Huge win for car owners! All TSBs to be made public. The Center for Auto Safety just made the NHTSA (US Government) make public the full text of all TSBs from now on. They are the same organization that has petitioned the NHTSA & filed lawsuits to protect car owners over exploding gas tanks & other major safety issues. Whenever you drive in your car, you are safer thanks in part to a lot of work over the years by this small but very effective consumer advocacy group.

Please take a moment & say thank you by donating $5 or whatever you can to the Center for Auto Safety.


definitely annoying
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
37,667 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2009 BMW 528 electrical problems

electrical problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2009 BMW 528:

Unsubscribe any time. We don't sell/share your email.

2009 BMW 528 Owner Comments

problem #3

Aug 152013


  • 32,000 miles


I received a message that the right brake light and signal light were malfunctioning. Dealer wants to charge inflated price of $550 to correct on a 4 year old car with only 32000, when I researched on the internet this seems to be a constant issue with 2008 and 2009 5 series bmws. 100S if not more of this problem are on internet and the complaints along with the cost BMW is charging to fix.

- Alexandria, VA, USA

problem #2

Aug 062013

528 6-cyl

  • 53,000 miles
The grounding wire in the connector to the tail light bulb holder melted and melted parts of the connector. This resulted in no signal, brake and running rear lights. A recall has been called for BMW E46 3 series for this exact problem (see below). The recall should be expanded to cover the 5 series as well.

- Manhattan Beach, CA, USA

problem #1

Jan 042011

528 8-cyl

  • 28,000 miles
Currently have a 2009 BMW 550I. Vehicle has had an ongoing and unidentifiable electrical issue causing the vehicle to often and without initial notice "loose power" and go into a "safety mode" operating at a reduced power by not going above 30mph and/or 3000rpm's. vehicle with often start "bogging" and "shuttering(shaking)" and will often attempt to "surge" forward while sitting in traffic often trying to cause a rear end accident with the vehicle infront. The driver of the BMW often has to "stand" on the brakes in order to prevent the vehicle surges from allowing the vehicle to shot forward at stops. Issues started in January of 2011, took it to fairfax BMW where they determined the vehicle had some sort of electrical issue with the battery. No fix was provided in the shop for 3 days. Issues persisted through January and took it to BMW of alexandria where they replaced a transmission solenoid and a intake sensor, in the shop for roughly 7 days. Electrical issue reappeared in March in with the same problems. Vehicle was in the shop for over 7 days and had the entire vehicle wiring harness replaced. Vehicle issue resurfaced several weeks later and a engineer from NJ came down and determined a faulty oil sensor was causing the vehicle to often "think? it was out of oil vehicle was in the shop for 7 days. Vehicle potentially was flooded with oil from service tech's adding more oil each time the vehicle "thought" it was out of oil. Vehicle as of 5-21-2011 suffered again from the same issue and was dropped back off at BMW of alexandria with vehicle engine light identifying ?engine malfunction". sent several emails to BMW corporate with little response.

- Alexandria, VA, USA

Not what you are looking for?