NHTSA — Engine And Engine Cooling: Exhaust System: Emission Control Problems

CarComplaints.com Seal Of This Might Hurt

CarComplaints.com Notes: With the 2007 model year we finally get to bid adieu to a car famous for poor safety marks, a dangerously defective ignition and power steering that would work … sometimes.


hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
52,000 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2007 Saturn Ion exhaust system problems

exhaust system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2007 Saturn Ion:

Unsubscribe any time. We don't sell/share your email.

2007 Saturn Ion Owner Comments

problem #1

Aug 282010

Ion 4-cyl

  • 52,000 miles


The contact owns a 2007 Saturn Ion. The contact stated that the vehicle was repaired under NHTSA campaign id number: 09V419000 (fuel system, gasoline: Delivery: Fuel pump) in May 2010. The contact began to notice an unusual gasoline fuel odor following repairs and noticed fuel leaking from the vehicle. The vehicle was taken to an authorized dealer where the contact was advised that the epoxy, placed around the fuel filler neck installed during the recall repair, was fracturing and causing the leak. In addition, the fuel tank would also need replacing. The dealer offered to take 10 percent off of the total repair cost. The vehicle was not repaired. The manufacturer advised the contact that his case would be escalated to the district manager and they would contact him. The contact was awaiting a return call. The failure mileage was approximately 52,000 and the current mileage was approximately 52,700. Updated 01/13/11 the consumer stated he performed the repair on the fuel tank that was partially effective. The consumer stated he was not able to afford the $800 repair. The check engine light is still on. The vehicle has a small evaporative emissions control leak. Updated 01/25/11.

- Cape Coral, FL, USA

Search CarComplaints.com for these popular complaint phrases...

Not what you are looking for?