[ switch models ] 1992 Ford Aerostar 1992 Ford Crown Victoria 1992 Ford Econoline 1992 Ford Explorer 1992 Ford F-150 1992 Ford F-350 1992 Ford Mustang 1992 Ford Probe 1992 Ford Ranger 1992 Ford Sierra 1992 Ford Tempo 1992 Ford Thunderbird [ switch years ] 2007 Ford Taurus 2006 Ford Taurus 2005 Ford Taurus 2004 Ford Taurus 2003 Ford Taurus 2002 Ford Taurus 2001 Ford Taurus 2000 Ford Taurus 1999 Ford Taurus 1998 Ford Taurus 1997 Ford Taurus 1996 Ford Taurus 1995 Ford Taurus 1994 Ford Taurus 1993 Ford Taurus 1991 Ford Taurus 1990 Ford Taurus 1989 Ford Taurus 1988 Ford Taurus 1987 Ford Taurus

1992 Ford Taurus

1992 Ford Taurus TSBs (Technical Service Bulletins)

There are also 6 Ford recalls » 16 defect investigations » 85 TSBs » for the Ford Taurus.

Please note: The TSB information displayed below are summaries. Unfortunately we do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.

ALSO: The TSB numbers are the NHTSA numbers, which are different from the TSB numbers the manufacturers use to track each bulletin -- yes, it's a very screwed up situation that's almost completely unhelpful to you as the consumer. The manufacturers don't give out their TSB numbers to us, so if you ask your dealer for more information about a TSB, have them look it up by the issue date or the TSB title.

STEERING:HYDRAULIC POWER ASSIST SYSTEM

• TSB #BC9584961001 -- INFORMATION FOR CONCERNS OF GRUNT OR GROAN DURING WHEEL RETURN FROM FULL RIGHT TURN. *TT (NHTSA ID #50503, OCTOBER 01 1996)
• TSB #95191 -- THE POWER STEERING SYSTEM MAY HAVE A 'GRUNT' AND/OR 'GROAN' NOISE. THIS MAY BE CAUSED BY HYDRAULIC FLUID MOVEMENT WITHIN THE POWER STEERING RACK. (NHTSA ID #46461, SEPTEMBER 01 1995)

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

• TSB #9716 -- SOME POWER STEERING HOSES HAVE BEEN REPLACED WITH A REVISED DESIGN AND SHOULD NO LONGER BE USED FOR SERVICE. *JD (NHTSA ID #51361, JANUARY 02 1997)

STEERING:LINKAGES:TIE ROD ASSEMBLY

• TSB #5897 -- EXPERIENCING A SQUEAKING AND / OR POPPING NOISE FROM THE FRONT OUTER TIRE RODS. *TT (NHTSA ID #605254, MARCH 01 1999)
• TSB #12570 -- SOME VEHICLES MAY EXHIBIT FRONT OUTER TIE RODS SQUEAK AND / OR POP NOISE OVER BUMPS AND / OR TURNING. *TT (NHTSA ID #6091815, MARCH 01 1999)

SUSPENSION:FRONT

• TSB #9534 -- RATTLING OR CLUNKING NOISE FROM THE FRON SUSPENSION. *TW (NHTSA ID #39217, FEBRUARY 01 1995)
• TSB #9511 -- PREMATURE WEAR ON THE INNER EDGES OF REAR TIRES. *TW (NHTSA ID #39127, JANUARY 01 1995)

SUSPENSION:FRONT:MACPHERSON STRUT

• TSB #94243 -- VEHICLES MAY EXHIBIT A CLICKING NOISE FROM THE FRONT STRUTS. *TW (NHTSA ID #37756, NOVEMBER 01 1994)

SUSPENSION:REAR

• TSB #9556 -- PREMATURE WEAR ON INNER EDGES OF REAR TIRES MAY BE CAUSED BY REAR CAMBER AND TOE SETTINGS THAT ARE NOT WITHIN SPECIFICATION. *TW (NHTSA ID #39880, MARCH 01 1995)
• TSB #RCL/94E55 -- UNKNOWN (NHTSA ID #3013100, MARCH 01 1995)

SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT

• TSB #02176 -- LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ (NHTSA ID #10008580, SEPTEMBER 02 2002)

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

• TSB #985A13 -- THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC (NHTSA ID #601012, MARCH 18 1998)
• TSB #9562 -- ROUGHNESS CONCERN DURING BRAKE APPLICATION. *TW (NHTSA ID #39900, MARCH 01 1995)
• TSB #RCL/94E55 -- UNKNOWN (NHTSA ID #3013100, MARCH 01 1995)

SERVICE BRAKES, HYDRAULIC:ANTILOCK

• TSB #985A6 -- SOME VEHICLES MAY CYCLE WHEN BRAKES ARE APPLIED ON ROUGH ROADS OR ON AN INCLINE WHILE MAKING A SHARP TURN. *YC (NHTSA ID #601004, MARCH 18 1998)
• TSB #95212 -- THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PAR (NHTSA ID #46478, OCTOBER 01 1995)

ENGINE AND ENGINE COOLING:ENGINE

• TSB #01124 -- ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT (NHTSA ID #622665, JUNE 25 2001)
• TSB #9874 -- A NEW SILICONE GASKET AND SEALANT. *YC (NHTSA ID #601343, APRIL 13 1998)
• TSB #9811329 -- INFORMATION REGARDING THE THE AVAILABILITY OF THE REVISED HEADGASKET FOR COOLANT LOSS CONDITIONS ON SOME ENGINES. *TT (NHTSA ID #607497, FEBRUARY 01 1998)
• TSB #97610 -- BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD (NHTSA ID #51990, MARCH 17 1997)
• TSB #9743 -- BLOWER MOTOR- "CHIRP" OR "SQUEAK" FROM BLOWER MOTOR AT LOW SPEEDS. *JD (NHTSA ID #51682, FEBRUARY 17 1997)
• TSB #ONP92M77 -- SUPPLEMENT TO ONP92M77 - PROGRAM EXPANDED TO INCLUDE 1992/93 FORD TAURUS AND MERCURY SABLES. *TW (NHTSA ID #45051, JUNE 01 1995)

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

• TSB #0214 -- SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT (NHTSA ID #630001, JANUARY 21 2002)
• TSB #99183 -- SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT (NHTSA ID #6090051, SEPTEMBER 06 1999)
• TSB #99816 -- FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT (NHTSA ID #606420, MAY 03 1999)
• TSB #95105 -- KNOCKING NOISE FROM THE LOWER FRONT OF THE ENGINE. *TW (NHTSA ID #42090, MAY 01 1995)

ENGINE AND ENGINE COOLING:COOLING SYSTEM

• TSB #9849 -- CONCERNS WITH COOLANT MAY LEAK FROM THE HEAD GASKETS AND / OR THE VEHICLE MAY OVERHEAT. *YC (NHTSA ID #601270, MARCH 02 1998)

ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

• TSB #95153 -- TEMPERATURE GAUGE - FLUCTUATING AND /OR INACCURATE HIGH READINGS. *SD (NHTSA ID #45934, JULY 01 1995)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

• TSB #9864 -- INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT (NHTSA ID #601312, MARCH 30 1998)

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

• TSB #982310 -- MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK (NHTSA ID #603724, NOVEMBER 23 1998)

FUEL SYSTEM, GASOLINE

• TSB #9523 -- ERRATIC DISTANCE-TO-EMPTY AND FUEL GAUGE READINGS. *TW (NHTSA ID #39119, JANUARY 01 1995)

FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM

• TSB #96225 -- MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW (NHTSA ID #50944, OCTOBER 21 1996)

POWER TRAIN

• TSB #12178 -- INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS (NHTSA ID #613234, NOVEMBER 01 1998)
• TSB #985027 -- VEHICLES MAY EXPERIENCE SPEEDOMETER POINTER WAVER. *TT (NHTSA ID #613061, NOVEMBER 01 1998)
• TSB #12967 -- VEHICLES MAY EXHIBIT SPEEDOMETER POINTER WAVER. *MJS (NHTSA ID #613037, NOVEMBER 01 1998)
• TSB #97111097237 -- CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC (NHTSA ID #53663, NOVEMBER 10 1997)

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/LINKAGE

• TSB #12559 -- CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT (NHTSA ID #605294, MARCH 01 1999)
• TSB #BC7235961101 -- VEHICLE MAY EXHIBIT A CHATTER WHEN RELEASING THE CLUTCH IN REVERSE GEAR. *TW (NHTSA ID #50849, NOVEMBER 01 1996)

POWER TRAIN:MANUAL TRANSMISSION

• TSB #9802169838 -- TRANSAXLES USE A NEW TRANSMISSION FLUID. *YC (NHTSA ID #600591, MAY 27 1998)
• TSB #BC0678961025 -- INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT (NHTSA ID #50356, OCTOBER 25 1996)

POWER TRAIN:AUTOMATIC TRANSMISSION

• TSB #0015 -- INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS (NHTSA ID #612203, JANUARY 10 2000)
• TSB #99152 -- INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT (NHTSA ID #608431, JULY 26 1999)
• TSB #9888 -- INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC (NHTSA ID #601238, APRIL 27 1998)
• TSB #97511 -- FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD (NHTSA ID #51945, MARCH 03 1997)
• TSB #BC101209702 -- VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD (NHTSA ID #51184, JANUARY 02 1997)
• TSB #BC9683961001 -- PROCEDURE FOR UPDATING THE CALIBRATION FROM R-11 TO R-12 FOR STALLING ON DECEL & MISFIRE CODES ON 3.0L VEHICLES. *TT (NHTSA ID #50542, OCTOBER 01 1996)
• TSB #94247 -- THE FORWARD CLUTCH PISTON MAY CRACK ON ITS OUTSIDE DIAMETER. *TW (NHTSA ID #37759, NOVEMBER 01 1994)

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

• TSB #14811 -- INFORMATION ON ADDITIONAL PARTS REQUIRED WHEN REPLACING TRANSFER CASE ON VEHICLES EQUIPPPED WITH AX4S TRANSAXLE. *TT (NHTSA ID #619293, APRIL 01 2001)
• TSB #12616 -- INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT (NHTSA ID #605338, MARCH 01 1999)

POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

• TSB #03148 -- NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT (NHTSA ID #10003748, JULY 21 2003)

POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

• TSB #962612 -- TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW (NHTSA ID #50997, DECEMBER 16 1996)
• TSB #96249 -- TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW (NHTSA ID #50908, NOVEMBER 18 1996)
• TSB #95157 -- THE TORQUE CONVERTER IDENTIFICATION CODES HAVE BEEN REVISED AS OF 3/1/95. *SD (NHTSA ID #45937, JULY 01 1995)

POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START SWITCH

• TSB #01181 -- BRAKE SHIFT INTERLOCK.*JB (NHTSA ID #625715, SEPTEMBER 17 2001)

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL

• TSB #982675 -- A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC (NHTSA ID #603573, APRIL 01 1998)

ELECTRICAL SYSTEM

• TSB #98246 -- FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC (NHTSA ID #604059, DECEMBER 07 1998)

ELECTRICAL SYSTEM:STARTER ASSEMBLY

• TSB #97111097234 -- VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC (NHTSA ID #53660, NOVEMBER 10 1997)

ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID

• TSB #94263 -- SOME VEHICLES MAY EXHIBIT A NO-CRANK CONDITION DUE TO CORROSION AT THE STARTER SOLENOID CONNECTOR. *TW (NHTSA ID #38060, DECEMBER 01 1994)

ELECTRICAL SYSTEM:WIRING

• TSB #99222 -- SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT (NHTSA ID #6089681, OCTOBER 18 1999)
• TSB #96246 -- WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW (NHTSA ID #50905, NOVEMBER 18 1996)

ELECTRICAL SYSTEM:IGNITION:MODULE

• TSB #97613 -- TRANSAXLE- AX4S/AX4N- DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744 STORED IN MEMORY AFTER TRANSAXLE EXCHANGE. *JD (NHTSA ID #51995, MARCH 17 1997)

EXTERIOR LIGHTING:BRAKE LIGHTS

• TSB #99139 -- CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT (NHTSA ID #606508, JUNE 28 1999)

VISIBILITY:WINDSHIELD

• TSB #96221 -- WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW (NHTSA ID #50940, OCTOBER 21 1996)

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

• TSB #95203 -- A 'GROANING' NOISE MAY COME FROM THE FRONT POWER WINDOWS AFTER THE GLASS IS POWERED FULL UP. THIS NOISE IS CAUSED BY IMPROPER LUBRICATION ON THE WINDOW REGULATOR MECHANISM SLIDING SURFACES. THE GREASE GETS WIPED OFF FROM SLIDING SURFACES D (NHTSA ID #46471, OCTOBER 01 1995)

VISIBILITY:WINDSHIELD WIPER/WASHER

• TSB #011201 -- THIS INFORMATION IS A SUPPLEMENT TO THE WIPER SYSTEM SERVICE INFORMATION PROVIDED IN THE WORKSHOP MANUALS. THIS SERVICE INFORMATION IS INTENDED AS AN AID TO ASSIST IN DIAGNOSIS AND REPAIR OF ERRATIC WIPER SYSTEM CONDITIONS. (NHTSA ID #622660, JUNE 25 2001)

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

• TSB #02107 -- TRANSFER SERVICE TIPS FOR THE FRONT WIPER MOTOR MOUNT BRACKET AND DEPRESSED PARK OUTPUT ARM. *TT (NHTSA ID #636080, MAY 27 2002)
• TSB #9582 -- A REVISED SERVICE WINDSHIELD WIPER MOTOR IS NOW AVAILABLE. *TW (NHTSA ID #41025, APRIL 01 1995)
• TSB #9546 -- WIPER MOTOR REPLACEMENT - UPGRADED SERVICE KITS. *TW (NHTSA ID #39717, FEBRUARY 01 1995)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:BLOWER

• TSB #9592 -- UNKNOWN (NHTSA ID #42077, MAY 01 1995)
• TSB #RCL/94E55 -- UNKNOWN (NHTSA ID #3013100, MARCH 01 1995)
• TSB #95511 -- CHIRP OR SQUEAK FROM BLOWER MOTOR. *TW (NHTSA ID #39884, MARCH 01 1995)
• TSB #9566 -- CHIRP OR SQUEAK NOISE FROM BLOWER MOTOR AT LOW SPEEDS. *TW (NHTSA ID #39903, MARCH 01 1995)

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:HEATER CORE

• TSB #01156 -- SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC (NHTSA ID #623944, AUGUST 06 2001)

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

• TSB #9671 -- SOME VEHICLES MAY EXPERIENCE THE AIR BAG DIAGNOSTIC LIGHT FLASHING. *TT (NHTSA ID #613324, MARCH 25 1996)

SEAT BELTS:FRONT:ANCHORAGE

• TSB #FD950526 -- UNKNOWN (NHTSA ID #42061, MAY 01 1995)

TIRES

• TSB #9852 -- INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC (NHTSA ID #601290, APRIL 13 1998)

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

• TSB #99129 -- EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT (NHTSA ID #606460, JUNE 14 1999)
• TSB #9873 -- EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT (NHTSA ID #601341, APRIL 13 1998)

EQUIPMENT:ELECTRICAL:AIR CONDITIONER

• TSB #02208 -- CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH (NHTSA ID #10013060, OCTOBER 14 2002)
• TSB #99196 -- INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT (NHTSA ID #6090087, SEPTEMBER 20 1999)
• TSB #9848 -- ANNOUNCING THE FORD OEM AIR CONDITIONING RETROFIT KIT AVAILABILITY. *YC (NHTSA ID #601269, MARCH 02 1998)

EQUIPMENT:MECHANICAL:WRECKER AND WHEEL LIFT DEVICES

• TSB #985A12 -- RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT (NHTSA ID #601010, MARCH 18 1998)

UNKNOWN OR OTHER

• TSB #01157 -- INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC (NHTSA ID #623988, AUGUST 06 2001)
• TSB #9817 -- CONDITIONS WITH THE MALFUNCTIONING OF THE INDICATOR LAMP. (NHTSA ID #605566, JANUARY 19 1998)
• TSB #9768 -- FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD (NHTSA ID #51987, MARCH 17 1997)