Huge win for car owners! All TSBs to be made public. The Center for Auto Safety just made the NHTSA (US Government) make public the full text of all TSBs from now on. They are the same organization that has petitioned the NHTSA & filed lawsuits to protect car owners over exploding gas tanks & other major safety issues. Whenever you drive in your car, you are safer thanks in part to a lot of work over the years by this small but very effective consumer advocacy group.

Please take a moment & say thank you by donating $5 or whatever you can to the Center for Auto Safety.

10.0

really awful
Crashes / Fires:
1 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
57,881 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2009 Chevrolet HHR brakes problems

brakes problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2009 Chevrolet HHR:

Unsubscribe any time. We don't sell/share your email.

2009 Chevrolet HHR Owner Comments

problem #17

Oct 182016

HHR

  • 110,000 miles

A D V E R T I S E M E N T S

The contact owns a 2009 Chevrolet HHR. While driving 65 mph, the vehicle stalled and the ESC warning indicator illuminated. The contact mentioned that the security lock warning indicator also illuminated. The contact had to make multiple attempts of turning the ignition key back and forth before the vehicle restarted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The VIN was unknown. The failure mileage was approximately 110,000.

- Morganton, NC, USA

problem #16

Jul 302016

HHR

  • 51,000 miles
The contact owns a 2009 Chevrolet HHR. When the traction control button was pushed, the vehicle only vibrated. The contact stated that the "service ESC" indicator remained illuminated. The failure was not diagnosed. The manufacturer was not made aware of the failure. The failure mileage was 51,000.

- Petersburg, WV, USA

problem #15

Feb 012014

HHR

  • miles
My 2009 HHR has what is referred to as the May 15, 2014 GM tail light malfunction. The malfunction is caused from faulty wiring and causes the brake lights illuminate without touching the brake pedal and they remain on while driving. This malfunction also disables safety features like electronic stability control which tries to correct for skids and panic braking assist, which is designed to make sure the vehicle's full braking power is being used in an emergency. It also disables the cruise control and the traction control. In 2014 G.M. said it knew of hundreds of complaints and 13 accidents associated with the problem. I have had several near accidents and several issues of road rage from other drivers since my HHR began the malfunctioning in February 2014 which is when I first contacted GM to get it fixed. Since then I have filed complaints with the NHTSA, the federal trade commission, the state of Wisconsin consumer protection Agency and GM but have not yet had anyone step up and fix the problem. Since the malfunction causes the BCM to lose memory with the brake positioning sensor I did take the vehicle to a certified GM dealership and had them re-learn the memory between the two. This solved the problem temporarily and lasted about two months. I cannot afford to have this done every two month as a solution. GM needs to be ordered to fix the issues correctly before someone is fatally injured.

- Gays Mills, WI, USA

problem #14

Oct 282015

HHR

  • 179,273 miles

A D V E R T I S E M E N T S

I have a 2009 HHR and I have been having a number of problems the ESC and the ABS warning lights come at low speeds around 5 to 15 mph and the brakes make a growling noise I drive 80 miles a day back and forth to work in stop and go traffic on the interstate and the turnpike I am afraid I will rear end somebody or worse I don't want to let my wife drive the car because when it occurs she might not know on to react. When I turn the car off and it goes away for a while but comes back. And the service air bag light comes on from time to time when it is raining or heavy dew I had the recall performed on the air bags and it still is happening the passenger air bag display on the dash will come on when there is no one sitting in the passenger seat. The service ABS light also comes on at the same time as the ESC and the traction control light I don't feel safe I have 179,000 miles on the car the electrical system in this car has a major problem and it needs to be addressed by GM before more people are hurt or killed as I have read in other comments I don't want to take it to the dealer and just go thru the remove and replace tango trying to get lucky and fix the problem or play car doctor and treat the symptoms and not address the malady

- Land O Lakes, FL, USA

problem #13

Jul 012013

HHR

  • miles
Car would not turn off. Key would not turn. Eventually pulled fuse and got car to stop. Took to dealer next recalls came out later and I took it in three times to get recall things fixed. I still have same problems as other owners with my electrical system, the dic giving false information such as no air pressure in one of the tires, the ABS and traction need repair etc. Steering wheel almost always shakes when brake pedal is pushed and sometimes seems like it is driving under its own control. I have loved the car since I bought it with less than 9,000 miles on it in December 2010, but I drive my handicapped husband and elderly mother to many doctor appointments and cannot handle the anxiety of being an accident waiting to happen all the time. There is already the feeling of helplessness in car accidents without one driving a car that can't be controlled at all times. And these things happen out of the blue without warning. It isn't like you have even a feeling that something may be going out or that a problem is beginning. It's just boom, here's the situation, handle it! I, at all times, must keep my mind on the fact that my brakes, steering, transmission and/or electrical system may fail as I am driving down the street. This does not make for a calm driving experience. Nervousness and high anxiety is not a condition that anyone should be in when handling a potentially deadly weapon in and around other people, animals and vehicles. All these other owners can't be wrong, maybe GMC should just recall the whole car and let us get one we don't have to be afraid of causing an accident, so we can concentrate on our own and other people's driving to prevent them..

- Fresno, CA, USA

problem #12

Jun 122015

HHR

  • miles
The contact owns a 2009 Chevrolet HHR. While driving at 50 mph, the cruise control failed to activate and the brake lights remained illuminated. The electronic stability control indicator illuminated prior to the failures. The vehicle was not repaired. The manufacturer was notified of the issue. The VIN and failure mileage were unknown. MA 08/11/15

- Gaysmills, WI, USA

problem #11

Feb 012014

HHR

  • miles

A D V E R T I S E M E N T S

The electrical system in the car has shut down and has caused my power steering to go out while I am driving. It dings so I have some notice. But none the less really scary and very hard to turn going 20 mph. My brakes are very hard when this happens. My thermostat/ coolant information is currently displayed as dashes (----) across my dash, making this really difficult to know if it is hot or has run out and my ac is connected to this also so when it decides to work my ac will work. It will turn off and on while driving too. My mph reads my speed going 20 mph over what I am actually driving. My car has completely shut off while driving. The check engine light comes on and off making it more difficult to get codes.

- Austin, TX, USA

problem #10

Jul 102013

HHR 4-cyl

  • 80,857 miles
Took my car N for the engine recall five days later I notice my head light on the left side is out. On the 18th im informed by other drivers that my brake light on the left side is out. Plus one of my turn signal light is out. Basically the lights on the left side of my car are out. Also the steering will shake while slowing down and slowing in order to stop the vehicle.

- Detroit, MI, USA

problem #9

May 122014

HHR

  • miles
The contact owns a 2009 Chevrolet HHR. The contact received a recall notice related to NHTSA campaign id number 14V047000 (air bags, electrical system.). the contact stated that the vehicle was not repaired in a reasonable amount of time. The dealer indicated that the parts were not available. There were no failures the manufacturer was not notified of the delay.

- Jacksonville, IL, USA

problem #8

Apr 022014

HHR

  • 90,000 miles
The ESC light cae on and it became difficult to steer, turn, and jerking when I apply the brakes. I've taken my HHR to the dealership on 3 and 4 of April 2014 for software update. Back to dealership on 7,8,9, for computer, however there was no additional charge. 17 April same issues as the 3 rd. 21 St to tweak the ESC problems. I have spoke with [xxx] the service manager at rinke Chevrolet 586 754 7000. I have left several messages for ed rinke the dealership owner. I need my vehicle to be safe! can you please assist me [xxx] information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Arlington, TX, USA

problem #7

Mar 032014

HHR

  • 88,000 miles

A D V E R T I S E M E N T S

My car started with the ignition switch back in October with the key not shutting off the car and having to disconnect the battery to shut it off, took it into the dealer and they fixed it, but now things are getting scary. Every other day my car is telling me that the ABS systems needs fixed and that the traction control needs serviced. The breaks were replaced in December of 2013 and we were told that there is nothing else wrong with the car and now this.. took it back to the dealer and they informed us that there is nothing wrong with it, but the lights come on and go off for no reason.. the passenger seat belt locks all the time and even after you unlatch it, it stays locked for some time. I am so frustrated over this issue and can't get any answers on it.

- Stevens Point, WI, USA

problem #6

Mar 172014

HHR

  • 42,000 miles
I have never received a recall notice relative to my car and feel that I should have. What options do I now have ?

- Livonia, NY, USA

problem #5

Nov 262013

HHR 4-cyl

  • 82,000 miles
When I parked my car in the driveway my keys got stuck in the ignition and I couldn't turn my car off.I had to get it towed to a dealers who replaced the ignition. The next day my security light went on so I took it back to the dealers they we're very busy so they checked to see if my keys were programmed then the light went off so we thought it was ok. I left the dealers and within 200ft my HHR stalled and doors locked with me inside the vehicle. I called them back with my cellphone from inside the car then the doors suddenly unlocked and I was able to drive back to the dealers.they gave me a car to use. I left my HHR there so they could hook it up to the computer to see what was wrong. Alot of codes came up they said but they cleared them and said they reprogrammed my keys. The only code left was a icp code but they said I didn't need a icp panel so I took my car back. When I came out of work at 1am I unlocked my car and started my HHR up. It stalled immeditatly.with the keys stuck in the start position I tried it again after about 10 min and it started up and I drove home. I called the dealer again and they said bring it Monday again but they cant lend me a car until its fixed or promise that they can fix it. I tried to start it now and I can but I really am afraid to drive it but I have too to bring it back to the dealers. Very scary and bothersome thing. I increased my insurance and will be only taking sideroads until someone figures this out.

- Wolcott, CT, USA

problem #4

Jun 122013

HHR 4-cyl

  • 22,200 miles
Called the Chevy dealer, told me that it was Friday and to call first thing Monday morning. As I continued on freeway I realized that the ride was rougher, something was very wrong. To steer was harder, trip odometer both were not working, cruise control would not engage, speedometer was not working, transmission not shifting easily, pulled into Chevy dealer, found the service manager. Asked him to check the car, hours on sign stated that someone would available until 5:30. It was currently 4:50 pm. He assured me that is was safe to drive care: Pulled out of dealership, transmission would not shift at all. Engine light came on turned around, went back. He was just leaving to go home it was 5:10 at this time. When he saw me he got out of his car, came over, I told him the increased changes and why I turned around:I had my 80 year old aunt with me I live 14 miles outside of town it was Friday afternoon I did not want to make matters worse by driving this car say an accident or doing more damage to the repairs needed. He put it on the analysis scope he said he had mixed messages. One was it said power steering but with the wrong code. After that there was nothing that showed up. He again assured me that we would be fine! I pulled out of the dealership, drove 2 miles, then was coasting! had no transmission. Pulled over to side of road, turned off the engine sat for a few minutes, restarted continued down the highway with my flashers on. It would not shift higher than second gear.we limped to a friends house parked the car, they gave us a ride home. What would have happened if I had continued down that road. Please help.

- Ellensburg, WA, USA

problem #3

May 072013

HHR 4-cyl

  • 87,154 miles
While driving on the highway my service ESC light came on along with the road traction picture and my car started jerking and shaking after a few minutes my check engine light came on. My husband thought it was misfiring so he changed out the spark plugs but it is still doing the same thing. The ESC light will go off for a few miles but will came back on.

- Willis , TX, USA

problem #2

May 142012

HHR 4-cyl

  • 103,500 miles
The eps (electronic power steering) goes out in my 2009 Chevrolet HHR every single day, usually after about 5 minutes of driving. It hasn't caused me to have a major accident yet, but it caused me to scrape against a guard rail. The eps motor needs a recall immediately, as this is a well known issue with many HHR owners!!!

- Huntington , WV, USA

problem #1

Aug 082011

HHR 4-cyl

  • 48,000 miles
My 2009 HHR has several times shown a ESC service light. Also, there is a constant roar and alternating roar from the front suspension, not sure what it is.

- Winston-Salem, NC, USA

Not what you are looking for?