If you find CarComplaints.com is helpful ... We rely completely on word of mouth. Talk about us on Facebook, Twitter, tell your mother-in-law. Help us help more people.


definitely annoying
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
35,110 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2009 Ford F-150 fuel system problems

fuel system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2009 Ford F-150:

Unsubscribe any time. We don't sell/share your email.

2009 Ford F-150 Owner Comments

problem #5

Nov 242011


  • 52,000 miles


The contact owns a 2009 Ford F-150. The contact stated that while driving 40 mph the vehicle stalled without warning. The vehicle was taken to the dealer who diagnosed that the battery was defective and that the vehicle ran out of fuel. The vehicle was taken to another dealer who diagnosed that the fuel tank had collapsed. The manufacturer was made aware of the failure who stated that they would contact him back at a later date. The vehicle was repaired. The failure and the current mileage was 52,000.

- Houston, TX, USA

problem #4

Sep 172011

F-150 8-cyl

  • 48,000 miles
The fan blower speed control stuck on high only and was replaced 09/2011. The vehicle kept stalling out upon deceleration going down the road. With loss of power steering and power brakes when this happens. Could be going 30 mph or 60 mph. When get motor is started again it usually runs rough. The left oxygen sensor code was on so this was replaced. 11/2011 the fuel gauge also stopped reading fuel in the tank when this happens. Replaced fuel pump in tank, fuel filter, fuel power module, all was fine for three weeks. Truck dies 8 times today and all the same problems are back. Engine light on, fuel gauge stopped working, truck runs rough for awhile when restarted then clears up. Engine light now stays on and fuel gauge will read 1/2 tank when it is full. 36 gal tank. 11/22/2011.

- Mooresville, IN, USA

problem #3

Jul 202011

F-150 8-cyl

  • 15,000 miles
**catastrophic fuel tank failure** two days ago my 2009 F150 died in my driveway, it acted as if out of fuel even though the gage read over half a tank. I had it towed to a Ford dealer and was initially informed that the truck was out of gas and the fuel gage wasn't working. A new unit was ordered and once the tank was removed from the truck it was discovered that the issue was exceedingly more severe. The mechanic and a Ford engineer concluded that the charcoal purge valve failed and the fuel pump created such a strong vacuum that the fuel tank collapsed on itself and crushed the fuel pump.although the truck has only 15,000 miles it is not a warranty repair due to a salvage title on the vehicle. After the inspection it was concluded that the fuel tank unit was not damage or effected by any incident and was in standard operating condition when the event occurred.I also understand that since this is not a warranty repair, Ford will not be collecting the parts for further evaluation. I believe this to be a mistake! I have asked to keep these parts and will provide them to Ford if need be. As an engineer I believe this to be a design flaw that could present a severe safety hazard.

- Blythewood, SC, USA

problem #2

Mar 032011


  • 48,000 miles
My 2009 Ford F150 suffers engine stall when stopping in traffic. There are no diagnostic indications (engine light, codes stored). It has a "lifetime" fuel filter, so it cannot be changed. When the engine stalls, power steering and power brakes are lost, resulting in possibility of rolling into oncoming traffic. I have suffered 3 near misses in the past 3 days. Ford will not accommodate my schedule for service.

- Bethel, OH, USA

problem #1

Oct 182010


  • 12,550 miles
I stopped at the mobil kanagroo express gas station in gainesville to fill my 2009 Ford F150 up with gas. I used the handle lock on the gas nozzle to fill the tank. I also held it with my hand. When it was not yet full the nozzle flew out of the filler tube spraying gasoline all over me and the ground. I pulled the truck away from the gas pumps because I was worried about a fire. I went into the store explain to the clerk what happened and told him that he had a problem out at the pump because there was a puddle of gasoline still on the ground. I had a change of clothes with me and the clerk gave me a bar of soap to wash up with. The clerk said the gas at the pump would just evaporate. I also reported the incident to the gainesville fire department who said they would check the stations pumps. I don't know whether it was the fault of the truck or the gas pump but I was afraid of dying because I was covered in gasoline.

- St. Petersburg, FL, USA

Not what you are looking for?