. If low, check for additional oil leaks and verify crankcase breather operation (repairing as necessary). Read More »
POWER TRAIN:CLUTCH ASSEMBLY
-
TSB #V301402 2031366
Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #TT 13-16-01
REMINDER TO FOLLOW THE CORRECT REPAIR PROCEDURE OF PILOT BEARING REPLACEMENT, WHEN REMOVING AND RE-INSTALLING THE DSG TRANSMISSION Read More »
-
TSB #V371601 2033975
This document was created In response to multiple dealership inquires about aftermarket universal (one fluid fits all) automatic transmission fluids and transmission flushing, Volkswagen Group of America, Volkswagen Canada have prepared ... Read More »
-
TSB #TB-35-11-01
VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
-
TSB #TT 32-14-01
Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. Read More »
ELECTRICAL SYSTEM
-
TSB #TT 901204_203072
INSTRUCTIONS TO MANUALLY SET SERVICE INTERNAL MAXIMUM VALUES AFTER INSTRUMENT CLUSTER REPLACEMENT, TO PREVENT FALSE MESSAGES TO THE CUSTOMER. Read More »
-
TSB #V011613_2033805
"ENGINE, MISFIRE DIAGNOSTIC AID THE MIL IS FLASHING OR ILLUMINATED." Read More »
-
TSB #TT 571004
UPDATE TO MODEL YEAR APPLICABILITY. Read More »
-
TSB #V011606_2014603
UPDATE TECHNICAL BULLETIN TO INCLUDE ALL MODELS FOR 2015, 2016, 2017 MODEL YEAR APPLICABILITY. Read More »
-
TSB #TT 97-14-02
TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION. Read More »
-
TSB #TT 97-14-02ss1
Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System) Read More »
-
TSB #V191601 2022549
Tech Bullentin concerning Electric Coolant Fans that Continue to Run after Ignition is Switched OFF Read More »
-
TSB #TT 57-10-15
Tech Tips: Vehicles with Immobilizer with Download/Discharge? New Key Will Not Program Read More »
-
TSB #V241501 2038161
Technical Bulletin (P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory ): Document discusses diagnosis Codes necessary to diagnosis, and potential remedy of issue. Read More »
-
TSB #V191401 2022549
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ... Read More »
-
TSB #V011422 2035464
Technical Bulletin (Cylinder Contribution/Balance Faults): This document informs that the diagnostic strategy for zero fuel calibration too sensitive. The production solution for this issue was new Software implemented. Read More »
-
TSB #TT 57-10-11
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. Read More »
-
TSB #V281403 2037386
Technical Bulletin (Glow Plug Pressure Sensor Faults): When diagnosing MIL ON with glow plug pressure sensor DTC?s it important to perform diagnosis prior to replacing the glow plug. Read More »
-
TSB #TB-69-12-02
VOLKSWAGEN: DUE TO A LOOSE OR UNFASTENED CONNECTOR FOR PASSENGER AIR BAG, THE AIRBAG WARNING LAMP MAY ILLUMINATE IN INSTRUMENT PANEL. MODELS 2010-2013 GOLF, GTI, JETTA SPORTWAGEN, JETTA SEDAN. Read More »
-
TSB # TB-94-10-02
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. THE HEADLAMPS OR INSIDE LIGHTS INTERMITTENTLY DIM SLIGHTLY AT IDLE SPEED. Read More »
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
-
TSB #V271503 2016076
Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw Read More »
-
TSB #V271501 2011894
Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger Read More »
-
TSB #TB-09-10-02
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. Read More »
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
-
TSB #TB-09-10-02
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. Read More »
ELECTRICAL SYSTEM:WIRING
-
TSB # TB-94-10-02
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. THE HEADLAMPS OR INSIDE LIGHTS INTERMITTENTLY DIM SLIGHTLY AT IDLE SPEED. Read More »
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
-
TSB #TB-80-10-03
VOLKSWAGEN: HVAC BLOWER ONLY OPERATES ON HIGH SPEED (US ONLY). FRESH AIR BLOWER RUNS ONLY AT HIGHEST LEVEL. BECAUSE OF PERMANENT FROST AND SNOWFALL FINE SNOW CAN GET INTO THE FRESH AIR BLOWER VIA THE AIR INTAKE. Read More »
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
-
TSB #TT 901204_203072
INSTRUCTIONS TO MANUALLY SET SERVICE INTERNAL MAXIMUM VALUES AFTER INSTRUMENT CLUSTER REPLACEMENT, TO PREVENT FALSE MESSAGES TO THE CUSTOMER. Read More »
-
TSB #TT 901204_203072
INSTRUCTIONS TO MANUALLY SET SERVICE INTERNAL MAXIMUM VALUES AFTER INSTRUMENT CLUSTER REPLACEMENT, TO PREVENT FALSE MESSAGES TO THE CUSTOMER. Read More »
-
TSB #TT 90-11-07
Tech Tips: Instrument Cluster Illumination Read More »
-
TSB #TB-21-14-03
VOLKSWAGEN: SOME VEHICLES FAIL TO HAVE ANY POWER OR THE CHECK ENGINE WARNING LIGHT IS ON. *PE Read More »
ELECTRICAL SYSTEM:SOFTWARE
-
TSB #V011608_2034898
TO UPDATE WARRANTY LABOR OPERATIONS DUE TO ELSA UPDATES, AND TO INCLUDE AN ADDITIONAL PARTS TABLE FOR REPLACING A ONE PIECE SYSTEM WITH A TWO PIECE SYSTEM. Read More »
-
TSB #V011606_2014603
UPDATE TECHNICAL BULLETIN TO INCLUDE ALL MODELS FOR 2015, 2016, 2017 MODEL YEAR APPLICABILITY. Read More »
-
TSB #TT 97-14-02
TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION. Read More »
-
TSB #V011419 2035464
Technical Bulletin (Cylinder Contribution/Balance Faults): This document informs that the Diagnostic strategy for zero fuel calibration was too sensitive. The production solution for this issue was Software implemented into production. Read More »
-
TSB #Quick Reference
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
-
TSB #V011414 2035464
Technical Bulletin (Cylinder Contribution / Balance Fault issues): The Diagnostic strategy for zero fuel calibration is too sensitive. The production solution for this issue was new software being implemented into production. Read More »
-
TSB #2023500
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #2023500
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #TB-24-11-03
VOLKSWAGEN: UNDER HIGH ELECTRIC POWER CONSUMPTION, VEHICLE WOULD RUN ROUGH AND HAVE COLD STARTS. *PE Read More »
-
TSB #SB-28E6
VOLKSWAGEN: THERE IS A WARRANTY EXTENSION ON HARD START CONDITIONS FOR CUSTOMERS WHO HAD AN EARLIER CAMPAIGN ADDRESSED ON THEIR VEHICLES. *RM Read More »
-
TSB #TB-24-10-02
VOLKSWAGEN: IMPROVED ECM SOFTWARE CALIBRATION TO STABILIZE 02 SENSOR DIAGNOSIS. 02 SENSOR DIAGNOSIS TOO SENSITIVE AND CONTAMINATION OF THE 02 SENSOR CAUSING MIL ON WITH DTCS P0136, P0139, P2271, P013B AND/OR P320C. Read More »
EXTERIOR LIGHTING
-
TSB #V941501 2011521
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
-
TSB #V941403 2011521
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
LIGHTING (PWS)
-
TSB #V941601_2011521
UPDATE TECHNICAL BULLETIN TO INCLUDE ALL 2017 MODELS Read More »
EXTERIOR LIGHTING:HEADLIGHTS
-
TSB #TB-09-10-02
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. Read More »
-
TSB # TB-94-10-02
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. THE HEADLAMPS OR INSIDE LIGHTS INTERMITTENTLY DIM SLIGHTLY AT IDLE SPEED. Read More »
AIR BAGS
-
TSB #69M8 and 69M9 pa
This communication informs the dealers of details on the Takata parts allocation. Read More »
-
TSB #TT 45-11-01
Tech Tips: Covers concerns with Both the Anti-lock Brake (ABS) and Airbag systems working together Read More »
-
TSB #TB-69-14-02
VOLKSWAGEN: AIRBAG WARNING LIGHT WAS ILLUMINATED INDICATING A FRONT SIDE AIRBAG PRESSURE SENSOR INTERRUPTION/SHORT TO B+. THE DTCS B101715 AND B103615. *JS Read More »
-
TSB #V-691202
VOLKSWAGEN: AIRBAG WARNING LAMP ILLUMINATED IN INSTRUMENT CLUSTER, DTC B101614 STORED IN AIRBAG CONTROL MODULE. AIRBAG LAM IN INSTRUMENT CLUSTER MAY ILLUMINATE DUE TO UNFASTENED CONNECTOR FOR PASSENGER AIRBAG WARNING LAMP. Read More »
AIR BAGS:FRONTAL
-
TSB #TB-69-12-02
VOLKSWAGEN: DUE TO A LOOSE OR UNFASTENED CONNECTOR FOR PASSENGER AIR BAG, THE AIRBAG WARNING LAMP MAY ILLUMINATE IN INSTRUMENT PANEL. MODELS 2010-2013 GOLF, GTI, JETTA SPORTWAGEN, JETTA SEDAN. Read More »
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
-
TSB #2029767
AIRBAG WARNING LAMP MAY ILLUMINATE DUE TO UNFASTENED CONNECTOR. *LJ Read More »
-
TSB #V-691202
VOLKSWAGEN: AIRBAG WARNING LAMP ILLUMINATED IN INSTRUMENT CLUSTER, DTC B101614 STORED IN AIRBAG CONTROL MODULE. AIRBAG LAM IN INSTRUMENT CLUSTER MAY ILLUMINATE DUE TO UNFASTENED CONNECTOR FOR PASSENGER AIRBAG WARNING LAMP. Read More »
STRUCTURE
-
TSB #V001706_2033708
Update TB to include model year 2016 & 2017 applicability Read More »
-
TSB #V001411 2033708
Technical Bulletin (Removing Paint Contaminants from Exterior Paint): This document informs how to remove paint contaminants such as rail dust and industrial fallout from exterior paint. Read More »
-
TSB #2023248
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
STRUCTURE:FRAME AND MEMBERS
-
TSB #V511601_2038990
TO UPDATE CLAIM PROCESS STATEMENT. Rocker Panel - Front Fender ? Corrosion Corrosion on contact surfaces of the front fender to rocker panel (side member). Read More »
STRUCTURE:BODY
-
TSB #V941601_2011521
UPDATE TECHNICAL BULLETIN TO INCLUDE ALL 2017 MODELS Read More »
-
TSB #V511603_2038990
BETTER DEFINE CORROSION DAMAGE AND LOCATION COVERED BY THIS TECHNICAL BULLETIN. Read More »
-
TSB #V501604 2014370
Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
-
TSB #V501602 2011761
Document refers to Surface corrosion or corrosion perforation that can occur on various locations around the front wheel arch. Read More »
-
TSB #V501601 2011761
Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace Read More »
STRUCTURE:BODY:BUMPERS
-
TSB #V501606_2011761
TO UPDATE CLAIM PROCESSING STATEMENT. Read More »
STRUCTURE:BODY:DOOR
-
TSB #V641501 2039887
Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not ... Read More »
TIRES
-
TSB #TT 50-14-01
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
-
TSB #TT 44-14-01
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
WHEELS
-
TSB #V501602 2011761
Document refers to Surface corrosion or corrosion perforation that can occur on various locations around the front wheel arch. Read More »
-
TSB #Elsa Newsletter
Summary of Technical Bulletin to include additional model and model year applicability. Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) Read More »
-
TSB #V501601 2011761
Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace Read More »
-
TSB #TT 45-06-122
Tech Tips (Active Wheel Speed Sensor Diagnosis): This document informs of a procedure to diagnose active wheel speed sensor complaints. Read More »
-
TSB #TT 50-14-01
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
EQUIPMENT
-
TSB #V001706_2033708
Update TB to include model year 2016 & 2017 applicability Read More »
-
TSB #V011701_2034898
Update parts table. Read More »
-
TSB #VWS-15-01
THIS COMMUNICATION INFORMS DEALERS OF THE WARRANTY CLAIM CODING FOR 30-DAY INVENTORY MAINTENANCES ON 2.0L AND 3.0L TDI VEHICLES. Read More »
-
TSB #V851601 2041609
Technical Bulletin concerning the Fresh Air Blower being Inoperative. It discusses possible issues and how to service these issues. Read More »
-
TSB #Revised_Oil_Capa
Job Aid ? VW Engine Oil Capacities (Gasoline, Diesel, Hybrid Engines) Read More »
-
TSB #Customer Program
This document includes what incentives are included in the Volkswagen TDI Customer Goodwill Package. Read More »
-
TSB #V001411 2033708
Technical Bulletin (Removing Paint Contaminants from Exterior Paint): This document informs how to remove paint contaminants such as rail dust and industrial fallout from exterior paint. Read More »
-
TSB #V941403 2011521
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
-
TSB #2023248
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
EQUIPMENT:ELECTRICAL
-
TSB #TT 901204_203072
INSTRUCTIONS TO MANUALLY SET SERVICE INTERNAL MAXIMUM VALUES AFTER INSTRUMENT CLUSTER REPLACEMENT, TO PREVENT FALSE MESSAGES TO THE CUSTOMER. Read More »
-
TSB #TT 20-13-01
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-
TSB #V451703_2046841
To update brake bleed labor operation time units. Read More »
-
TSB #TDI IN-FORM Rewa
TDI IN-FORM Rewards Announcement Read More »
-
TSB #TT451101ss3_2030
Update tech tip to include model year 2017 applicability. Read More »
-
TSB #Revised_Oil_Capa
Job Aid ? VW Engine Oil Capacities (Gasoline, Diesel, Hybrid Engines) Read More »
-
TSB #Elsa Newsletter
Reminder that ODIS Service V3.0.0 is now available for installation, and that it is mandatory on all diagnostic devices used on vehicles covered by the new vehicle warranty. With the release of V3.0.0. Installation DVDs are no longer used. Read More »
-
TSB #Customer Program
This document includes what incentives are included in the Volkswagen TDI Customer Goodwill Package. Read More »
-
TSB #V011601 2034898
01 16 01 January 8, 2016 2034898 Supersedes Technical Bulletin V011526 dated November 5, 2015 to update warranty labor operations due to ELSA updates. Read More »
-
TSB #V941501 2011521
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
-
TSB #V511501 2038990
Technical Bulletin (Rocker Panel - Front Fender ? Corrosion ): Document discusses diagnosis, and potential remedy of issue. The document also has example claim forms for repears. Read More »
-
TSB #V501501 2011761
Technical Bulletin Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) ): Document discusses diagnosis, and potential remedy of issue. Read More »
-
TSB #AL-2008-2011
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. AN EXTENSION WARRANTY, WITH SPECIFIC CONDITIONS, 10 YRS OR 120,000 MILES,WHICHEVER IS FIRST, HAS BEEN ISSUED FOR EMISSIONS CONTROL SYSTEMS WARRANTY FOR INTAKE MANIFOLD AND FUEL ... Read More »
-
TSB #TT 57-12-06
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #TT 44-14-01
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #91 10 12
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
EQUIPMENT ADAPTIVE/MOBILITY
-
TSB #TT 27-15-02
Tech Tips (Test Plan to Calibrate Adaptive Cruise Control Sensors Will Not Begin notice): Notification that If the test plan to calibrate the Adaptive Cruise Control Sensors will not begin, turn off the overhead lights in the shop. Read More »
-
TSB #V661502 2027119
Technical Bulletin: Diagnosing with Damage on External Chrome or Aluminum Surfaces Read More »
-
TSB #TT 57-10-15
Tech Tips: Vehicles with Immobilizer with Download/Discharge? New Key Will Not Program Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #V871409 2019947
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is ... Read More »
-
TSB #V211502 2025464
Technical Bulletin (Frozen Charge Air Cooler ? Engine Will Not Start): Document discusses diagnosis Codes necessary to diagnosis, and potential remedy of engine issue. Read More »
CHILD SEAT:LATCH CONNECTOR/CLIP
-
TSB #TB-00-10-06
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
CHILD SEAT:LATCH STRAP
-
TSB #TB-00-10-06
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
UNKNOWN OR OTHER
-
TSB #AL-2008-2011
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. AN EXTENSION WARRANTY, WITH SPECIFIC CONDITIONS, 10 YRS OR 120,000 MILES,WHICHEVER IS FIRST, HAS BEEN ISSUED FOR EMISSIONS CONTROL SYSTEMS WARRANTY FOR INTAKE MANIFOLD AND FUEL ... Read More »
-
TSB #TB-80-10-03
VOLKSWAGEN: HVAC BLOWER ONLY OPERATES ON HIGH SPEED (US ONLY). FRESH AIR BLOWER RUNS ONLY AT HIGHEST LEVEL. BECAUSE OF PERMANENT FROST AND SNOWFALL FINE SNOW CAN GET INTO THE FRESH AIR BLOWER VIA THE AIR INTAKE. Read More »
Browse Other Golf Years
- 2022 Volkswagen Golf
- 2021 Volkswagen Golf
- 2020 Volkswagen Golf
- 2019 Volkswagen Golf
- 2018 Volkswagen Golf
- 2017 Volkswagen Golf
- 2016 Volkswagen Golf
- 2015 Volkswagen Golf
- 2014 Volkswagen Golf
- 2013 Volkswagen Golf
- 2012 Volkswagen Golf