2007 Volvo XC90
68 Technical Service Bulletins (TSBs)
TSB List for the 2007 Volvo XC90
Technical Service Bulletins (TSBs) for the 2007 XC90 are official communications between Volvo & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING:COLUMN
-
TSB #TJ-19965-2
VOLVO: THERE MAY BE A CLICKING NOISE FROM THE STEERING COLUMN DUE TO MATERIAL DEVIATION. *RM Read More »
SUSPENSION:FRONT
-
TSB #RTJ-17498
VOLVO: WHEN DIAGNOSING A SINGLE KNOCK FROM THE FRONT SUSPENSION THAT OCCURS WHEN THE DRIVER BRAKES AND TURNS AT LOW SPEEDS, ATTENTION SHOULD BE PAID TO THE REAR BUSHING IN THE FRONT CONTROL ARM WHERE IT CONNECTS TO THE FRONT SUBFRAME. Read More »
SUSPENSION:FRONT:CONTROL ARM
-
TSB #RTJ-17498
VOLVO: WHEN DIAGNOSING A SINGLE KNOCK FROM THE FRONT SUSPENSION THAT OCCURS WHEN THE DRIVER BRAKES AND TURNS AT LOW SPEEDS, ATTENTION SHOULD BE PAID TO THE REAR BUSHING IN THE FRONT CONTROL ARM WHERE IT CONNECTS TO THE FRONT SUBFRAME. Read More »
SUSPENSION:REAR
-
TSB #RTJ-17499
VOLVO: STEERING WHEEL MISALIGNED, PULLING WHILE DRIVING. WHEN DIAGNOSING A PULLING CONDITION WHILE DRIVING, INCORRECT WHEEL ALIGNMENT, OR INCORRECT STEERING WHEEL POSITION, THE ROOT CAUSE MAY BE TOO MUCH PLAY IN THE LOWER CONTROL ARM ... Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
-
TSB #TJ-28031
VOLVO: ON CERTAIN VEHICLES, AFTER A FEW MINUTES DRIVING, ANTI SKID WARNING LAMP MESSAGE MAY BE SET AFTER SYSTEM START UP INDICATING A PLAUSIBILITY PROBLEM WITH ALIGNMENT OF STEERING ANGLE SENSOR OR WHEEL ALIGNMENT. MODELS 2006-2014 XC90. Read More »
SERVICE BRAKES, AIR:ANTILOCK
-
TSB #TJ-5931
VOLVO: UNNECESSARY BRAKE CONTROL MODULE (BCM) REPLACEMENTS. WHEN DIAGNOSING DIAGNOSTIC TROUBLE CODES (DTC'S) FOR BRAKE CONTROL SYSTEM, TECHNICIAN MUST ALWAYS FOLLOW COMPLETE DIAGNOSTIC FAULT TRACING PATH IN VIDA. Read More »
SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE
-
TSB #TJ-6438-5
VOLVO: YAW RATE SENSOR IS OUTSIDE OF PERMITTED RANGE. *RM Read More »
SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
-
TSB #TJ-28031
VOLVO: ON CERTAIN VEHICLES, AFTER A FEW MINUTES DRIVING, ANTI SKID WARNING LAMP MESSAGE MAY BE SET AFTER SYSTEM START UP INDICATING A PLAUSIBILITY PROBLEM WITH ALIGNMENT OF STEERING ANGLE SENSOR OR WHEEL ALIGNMENT. MODELS 2006-2014 XC90. Read More »
PARKING BRAKE
-
TSB #TJ-13766
VOLVO: REAR PARKING ASSISTANCE SENSORS MAY GIVE FALSE DETECTIONS IN WET CONDITIONS. *RM Read More »
ENGINE (PWS)
-
TSB #TJ20803
THIS IS A TECHNICAL JOURNAL: IN CASE OF COMPLAINT OF NOISE, SOME "TOOLS" HAVE BEEN CREATED TO HELP YOU TO DO A BETTER AND MORE PRECISE FAULT TRACING Read More »
-
TSB #SMB22-206
All new Volvo engines leave the factory filled with Castrol EDGE Professional as an integral part of their delivery of high performance. Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #TJ-19302
VOLVO: LOW OIL LEVEL OR EXCESSIVE OIL CONSUMPTION AND THE PROCEDURE TO HANDLE IT. *RM Read More »
-
TSB #28-200
VOLVO: EXTEND WARRANTY COVERAGE FOR THE ENGINE MANAGEMENT SOFTWARE (EMS) ON SOME MODEL YEAR 2003-2008 MODELS. P45 CSC LETTER WAS RECEIVED. *PE REF: 10026144 (P-46), 10026145 (P-54), 10026146 (P-55), 10026147 (P-76). Read More »
-
TSB #46-11
DEM DTCS (DIFFERENTIAL ELECTRONIC MODULE DIAGNOSTIC TROUBLE CODES). *NJ UPDATED 4/7/08. *NJ UPDATED 7/14/08 *PE Read More »
-
TSB #5915
DTC BCM C008249 SOFTWARE AVAILABLE. *KB Read More »
-
TSB #2123
ENGINE IDLER PULLEY MIGHT COME LOOSE DUE TO A EXTRA PLASTIC WASHER ASSEMBLED WITH THE PULLEY. *KB Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-
TSB #TJ-19883
VOLVO: SNOW IN FAN MOTOR. BLOWER FAN/DOES NOT WORK. BLOWER FAN/UNUSUAL NOISE. SNOW MAY ENTER INTO THE FAN MOTOR AREA DUE TO HEAVY SNOWSTORMS. Read More »
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
-
TSB #RTJ-16629
VOLVO: LEAKAGE DETECTION DIAGNOSTICS IMPROVEMENTS TO REMEDY DTC'S. ALL MODELS FROM MODEL YEARS 2003-2008. Read More »
-
TSB #28-74
LEAKAGE DIAGNOSTIC FUNCTION IMPROVEMENTS TO REMEDY DTC'S. *KB UPDATED 1/22/08. *NJ UPDATED 4/7/08. *NJ Read More »
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
-
TSB #166
FUEL FILLER DOOR REPLACEMENT PROCEDURES. *KB Read More »
FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK
-
TSB #28-74
LEAKAGE DIAGNOSTIC FUNCTION IMPROVEMENTS TO REMEDY DTC'S. *KB UPDATED 1/22/08. *NJ UPDATED 4/7/08. *NJ Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-
TSB #23-29
INSTALLING EXTRA FUEL PUMP FEED CABLE. *NJ Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
-
TSB #TJ-US16761
VOLVO: THERE IS A SOFTWARE UPDATE. *RM UPDATED 4/11/2012. *KB UPDATED 4/13/12. *PE UPDATED 5/15/12. *PE UPDATED 6/4/12. *PE Read More »
-
TSB #4002
TRANSMISSION CONTROL MODULE (TCM) UPGRADES AVAILABLE TO CORRECT COMPLAINTS/SYMPTOMS. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
-
TSB #432 025
SP 432-025, CONTROL UNIT, GEAR SELECTOR REPLACEMENT; AT2512C, ATO2512C, AT2812C, ATO3112C. *PE Read More »
POWER TRAIN:DRIVELINE
-
TSB #US19079
VOLVO: THERE IS A BEARING NOISE COMING FROM THE REAR GEAR HOUSING BECAUSE OF A FAULTY BEARING. *RM Read More »
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
-
TSB #US20756
VOLVO: ABS LIGHT ON, FOUR-WHEEL DRIVE IS NOT WORKING. THERE IS A SOFTWARE PROBLEM. *RM Read More »
ELECTRICAL SYSTEM
-
TSB #TJ26753
THIS IS A TECHNICAL JOURNAL: IT HAS BEEN NOTICED ON REQUESTED MATERIALS THAT PAS SENSORS ARE ANALYZED WITHOUT FINDING ANY FAULT ON THE PARTS. Read More »
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
-
TSB #TJ26745.7.2
This document is a Technical Journal: Effective immediately, all 12V batteries may be tested using the hand held battery tester 9513030 (BT3300). The VIDA test is still available but no longer required. Read More »
-
TSB #SPJ3070120160419
THIS IS A SERVICE PRODUCT JOURNAL : THE PREVIOUSLY REPORTED ISSUE WITH VIDA 2015 AND BATTERY TESTING HAS BEEN RESOLVED. VIDA 2015 BATTERY TESTING IS THE ONLY APPROVED METHOD FOR PRODUCING BATTERY TEST CODES. Read More »
ELECTRICAL SYSTEM:WIRING
-
TSB #SPJ31352.1.0
Alternative solution when VIDA is unavailable or the Electronic Wiring Diagrams function in VIDA is unstable. Access by using the applicable URL. Read More »
ELECTRICAL SYSTEM:SOFTWARE
-
TSB #TJ31543
THIS IS A TECHNICAL JOURNAL: THIS JOURNAL IS A GUIDE FOR PERFORMING SOFTWARE DOWNLOADS. SERVICE: *SEE GUIDE UPDATED OCT. 12, 2016 FOR RELEVANT P5/SPA SOFTWARE DOWNLOAD INFORMATION: P5_SPA_SW_GUIDE. Read More »
-
TSB #SPJ31628.7.0
VIDA users are not able to check Operations & Packages An error message will be shown saying "Database error. Please contact System Administrator" Read More »
-
TSB #SPJ31721.1.0
Below error message may be shown in VIDA when selecting the Software tab in VIDA. With this message, it will not be possible to purchase Software Products. "124 - Client ID is not registered" Read More »
-
TSB #SPJ31722.1.1
A new feature will be available in VIDA version 16.4 where by users will be automatically informed when their passwords are about to expire. The pop-up window example, in the attachment, will be shown 14 days prior to the expiraton date. Read More »
-
TSB #SPJ31352.1.0
Alternative solution when VIDA is unavailable or the Electronic Wiring Diagrams function in VIDA is unstable. Access by using the applicable URL. Read More »
-
TSB #TJ27536
Information about valid Software partnumbers to order and download Software for "PDS" Pre-Delivery Service Read More »
-
TSB #RTJ-20756
VOLVO: DIFFERENTIAL ELECTRONIC MODULE (DEM), SOFTWARE. THIS TECHNICAL JOURNAL APPLIES TO ALL AWD MODEL VEHICLES, STARTING FROM 2003. *PE UPDATED ON 4/10/2012. *KB UPDATED 6/13/12. *PE Read More »
-
TSB #TJ-14902
VOLVO: SOFTWARE BEING DOWNLOADED IS INTERRUPTED AND THE CEM FAILS. THERE IS A CEM RECOVERY METHOD. *RM Read More »
-
TSB #RTJ-16629
VOLVO: LEAKAGE DETECTION DIAGNOSTICS IMPROVEMENTS TO REMEDY DTC'S. ALL MODELS FROM MODEL YEARS 2003-2008. Read More »
-
TSB #182
VOLVO 2007 S60, V70, XC70 AND XC90 VEHICLES EQUIPPED WITH ACTIVE BI-XENON (ABL) HEADLIGHTS HAVE AN ABL TOURIST FUNCTIONALITY. DESIGNED FOR MARKETS WHERE THEY DRIVE ON OPPOSITE SIDES OF THE ROAD. Read More »
EXTERIOR LIGHTING:HEADLIGHTS
-
TSB #TJ 27303
HEADLAMP MOISTURE DUE TO BROKEN GUIDE PIN. VOLVO. *KB Read More »
EXTERIOR LIGHTING:HEADLIGHTS:CONCEALMENT DEVICES
-
TSB #TJ 27303
HEADLAMP MOISTURE DUE TO BROKEN GUIDE PIN. VOLVO. *KB Read More »
EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH
-
TSB #RTJ-19254
VOLVO: HEADLAMP LOW BEAM CONNECTOR REPLACEMENT. A NEW METHOD OF REPAIR FOR HALOGEN TYPE LOW-BEAM HEADLAMPS HAS BEEN DEVELOPED TO ADDRESS COMPLAINTS FOR VEHICLES. UPDATED 3/27/09. *PE UPDATED 12/23/09. Read More »
EXTERIOR LIGHTING:TAIL LIGHTS
-
TSB #RTJ-20235
VOLVO: WATER/DISCOLORATION/MOISTURE IN THE TAIL LAMP. WATER MAY LEAK IN FROM THE BULB SOCKET BACK SEAL. IN SOME CASES TAIL LAMP HOUSING REPLACEMENT IS NECESSARY. WITH A HOSE, VERIFY THE WATER IS NOT ENTERING THE AREA FROM THE OUTSIDE. Read More »
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
-
TSB #8845
PASSENGER AIRBAG OFF INDICATION WITH BELTED ADULT PASSENGER. *KB Read More »
SEAT BELTS
-
TSB #SMB88-001A
Seat Belt Extender Read More »
SEAT BELTS:FRONT
-
TSB #SMB-88-001A
VOLVO: FOR OWNERS WHO REQUIRE FRONT SEAT BELT EXTENDERS WHICH ARE AVAILABLE. *PE Read More »
STRUCTURE:BODY:BUMPERS
-
TSB #RTJ-21524
VOLVO: TAILGATE BUMP STOPS, ADJUSTMENTS FOR BOOMING IN 3RD ROW SEAT. A BOOMING PULSATION MAY BE FELT OR HEARD IN THE 3RD ROW SEATS WHEN THE VEHICLE IS STOPPED IN DRIVE, WITH THE BRAKE APPLIED, AND THE ENGINE AT IDLE. Read More »
STRUCTURE:BODY:TAILGATE
-
TSB #RTJ-21524
VOLVO: TAILGATE BUMP STOPS, ADJUSTMENTS FOR BOOMING IN 3RD ROW SEAT. A BOOMING PULSATION MAY BE FELT OR HEARD IN THE 3RD ROW SEATS WHEN THE VEHICLE IS STOPPED IN DRIVE, WITH THE BRAKE APPLIED, AND THE ENGINE AT IDLE. Read More »
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
-
TSB #00211
NEW TECHNICAL COURSES AVAILABLE. INTRODUCTION TO TIRE PRESSURE MONITORING SYSTEMS - CLASSES NOW AVAILABLE. THIS COURSE IS INTENDED TO FAMILIARIZE TECHNICIANS AND WORKSHOP FOREMEN WITH VOLVO'S TIRE PRESSURE MONITORING SYSTEMS. Read More »
WHEELS
-
TSB #PB77-006
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
WHEELS:RIM
-
TSB #PB77-006
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
-
TSB #US24111
VOLVO: REAR SEAT ENTERTAINMENT IS NOT WORKING BECAUSE OF AN ELECTRICAL HARNESS. *RM Read More »
SEATS:MID/REAR ASSEMBLY
-
TSB #RTJ-21524
VOLVO: TAILGATE BUMP STOPS, ADJUSTMENTS FOR BOOMING IN 3RD ROW SEAT. A BOOMING PULSATION MAY BE FELT OR HEARD IN THE 3RD ROW SEATS WHEN THE VEHICLE IS STOPPED IN DRIVE, WITH THE BRAKE APPLIED, AND THE ENGINE AT IDLE. Read More »
EQUIPMENT
-
TSB #SMB17-2017A
VOLVO CARS SERVICE AND PARTS BUSINESS SERVICE MANAGER BULLETIN TITLE : RETAIL CAR DELIVERY PROCESS ALL MY 2016 S60 , V60 , XC60 , XC70 AND S80 GROUP : NO:ISSUING DEPARTMENT : CAR MARKET : UNITED STATES AND CANADA 17 2016A SERVICE ... Read More »
-
TSB #TJ20803.9.0
In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #SMB00-325
*No Description Read More »
EQUIPMENT:ELECTRICAL
-
TSB #SPJ31593
There has been an increasing amount of reports where users state that its not possible to perform a vehicle readout when pressing ?Connect? There will be an error message asking the user if they wants to retry after an error message ... Read More »
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-
TSB #SMB17-2017A
VOLVO CARS SERVICE AND PARTS BUSINESS SERVICE MANAGER BULLETIN TITLE : RETAIL CAR DELIVERY PROCESS ALL MY 2016 S60 , V60 , XC60 , XC70 AND S80 GROUP : NO:ISSUING DEPARTMENT : CAR MARKET : UNITED STATES AND CANADA 17 2016A SERVICE ... Read More »
-
TSB #SMB00-354
WARRANTY, CUSTOMER PAY AND/OR INTERNAL REPAIRS PERFORMED MUST BE VERIFIED BY A PUNCHED TIME FLAG ON THE BACK OF THE REPAIR ORDER HARD COPY. Read More »
-
TSB #SMB-00-353
The Volvo Technical Helpdesk (THD) is a central contact point available to authorized Volvo dealer technicians to assist with difficult to repair situations. Read More »
-
TSB #TJ-19302
VOLVO: LOW OIL LEVEL OR EXCESSIVE OIL CONSUMPTION AND THE PROCEDURE TO HANDLE IT. *RM Read More »
EQUIPMENT ADAPTIVE/MOBILITY
-
TSB #TJ19967
Blisters/bubbles may appear on the air vent surfaces. The blistering of the material is often caused by an air freshener applied directly to the air vents. Do not attach any sort of air freshener directly on air vents. Read More »
-
TSB #SMB88-001A
Seat Belt Extender Read More »
-
TSB #SPJ31593
There has been an increasing amount of reports where users state that its not possible to perform a vehicle readout when pressing ?Connect? There will be an error message asking the user if they wants to retry after an error message ... Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #TJ19967
Blisters/bubbles may appear on the air vent surfaces. The blistering of the material is often caused by an air freshener applied directly to the air vents. Do not attach any sort of air freshener directly on air vents. Read More »
UNKNOWN OR OTHER
-
TSB #TJ26745.7.2
This document is a Technical Journal: Effective immediately, all 12V batteries may be tested using the hand held battery tester 9513030 (BT3300). The VIDA test is still available but no longer required. Read More »