- January 16: Volvo Recalls S60, V60 and XC60 Vehicles to Fix Side Airbags recalls | 2 days ago
- November 27: Volvo Leaking Sunroof Lawsuit Alleges Drain Tubes Clog news | 52 days ago
- November 18: Volvo Wins Motion to Dismiss XC90 T8 Lawsuit news | 61 days ago
- November 10: Volvo Recalls 74,000 Vehicles to Fix Seat Belt Buckles recalls | 69 days ago
2004 Volvo S80
4 Recalls & Safety Reports
Recall List for the 2004 Volvo S80
Official recalls have been issued for the 2004 Volvo S80 by the NHTSA. The complete details of all recalls are listed below, along with what they cover and the recommended solutions.
Recalls don't cost you anything to get fixed, but most are time-limited, so if your car is affected you should call your local Volvo service department immediately!
If you have questions about a recall, write down your VIN & then call Volvo customer service.
2004 Volvo S80 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) NHTSA Campaign #10V566000
Summary: Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (gps) units because the batteries on those units may overheat.
Consequence: An overheated battery could lead to a fire.
Actions: Volvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of charge. The safety recall began on November 18, 2010. Owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall. For detailed information & supporting documents, see the official NHTSA page concerning recall #10V566000 »
2004 Volvo S80 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP NHTSA Campaign #09V483000
Summary: Volvo is recalling certain model year 2001-2005 S80, model year 2001-2004 V70, S60, XC70 and model year 2003-2005 XC90 vehicles sold in or registered in the states of Alabama, Arizona, Arkansas, California, Florida, Georgia, Hawaii, Kentucky, Louisiana, Mississippi, Nevada, New Mexico, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Utah, Virginia and the U.S. territories. When exposed to certain environmental conditions (hot climate and temperature cycling) over time and in combination with varying fuel quality, the fuel pump can develop cracks in the fuel pump flange.
Consequence: If the condition occurs vehicle owners may notice fuel smell and/or fuel leak which, in the presence of an ignition source, could result in a fire.
Actions: Dealers will inspect the fuel pump installed in the vehicle, and if necessary replace the fuel pump with a part of a modified design. This service will be performed free of charge. The safety recall began on January 15, 2010. Owners may contact Volvo at 1-800-458-1552. For detailed information & supporting documents, see the official NHTSA page concerning recall #09V483000 »
2004 Volvo S80 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER NHTSA Campaign #07E023000
Summary: Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. The seal on master cylinder can fail and leak brake fluid.
Consequence: Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.
Actions: Cardone will notify owners and offer to repurchase any defective master cylinders. The recall began during April 2007. Owners can contact cardone at 1-800-777-4780. For detailed information & supporting documents, see the official NHTSA page concerning recall #07E023000 »
2004 Volvo S80 STEERING:LINKAGES NHTSA Campaign #04V029000
Summary: On certain passenger vehicles, the front control arms may not have been manufactured correctly and, as a result, the stud and nut that secure the arm to the spindle may lose their initial axial tension. Under certain driving conditions, the steering may become less responsive and the driver may experience steering wheel play.
Consequence: This driving condition could eventually lead to separation between the front control arm and the spindle, which could result in a crash.
Actions: Dealers will install a new type of nut. Owner notification began on February 16, 2004. Owners should contact Volvo cars at 1-800-458-1552. For detailed information & supporting documents, see the official NHTSA page concerning recall #04V029000 »