NHTSA — Equipment: Appliance: Air Conditioner Problems

10.0

really awful
Crashes / Fires:
0 / 1
Injuries / Deaths:
0 / 0
Average Mileage:
16,579 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

1996 Mercury Villager accessories - interior problems

accessories - interior problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 1996 Mercury Villager:

Unsubscribe any time. We don't sell/share your email.

1996 Mercury Villager Owner Comments

problem #6

Mar 122005

Villager 6-cyl

  • Automatic transmission
  • 99,472 miles

A D V E R T I S E M E N T S

Consumer stated: It was night, cold outside, and while driving smelled burning rubber. Pulled over, turned off the vehicle, opened hood bedore hood was completed opened, consumer could see flames burning and the air conditioner compressor pulley was so hot that it was glowing red. The belt attached to the compressor was burning. The vehicle caught on fire damaging the compressor and belt(s) and likely other A/C components. Consumer was able to put out fire. The A/C comressor failed causing the fire.

- Kaweah, CA, USA

Add Complaint
problem #5

Jun 112002

(reported on)

Villager

  • Automatic transmission
  • miles
Consumer states the tube line failed causing freon to leak from air conditioning unit.

- Worcester, MA, USA

Add Complaint
problem #4

Jun 222001

Villager

  • miles
A/C compressor failed with only 46,000 miles on this vehicle. Said compressor is only used during hot season. I think that they installed a substandard/defective compressor on this vehicle. Called a Mercury dealership and was told that I have to pay for the repair/replacement since it is out of warranty. A/C compressors should last more than 46K on a vehicle. Please investigate. Thanks.

- Chino Hills, CA, USA

Add Complaint
problem #3

Mar 122001

(reported on)

Villager

  • Automatic transmission
  • miles

A D V E R T I S E M E N T S

Head control module wire harness in back of the dash panel burned up. Wires were completely melted. Several electrical related problems: Battery failure, open circuit in main engine harness to egr solenoid, overhead light failed, power door locks were operating by themselves, power locks would not lock with the switch, rear windshiled wiper switch failed and rear wipers would not stop even after fuse was removed, sliding door would not open with remote or switch. Check engine light illuminated. Power steering pump noisy and was replaced. Air conditioner motor failed. When locking vehicle with key, horn would operate, keyless entry had just been installed.

- North Providence, RI, USA

Add Complaint
problem #2

Jan 252000

Villager

  • miles
No summary listed for above vehicle.

- Delaware, OH, USA

Add Complaint

Search CarComplaints.com for these popular complaint phrases...

stereo broke power windows stopped working dome light comes on engine complaint electrical issue heater complaint transmission complaint paint defect Villager recall
problem #1

Jul 011998

Villager

  • Automatic transmission
  • miles
Rear windshield wiper activated during a rain storm, swiped one way across the window and stopped. When finally was able to get it to move, and it dropped 6 inches below its actual resting spot. Also, difficulty getting shifter out of park, whether vehicle is parked on flat surface or slight incline. Finally, replaced air conditioner motor.

- Springfield, VA, USA

Add Complaint

Not what you are looking for?